Documente Academic
Documente Profesional
Documente Cultură
SN:
Kuwait University Electrical Engineering Department ENG 205 Fundamentals of Electrical Engineering Second Exam April 20, 2009
Instructions: 1) Verify your name and ID number below. 2) Have ready on the table a photo ID card. 3) Use only the sheets given to you in the exam. 4) No mobile phones are allowed Leave yours with the Engineer after switching it off. 5) No borrowing of calculators is allowed. Bring your own. 6) Exam Duration: 80 Minutes. 7) GOOD LUCK
SN:
Question 1: Use the node-voltage method to nd the power developed by the dependent voltage source.
SN:
Question 1 (Contd.):
SN:
Question 2: The variable dc current source is adjusted so that the power developed by the 15 Ampere current source is 2.75KW. Use the mesh current method to nd the value of idc
SN:
Question 2 (Contd.):
SN:
Question 3: The variable resistor (R0 ) in the circuit is adjusted until the power dissipated in the resistor in 2W. Find the value of R0 that satisfy this condition.
SN:
Question 3 (Contd.):
SN:
SN:
Question 4 (Contd.):