Documente Academic
Documente Profesional
Documente Cultură
Continue to decreasethe MICROVOLTSOUT- If the receiver meets or exceeds the EIA specifica-
PUT controls until the DIGITAL READOUT tions, the settings of the MICROVOLTS OUTPUT
indicates0.25. This point is -16 dB from the controls should be lessthan or equal to the sensitivity
originalreadingat 50,000 uV. point found with the SSB Receiver Sensitivity Test.
S S BR E C E I V E RS O U E L C H
CB RF TUNER
v
z{J-1T}..
6li6j1)
vYl;/ S
r-1 l-r l-t =l l-t t1
Lr Lr l_t l_.Lt Ll
\lj_:_i-l
r zt f..I-Jl-lfl zaoo
o
WATTS
RF-IF GENERATOR D I G I T A L R E A O O U TS E L E C T O R
,r-r@.
SIGNALS MOOEL O I G I T A LR E A D O U TI N P U T S I G N A T S
ca42 sPtAxtn
sut
otf 0N
m
Fig. 42-Control setup /or SSB squelch test.
This test indicates the point at which the squelch 6. Set the receiver's squelch control to the mini-
circuit opens when set to the maximum squelched mum squelched (open) position.
position.
7. Set the DIGITAL READOUT SELECTOR to
To test for squelch operation: the AUDIO WATTS position.
1. Supply the proper power to the CB receivers. 8. Set the MICROVOLTS OUTPUT controls to
provide 50 uV of signal (x10 and 5).
2. Connect the output of the CB42,s RF-IF OUT-
PUT jack to the antenna input of the receiver 9. Set the RF-IF CONTROL switch to the LSB
using the supplied RF cable. position.
39