Documente Academic
Documente Profesional
Documente Cultură
General:
Q1. What would be the throat thickness of the 6mm weld if fusion face has angle 1000.
Q2. Find the design strength of 6mm shop fillet weld per mm length of weld. Take fu = 410 N/mm2.
Q3. Two plates are connected by a pair of fillet welds as shown. Find the size of the weld required if
16mm plate is subjected to a pull of 2.5kN per mm width.
Q4. What is the minimum and maximum size of the fillet weld for following cases:
Q5. What is the effective throat thickness for groove weld for following case:
If a single groove weld is provided to connect two plate thickness of 18mm and 16mm.
If Double groove weld is provided to connect two plate thickness of 18mm and 16mm.
Try to visualize the problem by your own, Diagram is given as hint to aid your visualization
Hint : For size of weld = 6mm
Assuming the arrangement shown below find l
For calculation do not use end return
Try to visualize the problem by your own, Diagram is given as hint to aid your visualization
Hint :
Try to visualize the problem by your own, Diagram is given as hint to aid your visualization
Hint :