Documente Academic
Documente Profesional
Documente Cultură
131
Dia. In Inches. =
23
1.917
=L =D Dia. In Ft. =
Volume of Gas @
58
PSIG:
1,868
CF
T Cyl.s 6.3
The Nitrogen volumes shown are for pressurizing a pipe to the selected pressure only. Additional Nitrogen would be required for any additional purging or volume changes. See below for purging calculations. It is always recommended to have additional Nitrogen available to compensate for any leaks or un-foreseen requirements.
131
2
T' Cyl.s Req. to Achieve Volume Changes
Purging Data
Volume Required for Air Purge @ 1 Atm: Volume Required for Food Purge @ 1 Atm.: Volume Required for 100 % Purge @ 1 Atm.:
3 7 5
Purging does not require pressurization. The results shown are for the number of 'T' cylinders to provide the appropriate number of volume changes at very low flow with no pressurization. Note: NEVER enter a vessel that has been purged with Nitrogen, or any other gas unless you have tested that atmosphere for proper levels of oxygen.
For Pressure Test of Vessel, Add Test Pressure Required. Volume of Gas @
25
PSIG:
1,003
CF
T Cyl.s 3.3
www.weldspecialty.com
Page 1 of 2
Printed: 11/27/2012
Length In Ft. =
12
Height In Ft. =
Width In Ft. =
6
Appr. Residual Oxygen Approximate Vol. Levels Changes Rqd.
Purging Data
Volume Required for Air Purge @ 1 Atm: Volume Required for Food Purge @ 1 Atm.: Volume Required for 100 % Purge @ 1 Atm.:
3 7 5
Purging does not require pressurization. The results shown are for the number of 'T' cylinders to provide the appropriate number of volume changes at very low flow with no pressurization. Note: NEVER enter a vessel that has been purged with Nitrogen, or any other gas unless you have tested that atmosphere for proper levels of oxygen.
For Pressure Test of Vessel, Add Test Pressure Required. Volume of Gas @
50
PSIG:
1,584
CF
T Cyl.s 5.3
** This information is used to determine volumes of N2 requirements for purging pipelines and vessels, and is not intended to replace proper monitoring of oxygen levels with proper equipment.
www.weldspecialty.com
Page 2 of 2