Documente Academic
Documente Profesional
Documente Cultură
The mainMCT2E purpose of driver circuit is we have to enhance the swithching voltage for the mosfet or any switching device.And also we have to isolate the power circuit from the icrocontroller circuit.Because 1K GROUND the power circuit current must not enter into the microcontroller circuit.MCT2E is the optocoupler which will be connected to the buffer CD4050 which send pulse signals of 5 v from microcontroller to the driver circuit.MCT2E is the device which isolates the power circuit with the microcontroller 330 OHM OHM microcontroller it will get enhanced using the 2N2222 transistor circuit.After it gets the signal from100 thre 1K to higher level of voltage .after this the voltage 22 K 100get OHM regulated by the use of darlington pair.The darlington is made of 2N2222(NPN) and SK100 (PNP) transistor 100 OHM
G MCT2E GROUND 1K
F/25 A 00 m 10
330 OHM 1K 22 K
GROUND
1K
1K
100 OHM
1K
2N2222 CK100
330 OHM 100 OHM 1K 22 K 100 OHM G MCT2E 100 OHM
6.Resistors
GROUND
1K
F/25 A 00 m 10
8.10.Microcontrol Unit
VCC
40
C4 0.1uF
20
U2 P1_0 P1_1 P1_2 P1_3 P1_4 P1_5 P1_6 P1_7 1 2 3 4 5 6 7 8 10 11 12 13 14 15 16 17 P1.0 P1.1 P1.2 P1.3 P1.4 P1.5 P1.6 P1.7
R2 P0.0/AD0 P0.1/AD1 P0.2/AD2 P0.3/AD3 P0.4/AD4 P0.5/AD5 P0.6/AD6 P0.7/AD7 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 P0_0 P0_1 P0_2 P0_3 P0_4 P0_5 P0_6 P0_7 2 3 4 5 6 7 8 9 C
GND
VCC
VCC 1
SIP 9 1k
VCC
SW0 10uF C5
RST
EA/VPP ALE/PROG PSEN P2.7/A15 P2.6/A14 P2.5/A13 P2.4/A12 P2.3/A11 P2.2/A10 P2.1/A9 P2.0/A8
9 18 19 C7 33PF
Inverter circuit