Documente Academic
Documente Profesional
Documente Cultură
‘How-to’ guides
Date: 7 June 2009 Title: Changing the Timing Belt on a RB25DET &RB25DE
Written by: seastate of Nissan Stagea Owners Club
Tools you will need:Basic hand tools, pulley puller.
Parts you will need (Nissan part no’s):
Idler Pulley N1307458S00
Tensioner Pulley NAY460NS010
Timing Belt N1302820P25
Crank sensor O ring N2213158S10
1./ Remove the battery 2/ Remove the air inlet 3/Remove the under-tray
5./ Undo the clip and pull off the lower coolant pipe .
10./ And finally remove the two oil cooler pipes at the
bottom of the radiator. Have something handy to plug
the pipes to stop oil dribbling out. I used a couple of
8mm bolts with a bit of tape on them.
13./ Remove the fan/alternator, power steering and aircon compressor belts
You don’t have to use the Nissan one, any pulley puller
will do. The crank has two 6mm screw holes set 75mm
apart.
NOTE: The washers have a particular order (as shown in the pics below)
26./ To tension the belt, replace the Crank Pulley bolt and use it to turn the crank clockwise twice with the
Tensioner Pulley still loose.
27./ Replace the Crank Pulley Plate and the lower timing belt cover.
28./ Replace the Crank Pulley and bolt and tighten it up. NOTE: The washer goes with the flat face towards the
Crank Pulley
Make sure it can spin freely. If not loosen the timing belt
cover screws and move the cover around a bit.
NOTES: