Documente Academic
Documente Profesional
Documente Cultură
SITE LRD :
IMSIM1
Lat (N-WGS 84-Decimal): Long (E-WGS 84-Decimal): Landlord / Building Management: Surveyor: Dunstan Contact: 019-8280671 Key Info : TOC Access Hour: 24 hours
4.430350 114.019120
Site LRD:
IMSIM1
Address:
Geographical coordinates
4.430350 114.019120
Ground Elevation : 8m
Existing Information 1. General Information Site Type: Vacant Land If other: If other:
Sharing Type (Site Category): SACOFA Building Category: Equipment Housing: Structure Type: Structure Height: Residential Commercial CABIN VACANT LAND WITH CABIN - MONOPOLE 36m
2. 2G BTS Equipment 900 Current Vendor Equipment Model no of Equipment/BTS. No of Sector System Configuration Tx equipment/ Tx location No of physical. E1 2G BTS Equipment 1800 Current Vendor Equipment Model no of Equipment/BTS. No of Sector System Configuration Tx equipment/ Tx location No of physical. E1 3. 3G NodeB Equipment Current Vendor Equipment Model no of Equipment/BTS. No of sector (W2100) System Configuration (W2100) W900 availability No of sector (W900) System Configuration (W900) Tx equipment/ Tx location No of E1/ IP No of GE/FE spare port 4. New LTE Transmission Information Vendor Equipment Model Equipment Location
5. DC Power Information Rectifier Brand & Model Existing Total DC Loading Spare Breaker (Amp) Space for additional Breaker Requirement - 4X80A No of existing power modules No of active power modules 3G DCDU / DCPDU Information DCDU / DCPDU / PDU Main incoming breaker per feed (Amp) Spare Breaker (Amp) 6. DCPDB (if available) Description DCPDB total load (sys A & B) Main incoming breaker per feed (Amp) Spare Breaker (Amp) Space for additional Breaker 7. Grounding System External Ground Bar Internal Ground Bar Grounding Cable Description Available Available Available Condition GOOD
Not Available
Condition GOOD
Condition
Not Available
Not Available Not Available
8. AC Power Supply Main Source Source if tapping, indicate from where Description SESCO Condition
ACPDB Incoming Amp / Voltage Spare Breaker (Amp) Space for additional Breaker Description Available Not Available Not Available Condition GOOD
9. 2G Antenna Information: GSM900 Brand & Model Type of Antenna Sharing Antenna with Antenna Height (AGL) Antenna Azimuth Mechanical Tilt Electrical Tilt Type of Jumper Type of Feeder Connector Type Jumper Length (m) Feeder Length (m) Model of TMA Model of RET Diplexer / Triplexer Brand & Model 10. 2G Antenna Pole / Boom Information: GSM900 Pole/Boom Type ( Bipod / Tripod) Pole/Boom Height (m) Pole/Boom Diameter (upper/lower boom) (mm) Bracing Length (m) / Diameter (mm) Wall Mount / Floor Mount Arm Bracket Type / Length (m) Arm Boom Length (m) / Diameter (mm) Pole / Boom Condition Space Availability at Pole / Boom 11. Cable Ladder Information Internal Cable Ladder External Cable Ladder Other Information:
Sector 1 KATHREIN 742271 TRIBAND W2100 32M 50 0 N/A 1/2" Superflex 7/8" 7/16 Male/Female 5M x 2pcs 36M x 2pcs N/A N/A N/A
Sector 2 KATHREIN 742271 TRIBAND W2100 32M 170 0 N/A 1/2" Superflex 7/8" 7/16 Male/Female 5M x 2pcs 36M x 2pcs N/A N/A N/A
Sector 3 KATHREIN 742271 TRIBAND W2100 32M 290 0 N/A 1/2" Superflex 7/8" 7/16 Male/Female 5M x 2pcs 36M x 2pcs N/A N/A N/A
12. 2G Antenna Information: GSM1800 Brand & Model Type of Antenna Sharing Antenna with Antenna Height (AGL) Antenna Azimuth Mechanical Tilt Electrical Tilt Type of Jumper Type of Feeder Connector Type Jumper Length (m) Feeder Length (m) Model of TMA Model of RET Diplexer / Triplexer Brand & Model 13. 3G Antenna Pole / Boom Information: GSM1800 Pole/Boom Type ( Bipod / Tripod) Pole/Boom Height (m) Pole/Boom Diameter (upper/lower boom) (mm) Bracing Length (m) / Diameter (mm) Wall Mount / Floor Mount Arm Bracket Type / Length (m) Arm Boom Length (m) / Diameter (mm) Pole / Boom Condition Space Availability at Pole / Boom 14. Cable Ladder Information GSM1800 Internal Cable Ladder External Cable Ladder Others Information:
Sector 1 N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
Sector 2 N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
Sector 3 N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
Sector 1 N/A N/A N/A N/A N/A N/A N/A N/A N/A
Sector 2 N/A N/A N/A N/A N/A N/A N/A N/A N/A
Sector 3 N/A N/A N/A N/A N/A N/A N/A N/A N/A
15. 3G Antenna Information: W900 Brand & Model Type of Antenna Sharing Antenna with Antenna Height (AGL) Antenna Azimuth Mechanical Tilt Electrical Tilt RRU CPRI Length RRU Power cable length Type of Jumper Type of Feeder Connector Type Jumper Length (m) Feeder Length (m) Model of TMA Model of RET Diplexer / Triplexer Brand & Model 16. 3G Antenna Pole / Boom Information: W900 Pole/Boom Type ( Bipod / Tripod) Pole/Boom Height (m) Pole/Boom Diameter (upper/lower boom) (mm) Bracing Length (m) / Diameter (mm) Wall Mount / Floor Mount Arm Bracket Type / Length (m) Arm Boom Length (m) / Diameter (mm) Pole / Boom Condition Space Availability at Pole / Boom 17. Cable Ladder Information W900 Internal Cable Ladder External Cable Ladder Others Information:
Sector 1 N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
Sector 2 N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
Sector 3 N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A
Sector 1 N/A N/A N/A N/A N/A N/A N/A N/A N/A
Sector 2 N/A N/A N/A N/A N/A N/A N/A N/A N/A
Sector 3 N/A N/A N/A N/A N/A N/A N/A N/A N/A
15. 3G Antenna Information: W2100 Brand & Model Type of Antenna Sharing Antenna with Antenna Height (AGL) Antenna Azimuth Mechanical Tilt Electrical Tilt RRU CPRI Length RRU Power cable length Type of Jumper Type of Feeder Connector Type Jumper Length (m) Feeder Length (m) Model of TMA Model of RET Diplexer / Triplexer Brand & Model 16. 3G Antenna Pole / Boom Information: W2100 Pole/Boom Type ( Bipod / Tripod) Pole/Boom Height (m) Pole/Boom Diameter (upper/lower boom) (mm) Bracing Length (m) / Diameter (mm) Wall Mount / Floor Mount Arm Bracket Type / Length (m) Arm Boom Length (m) / Diameter (mm) Pole / Boom Condition Space Availability at Pole / Boom 17. Cable Ladder Information W2100 Internal Cable Ladder External Cable Ladder Others Information:
Sector 1 KATHREIN 742271 TRIBAND G900 32M 50 0 N/A N/A N/A 1/2" Superflex 7/8" 7/16 Male/Female 5m X 2 Pcs 50m X 2 Pcs ERICSSON N/A N/A
Sector 2 KATHREIN 742271 TRIBAND G900 32M 170 0 N/A N/A N/A 1/2" Superflex 7/8" 7/16 Male/Female 5m X 2 Pcs 50m X 2 Pcs ERICSSON N/A N/A
Sector 3 KATHREIN 742271 TRIBAND G900 32M 290 0 N/A N/A N/A 1/2" Superflex 7/8" 7/16 Male/Female 5m X 2 Pcs 50m X 2 Pcs ERICSSON N/A N/A
Sector 1 N/A N/A N/A N/A N/A T-BRACKET 0.5M OK NO Size 400mm 300mm
Sector 3 N/A N/A N/A N/A N/A T-BRACKET 0.5M OK NO Space Availability Available Available
Proposed Equipments Equipment Information Swap Type Swap Activity Equipment Type G900/W900 RF type G1800/L1800 RF type W2100 RF type L2600 RF type Type of Auxiliary Products Power Supply Information
DC Power Cable Length Grounding Cable total length AC Power Cable Length (OD Cabinet to AC source) Grounding Cable Length in total of (Outdoor Cabinet)
Cold Swap Hot Swap N/A G900 G1800/L1800 W900 W2100 L2600 DBS3900 BTS3900L BTS3900E MRFU MRFUd RRU3929 RRU3926 RRU3908 MRFU MRFUd RRU3929 WRFU RRU3829 LRFU RRU3229 APM SPB DDF Panel DCDU
Additonal Information:
Transmission Information
Type of Trunk Type of Connector (from BBU to DDF) BBU Trunk Cable(E1 between BBU and DDF) 2G Abis Quantity (PCS) Trunk Cable (E1) Trunk Cable (E1 between DDF and other operator DDF, if required) Type of Connector (for E1 between DDF and other operator DDF, if required) SPB Trunk Cable S1 IP Cable Length(FE cable) 75E1 L9(M) 10m
10m x 4 pcs
Not Available Not Available Not Available m 2G 3G LTE 1 unit/Optica l
Existing SFP module (Electrical/Optical - max length 100m) IP >100M use optical Configura <100m use FE tion
Additonal Information:
2G Antenna & Feeder Information (G/W900) Antenna height (AGL/m) Antenna Azimuth Antenna Mechanical Tilting Antenna Electrical Tilting No. of antennas (no) Brand & Model Type of Antenna Feeder Size Feeder Length Feeder Connector (Type and Qty) Type of jumpers Jumper Quantity Jumper Connector (Type and Qty) TMA RET Qty Diplexer/Triplexer/Combiner Brand&Model Sector 1 32m 50 0 N/A 1 Triband Reuse Existing
Reuse Existing Feeder
Reuse Existing 1/2" Superflex 4m x 2pcs N/A N/A Spiner Combiner Proposed CME Works
7/16 Male 2pcs/Female 2pcs 7/16 Male 2pcs/Female 2pcs 7/16 Male 2pcs/Female 2pcs
Sector 2
N/A N/A N/A N/A N/A N/A N/A N/A N/A
Sector 3
N/A N/A N/A N/A N/A N/A N/A N/A N/A
Add "H" Bracket Add "Y" Bracket (for MP & Tower site) Add Support
Others Information: Remark: 2012 - antenna reused and antenna new LMM antenna (GL1800/W900) 2013 - swap 2G antenna to LWW (GL1800 and W900 jumper swing to this antenna) and existing LMM (G900 jumper swing to this antenna)
2G Antenna & Feeder Information (G1800 / L1800) Sector 1 Sector 2 Sector 3 32m 32m 32m Antenna height (AGL/m) 50 170 290 Antenna Azimuth 0 0 0 Antenna Mechanical Tilting Antenna Electrical Tilting 1 1 1 No. of antennas (no) Triband Triband Triband Type of antennas Brand & Model Agisson ATR451606 Agisson ATR451606 Agisson ATR451606 Type of Feeder 7/8" 7/8" 7/8" 36m x 2pcs 36m x 2pcs 36m x 2pcs Feeder / CPRI Length 7/16" Female/Female 4pcs 7/16" Female/Female 4pcs 7/16" Female/Female 4pcs Connector (Type and Qty) 1/2" Superflex 1/2" Superflex 1/2" Superflex Type of jumpers 4mx2pcs 4mx2pcs 4mx2pcs Jumper Quantity 7/16" Male 8pcs 7/16" Male 8pcs 7/16" Male 8pcs Connector (Type and Qty) N/A N/A N/A TMA N/A N/A N/A RET Qty N/A N/A N/A Diplexer/Triplexer/Combiner Brand&Model Proposed CME Works Proposed Pole For Antenna (G1800/L1800) Sector 1
New Pole (Tower, MP, MT Site) Pole Bracket Add in New Wall Mounted (Rooftop Site) Add in New Bipod (Rooftop Site) Add in New Tripod (Rooftop Site) Add in New Mini Monopole (Rooftop Site) N/A N/A N/A N/A N/A N/A N/A N/A N/A
Sector 2
N/A N/A N/A N/A N/A N/A N/A N/A N/A
Sector 3
N/A N/A N/A N/A N/A N/A N/A N/A N/A
Add "H" Bracket Add "Y" Bracket (for MP & Tower site) Add Support
Others Information: Remark: 2012 - antenna reused and antenna new LMM antenna (GL1800/W900) 2013 - swap 2G antenna to LWW (GL1800 and W900 jumper swing to this antenna) and existing LMM (G900 jumper swing to this antenna)
Cable Ladder (G900/G1800/L1800) 200mm 300mm Inside Cabin (400mm) At Tower / MP / MP3 / BB (300mm) Other Information: Sector 1 N/A N/A N/A N/A Sector 2 N/A N/A N/A N/A Sector 3 N/A N/A N/A N/A
Grounding System (G900/G1800/L1800) Sector 1 Lightning Spike Grounding Cable to nearest Busbar EGB IGB N/A 16 mm X 20 m N/A N/A Sector 2 N/A 16 mm X 20 m N/A N/A Sector 3 N/A 16 mm X 20 m N/A N/A
Other Information: (Pls state if have any grounding replacement items with quantity)
Use Existing Feeder Inlet (space available) Propose New (Specify type, size and location)
Concrete Plinth
I-beam
C-Channel
Antenna & Feeder Information (W2100) Antenna height (AGL/m) Antenna Azimuth Antenna Mechanical Tilting Antenna Electrical Tilting No. of antennas (no) Brand & Model Type of Antenna Feeder Size Feeder Lenght Connector (Type and Qty) Type of jumpers Jumper Quantity Connector (Type and Qty) TMA RET Qty Diplexer/Triplexer/Combiner Brand&Model Sector 1 32m 50 0 N/A
1
Agisson ATR451606 Agisson ATR451606 Agisson ATR451606 Triband Triband Triband 7/8" 7/8" 7/8" 36m x 2pcs 36m x 2pcs 36m x 2pcs
7/16" Female/Female 4pcs 7/16" Female/Female 4pcs 7/16" Female/Female 4pcs
1/2" Superflex
2m x 2 pcs
1/2" Superflex
2m x 2 pcs
1/2" Superflex
2m x 2 pcs
Sector 2
N/A N/A N/A N/A N/A N/A N/A N/A N/A
Sector 3
N/A N/A N/A N/A N/A N/A N/A N/A N/A
Add "H" Bracket Add "Y" Bracket (for MP & Tower site) Add Support
Others Information: Remark: 2012 - antenna reused and antenna new LMM antenna (GL1800/W900) 2013 - swap 2G antenna to LWW (GL1800 and W900 jumper swing to this antenna) and existing LMM (G900 jumper swing to this antenna)
Cable Ladder (W2100) 200mm 300mm Inside Cabin (400mm) At Tower / MP / MP3 / BB (300mm) Other Information: Sector 1 N/A N/A N/A N/A Sector 2 N/A N/A N/A N/A Sector 3 N/A N/A N/A N/A
Grounding System (W2100) Sector 1 Lightning Spike Grounding Cable to nearest Busbar EGB IGB N/A 16 mm X 10 m N/A N/A Sector 2 N/A 16 mm X 10 m N/A N/A Sector 3 N/A 16 mm X 10 m N/A N/A
Other Information: (Pls state if have any grounding replacement items with quantity)
Use Existing Feeder Inlet (space available) Propose New (Specify type, size and location)
Concrete Plinth
I-beam
C-Channel
Summary: Existing vs Proposed (eg: equipment, CME) No 1 2 3 4 5 6 7 8 9 10 Existing H2M MOTOROLA RBS 3206 KATHREIN ANTENNA Proposed BTS 3900 L Agisson ATR451606 Triband Antenna 80A X 4 nos breaker MFRUd x 6 WFRU x 3
Remark: 2012 - antenna reused and antenna new LMM antenna (GL1800/W900) 2013 - swap 2G antenna to LWW (GL1800 and W900 jumper swing to this antenna) and existing LMM (G900 jumper swing to this antenna) LMM (G900 jumper swing to this antenna)
Don't leave it blank You can put 2 or 3 photo here Some access photo too.
Don't leave it blank You can put 2 or 3 photo here Some access photo too.
If Tower or Monopole site, put platform surrounding photo Don't leave it blank
If Tower or Monopole site, put platform surrounding photo Don't leave it blank
If Tower or Monopole site, put platform surrounding photo Don't leave it blank
If Tower or Monopole site, put platform surrounding photo Don't leave it blank
Exisiting 3G BBU/DCDU
N/A
N/A
N/A
Existing G900 equipment pwr tapping point at Rectifier/ACPDB or PDU photo You can put 2 or 3 photo here If unavailable, just put N/A
N/A
New BBU/DCDU
N/A
N/A
New BBU/BTS location Do put remark at the photo - Where to mount BBU - swap existing RBS DCDU- etc
4x 80A breaker location Do put remark at the photo - New Breaker -Reuse breaker - propose New DB box etc (Remark: If BTS3900E, mostly will reuse existing AC pwr supply) Proposed to swap 63A x 4 nos with 80A x 4 nos for new BTS 3900L
Proposed to install MRFUd for G900 sector 1 inside BTS3900L Do put remark at the photo, - where to mount - which sector -got New pole? BBU -If use BTS, just put BTS proposed location photo here DCDU -If use IFS, just put IFS proposed location photo here If unavailable, just put N/A
Proposed to install MRFUd for G900 sector 2 inside BTS3900L Do put remark at the photo, - where to mount - which sector -got New pole? -If use BTS, just put BTS proposed location photo here -If use IFS, just put IFS proposed location photo here If unavailable, just put N/A
Sector 3
Proposed to install MRFUd for G900 sector 3 inside BTS3900L Do put remark at the photo, - where to mount - which sector -got New pole? BBU -If use BTS, just put BTS proposed location photo here DCDU -If use IFS, just put IFS proposed location photo here If unavailable, just put N/A
Proposed to install MRFUd for L1800 sector 1 inside BTS3900L Do put remark at the photo, - where to mount - which sector -got New pole?BBU -If use BTS, just put BTS proposed location photo here DCDU -If use IFS, just put IFS proposed location photo here If unavailable, just put N/A
Proposed to install MRFUd for L1800 sector 2 inside BTS3900L Do put remark at the photo, - where to mount - which sector -got New pole? BBU -If use BTS, just put BTS proposed location photo here DCDU -If use IFS, just put IFS proposed location photo here If unavailable, just put N/A
Sector 3
Proposed to install MRFUd for L1800 sector 3 inside BTS3900L Do put remark at the photo,
- where to mount - which sector -got New pole?BBU -If use BTS, just put BTS proposed location photo here DCDU -If use IFS, just put IFS proposed location photo here If unavailable, just put N/A
Proposed to install WRFU for W2100 sector 1 inside BTS3900L Do put remark at the photo, - where to mount - which sector -got New pole?BBU -If use BTS, just put BTS proposed location photo here DCDU -If use IFS, just put IFS proposed location photo here If unavailable, just put N/A
Proposed to install WRFU for W2100 sector 2 inside BTS3900L Do put remark at the photo, - where to mount - which sector -got New pole? BBU -If use BTS, just put BTS proposed location photo here DCDU -If use IFS, just put IFS proposed location photo here If unavailable, just put N/A
Sector 3
Proposed to install WRFU for W2100 sector 3 inside BTS3900L Do put remark at the photo,
- where to mount - which sector -got New pole?BBU -If use BTS, just put BTS proposed location photo here DCDU -If use IFS, just put IFS proposed location photo here If unavailable, just put N/A
W2100 Sector 2
Proposed new AGisson ATR451606 triband antenna to be shared with G900, L1800 and W2100 for sector 1
Do put remark at the photo, - swap what antenna - which sector -reuse existing If unavailable, just put N/A
Proposed new AGisson ATR451606 triband antenna to be shared with G900, L1800 and W2100 for sector 2 Do put remark at the photo, - swap what antenna - which sector -reuse existing If unavailable, just put N/A
Proposed new AGisson ATR451606 triband antenna to be shared with G900, L1800 and W2100 for sector 3
Do put remark at the photo, - swap what antenna - which sector -reuse existing If unavailable, just put N/A
Photo must show the Number clearly. If unavailable, just put N/A
Photo must show the Number clearly. If unavailable, just put N/A
Sector 3
Photo must show the Number clearly. If unavailable, just put N/A
Photo must show the Number clearly. If unavailable, just put N/A
Photo must show the Number clearly. If unavailable, just put N/A
Sector 3
Photo must show the Number clearly. If unavailable, just put N/A
N/A
N/A
Sector 3
N/A
N/A
N/A
Sector 3
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Must show the port TX/RX clearly. If this sector is unavailable, just put N/A
Must show the port TX/RX clearly. If this sector is unavailable, just put N/A
Sector 3
Must show the port TX/RX clearly. If this sector is unavailable, just put N/A
Must show the port TX/RX clearly. If this sector is unavailable, just put N/A
Must show the port TX/RX clearly. If this sector is unavailable, just put N/A
Sector 3
Must show the port TX/RX clearly. If this sector is unavailable, just put N/A
N/A
N/A
Spare Breaker
CPRI Cable or Feeder routing photo You can put few photo here Highlight dotted line for cable routing
CPRI Cable or Feeder routing photo You can put few photo here Highlight dotted line for cable routing
E1 termination/DDF location.
FE cable from our new equipment to Existing Tranmission Do highlight which port to be connect, pointed the port
Existing IGB/EGB
You can put few photo here, do highlight if propose new IGB/EGB (Do put remark as Supply and install by Maxis)
You can put few photo here, do highlight if propose new IGB/EGB (Do put remark as Supply and install by Maxis)
Proposed IGB
Existing Inlet
Proposed inlet
Proposed Inlet
You can put few photo here, Highlight which inlet to be use. Do highlight if propose new Inlet and remark as Supply and install by Maxis
Vandalisme
N/A
Evidence
N/A
G900
W2100
G900
W2100
G900
W2100
G/W 900
G/W 900
G/W 900
G/L 1800
7/8"