Documente Academic
Documente Profesional
Documente Cultură
Answer any ONE question form Part A and THREE from Part B
Use of IS code is permitted
___
PART A
1. a) Design a welded plate girder to carry a superimposed load of 50 KN/m. The span
of the girder =25m. Design cross section, connection and curtailment.
b) Sketch the longitudinal section and cross section of the girder. Show typical
arrangement of stiffness. [24+8]
Part –B
3. a) Write about various butt welds and explain the throat thickness and permissible
stresses for butt welds.
b) Design a lap joint to carry a load of 5000 kN. The plates are 150 × 8mm and
200 × 8mm. The lap length of the plates should not exceed 150mm. [4+12]
Contd..2
Code No: 310107 -2- NR
6. A steel column 12 m long and carries an axial load of 1500KN. The column is
hinged at both the ends. Design an economical built up section, with double
lacing. Design the lacing also. [16]
*****