Documente Academic
Documente Profesional
Documente Cultură
Step 1: Set up your Personal Computer (PC) or laptop to receive data. (Click here for information on RS232 setup) Step 2: Punch out NC Parameters as follow Select EDIT mode. Select PARAMETER screen (by pressing PARAM/DGNOS key once). Press and hold EOB key while pressing OUTPUT START. * Note: OUTPUT will flash in the lower right-hand corner and NC parameters will be output. Step 3: Punch out PMC Parameters as follow Select EDIT mode. Select DIAGNOSTICS screen (by pressing PARAM/DGNOS key twice). Press OUTPUT START. Step 4: Punch out all NC Programs as follow Make sure parameter no. 10 bit#4 = 0 (unprotect programs 9000 ~ 9999) Select EDIT mode. Select PROGRAM Memory screen. Key in O-9999. Press OUTPUT START. Step 5: Punch out Offsets as follow Select EDIT mode. Select OFFSET screen. Press OUTPUT START. Step 6: Punch out Macro Variables as follow *Note: Depending on the CNC software version, macro common variables (#500 to #999) can be output. However, common variables #100 to #199 cannot be output. It is best to write them down, rather than outputting them. Select EDIT mode. Select Macro Variable screen. Press OUTPUT START. (Variables will be output in program format.)
Page 1 of 3
Alarm 000 Please turn power off message will appear once parameters are loaded. Power OFF/ON. Step 7: Input PMC Parameters as follow: Select EDIT mode. Select DGN screen. Hold EOB and press INPUT. Step 8: Input NC Programs as follow: Select EDIT mode. Select PROGRAM Memory screen. Verify Program Protect Key is OFF. Press INPUT. Step 9: Input Offsets as follow: Select EDIT mode. Select PROGRAM Memory screen. Verify Memory Protect Key is OFF. Press INPUT. Run this program to write data to OFFSET screen.
Page 3 of 3