Documente Academic
Documente Profesional
Documente Cultură
Introduction
Some liquids like petrol, alcohol, water etc. flow more freely than honey, glycerin, oil
etc. This is due to the property of the liquid called viscosity by virtue of which the
liquid opposes the relative motion between its different layers. It is analogous to
friction between solid surfaces, except that it comes into play only when the fluid
flows. Viscosity is estimated in terms of coefficient of viscosity. Poiseuille’s method
is used to determine the coefficient of viscosity where liquid flows through the
capillary tube at different pressures.
I O D
F
To sink
A B
To tap
Q
l
Figure 1: Poiseuille’s apparatus
In this section we will use the Poiseuille’s apparatus to study the linear and nonlinear
flow of water through the capillary tube and use the data to determine the coefficient of
viscosity of water at room temperature.
Apparatus
• Poiseuille’s apparatus
• Travelling microscope
• Measuring cylinder
• Stop watch.
• Thermometer
Theory
Consider a liquid flowing over a fixed horizontal surface. Each layer of the liquid moves
steadily, parallel to the fixed surface, as long as the motion is slow. The velocity of
different layers of the liquid is different and increases with distance from the fixed
surface (Figure 2). This kind of flow is called laminar or streamline. In case of a liquid
flowing in a tube / capillary, the axial stream is moving with a definite velocity and the
layer in contact with the wall of the tube is at rest (provided the pressure difference
causing the flow is not too great) (Figure 3).
If the pressure difference exceeds a certain limit, the liquid departs from its streamline
and the flow becomes turbulent (Figure 4).Generally in the capillary tube, liquid flow is
laminar. However, when the flow becomes faster, laminar flow gets disrupted and
becomes turbulent. When this occurs, liquid does not flow linearly and smoothly in
adjacent layers, but instead the flow can be described as being chaotic.
A Layer in motion B
C Stationary layer D
dr
r
Figure3: Cross-sectional view of the capillary tube
Laminar
flow
Turbulent
flow
Rate
of
Flow
Reynolds number
exceeded
Pressure Difference
In case the flow remains streamline, the motion is such that any two adjacent layers tend
to destroy their relative motion as if there is a backward dragging tangential force. An
external force is required to overcome this backward drag and to maintain the relative
velocity between different layers of the liquid. According to Newton, the backward
tangential force F on any layer is directly proportional to area A and velocity v of the
layer at a distance x above the surface and inversely proportional to x.
Aν
Fα
x
ηAν
F =− ,
x
(F and v are in opposite directions).
Alternatively,
dν
F = − ηA , (1)
dx
where η is the constant of proportionality called the coefficient of viscosity and dv/dx is
the rate of change of velocity with distance, called the velocity gradient. The value of η
depends on the nature of the liquid. According to Equation (1), the coefficient of
viscosity can be defined as the tangential force per unit area required to maintain a unit
velocity gradient in the liquid.
Consider a liquid flowing through a horizontal capillary tube of internal radius r and
length l. If the flow is streamline, then the volume V of the liquid that flows out per
second under a steady pressure difference P between ends of the tube is given by
π Pr 4
V = .
8lη
This implies
π Pr 4
η= (2)
8lV
This relation is known as Poiseuille’s equation and can be utilized to determine the
coefficient of viscosity by measuring P,r,l and V. If P is expressed in dynes per cm2, r and
l in cm, V in cm3 / sec, then η is determined in dynes sec/cm 2 or poise. If h is the
difference in heights of the free surface of the liquid at the two ends of the capillary tube
and ρ is the density of the liquid, then
P = hρg (3)
Hence from Equations (2) and (3), we get
π hρgr 4
η= . (4)
8lV
Using Equation (4), coefficient of viscosity of water is determined. This is true in case of
streamline motion.
Turbulence does not begin to occur until the velocity of flow becomes high enough that
the flow lamina breaks apart. Therefore, as liquid flow velocity increases, there is not a
gradual increase in turbulence. Instead, the transition between laminar and turbulent flow
is often indicated by a critical Reynolds number. The equation for Reynolds number is
vdρ
R=
η
where v = mean velocity, d = tube/capillary diameter, ρ = density of liquid,
and η= coefficient of viscosity of the liquid.
Learning Outcomes
Pre-Lab Assessment
Procedure
left right
d
lower
Figure 5: Cross-sectional view of the bore of the capillary tube
Observations
Table 3: For determination of diameter of the capillary along the vertical direction
Calculations
1. Using Table 3, draw a graph (Figure 4) between rate of flow, V in cc/sec and the
difference of levels, h in cm (pressure difference).
2. The straight line portion of the graph indicates the streamline flow at low pressures
(linear flow). The curved portion of the graph depicts turbulent flow (nonlinear flow).
3. Calculate the slope of the straight line portion of the graph.
4. Substitute the values of r, ρ, g, l and slope in the Equation.(4) and calculate the
coefficient of viscosity, i.e.,
π hρ g r4
η=
8V l
π ρ gr 4 1
= ×
8l slope
Calculation of % error
Estimation of error
π Pr4
η=
8V l
π h ρ g r4
=
8V l
π (h1 − h2 )ρ g r 4
=
8V l
By logarithmic differentiation,
Result
Glossary
Constant level water tank: This is a set up to maintain a constant pressure by keeping
the level of water in a tank, constant, through continuous flow of water.
Critical velocity: The critical velocity is that velocity of liquid flow, up to which its flow
is streamlined and above which its flow becomes turbulent.
Density: This is the mass of a substance occupying unit volume.
Dragging force: This is the force which opposes the relative motion between the
adjacent layers of liquid.
Laminar flow: A flow in which liquid moves in layers is called a laminar flow.
Manometer: A manometer is a device which indicates the difference between two
pressures or between a single pressure and atmospheric pressure. It is a U-shaped glass
tube filled with some liquid like water or mercury.
Poise: Poise is unit of coefficient of viscosity in CGS units. A liquid has a coefficient of
viscosity of one poise if a force of one dyne is required to maintain a unit velocity
gradient between the layers of area one sq. cm. each.
Reynolds number: A dimensionless number which depends on viscosity , density of
liquid, diameter of the vessel and the velocity of liquid flow. It signifies the transition
from laminar to turbulent flow of the liquid.
Streamline flow: The streamline flow of a liquid is that flow in which every particle of
the liquid follows exactly the path of its preceding particle and has the same velocity in
magnitude and direction as that of its preceding particle while crossing through that point.
Turbulent flow: When a liquid moves with a velocity greater than its critical velocity,
the motion of the particles of liquid becomes irregular. Such a flow is called turbulent
flow.
Traveling microscope: Traveling microscope is an instrument used to measure the
length with a resolution of about 0.05-0.1mm.The purpose of this is to aim at reference
marks with higher accuracy.
Velocity gradient: The rate of change of velocity with distance is called velocity
gradient.
Viscosity: The property of a liquid, which indicates how resistant that liquid is to flow, is
called viscosity. It is estimated in terms of coefficient of viscosity (η). The unit of
coefficient of viscosity is poise or deca poise.
Post-lab Assessment
(11) If the walls of arteries of a person are thickened so that their radius reduces to half
of the original value, the blood pressure of the person is expected to
a) increase by a factor of 4
b) increase by a factor of 16
c) decrease by a factor of 4
d) decrease by a factor of 16
(12) Effect of increasing pressure on tooth-paste is to
a) increase its viscosity
b) decrease its viscosity
c) no effect
d) can not be predicted
1. The radius of the capillary tube requires greater care in its measurement since it
occurs in the fourth power in the expression of η .Thus a small error in the
measurement of r, which itself is small will contribute a large proportional error in η.
2. If the pressure difference under which the liquid flows in a horizontal capillary tube
is small, the liquid particles move in a straight path parallel to the axis of the tube and
the motion is streamline
3. By making the pressure difference at the ends of the capillary tube large, the
flow of the liquid becomes turbulent because the liquid particles move in zigzag
paths.
4. No. This method can be suitably applied for liquids of low viscosity.
5. A capillary tube of uniform bore, small radius and large length should be
used. Then only we can assume the motion to be streamlined.
6. It depends on the pressure difference at the two ends of the capillary tube and the
radius of the capillary tube.
1. Viscosity of a liquid decreases but for gases it increases with rise of temperature.
2. No, this method is suitable for liquids having low viscosity. For high viscous
liquids other methods like Stoke’s method is suitable.
3. The unit of viscosity in S.I system is Newton sec /m2.
4. The capillary should be placed in horizontal position to avoid any flow under the
effect of gravity.
5. The property of liquid called viscosity, by virtue of which the liquid opposes the
relative motion between its different layers.
The coefficient of viscosity of a liquid is tangential force acting per unit area over
two adjacent layers of the liquid for a unit velocity gradient.
6. Practical uses of the knowledge of viscosity
(i) The knowledge of viscosity and its variation with temperature helps us to
select a suitable lubricant for a given machine.
(ii) The knowledge of viscosity of some organic liquids such as proteins,
cellulose etc. helps us in determining their shape and molecular weight.
(iii) At railway terminals, the liquids of high viscosity are used as buffers.
(iv) Motion of some instruments is damped by using the viscosity of air or
liquid.
(v) The knowledge of viscosity helped Milliken in determining charge on an
electron.
(vi) The phenomenon of viscosity plays an important role in the circulation of blood
through arteries and veins of human body.
7. The motion of the liquid near the tube axis becomes turbulent and the working
formula can not be used.
8. The critical velocity is that velocity of liquid flow, up to which its flow is streamlined
and above which its flow becomes turbulent.
9. b
10. a
11. b
12. b