Documente Academic
Documente Profesional
Documente Cultură
Vehicle identification
No. of cylinders Capacity (Fiscal) Compression ratio Suitable for unleaded petrol Minimum octane rating Ignition system Ignition system Ignition system Trigger location Fuel system Fuel system Fuel system Air metering Combined ignition and fuel ECM Diagnostic socket Type 4/DOHC cc 1364 :1 10,5 Yes RON 91 Make Bosch Type Motronic ME7.6.1/2 Description Map-DI Cam / Crankshaft Make Bosch Type Motronic ME 7.6.1 Description MFI-s Type Mass Yes Yes
Ignition system
Ignition coil supply voltage Firing order + with ballast V 12,0 1-3-4-2
Spark plugs
Spark plugs Spark plug Electrode gap Spark plugs Spark plug Electrode gap Original equipment Bosch Type FQR8LEU2 mm 0,85-0,95 Make Bosch Type FQR8LEU2 mm 0,85-0,95
Fuel system
System pressure bar 3,6-4,0
Thermostat opens
C 92
Tightening torques
Cylinder head instructions Cylinder head Renew bolts Yes Stage 1 Stage 2 Stage 3 Stage 4 Other engine tightening torques Main bearings 107 Main bearings Big end bearings 222 Big end bearings 133 Sump bolts 126 Sump drain bolt 108 Flywheel/driveplate Clutch pressure plate Crankshaft pulley/damper centre bolt 109 Camshaft sprocket/gear Camshaft carrier/cap Camshaft/rocker cover Inlet manifold to cylinder head 3 3 3 Exhaust manifold to cylinder head Exhaust downpipe to manifold Water pump Spark plugs Fuel rail Crankshaft position (CKP) sensor/engine speed (RPM) sensor Camshaft position (CMP) sensor Engine coolant temperature (ECT) sensor Lambda sensor (Oxygen) Knock sensor (KS) Engine oil pressure switch Oil filter Chassis tightening torques 219 Front hub 8 Nm 8 Nm 10 Nm 15 Nm 20 Nm 8 Nm 25 Nm 8 Nm 8 Nm 6 Nm 18 Nm 40 Nm 20 Nm 20 Nm 15 Nm 15 Nm 150 Nm+45 Renew bolts/nuts Yes Stage 1 Renew bolts/nuts Yes Stage 1 Tighten 25 Nm Tighten 60 Tighten 60 Tighten 60
3 3 3
Front hub - wheel bearing housing bolts Rear hub - wheel bearing housing bolts Steering track rod end Brake disc to hub Brake caliper to carrier Brake caliper carrier to hub Brake disc to hub Brake caliper to carrier Brake caliper carrier to hub
90 Nm+30+15 50 Nm+30+15 20 Nm 50 Nm Front 7 Nm Front 25 Nm Front 100 Nm Rear 7 Nm Rear 25 Nm Rear 100 Nm 110 Nm
Air conditioning
No. of AC service connectors Air conditioning restrictor type Air conditioning refrigerant Air conditioning refrigerant quantity Air conditioning oil Air conditioning oil quantity Air conditioning oil viscosity 2 Expansion valve Type R134a grams 600 Type Dens Oil 8 cm 150 ISO 46
Autodata Note 158 Gearbox oil type F13/23/35 = Opel No. 93 165 290 F17 = Opel No. 90 540 998 Autodata Note 157 Gearbox capacity F13 + F17 = 1,6 litres F18 = 1,8 litres F23 = 1,75 litres. Autodata Note 107 Main bearings M8 Use new bolts and tighten in the following stages: 1) 25 Nm 2) 60 M6 Use new bolts and tighten in the following stages: 1) 10 Nm 2) 60.
Manufacturer: Vauxhall/Opel Engine code: Z14XEP Tuned for: R-Cat Model: Astra-G 1,4 Output: 66 (90) 5600 Year: 2003-06 Autodata Limited 2010 Valid forever. 26-May-13 V8.500-
Autodata Note 222 Big end bearings M6 Use new bolts and tighten as follows: 1) 10 Nm 2) 60 3) 15 M6.5 Use new bolts and tighten as follows: 1) 13 Nm 2) 60 3) 15. Autodata Note 133 Sump bolts Sump to cylinder block = 10 Nm Sump to transmission = 40 Nm. Autodata Note 126 Sump drain bolt Torx bolt = 10-15 Nm Hexagonal bolt = 45-55 Nm. Autodata Note 108 Flywheel Use new bolts and tighten in the following stages: 1) 35 Nm 2) 30. Autodata Note 109 Camshaft sprocket Use new bolts and tighten in the following stages: 1) 50 Nm 2) 60. Autodata Note 3 Use new nuts/bolts.
Autodata Note 219 Front hub Use new nut and tighten as follows: 1) 120 Nm 2) Slacken off 3) 20 Nm + 80 4) If necessary, turn nut further to align split pin. Autodata Note 214 Use new nuts/bolts. Apply locking fluid.
Road wheels Lightly coat conical seat of bolt and mating surfaces between wheel centre hole and hub (use grease). Do NOT lubricate bolt thread.
Cylinder layout
Tightening sequence