Documente Academic
Documente Profesional
Documente Cultură
S S BR E C E I V E RS E N S I T I V I T Y
CB RF TUilEN
v
t-r r-t rt = Ft 11
t_t t_t t_t t_. Lt l_,
r zr fi-ll-lfl zoro
RF.IF GENERATOR
:::@: .4.
'P'^'*,*-*a,r'
trl
s/f{ cHtcK
M I C N O V O L TO U T P U T P U S Hf O N N O I S I R f I
Xl|)
.
Xl00
. 4 4
q SPEAKER SUB
r^',B,5lllil,.i{.,r"
*r "*"@
The EIA defines receiver sensitivity as the point audio cable. Set the SPEAKER SUB control for
where the sigrral plus noise (S+N) is 10 dB greater the same impedance as the output of the
than the noise (N) of the receiver. The formula for receiver.
sensitivity
- is - ^ -_ (S+N)
10 dB: _ 4. Set clarifier by performing General SSB Receiver
(N) Test.
To test for receiver sensitivity:
1. Supply the proper power to the SSB receiver. 5. Set the receiver's function switch to LSB.
2. Connect the output of the CB42's RF-IF OUT-
PUT jack to the antenna input of the receiver 6. Set the DIGITAL READOUT SELECTOR to
using the supplied RF cable. the AUDIO WATTS position.
3. Connect the receiver audio output to the 7. Set the MICROVOLTS OUTPUT controls to
SPEAKER SUB input jack using the supplied provide 1 uV of signal (x.1 and 10).
36