Documente Academic
Documente Profesional
Documente Cultură
Electronics line (E.L) recommends testng the system at least once a week. Rafer to the testing procedure found in the installation manual Receiver communication must be tested monthly. For maximum current calculation, add keypad consumption (approx. 60mA per keypad) t the total current drawn from the AUX power output. 1 2 3 4 5
BLACK Telephone Line Connections
PROTECTION FUSES F1 (BATT): 3A/250V (bel 5MF3) F2 (AUX): 1.6A/250V (bel 5MF1.6) F3 (BELL): 3A/250V (bel 5MF3) Install F3 horizontally to supply 12v nominal regulated power to bell. Install vertically to supply 9-18V unregulated to bell and terminal 28. AUXILIARY POWER OUTPUT Regulated 12VDC nominal. Fire: Supplies 220mA for 24 hours Burglary: Supplies 1A for 4 hours (inclding 100mA to smoke detector. terminasl 24 and 25) 14 15 16 17
F1
12V 7Ah BATTERY Charging current 700mA max. Replace the battery every 3 - 5 years
F3
F2 RED BLACK
LED SYSTEM STATUS INDICATOR On = Telephone Tone Detection Off = System in Communication Flashing = Dialing Flashing (1 pulse/sec) = Standby
6
RED
7
GREEN
8
WHITE
10 11 12 13
18 19 20 21 22 23 24 25 26 27 28 29 30
Mic Input
Connect to Earth
Z1
Z2
Z3
Z4
Z5
Z6
Z7
Transformer 15VAC/30VA
Zone Connections
3108/3118/3126 LCD Keypad N.C. Typical End of Line Resistr Zone Connections (EOLR)
Power connection to the unit should be according to the national electrical code for permanent installation