0 evaluări0% au considerat acest document util (0 voturi)
7 vizualizări0 pagini
INEOS HDPE T50-500 is a high density polyethylene copolymer having a narrow molecular weight distribution. It is intended for injection molding applications where a good balance of processability and end-use properties are required. This material meets the Food and Drug Administration requirements of 21CFR 177.1520.
INEOS HDPE T50-500 is a high density polyethylene copolymer having a narrow molecular weight distribution. It is intended for injection molding applications where a good balance of processability and end-use properties are required. This material meets the Food and Drug Administration requirements of 21CFR 177.1520.
Drepturi de autor:
Attribution Non-Commercial (BY-NC)
Formate disponibile
Descărcați ca PDF, TXT sau citiți online pe Scribd
INEOS HDPE T50-500 is a high density polyethylene copolymer having a narrow molecular weight distribution. It is intended for injection molding applications where a good balance of processability and end-use properties are required. This material meets the Food and Drug Administration requirements of 21CFR 177.1520.
Drepturi de autor:
Attribution Non-Commercial (BY-NC)
Formate disponibile
Descărcați ca PDF, TXT sau citiți online pe Scribd
INEOS Olefins & Polymers USA Page 1 of 1 Copyright 2009 - IDES - The Plastics Web | 800-788-4668 or 307-742-9227 | www.ides.com. The information presented on this datasheet was acquired by IDES from the producer of this material. IDES makes substantial efforts to assure the accuracy of this data. However, IDES assumes no responsibility for the data values and encourages that upon final material selection, data points are validated with the material supplier. Revision History Document Created: Friday, December 18, 2009 Added to Prospector: November, 1995 Last Updated: 7/6/2007 Product Description T50-500 is a high density polyethylene copolymer having a narrow molecular weight distribution. It is intended for injection molding applications where a good balance of processability and end-use properties are required. This material meets the Food and Drug Administration requirements of 21CFR 177.1520. This resin is Kosher certified. General Material Status Commercial: Active Availability North America Features Copolymer Food Contact Acceptable Good Processability High Density Kosher Approved Narrow Molecular Weight Distribution Agency Ratings FDA21 CFR 177.1520 RoHS Compliance Contact Manufacturer Forms Pellets Processing Method Injection Molding Physical Nominal Value Unit Test Method Density 0.953 g/cm ASTM D4883 Melt Mass-Flow Rate (MFR) (190C/2.16 kg) 6.0 g/10 min ASTM D1238 Environmental Stress-Cracking Resistance ASTM D1693B F50 6.50 hr Mechanical Nominal Value Unit Test Method Tensile Strength 2 (Yield) 26.9 MPa ASTM D638 Tensile Elongation 2 (Break) 800 % ASTM D638 Flexural Modulus - Tangent 1280 MPa ASTM D790 Impact Nominal Value Unit Test Method Notched Izod Impact 64.0 J/m ASTM D256 Hardness Nominal Value Unit Test Method Durometer Hardness (Shore D) 65 ASTM D2240 Thermal Nominal Value Unit Test Method Deflection Temperature Under Load ASTM D648 0.45 MPa, Unannealed 81.0 C Brittleness Temperature -75.0 C ASTM D746 Vicat Softening Temperature 128 C ASTM D1525 Additional Information Brittle Temperature, ASTM D746: < -103F Notes 1 Typical properties: these are not to be construed as specifications. 2 51 mm/min