Documente Academic
Documente Profesional
Documente Cultură
Presenta:
PROGRAMACION DE CONTROLE REMOTO, CODIGO DE COLORES.
Realizado por:
www.seguridadautomotriz.com.mx
Edicin Enero 2009
PROGRAMACIN
1. PARA MODELOS 1997. 2. LOCALICE EL CONECTOR DE DIAGNOSTICO (DLC). 3. GIRE EL SWITCH A ON. 4. REALICE UN PUENTE CON FUSIBLE ENTRE LA TERMINAL 1 Y TIERRA. 5. LOS SEGUROS CIERAN Y ABREN INDICANDO QUE ESTA EN PROGRAMACIN. 6. PRESIONE CUALQUIER BOTON DE LOS CONTROLES A PROGRAMAR. 7. LOS SEGUROS CIERRAN Y ABREN INDICANDO QUE ACEPTO EL CONTROL. 8. REPITA LA OPERACIN ANTERIOR PARA EL SEGUNDO CONTROL. 9. RETIRE EL PUENTE ENTRE EL ARNES Y TIERRA.
6. PRESIONE UN BOTON DE LOS CONTROLES A PROGRAMAR. 7. ESCUCHARA UNA SEAL ACUSTICA DE CADA CONTROL PROGRAMADO. 8. GIRE EL SWITCH A OFF O ESPERE 30 SEG. PARA SALIR DE PROGRAMACIN. 9. UNA SEAL ACUSTICA CONFIRMA LA SALIDA. 10.SOLO SE PUEDEN PROGRAMAR 4 CONTROLES COMO MXIMO. 11.SE PUEDEN PROGRAMAR LOS CONTROLES CON EQUIPO DE DIAGNOSTICO. CODIGO DE COLORES:
MODEL YEAR(S)
RAM FULL SIZE PICKUP 2002 -2003 TKEY IMMOBILIZER HARNESS CHRY KEYCHRYSLER'S SENTRY ANTI-THEFT TRANSPONDER System (GRAY IGNITION KEY), Requires 791 Bypass Module and Extra N/A 1 Ignition Key PART 12 VOLT CONSTANT STARTER STARTER 2 IGNITION 1 IGNITION 2 IGNITION 3 ACCESSORY/HEATER BLOWER 1 ACCESSORY/HEATER BLOWER 2 KEYSENSE COLOR PINK/BLACK (+) YELLOW (+) N/A BLUE (+) 16 Gauge wire, See NOTE *4 RED/WHITE (+) 16 Gauge wire, See NOTE *4 N/A GREEN (+) See NOTE *5 ORANGE (+) See NOTE *5 N/A IGNITION SWITCH HARNESS IGNITION SWITCH HARNESS IGNITION SWITCH HARNESS IGNITION SWITCH HARNESS LOCATION IGNITION SWITCH HARNESS IGNITION SWITCH HARNESS DIAGRAM
PARKING LIGHTS ( - )
PARKING LIGHTS ( + )
BLACK/YELLOW (+)
@ RELAY UNDER HOOD, at POWER CENTER IN DRIVERS KICK PANEL, in DOOR HARNESS, heading to REAR of vehicle, See DAIGRAM 26500_RAM-FULLSIZE-PICKUP_DODGE RAM 1 WIRE JBS UNITS.pdf 26500_RAM-FULLSIZE-PICKUP_DODGE RAM 1 WIRE ALERT SHELBY UNITS.pdf
POWER LOCK
POWER UNLOCK
See DIAGRAMS
IN DRIVERS KICK PANEL, at DOOR HARNESS 26500_RAM-FULLSIZE-PICKUP-_(-) NEGATIVE DOOR PIN ISOLATION CIRCUIT.pdf See NOTE *3
DOOR TRIGGER
See NOTE *3
DOMELIGHT SUPERVISION TRUNK RELEASE SLIDING POWER DOOR HORN TACH WAIT TO START LIGHT BRAKE
TAN (-), Requires #775 Relay N/A N/A BLACK/RED (-) ANY wire NOT DARK GREEN/ORANGE See NOTE *6 WHITE/TAN (+)
ANTI-THEFT
NOTE *1 the (-) Negative PARKING LIGHTS on this vehicle will require a (-)Negative thru a 330 or 1400 Ohm Resistor and an extra Relay part #775, to connect, See DIAGRAM
NOTE *2 the Door Locking System is a 1-Wire, to LOCK requires a (-)Negative thru a 820 Ohm Resistor and to UNLOCK requires a (-)Negative thru a 330 Ohm Resistor, some units require 2 extra relays part #775, to connect, See DIAGRAM
NOTE *3 the DRIVERS DOOR is a TAN (-), the DRIVERS REAR DOOR is a TAN/ORANGE (-) or a PURPLE/ORANGE (-), these wires are in the DRIVERS KICK PANEL. The PASSENGE DOOR is a TAN/RED (-) and the PASSENGER REAR DOOR is a TAN/YELLOW (-), these wires are in the PASSENGER KICK PANEL. When connecting to an ALARM SYSTEM, use all 4 DOOR TRIGGER wires and DIODE ISOLATE. to connect, See DIAGRAM
NOTE *4 use the BLUE 16 Gauge wire as IGNITION #1, DO NOT use the HEAVY GAUGE BLUE wire for IGNITION #1. The Ignition #2 wire, RED/WHITE, is also 16 Gauge, there will be (2) RED/WHITE wires of the same gauge in the Ignition Switch Harness, one wire will test 12 Volts constant all the time and the other will test as Ignition #2, only use the wires that tests like an Ignition wire.
NOTE *5 When connecting to a Remote Starter, connect the Accessory wire from the unit to both the GREEN (+) Accessory #1 wire (Large Gauge wire) and the ORANGE (+) Accessory #2 wire (16 Gauge wire) in the Ignition Switch Harness.
NOTE *6 the DIESEL tach wire is a GRAY/BLACK in the BLACK plug at the PCM (Powertrain Control Module)
NOTE *7 the DISARM wire requires a (-) Negative thru a 480 Ohm Resistor and an extra relay part #775, to connect, See DIAGRAM
Ms informes: ventas@seguridadautomotriz.com.mx www.seguridadautomotriz.com.mx MSN: jc.audio@hotmail.com Skype: jc2924 Tel: 01 (722) 492-7610 ID NEXTEL: 62*11*9719 Atte. Juan Carlos Martinez Director General Seguridad Automotriz ((((ASISA))))
SEGURIDAD AUTOMTORIZ no ser responsable de ningn tipo de dao, intencional o de otra manera, causado por los usos de las instrucciones y de la direccin de programacin, SEGURIDAD AUTOMOTRIZ no ser responsable de ningn tipo de dao.