Documente Academic
Documente Profesional
Documente Cultură
PRESENTED BY:-
DEFINATION
OPERATION STEP FOR FRICTION WELDING:STEP:-1 The two components to be friction welded are held in axial alignment.
STEP 2:One component that is held in chucking spindle of the machine is rotated and accelerated to the desired speed.
STEP 3:The other component that is held in the movable clamp is moved forward to come into pressure contact with the rotating component.
STEP 4:Pressure and rotation are maintained until the resulting high temp
A D VA N TA G E S O F F R I C T I O N WELDING:1. Simplicity of operation. 2. Low power requirements. 3. Less time for welding.
DISADVANTAGES OF FRICTION WELDING: 1. The use of this process is restricted to flat and angular butt welds, where one part is normal to the other part. 2. So far the process has been applied only to the joining of small pieces in the form of bar stock 3. Sometimes, quite a heavy flash is forced out in all inertia and friction welds. 4. If tubing is welded, flash may have to be removed from inside the joint. 5. Flash from medium and high carbon steels being hard, must either be removed while it is hot or annealed before it is machined.
6.
APPLICATION OF FRICTION WELDING: 1. Friction welding is use for joining steels, super alloys, nonferrous metals and combination of metals. 2. Among its varied applications are: Production of steering shafts and worm gears, control shafts, axle shafts, engine valves, transmission shafts etc., for automobile indus.
CONTINUOUS:Axles Turbochargers