Documente Academic
Documente Profesional
Documente Cultură
Difficulty: ***** super-complex Recommended starting size: 20 inches (50 cm) Finished size: 5 1/2 inches tall (14 cm) Expected time needed to fold: 7 hours
7. Kite-fold behind.
13. Unfold.
26. Fold and unfold into thirds, crease through all layers.
45
34. Fold and unfold the top layers into sixths. Use the previous creases to help with alignment.
41. Open-sink in and out on existing creases. The creases do not need to extend to the edge, but are drawn that way in the next steps.
46. Unfold.
48. Sink (spread-sink and close back up) the small corner.
51. Open-sink.
52. Squash-fold.
53. Petal-fold.
54. Open sink the edge in and out and flatten completely.
42-55
63. Fold the assembly of layers to the left, the model will not lie flat. Repeat behind.
64. Fold the top edge down so that it points straight out. Repeat behind.
65. Pull the top layer up while squeezing the sides in extending a central mountain-fold.
68. In progress.
70. Reverse-fold in and out. These flaps will not lie flat for some time to come.
71. Sink in and out on existing creases. The sinks must be performed simultaneously and form accordion-like folds at the base.
75. Unfold.
73-77
85. Squash-fold.
87. Squash-fold.
88. Petal-fold.
92. Squash-fold.
87-91
94. Squash-fold.
95. Petal-fold.
97. Squash-fold.
103. Mountain-fold the top layer and valley-fold the second one.
115. Reverse-fold
114-117 114-117
116. Reverse-fold.
117. Reverse-fold.
122. Carefully release the top layer and bring it to the right.
123. Pull the top layer down, you will need to release some paper at the neck.
124. Close back up, incorporating two reverse-folds at the base of the wing.
126. Sink in on existing creases. This is a litte more complicated, so check out the next step for details.
135. Mountain-fold the lower edge of the wing and reverse-fold the edge above.
136. Closed-sink the bottom edge and reverse-fold the other one into the new pocket.
120-138 114-118
x12
142. Sink the second layer on the side and pull out some paper below.
144. Open-sink.
145. Spread-sink.
147. Open-sink.
142-145
142-155
x6
161. Open-sink.
163. Push the sides in on existing creases and swing the long flap up.
166. Open-sink.
158-164
174. Reverse-fold the next point to the right as you fold some layers down.
158-176
90
193. Push the sides in and swing the long flap to the right.
185-195
200. In progress. Pull a loose edge out and flatten it to the right.
201. Swivel the edge as you swing the large flap to the left.
204. Squash-fold.
204-207
211. Fold to the sides while incorporating a tiny reverse-fold on the first layer (skip the reverse -fold if the figure is too small).
90
216. Fold the model back in half and rotate counterclockwise 90.
222. Fold the edge of the wing inward and zoom in.
222-224
224. Reverse-fold the claw on the wing, fold it down, and shape the wings further.
227. Squeeze the arms in and crimp (or pleat) the legs.
228. Crimp the arms and spread out the claws. Repeat similarly on the legs.
232. Add a couple rabbit-ears for spikes and shape the model to taste.