Documente Academic
Documente Profesional
Documente Cultură
Elementary workshop on
COMPUTER CONTROLLED WIRELESS SYSTEM
“SPYBOT”
MINILAB CONTENT:-
1. BOX
2. WIRELESS CAR
3. PARALLEL PORT
4. 10 LED,10 REG,5 DIODE
5. PCB
6. SOLDRING IRON,SOLDER WIRE,FLUX
7. WIRE STRIPPER
8. STAR SCREW DRIVER
9. INSULATION TAPE
10. MULTI METER
RULES:-
• Please check your minilab kit as listed above. Required components and tools are
included as per this workshop.
• Do no tampering with the components and tools without instructions.
• Keep safeyour components, missing and destroyed component not be responded by us.
• Do not ground yourself while soldering, and other time you should grounded.
• Every time use solders flux while soldering and do not use more solder wire while
soldering.
• Please listen every point carefully & work as per instruction, don’t go forward.
• Do not waste battery.
• Please keep silence & maintain discipline.
Parallel Port is same as the printer port in the back side of computer. Parallel Port Interfacing is
the simplest method of interfacing. Now parallel port interfacing is used for programming
microcontrollers and hobby circuit.
Parallel port
Parallel Port interfacing is the simplest method of interfacing. So it is widely used. The main
problem with parallel port interfacing is that it has data transfer speed up to 1Mbytes/sec. USB
interfacing are Available having speed near to 12MBytes/sec.
L.P.T. port contain 8 data pin these can be used to autonomous any system as your requirement.
HERE 8 PIN are used for LED D.J. lightning. & any four pin is used for transmission of data.
For Improvement & Research In Science & Technology
CONNECTION ON PCB:-
+ D
R R R R R R R R TO
TRANSMIT
TER
CIRCUIT
_ GND
LPT
1. Made the connections for the LED. Lightning.
2. First four pin connect to the (GROUNG ENABLE) switch of the remote control VIA
DIODE.
3. Install “user port” and do the program in “c” language.