Documente Academic
Documente Profesional
Documente Cultură
SECTION-A Attempt ALL parts of following. QUES-1. Define metrology and also explain it necessity and importance? QUES-2. Discuss briefly the following a) Line Standard b) End Standard c) Wave Length Standard QUES-3. Define the following a) Nominal size b) Basic dimension c) Tolerance d) Upper deviations e) Allowance with neat sketch.
QUES-4. Define the fits. Calculate fundamental deviation and tolerance and hence the limit of size for the shaft and hole for the following fit.60H8h7.
SECTION-B Attempt ALL parts of following. QUES-6. Explain the following: a) Snap/ plug gauges b) Ring gauges
QUES-7. Discuss the working of Sigma Comparator / Johansson Mikrokator with neat sketch. QUES-8. Explain the following terms I)Straightness ii)flatness III)Squareness IV)Roundness QUES-9. Write short note on Autocollimator with neat Sketch. QUES-10. For each of the following hole and shaft assembly, find shafttolerance, hole tolerance, and state whether the type of fit is clearance ,transition or interference. b) HOLE: 50+0.25+0.00 mm , SHAFT: 50+0.05 +0.005 mm , SHAFT: 30-0.02+0.05 mm , SHAFT: 25+0.06+0.04 mm