Sunteți pe pagina 1din 6

RENR9024-08

June 2015
Component Identifiers (CID)
Module Identifier (MID)
Electronic Transmission/Chassis Control System
(MID No. 027)

Schematic
Location

Machine
Location
31

Camera - Rear Vision

B-12

16

Solenoid - Auxiliary Valve 5 Solenoid A

D-6

C-11

Solenoid - Auxiliary Valve 5 Solenoid B

D-6

31

Control - Product Link 300

I-9

28

Solenoid - Auxiliary Valve 6 Solenoid A

C-6

32
32

0070

Parking Brake Switch

Data valid but below normal operational range.

0096

Fuel Level Sensor

Data erratic, intermittent, or incorrect.

Control - Implement 3

I-13

Solenoid - Auxiliary Valve 6 Solenoid B

C-6

Backup Alarm Relay

Voltage above normal or shorted high.

Ground - Cab 1

H-14

Solenoid - Blade Left Lower

F-4

32

0168

Electrical System Voltage

Voltage below normal or shorted low.

Ground - Front Frame 1

F-8

14

Solenoid - Blade Left Raise

F-4

32

0177

Transmission Oil Temperature Sensor

Current below normal or open circuit.

Horn - Air

I-2

36

Solenoid - Blade Pitch Backward

G-4

31

0247

SAE J1939 Data Link

Current above normal or grounded circuit.

Horn - Forward (High)

G-3

35

Solenoid - Blade Pitch Forward

G-4

31

0248

Cat Data Link

Mechanical system not responding properly.

Key Reader - MSS

C-11

Solenoid - Blade Right Lower

F-4

32

CONN 1

B-15

0262

5 Volt Sensor DC Power Supply

Abnormal frequency, pulse width, or period.

LED - MSS Status

C-11

Solenoid - Blade Right Raise

F-4

32

CONN 2

D-15

0368

Transmission Auto / Manual Switch

Abnormal update.

Mirror - LH Heated

F-9

30

Solenoid - Blade Side Shift Left

G-4

31

CONN 3

D-15

Secondary Steering Relay

10

Abnormal rate of change.

Mirror - RH Heated

E-9

29

Solenoid - Blade Side Shift Right

H-4

31

CONN 4

F-15

Failure mode not identifiable.

Module - Steering Control Valve

H-3

32

Solenoid - Centershift Pin Puller

I-4

38

CONN 5

D-8 , G-15

14

Bad device or component.

Monitor - Rear Vision

B-10

15

Solenoid - Circle Left

H-4

31

CONN 6

I-15

Out of calibration.

Motor - Air Cleaner

D-9

19

Solenoid - Circle Right

H-4

31

CONN 7

C-12

E-2

90

Solenoid - Circle Side Shift Left

G-4

31

CONN 8

E-12

0144

0420
0444

Starter Motor Relay

11

0573

Inching Pedal Position Sensor

12

0585

Transmission Output Speed Sensor 1

13

Connector Location - Volume 1


Connector Number

Schematic
Location

Machine
Location

Monitoring System Display

14

Parameter failures.

Motor - Autolube Pump

Engine ECM

15

Parameter failures.

Motor - LH Side Wiper

B-13

18

Solenoid - Circle Side Shift Right

G-4

31

CONN 9

F-12

0596

Implement ECM

16

Parameter not available.

Motor - RH Side Wiper

A-13

17

Solenoid - L Blade Down Force Cont

D-3

93

CONN 10

G-11

20

0615

Machine Articulation Angle Position

17

Module not responding.

Radio - Gen 2

I-10

28

Solenoid - L Blade Down Force Op

D-3

93

CONN 11

D-9

21

Resistor - Steer Valve Pull-Up

G-3

32

Solenoid - LH Blade Cushion

G-3

37

CONN 12

D-9

21

0588
0590

0621

Downshift Switch

18

Sensor supply fault.

0622

Upshift Switch

19

Condition not met.

Sensor - Autolube Pressure

H-3

91

Solenoid - R Blade Down Force Cont

D-3

94

CONN 13

E-9

22

0623

Directional Switch

20

Parameter failures.

Sensor - Left Steer Cylinder Position

G-2

34

Solenoid - R Blade Down Force Op

D-3

94

CONN 14

E-9

21

0627

Park Brake Pressure Switch

0669

Transmission Input Speed Sensor

0673

Transmission Output Speed Sensor 3

0674

The FMI is a diagnostic code that indicates what type of failure has occurred.

Transmission Intermediate Speed Sensor 1

0675

Transmission Intermediate Speed Sensor 2

0681

Parking Brake Solenoid Valve

0967

Machine Application

1326

Location Code

1401

Transmission Clutch Solenoid 1

1402

Transmission Clutch Solenoid 2

1403

Transmission Clutch Solenoid 3

1404

Transmission Clutch Solenoid 4

1405

Transmission Clutch Solenoid 5

1406

Transmission Clutch Solenoid 6

Wire Description
Wire
Number

Wire Color

101

RD

Description

Wire
Number

Wire Color

J769

YL

Power Circuits
Battery +24V

Description

Control Circuits (Continued)


Right Side Auto/Manual SW (NC)

1407

Transmission Clutch Solenoid 7

103

RD

LH Position Lamps Fuse

J771

BU

Left Side Auto/Manual SW (NC)

1408

Transmission Clutch Solenoid 8

104

RD

RH Position Lamps Fuse

K722

YL

RT Inc/Dec SW (Dec)

1471

Steering Control Position Sensor 1

105

RD

Key Switch Fuse

K723

PU

RT Inc/Dec SW (Inc)

1472

Steering Control Position Sensor 2

106

WH

Cab Work Lamps

K737

BR

Engine Brake Cylinders 1 to 4

Sensor - Right Steer Cylinder Position

F-2

33

Solenoid - RH Blade Cushion

G-3

37

CONN 15

E-9

22

Solenoid - Articulate Left

F-4

32

Solenoid - Secondary Steering Left

E-4

32

CONN 16

E-9

23
23

Solenoid - Articulate Right

E-4

32

Solenoid - Secondary Steering Right

E-4

32

CONN 17

E-9

Solenoid - Autolube

E-2

90

Solenoid - Wheel Lean Left

H-4

31

CONN 18

E-9

25

Solenoid - Auxiliary Valve 1 Solenoid A

H-4

31

Solenoid - Wheel Lean Right

H-4

31

CONN 19

F-9

26

Solenoid - Auxiliary Valve 1 Solenoid B

I-4

31

Switch - Beacon

C-13

CONN 20

F-9

24

Solenoid - Auxiliary Valve 2 Solenoid A

E-4

32

Switch - Cab Flood Lamp

D-13

CONN 21

F-9

24

Solenoid - Auxiliary Valve 2 Solenoid B

E-4

32

Switch - Center Shift Pin Puller

I-4

38

CONN 22

F-9

22

Solenoid - Auxiliary Valve 3 Solenoid A

C-6

31

Switch - Dimmer

D-13

CONN 23

F-9

27

Solenoid - Auxiliary Valve 3 Solenoid B

C-6

31

Switch - Floodlamps

D-13

CONN 24

G-8

14

Solenoid - Auxiliary Valve 4 Solenoid A

C-6

32

Switch - Snow Wing Flood

C-13

CONN 25

H-8

14

Solenoid - Auxiliary Valve 4 Solenoid B

C-6

32

CONN 26

D-5

93

Check Part Numbers in the Parts Manuals for your Specific Machine
Machine locations are repeated for components located close together.

CONN 27

F-3

92

CONN 28

F-3

35

A = Located below or inside of dash.

CONN 29

F-3

39

E = Located inside rear covered compartment.

CONN 30

F-3

40

F = Located on right hand cab column.

CONN 31

F-3

42

CONN 32

G-8

CONN 33

F-3

35

CONN 34

G-3

35

CONN 35

G-2 , H-2

41

CONN 36

G-2 , H-2

41

CONN 82

B-11

CONN 83

I-3

44

CONN 84

I-3

39

CONN 85

I-3

35

1473

Steering Control Position Sensor 3

108

RD

Dome Lamps

K738

GN

Engine Brake Cylinders 5 & 6

1482

10 Volt Sensor DC Power Supply

109

RD

Alternator Breaker

K739

BU

Engine Brake Cylinder Common

112

PU

Main Power Relay Output

K748

OR

Secondary Steer Motor Relay

114

RD

Warning Horn (Forward)

K749

WH

Blade Right Lever Pos Sensor

Part No.

115

RD

Load Breaker

K750

PU

Blade Left Lever Pos Sensor

152-8346

1484
1674
1960

Inching Pedal Switch


Solenoid Return 1
Ignition Key Reader

Resistor, Sender and Solenoid Specifications - Volume 1


Component Description
Solenoid:

Center Shift Pin Puller

Resistance (Ohms)
32.6 1.6

1961

Service Brake Accumulator Pressure

116

BR

Beacon

K758

BU

Articulation Lever Pos Sensor

240-7193

Resistor:

Steer Valve Pull -Up

500 25

2113

Operator Present Switch

117

RD

Main Breaker

K788

GY

Articulation Right Solenoid

254-3414

Solenoid:

Secondary Steer Left & Right

2.2 0.2

2175

Secondary Steer Left Solenoid

118

GY

LH Door Wipers

K789

YL

Articulation Left Solenoid

2176

Secondary Steer Right Solenoid

119

PK

RH Door Wipers

L730

OR

+5V Supply (XMSN Cont)

2199

Secondary Steering Request Signal Line From Implement ECM

120

YL

Front / Rear Wipers

L731

BR

5V Return (XMSN Cont)

2200

Left Steering Cylinder Position Sensor

121

YL

Back Alarm To Lamp

M719

GN

Blade Sideshift Left Pos Sensor

2201

Right Steering Cylinder Position Sensor

122

BU

Side Wiper

M720

BU

Circle Sideshift Left Solenoid

2252

Machine Articulation Angle Sensor 2

123

WH

Rear Work Lights

M722

OR

Circle Sideshift Right Solenoid

2304

Differential Lock Relay

Fuel Pressure SW Return

Engine Control System


(MID No. 036)
CID

Component

124

GN

HVAC

N707

PU

125

RD

Back Light

N787

BU

Hydraulic Filter Bypass Switch Pilot Supply

126

RD

Transmission Control Fuse

N788

PK

Not Used

127

RD

Monitoring

R732

BR

Hydraulic Oil Inlet Temp Sensor

128

PK

Autolube

R736

PK

Park Brake Press SW (NO)

0001

Cylinder Injector #1

0002

Cylinder Injector #2

129

RD

Cigar Lighter

R746

PK

Intake Manifold Press Sensor

Cylinder Injector #3

130

GN

Waves

R747

GY

Atmospheric Pressure Sensor


Fuel Pressure SW

0003
0004

Cylinder Injector #4

132

RD

Condenser Fan #1

T725

WH

0005

Cylinder Injector #5

134

RD

Air Cleaner

U700

WH

Circle Rt Sol

0006

Cylinder Injector #6

135

RD

Condenser Fan #2

U701

GN

Circle Lt Sol

0041

8 Volt DC Supply

140

BU

Fast Speed Blower Breaker

U702

GY

Aux Valve 1 Sol B

PK

Defrost Fan

U703

YL

Aux Valve 1 Sol A

BU

Flasher

U704

PK

Aux Valve 2 Sol B


Aux Valve 2 Sol A

0091

Throttle Position Sensor

141

0094

Fuel Delivery Pressure Sensor

142

0100

Engine Oil Pressure Sensor

143

BR

Blade Work Lights

U705

PU

Engine Coolant Temperature Sensor

144

GN

Seat

U706

BR

Aux Lever 1 Pos Sensor

GY

Blade Work Light #2

U707

BU

Aux Lever 2 Pos Sensor

RD

Engine Control Fuse

U708

OR

Aux Lever 3 Pos Sensor

0110
0168

Electrical System Voltage

146

0172

Intake Manifold Air Temperature Sensor

150

0174

Fuel Temperature Sensor

152

RD

AccuGrade Fuse

U709

WH

Aux Lever 4 Pos Sensor

Engine Speed Sensor

155

RD

AWD Control (Not used 14M)

U710

GN

Aux Lever 5 Pos Sensor

0190
0253

Personality Module

156

YL

Sensor Power

U711

GY

Aux Lever 6 Pos Sensor

0261

Engine Timing

160

PU

Heated Mirrors

U712

YL

Aux Lever 7 Pos Sensor

0262

5 Volt Sensor DC Power Supply

165

YL

Differential Lock

U713

PK

Aux Valve 3 Sol B

0267

Remote Shutdown

169

PK

Center Shift / Blade Cushion

U714

PU

Aux Valve 3 Sol A

0268

Programmed Parameter

170

RD

Product Link

U715

BR

Aux Valve 4 Sol B

0269

Sensor Power Supply

171

RD

Implement Control #1

U716

BU

Aux Valve 4 Sol A

0274

Atmospheric Pressure Sensor

172

RD

Implement Control #2

U717

OR

Aux Valve 5 Sol B

0291

Engine Cooling Fan

176

RD

Communication Radio Converter

U718

WH

Aux Valve 5 Sol A

Transmission Control

179

RD

Entertainment Radio Converter

U719

GN

Aux Valve 6 Sol B

0296
0297

All Wheel Drive Control

180

RD

Implement Control Main

U720

GY

Aux Valve 6 Sol A

0342

Secondary Engine Speed Sensor

199

RD

Steering Valve

U723

PU

Fuel Level Sender

Ground Circuits

U724

WH

XMSN Filter Bypass SW

0549

Throttle Lock Switch

0588

Monitoring System Display

200

BK

Main Chassis

U725

GN

Auto Shift SW (NC)

Implement Control

210

BK

Ent Radio Converter Output (24/12 Volt)

U726

GY

Auto Shift SW (NO)

0596
0791

Compression Brake Low/High Solenoid

229

BK

Engine Control Gnd

U727

WH

Inching Pedal (NO)

0792

Compression Brake Medium/High Solenoid

A201

BK

Not Used

U728

PK

Serv Brake Accum Charge Press Sensor

1551

Cooling Fan Calibrate

A202

BK

Trans & Chassis Control

U734

GN

Park Brake SW (Off)

1589

Turbocharger Inlet Air Pressure Sensor

A210

BK

Not Used

U735

GY

Park Brake SW(On)

1627

Fuel Pump Relay

A250

BK

Cab Gnd

U736

YL

Steering Valve Signal

1639

Machine Security System Module

A274

BK

AccuGrade Gnd

U739

BR

Steering Lever Pos 1

1785

Intake Manifold pressure Sensor

A295

BK

Implement Control Ground

U740

BU

Steering Lever Pos 2

Ether Injection Control Solenoid

A296

BK

Implement 1 Control Ground

U741

OR

Steering Lever Pos 3

2770

Throttle Lock Resume/Decel Switch

A297

BK

Implement 2 Control Ground

U742

WH

Steer Valve Error Signal

2771

Throttle Lock Set/Accel Switch

U743

GY

Wheel Lean Input Pos Sensor

2417

Electronic Implement Control (MID No. 082)


Electronic Implement Control 2 (Mid No. 147)
CID

Component

Basic Machine Circuits


304

WH

Cranking Motor

U744

OR

Auto Neutral Art Sw (NO)

306

GN

Starter Motor Relay Output

U745

PK

Auto Neutral Art Sw (NC)

307

OR

Key Switch Start

U747

OR

Wheel Lean Sol Left

308

YL

Main Power Relay Coil

U748

GY

Wheel Lean Sol Right

0041

8 VDC Sensor Power Supply

320

OR

Horn Relay Coil To Switch

U749

BR

Blade Sideshift Sol Right

0168

Electrical System Voltage

321

BR

Backup Alarm

U750

PK

Blade Sideshift Sol Left

0247

SAE J1939 Data Link

322

GY

Warning Horn (Forward)

U751

WH

Blade Pitch Sol Fwd

0248

Cat Data Link

365

YL

Fuel Priming Pump Relay

U752

PU

Blade Pitch Sol Reverse

0262

5 Volt Sensor DC Power Supply

U753

BR

Sec Steer Request Sig

403

GN

Alternator (r) Term.

U760

PK

Optional Float Ind 1

439

YL

Center Shift Pin Pulled Indicator

U761

PU

Optional Float Ind 4

C491

PU

Park Brake Pressure SW (NC)

U762

GN

Optional Float Ind 6

F421

YL

Fuel Supply Temp

U763

BU

Circle Drive Lever Pos Sensor

Not Used

U764

GY

Blade Pitch Input Pos Sensor

Action Alarm

U765

WH

Circle Sideshift IP Pos Sensor

Accessory Circuits

U766

BR

Op Seat Sw (NO)

Wiper - Front (Park)

U767

BU

Op Seat Sw (NC)

Monitoring Circuits

0296

Transmission / Chassis ECM

0358

Implement Pilot Pressure Supply Solenoid

0490

Hydraulic Lockout Switch

0588

Monitoring System Display

G434

BU

H414

YL

0590

Engine Electronic Control Module

0597

Main Hydraulic Pump Discharge Pressure

0600

Hydraulic Oil Temperature Sensor

0615

Machine Articulation Angle Position Sensor

0967

Machine Application

1326

Location Code

1471

Steering Control Position Sensor 1

1472

500

BR

501

GN

Wiper - Front (Low)

U768

BU

Art Angle Pos Sensor 2

502

OR

Wiper - Front (Hi)

U769

OR

Aux Valve 7 Sol B

503

BR

Wiper - Rear (Park)

U770

WH

Aux Valve 7 Sol A

504

YL

Wiper - Rear (Low)

X725

GY

Steering Signal To Controller

505

BU

Wiper - Rear (Hi)

X754

GN

Sec Steer Left Solenoid

Steering Control Position Sensor 2

506

PU

Washer - Front

X755

WH

Sec Steer Right Solenoid

1473

Steering Control Position Sensor 3

507

WH

Washer - Rear

Y787

YL

PHS Can (+) (Not Used)

1482

10 Volt Sensor DC Power Supply

508

PU

Radio Speaker - Left

Y788

GN

PHS Can (-) (Not Used)

Electrical Implement Control 2

509

WH

Radio Speaker - Left (Common)

801

PK

Autolube Solenoid & Pump Motor

511

BR

Radio Speaker - Right

843

WH

Not Used

512

GN

Radio Speaker - Right (Common)

844

GN

Not Used

515

GY

Blower Motor (Hi)

849

YL

Not Used

1558
2113

Operator Present Switch

2143

Electronic Implement Control 3

2146

Articulation Lever Position Sensor

516

GN

Blower Motor (Medium)

850

PU

Not Used

2147

Automatic Neutral Articulation Switch

517

BU

Blower Motor (Low)

892

BR

Cat Data Link (-)

2150

Blade Left Lift Lever Position Sensor

518

OR

+24V Flasher Input

893

GN

Cat Data Link (+)

2151

Blade Right Lift Lever Position Sensor

519

PK

Thermostat To Refrigerant Press. SW

A847

YL

Left Blade Down Force Pro Valve

2152

Wheel Lean Control Position Sensor

520

WH

Opr A/C SW To Thermostat

A849

OR

Right Blade Down Force Pro Valve

2153

Blade Pitch Control Position Sensor

521

YL

A/C SW To Refrigerant SW

A893

OR

Fuel Prime SW To Fuel Prime Pump

522

WH

A/C Clutch To Thermostat SW

F843

YL

Inching Pedal Pos Sensor

523

BR

Wiper - Left (Park)

F846

PU

MSS Status LED

524

BU

Wiper - Left (Low)

G826

WH

Fuel Press Sensor (+5V)

525

GY

Wiper - Left (Hi)

G827

GN

Fuel Press Sensor (Gnd)

2154

Blade Sideshift Lever Position Sensor

2155

Circle Drive Lever Position Sensor

2156

Circle Sideshift Control Position Sensor

2160

Blade Left Raise Solenoid Valve

526

YL

Wiper - Right (Park)

G828

WH

+5V Supply 1 (Eng Cont)

2161

Blade Right Raise Solenoid Valve

527

GN

Wiper - Right (Low)

G829

GN

5V Return (Eng Cont)

2162

Blade Left Lower Solenoid Valve

528

PK

Wiper - Right (Hi)

G833

PK

Temp Sensor Return

WH

Washer Left

G856

WH

TDC Service Probe (+)

OR

Washer Right

G857

YL

TDC Service Probe (-)

2163

Blade Right Lower Solenoid Valve

529

2165

Blade Sideshift Left Solenoid Valve

530

2166

Blade Sideshift Right Solenoid Valve

2167

Circle Left Solenoid Valve

2168

Circle Right Solenoid Valve

2169

Circle Sideshift Left Solenoid Valve

567

WH

A/C SW To Condenser Fan Relays

H862

2170

Circle Sideshift Right Solenoid Valve

570

BU

Blade Cushion Sol

H863

2171

Articulation Left Solenoid Valve

581

GY

Left Rear Turn Flasher

2172

Articulation Right Solenoid Valve

582

PK

Right Rear Turn Flasher

2173

Wheel Lean Left Solenoid Valve

538

BR

Dash Flasher Indicator Output

H803

BU

Proportional Driver Return (9-12) (Imp Cont1)

539

BU

Turn Signal Indicator Right

H807

YL

Load Return 1 (Imp Cont)

24 89
27

16

93

91

34

43

35

Solenoid: A solenoid is an electrical component that is activated by electricity. It has a


coil that makes an electromagnet when current flows through it. The electromagnet
can open or close a valve or move a piece of metal that can do work.

15

28

22 A

14

32

38

90
94

E
3
20

23

17

25

44

Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity.


It has a coil that makes an electromagnet when current flows through it. The
electromagnet can open or close the switch part of the relay.

37
39

19

41

31

42

33
92

36

Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is


activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)
that make electromagnet when current flows through them. It also has an internal switch that places
the latch coil circuit open at the time the coil latches.

40

21
29

Harness and Wire Symbols


Wire,
Cable,
or
Harness
Assembly Identification: Includes
Harness Identification Letters and
Harness Connector Serialization
Codes (see sample).

Harness Identification Letter(s):


(A, B, C, ..., AA, AB, AC, ...)

L-C12
3E-5179

AG-C4
111-7898

L-C12
3E-5179

Part Number: for Connector Receptacle

2
Plug

Receptacle
Pin or Socket Number

1
2

Deutsch connector: Typical representation


of a Deutsch connector. The plug contains all
sockets and the receptacle contains all pins.

1
2

Sure-Seal connector: Typical representation


of a Sure-Seal connector. The plug and receptacle
contain both pins and sockets.

Event Codes
Engine Control
Event Code

Condition

E096

Fuel Pressure Is High


Inlet Air Is Restricted

Oil Pressure Is Low

E361

Coolant Temperature Is High

Dc/Dc Converter Power Output

K831

GY

LH Down Force Enable Solenoid

Condenser Fan Relay To Motors

K832

OR

RH Down Force Enable Solenoid

Temp Potentiometer Pos 2

T858

GY

Injector 1 & 2 High Side

2202

Steering Valve Control Module

A557

WH

Precleaner Blower +B

T859

WH

Injector 3 & 4 High Side

2203

Steering Valve Control Module Spool Position Sensor

A572

PK

Comm Converter 12V Output

T860

OR

Injector 5 & 6 High Side

2204

Auxiliary Lever 1 Position Sensor

X800

OR

+8V Sensor Return (XMSN Cont)

900

PU

XMSN Shift Sol 4

A504

GN

Rear Defroster Fan (Low)

L854

YL

AccuGrade Can (+)

A507

YL

Rear Defroster Fan (Hi)

L855

GN

AccuGrade Can (-)

C532

GN

Autolube Pressure Sensor Signal

C542

GN

Heated Mirror Power

2205

Auxiliary Lever 2 Position Sensor

2206

Auxiliary Lever 3 Position Sensor

2207

Auxiliary Lever 4 Position Sensor

C568

WH

Blower Motor (Max)

903

GY

XMSN Shift Sol 8

2208

Auxiliary Lever 5 Position Sensor

E529

YL

Power Air Cleaner Relay Coil

921

WH

XMSN Sol Return

E554

PK

A/C Cont To A/C Comp Clutch

C546

WH

Blower Fast Speed Relay

901

WH

XMSN Shift Sol 6

C558

BU

Condenser Fan 2 Relay Out

902

BR

XMSN Shift Sol 7

603

PK

922

BR

XMSN Sol Return

Lighting Circuits

925

YL

XMSN Sol Shift 1

Rotary Beacon

994

GY

Engine Oil Pressure Sensor

19
25

28

26
20

27

21

24
22 23

15
29

E362

Engine Overspeeds

E363

Fuel Temperature Is High

E390

Fuel Filter Is Restricted

E441

Idle Speed Is High

E539

Intake Manifold Air Temperature Is High

30

Transmission / Chassis Control

Event Code

32

16

0284

41
18

93

14

17

94
31

91
E

43

36

42

0329

Transmission Filter Plugged

0490

Parking Brake ON

0627

Parking Brake Abuse

0795

Machine Speed Excessive For Machine Articulation Angle

0877

High Transmission Oil Temperature

38
39

Implement Control

44
40

89

Condition
Low Brake Pressure

Event Code

90

92

35

Condition

0192

Steering System Malfunction

604

OR

Stop Lamp

995

BU

Engine Coolant Temperature

605

YL

Turn Lamp - Left

997

OR

Analog Sensor Power (+ 5V)(Imp Cont)

0256

Steering Output Detected In The Wrong Direction

5V Return (Imp Cont)

0257

Steering Output Detected With No Command

0258

No Steering Detected With Command Given

0263

Low Main Pump Pressure

606

GY

Turn Lamp - Right

998

BR

607

PK

Blade Floods #2

A975

BU

Differential Lock Relay

609

YL

Snow Wing Lamps

C967

BU

Intake Manifold Air Temp

610

OR

Head Lamp Relay Out

C978

BR

Set Throttle SW (NC)

611

PU

Head Lamp Hi

C979

OR

Resume Throttle SW (NO)

614

PU

Backlight Relay Input

C981

GN

Compression Brake

617

BR

Tail/Position Lamp - Left

C991

PK

Fuel Pressure Sensor

618

YL

Tail/Position Lamp - Right

E900

WH

XMNS Output Spd (-)

619

GN

Head Lamp Lo

E901

GN

XMNS Output Spd (+)

626

BU

Backlight Relay Out

E902

PU

XMNS Intermediate Spd (-)

34
33

0455

Hydraulic Pilot Supply Filter Plugged

0560

Secondary Steer Pump No Response

0562

Steering Lever Has Not Been Aligned To Wheel Steering


Angle

0598

Steering Limited Due To Cold Hydraulic Oil

0599

Gear Too High For Steering With Cold Oil

0795

Machine Speed Excessive For Articulation Angle

2221

Auxiliary Valve 6 - Port B Solenoid

2222

Auxiliary Valve 6 - Port A Solenoid

645

PK

Headlamp Relay Coil

E903

YL

XMNS Intermediate Spd (+)

2223

Auxiliary Valve 7 - Port B Solenoid

646

OR

Rear Flood Relay Coil

E904

BR

XMNS Intermediate Spd (-)

0796

Machine Articulation Angle Limited Due To Machine Speed

2224

Auxiliary Valve 7 - Port A Solenoid

647

GN

Blade Flood Relay Coil

E905

BU

XMNS Intermediate Spd (+)

0861

Clock Manual Alignment Required

2252

Machine Articulation Angle Sensor 2

660

PU

Ind Lamp - Auto Shift 1st Gear

E906

OR

XMNS Trans Output Spd (-)

0878

High Hydraulic Oil Temperature

2650

Steering Valve Control Module Power Supply

668

BU

Backlight Relay Out

E907

GY

XMNS Trans Output Spd (+)

2085

Invalid Articulation Response Detected

680

GN

Cab Floodlights Relay Out

E908

BR

XMNS Trans Input Spd (-)


XMNS Trans Input Spd (+)

The CID is a diagnostic code that indicates which circuit is faulty.

683

PU

Rear Flood Relay Out

E909

WH

The MID is a diagnostic code that indicates which electronic control module
diagnosed the fault.

684

OR

Cab Flood Relay Input

E929

GY

Articulation Angle Pos Sensor

685

BR

Blade Floods

E963

BK

Engine Speed Sensor (-)

695

OR

Left Turn Lamp Relay Coil

E964

WH

Engine Speed Sensor (+)

696

GN

Right Turn Lamp Relay Coil

E965

BU

Sec Engine Speed Sensor (-)

A608

GY

Dimmer Relay Coil

E966

YL

Sec Engine Speed Sensor (+)

E974

GN

Inching Pedal SW (NC)

Control Circuits
709

OR

+10V Supply (Imp Cont)

F916

GN

Backup Alarm Relay

727

GN

Sec Steer Test SW

G946

OR

Throttle Set SW (NO)

751

GN

XMSN Shift Sol 3

G953

BU

Impl Pilot Supply Solenoid

752

YL

XMSN Shift Sol 2

G965

PU

Load Return 2 (Imp Cont)

754

BU

XMSN Shift Sol 1

K900

YL

J1939 Data Link +

755

OR

XMSN Shift Sol 5

K927

BU

PWM Driver Return (5-8) (Imp Cont1)

799

WH

+10V Supply (XMSN Cont)

K952

BR

PWM Driver Return (1-4) (Imp Cont1)

Component
Part Number

325-AG135 PK-14

E360

BU

9X-1123

Harness identification code:


This example indicates wire group 325,
wire 135 in harness "AG".

+8 Volt Supply (Eng Cont)

GN

5A
Fuse (5 Amps)

Not Used

592

Harness Connector Serialization Code:


The "C" stands for "Connector" and the
number indicates which connector in the
harness (C1, C2, C3, ...).

Part Number: for Connector Plug

GY

BR

Auxiliary Valve 5 - Port A Solenoid

18
26

GN

A524

2220

Sender: A component that is used with a temperature or pressure gauge. The sender
measures the temperature or pressure. Its resistance changes to give an indication to
the gauge of the temperature or pressure.

30

J844

Right Steering Cylinder Position Sensor

Auxiliary Valve 4 - Port A Solenoid

Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.

H864

2201

Auxiliary Valve 5 - Port B Solenoid

Ground (Case): This indicates that the component does not have a wire connected to ground.
It is grounded by being fastened to the machine.

Exhaust Temperature Is High

+8V Sensor Power (Imp Cont)

2218

Ground (Wired): This indicates that the component is connected to a grounded wire. The
grounded wire is fastened to the machine.

Shutdown (Ground Level)

Transmission Oil Temp Sensor

2219

Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
No circle indicates that the wire cannot be disconnected from the component.

E265

YL

Auxiliary Valve 4 - Port B Solenoid

Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
circle indicates that the component has screw terminals and a wire can be disconnected from it.

Proportional Driver Return (9-12) (Imp Cont)

OR

2217

Fuse: A component in an electrical circuit that will open the circuit if too much current flows
through it.

Proportional Driver Return (5-8) (Imp Cont)

R818

Auxiliary Valve 3 - Port A Solenoid

Symbols and Definitions

BU

593

Circuit Breaker
Symbol

Flow
Symbol

GY

R800

2216

Level
Symbol

E194

Heated Mirror Power

Auxiliary Valve 3 - Port B Solenoid

Temperature
Symbol

E172

Dc/Dc Converter Memory Output

2215

Pressure
Symbol

Load Return 1 (Imp Cont2)

YL

Auxiliary Valve 2- Port A Solenoid

Symbols

Proportional Driver Return (1-4) (Imp Cont)

PK

2214

Harness And Wire Electrical Schematic Symbols

PU

A513

Auxiliary Valve 2 - Port B Solenoid

Printed in U.S.A.

WH

A514

2213

2015 Caterpillar, All Rights Reserved

H808

Left Steering Cylinder Position Sensor

Auxiliary Valve 1 - Port A Solenoid

At room temperature unless otherwise noted.

H861

2200

2212

Volume 1 of 3: Cab and Chassis

Turn Signal Indicator Left

Blade Pitch Backward Solenoid Valve

Auxiliary Valve 1 - Port B Solenoid

8.7 0.4

Differential Lock

2182

2211

The connectors shown in this chart are for harness to harness connectors.
Connectors that join a harness to a component are generally located at or near
the component. See the Component Location Chart.

WH

Blade Pitch Forward Solenoid Valve

Auxiliary Lever 6 Position Sensor

89
43

WH

2181

Auxiliary Lever 7 Position Sensor

I-3
I-3

540

Wheel Lean Right Solenoid Valve

2209

Solenoid:

CONN 86
CONN 87

B9H1-750

556

2174

2210

278-1799

Auxiliary Valve 1 thru 6


Articulate LT / RT
Blade Left Raise / Lower
Blade Right Raise / Lower
Blade Pitch Forward / Backward
Blade Sideshift LT / RT
Circle Left / Right
Circle Side Shift LT / RT
Left & Right Blade Down Force Control
Left & Right Down Force Op
Wheel Lean LT / RT

16M Motor Grader


Electrical System

MACHINE HARNESS CONNECTOR AND COMPONENT LOCATIONS


Related Electrical Service Manuals
Title

Form Number

Alternator:

235-7133

SENR4130

Electric Starting Motor:

207-1556

SENR3581

Engine Control:

RENR9344

Implement Control:

RENR9013

Transmission / Chassis Control:

RENR9004

Wire Gauge
Wire Color

(Dimensions: 48 inches x 35 inches)

8V DC Sensor Power Supply

Component

Coil - MSS Exciter

Failure Description

Machine
Location

Data valid but above normal operational range.

FMI No.

Component

Schematic
Location

36 Page,

0041

Component

Failure Mode Identifiers (FMI)

RENR9024-08 VOL 1 of 3

CID

Component Location - Volume 1 (Cab / Chassis)

(Dimensions: 48 inches x 35 inches)

14
CK-C4
1907613

CONN 6
P-C68
VOLUME 2
LOC G-14

1
2
3
4
5
6
7
8
9
10
11
12

308-CK1
893-CK2
892-CK4
172-CK27
H807-CK39
Y787-CK31
Y788-CK30
K900-CK23
K990-CK35
U769-CK37
U770-CK38

13

308-CK1

YL - 18
GN- 18
BR - 18
RD- 14
YL - 18
YL-18
GN-18
YL - 18
GN- 18
OR- 18
WH- 18

172-CK10
172-CK11

172-CK27
RD- 14
172-CK32
RD- 14

RD- 14
RD- 14

172-CK8
172-CK13
172-CK12
308-CK1
892-CK4
893-CK2

A297-CK34

E789-CK16
E790-CK36

PU- 18
PK - 18

H807-CK39
U713-CK14
U714-CK15
U715-CK17
U716-CK18
U717-CK21
U718-CK22
U719-CK24
U720-CK25
U769-CK37
U770-CK38

YL PK PUBR BUORWHGNGYORWH-

A297-CK26
A297-CK19

BK - 14

A297-CK28

BK - 14
BK - 16

BK - 14

BK - 14
BK - 14

A297-CK5
A297-CK7

BK - 14
BK - 16

A297-CK20
A297-CK9

BK - 14
BK - 16

GN- 18

A297-CK3

BK - 14

CK-C3
1642336

CL-C1
VOLUME 1
LOC D-8
CHASSIS SCHEMATIC

CK-C6
3E3376

CONN 4
AUX VALVE #7 SOLENOIDS
FOR EXTERNAL APPLICATIONS

U718-CK22
U717-CK21
U714-CK15
U713-CK14
U715-CK17
U716-CK18
U719-CK24
U720-CK25
E790-CK36
E789-CK16

1
2
3
4
5
6
7
8
9
10
11
12

CONN 5

CK-C5
1552272
1
2
3
4

BK - 14

A297-CK6

BK - 16

A297-CK7

BK - 16

172-CK8
A297-CK9

172-CK10
172-CK11

RD- 14
BK - 16

RD- 14
RD- 14

CAB GROUND 1
GND
E789-CK16
E790-CK36
K900-CK23
K990-CK35
U713-CK14
U714-CK15
U715-CK17
U716-CK18
U717-CK21
U718-CK22
U719-CK24
U720-CK25
Y787-CK31
Y788-CK30

18
18
18
18
18
18
18
18
18
18
18

H807-CK39
U769-CK37
U770-CK38

WH- 18
OR- 18
PU- 18
PK - 18
BR - 18
BU- 18
GN- 18
GY- 18
PK - 18
PU- 18

U770-CK38
U769-CK37
H807-CK39

BR - 18

A297-CK5

PU- 18
PK - 18
YL - 18
GN- 18
PK - 18
PU- 18
BR - 18
BU- 18
OR- 18
WH- 18
GN- 18
GY- 18
YL-18
GN-18

172-CK12
172-CK13
U713-CK14
U714-CK15
E789-CK16
U715-CK17
U716-CK18

A297-CK19
A297-CK20
U717-CK21
U718-CK22
E790-CK36
U719-CK24
U720-CK25

A297-CK26

CK-C1
1471445
YL - 18

893-CK2

892-CK4

A297-CK3
A297-CK6

BK - 14

A297-CK29

RD- 14
RD- 14
RD- 14

YL - 18
BR - 18
GN- 18

A297-CK28
BK - 14
A297-CK33
BK - 14

36 Page,

RENR9024-08 VOL 1 of 3

15

H807-CK39
U769-CK37
U770-CK38

RD- 14
RD- 14
PK - 18
PU- 18
PU- 18
BR - 18
BU- 18

BK BK ORWHPK GNGY-

14
14
18
18
18
18
18

BK - 14

YL - 18
OR- 18
WH- 18

WH- 18
OR- 18
YL - 18

Y787-CK31
Y788-CK30
K900-CK23
K990-CK35

YL-18
GN-18
YL - 18
GN- 18

11

10

IMPLEMENT CONTROLLER 3
262-1408
J1
KEY SWITCH - RUN

1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70

- UNSWITCHED BATTERY

CAT DATA LINK LOW

170-WA1

RD-18

170-WA2
170-WA3

170-WA2 RD-18
A295-WA15 BK-18
308-WA11 YL-18
403-WA13 GN-18
N957-WA19

PK-18

N960-WA18
N979-WA17
N970-WA20
N973-WA21

OR-18
GN-18
YL-18
BR-18

RD-18
RD-18

308-WA8

ECM LOCATION 0 (GND)


ECM LOCATION 1 (OPEN)
ECM LOCATION 2 (GND)

YL-18

403-WA10

+ UNSWITCHED BATTERY
ECM LOCATION ENABLE (GND)

A295-WA9

308-WA12
308-WA11

403-WA14
403-WA13

GN-18

BK-18

N957-WA19
N960-WA18
N970-WA20
N973-WA21
N979-WA17

GN-18
GN-18

A295-WA16
A295-WA15

BATT +
BATT KEYSWITCH RUN
R-TERM
RS-232 TXD

893-WA4
892-WA5

RS-232 RXD
RS-232 GND
RS-232 DTR
RS-232 DCD

BK-18
BK-18

N957-WA19

+ UNSWITCHED BATTERY
+ UNSWITCHED BATTERY

PK-18
OR-18
YL-18
BR-18
GN-18

N960-WA18
N970-WA20

N973-WA21
N979-WA17
K990-WA7

+ UNSWITCHED BATTERY
+ UNSWITCHED BATTERY
AUX VALVE #3 SOL B
AUX VALVE #3 SOL A
PWM DR RETURN 1-4
AUX VALVE #4 SOL B
AUX VALVE #4 SOL A
NO CONNECTION
PWM DR RETURN 11-12
PWM DR RETURN 9-12
- UNSWITCHED BATTERY
- UNSWITCHED BATTERY
AUX VALVE #5 SOL B
AUX VALVE #5 SOL A
PWM DR RETURN 5-8
AUX VALVE #6 SOL B
AUX VALVE #6 SOL A

892-WA5 BR-18
893-WA4 GN-18
K900-WA6 YL-18
K990-WA7 GN-18

AE-C2
1552273

CONN 3

1
2
3
4
5
6

TO P-HARNESS
VOLUME 2(P-C58)
LOC D-3

CONN 2
TO P-HARNESS
VOLUME 2(P-C130)
LOC D-3

1
2
3
4
5
6
7
8
9
10
11
12

125-AE53
125-AE59
A608-AE2
668-AE10
614-AE21
609-AE39
603-AE52
684-AE43

BR-18

RD- 18
RD- 18

GY- 18
BU- 18
PU- 18
YL-18
PK-18
OR- 18

AE-C3
1552252
116-AE22
125-AE53
646-AE58
647-AE56
200-AE48
104-AE1

BR - 18
RD- 18
OR- 18
GN- 18
BK - 18
RD- 18

106-AE45

WH- 18

200-AE48

614-AE21

125-AE18
125-AE17
125-AE16

RD- 18
RD- 18
RD- 18

125-AE3
125-AE9
125-AE47
125-AE40
125-AE42
125-AE55

RD- 18
RD- 18
RD- 18
RD-18
RD-18
RD- 18

200-AE7
200-AE20
200-AE6

BK - 18
603-AE52

609-AE39

BR-18
BR - 18

403-WA14

LOAD RETURN #2

BK - 18
BK - 18
BK - 18

PK-18

YL - 18

609-AE5
609-AE15

YL - 18
YL - 18

PU - 18

614-AE57
614-AE11
614-AE46
614-AE41

PU - 18
PU - 18
PU - 18
PU-18

646-AE58
647-AE56

J-C22
1552252

RD- 18
BK - 18
YL - 18
GN- 18
GN- 18
BR - 18
YL - 18
GN- 18

J-C23
3E5179
1
2
3
4
5
6
7
8
9
10
11
12

WA-C1
3E5179
1
2
3
4
5
6
7
8
9
10
11
12

A295-WA16
170-WA1
A295-WA9
308-WA8
403-WA10
893-WA4
892-WA5
K900-WA6
K990-WA7

RD-18
BK-18
YL-18
GN-18
GN-18
BR-18
YL-18
GN-18

308-WA12

200-J46

200-J26

200-J2
200-J5
200-J7
200-J35

BK-14

200-J3
200-J6
200-J34
200-J1
200-J38

BK - 14

J-C24
1552252

CONN 9
TO P HARNESS
P-C124
VOLUME 2
LOC A-14

1
2
3
4
5
6
7
8
9
10
11
12

J-C25
1552264

PHS CAN HIGH


PHS CAN LOW
PHS CAN SHIELD
J1939 HIGH
J1939 LOW
J1939 SHIELD

CONN 8
TO P HARNESS
P-C126
VOLUME 2
LOC A-14

J2

1
2
3
4
5
6
7
8

617-J17
618-J25
603-J13
C542-J16

BR - 14
YL - 14
PK - 18
GN- 18

200-J12

680-J22
200-J26
609-J40
200-J12
A557-J44
200-J46

GN- 14
BK - 14
YL - 18
BK - 18
WH-18
BK-14

609-J40

170-J11
A295-J24
308-J27
403-J28
893-J29
892-J30
K990-J31
K900-J32

603-J13

609-J18
609-J39

680-J22

YL - 18
YL-18

680-J20
680-J23
680-J19
680-J21
680-J37
680-J36

GN- 14

GN- 14
GN- 14
GN- 14
GN- 14
GN-14
GN-14

J-C17
1552269

GN- 18
GN- 18

668-AE10

BU- 18

668-AE4
668-AE8
668-AE61

BU- 18
BU- 18
BU- 18

668-AE60

BU- 18

668-AE35
668-AE12
668-AE13

BU- 18
BU- 18
BU- 18

684-AE43

OR- 18

684-AE14
684-AE19

OR- 18
OR- 18

A608-AE2

AE-C4
2234778
OR- 18
BK - 18
GN- 18
PU- 18
RD- 18
PU- 18
RD- 18
BU- 18
BU- 18
RD- 18

CONN 21
680-J21
200-J2

680-J37
200-J35

GN- 14
BK - 14

106-AE45
684-AE19

WH- 18
OR- 18

680-J23
200-J4

680-J36
200-J34

J-C12
3E3364

L-C1
3E3364

1
2

1
2

K-C1
3E3364

J-C10
3E3364
1
2

1
2

CONN 17

GN-14
BK-14

680-J19
200-J3

GN- 14
BK - 14

125-AE9
614-AE46
125-AE47
200-AE7
668-AE12
684-AE14

RD- 18
PU- 18
RD- 18
BK - 18
BU- 18
OR- 18
AE-C8
2234778

116-AE30
603-AE52

GY- 18

125-AE55

RD- 18

668-AE35

BU- 18

AE-C6
2234778

B POST LIGHTS

116-AE23
609-AE5

BR-18
YL - 18

125-AE40
614-AE41
125-AE42
200-AE20
668-AE13
609-AE15

RDPURDBK BUYL -

18
18
18
18
18
18

TO CAB SCHEMATIC
VOLUME 2 (P-C50)
LOC I-2

CAN LOW

CAN SHIELD

CAN HIGH
BATT+
R-TERM

CONN 24

RS232 PORT3-TXD
RS232 PORT3-RXD
RS232 PORT3-GND
BATT-

618-J25
200-J10

YL-14
BK - 14

603-J13
200-J7

PK - 18
BK - 18

RH REAR WORK LAMP


234-4325

RH FRONT WORK LAMP1


290-5749

PK-14

H765-U85

CONN 7
TO P HARNESS
P-C80
VOLUME 2
LOC B-5

BEACON SW
237-9736
OFF
ON

1
2
3
4
5
6

CT-C4
3E3382
308-CT1
YL-18
200-CT2
BK-18
K900-CT3
YL-18
K990-CT4
GN-18
308-CT5
YL-18
F846-CT7
PU-18

T901-CT8
T902-CT9

YL-18
PK-18

T901-CT8
T902-CT9

YL-18
PK-18

SNOW WING FLOOD SW


249-5480

308-CT1
200-CT2
K900-CT3
K990-CT4
T901-CT8
T902-CT9

CT-C1
1552264
YL-18
BK-18
YL-18
GN-18
YL-18
PK-18

308-CT5
F846-CT7

CT-C2
1552269
YL-18
PU-18

T901-CT8
T902-CT9

OFF
ON

CT-C3
1552269
YL-18
PK-18

KEYSWITCH ON
GROUND
CAN DATA HIGH
CAN DATA LOW
EXCITER COIL SIG
EXCITER COIL RET

1
2
3
4
5
6
7
8

RD
BK

1
2

RD

MSS STATUS LED


242-3282
BK-18
BK-18

1
2

MSS EXCITER COIL


206-5208

MSS

200-U103
200-U99

BK-18
BK-18

200-U112
200-U113

BK-14
BK-14

200-U116
200-U46
200-U79
200-U115

BK-14
BK-18
BK-18
BK-18

322-U102

GY - 18

322-U87
322-U86

GY-18
GY-18

607-U28

GY - 18

U742-U94

WH- 18

801-U117
C532-U41

PK-14
GN-18

T998-U26
X800-U71

TO CAB SCHEMATIC
VOLUME 2 (P-C151)
LOC G-2

685-U81

BR-18
OR-18

A202-U25
A847-U122
A849-U123
C532-U41
F775-U78
H764-U82
H765-U85
H803-U121
H807-U51
H808-U118

U-C68
1552264

H862-U37
YL-18
BR-14
GY-18
PU-14
GN-14
YL-14
BR-14
BK-14

H863-U39

PU - 18

GY - 18

BU- 18

K788-U22
K789-U21
K831-U119
K832-U120

BK-14
BK-14
BK - 14

925-U68
925-U69

YL - 18

H861-U40

605-U124
617-U125
606-U127
611-U128
619-U129
618-U130
685-U81
200-U131

685-U90
685-U108
685-U109
685-U107

200-U45
BK-14
200-U46
BK - 18
200-U91
BK-14
200-U96
BK-14
200-U97
BK-14
200-U98
BK - 14
200-U99
BK - 18
200-U103
BK - 18
200-U104
BK - 14
200-U110
BK-14

BR-14
BR-14
BR-14
BR-14

200-U111
BK-14
200-U115
BK - 18
200-U116
BK-14
200-U131
BK-14
322-U86
GY- 18
322-U87
GY- 18
570-U27
BU-18
570-U33
BU-18
605-U124
YL-18
606-U127
GY-18

YL-18
YL-18

BK-18
YL-18
OR-18
GN-18
BU-18
GY-18
WH-18
BU-18
YL-18
WH-18
PU-18
PU-18
PU-18
PU-18

H862-U62
H862-U63
H862-U60
H862-U61

GY-18
GY-18
GY-18
GY-18

H863-U73
H863-U72
H863-U75
H863-U74

BU-18
BU-18
BU-18
BU-18

BU- 18

K927-U55
K927-U53
K927-U52
K927-U54

BU-18
BU-18
BU-18
BU-18

K952-U36

BR - 18

K952-U56
K952-U59
K952-U57
K952-U58

BR-18
BR-18
BR-18
BR-18

M720-U14
M722-U13
M906-U48

BU-18
P967-U84
R800-U83
R900-U20
R901-U19
R902-U18
R903-U17
T998-U26
U700-U7
U701-U8
U702-U5
U703-U6

LH REAR WORK LAMP HID


289-3820

X725-U92

GY- 18
X754-U31
X755-U32
X800-U71

RH FRONT WORK LAMP2 HID


289-3820

685-U108
BR-14
685-U109
BR-14
799-U4 WH- 18
801-U117
PK-14
A202-U25
BK - 18
C532-U41
GN-18
H764-U82 GY- 18
H765-U85 WH- 18
H807-U51
YL-18
M906-U1 BU-18

X725-U30
X725-U29

BUBUBUGYGNORPK PUGNWH-

U-C14
1552269
GY- 18
BU- 18

18
18
18
18
18
18
18
18
18
18

GY- 18
GY- 18

GN-18
WH-18
OR-18

RH FWD POSITION LAMP


212-3924

SNOW WING LAMP1


234-4325

YL - 18
BU- 18

1
2

U-C30
3E3364

AUX VALVE 1 PORT B SOL


278-1799

U-C31
3E3364

AUX VALVE 1 PORT A SOL


278-1799

U-C16
1552269
1
2

U701-U8
K952-U57

U-C17
1552269
GN- 18
BR - 18

1
2

1
2

FLOODS LH HEEL
153-2073
FLOODS HID LH HEEL
U-C3
210-8423
3E3364

U748-U10
H862-U63

U749-U11
H862-U60

U-C46
1552269
BR - 18
GY- 18

1
2

U750-U12
H862-U61

U-C45
1552269
PK - 18
GY- 18

1
2

M722-U13
K952-U59

M720-U14
K952-U58

U-C43
1552269
BU- 18
BR - 18

1
2

U752-U15
H861-U65

U-C42
1552269
PU - 18
PU - 18

1
2

U751-U16
H861-U64

U-C41
1552269
WH- 18
PU - 18

R903-U17
H863-U74

U-C22
1552269
OR- 18
BU- 18

1
2

R902-U18
H863-U72

U-C23
1552269
GN- 18
BU- 18

1
2

R901-U19
H863-U75

U-C24
1552269
GY- 18
BU- 18

1
2

R900-U20
H863-U73

U-C25
1552269
BU- 18
BU- 18

1
2

K789-U21
H861-U66

U-C26
1552269
YL - 18
PU - 18

K788-U22
H861-U67

U-C27
1552269
GY- 18
PU - 18

U704-U23
K927-U52

U-C28
1552269
PK - 18
BU- 18

1
2

U705-U24
K927-U54

U-C29
1552269
PU - 18
BU- 18

1
2

X754-U31
925-U69

U-C39
1552269
GN- 18
YL - 18

1
2

X755-U32
925-U68

U-C40
1552269
WH- 18
YL - 18

1
2

1
2

1
2

CONN 84

U-C54
3E3364

PK - 14
BK-14

U-C55
1552269

1
2

1
2

GY- 18
BK - 18

AH-C1
1552269
685-AH4
200-AH1

322-UH1
200-UH2

BR - 14
BK - 14

PK-14
BK-14

1
2

U-C53 AJ-C1
3E3364 3E3364
1
685-AJ20
2
200-AJ19

BR - 14
BK - 14

605-U124
617-U125
606-U127
611-U128
619-U129
618-U130

685-AH4
200-AH1

AH-C2
1552269
BR - 14
BK - 14

685-AJ20
200-AJ19

AJ-C2
1552269
BR - 14
BK - 14

FLOODS LH TANDEM
153-2073

FLOODS HID LH TANDEM


283-8144

FLOOD LH FRONT
153-2073

FLOOD HID LH FRONT


210-8425

1
2

1
2

T998-U26
X800-U71
C532-U41

WHEEL LEAN RIGHT SOLENOID


278-1799

1
2
3
4
5
6

BLADE SIDE SHIFT RIGHT SOL


278-1799

1
2
3
4
5
6

U736-U2 YL - 18
H807-U51
YL-18
M906-U34 BU- 18

BLADE SIDE SHIFT LEFT SOL


278-1799

M906-U1
X725-U29

+8V
GROUND
SIGNAL

COMMAND SIGNAL
ERROR SIGNAL
SPOOL POSITION
GROUND
POWER

CONN 36

STEER VALVE PULL UP RES


240-7193

U-C11
1552269
BU- 18
GY - 18

1
2

1
2
3
4
5
6

A-C3
3E3382
605-A1
617-A3
606-A8
611-A11
619-A12
618-A9

200-A10

YL - 14
BR - 14
GY - 14
PU - 14
GN- 14
YL - 14

611-A11

A-C4
3E3364

BK-18
BK-18

CONN 35

1
2

200-A10

BLADE PITCH BACKWARD SOL


278-1799

BLADE PITCH FORWARD SOL


278-1799

1
2

U-C7
1552269
BU- 18
BK - 18

617-A3
618-A9

BK - 14

570-U33
200-U115

BU- 18
BK - 18

322-U86
200-U103

U-C21
1552269
GY - 18
BK - 18

U-C10
1552269
1
2

R800-U83
P967-U84
H765-U85

U-C51
1552272
1
2
3
4

U-C58
3E3376

OR- 18
PU - 18
WH- 18

1
2
3
4

CONN 31

BLADE LEFT RAISE SOL


278-1799

685-U90
200-U104

U-C4
1552269
BR-14
BK - 14

685-U109
200-U111

U-C50
1552269
BR-14
BK-14

607-U114
200-U45

U-C62
3E3364
PK-14
BK-14

607-U89
200-U91

U-C60
1552269
PK - 14
BK-14

801-U117
200-U116

U-C63
3E3364
PK-14
BK-14

1
2

U-C13
3E3364

611-A6
611-A4

A-C1
1552273
YL - 14
BK - 14
BR - 14
PU - 14

619-A5

GN- 14

606-A8
200-A13
618-A9
611-A6

A-C2
1552273
GY - 14
BK - 14
YL - 14
PU - 14

619-A7

GN- 14

BK-18
BU-18
BR-18
RD-18
GN-18

PU- 14
PU- 14

BR - 14
YL - 14

619-A7
619-A5

1
2
3
4
5
6

GN- 14
GN- 14

1
2
3
4
5
6

LH LAMP GP
259-9287

BK-18
BU-18
BR-18
RD-18
GN-18

RH LAMP GP
259-9288

RH BLADE CUSHION
253-1320

GN-18
GN-18

UA-C1
3E3376
799-UA1
WH-18
A202-UA2
BK-18
H764-UA3
GY-18
UC-C1
1552272
R800-UC1
P967-UC2
H765-UC3

FLOODS RH HEEL
153-2073
U-C5
3E3364

UA-C2
1552272
799-UA1
WH-18
A202-UA2
BK-18
H764-UA3
GY-18

OR-18
PU-18
WH-18

R800-UC1
P967-UC2
H765-UC3

UC-C2
1552272
OR-18
PU-18
WH-18

LEFT STEER CYL POS SENS


267-5257
OR-18
BK-18
WH-18

1
2
3
4

+10V
GROUND
SIGNAL

RIGHT STEER CYL POS SENS


267-5257
OR-18
BK-18
WH-18

1
2
3
4

+8V
GROUND
SIGNAL

FLOODS HID RH HEEL


210-8423

CONN 30
1
2

FLOOD LIGHT TOE LH


U-C59 153-2073
FLOODS HID RH TOE
3E3364
210-8423

CONN 29

U-C6
1552269

1
2

AC-C1
1552269
685-AC1
200-AC2

1
2

1
2

U-C61 AF-C1
3E3364 3E3364
1
685-AF1
2
200-AF2

CONN 27

ARTICULATE RIGHT SOL


278-1799

YL - 14
GY- 14

605-A1
200-A2
617-A3
611-A4

BR - 14
BK - 14

685-AC1
200-AC2

AC-C2
1552269
BR - 14
BK - 14

685-AF1
200-AF2

AF-C2
1552269
BR - 14
BK - 14

U-C64
1552269

1
2

1
2

EG-C1
1552269
801-EG1
200-EG2

AUX VALVE 2 PORT A SOLENOID


278-1799

BR - 14
BK - 14

PK - 14
BK - 14

200-EG5
200-EG6
200-EG7

BK-14
BK-14
BK-14

200-EG2

BK - 14

801-EG1

PK - 14

801-EG3
801-EG4

PK-14
PK-14

FLOODS RH TANDEM
153-2073

FLOODS HID RH TANDEM


283-8144

FLOOD RH FRONT
153-2073

FLOODS HID RH FRONT


210-8425

1
2

CONN 28
ARTICULATE LEFT SOL
278-1799

BK - 14
BK - 14

FWD HORN HIGH


174-7875

1
2

CONN 34

GN- 14

200-A13
200-A2

LH BLADE CUSHION
253-1320

GN-18
GN-18

1
2

799-U4 WH- 18
A202-U25
BK - 18
H764-U82
GY - 18

BLADE LEFT LOWER SOL


278-1799

U-C12
3E3364

PU- 14

619-A12

570-U27
200-U46

BK - 14
605-A1
606-A8

CIRCLE SIDE SHIFT RIGHT SOL


278-1799

CIRCLE SIDE SHIFT LEFT SOL


278-1799

CONN 35

AUTOLUBE PRESS SENSE


221-3405

A
A
OR-18
B
B
BK-18
C
C
WH-18
STEERING VALVE CONT MOD
301-5360

U-C34
1552273
GY - 18
WH- 18

CONN 36
U-C33
3E3364

1
2

BK-14

U-C69
1552267

U-C67
3E3370

BR-18
OR-18
GN-18

X725-U30
U742-U94

1
2

U-C49
3E3382

U-C48
1552273

YL-18
BR-14
GY-18
PU-14
GN-14
YL-14

200-U131

WHEEL LEAN LEFT SOLENOID


278-1799

BLADE RIGHT RAISE SOL


278-1799

1
2

1
2

U-C32
1552269

BLADE RIGHT LOWER SOL


278-1799

1
2

AIR HORN
146-5804

UH-C2
1552269
GY- 18
BK - 18

CONN 83

U-C52
1552269
607-U105
200-U96

UH-C1
3E3364
322-UH1
200-UH2

CIRCLE LEFT SOL


278-1799

1
2

U-C44
1552269
OR- 18
BR - 18

U-C35
3E3364

CIRCLE RIGHT SOL


278-1799

1
2

U-C19
1552269
GY- 18
GY- 18

607-U88
200-U97

1
2

AUX VALVE 2 PORT B SOLENOID


278-1799

801-EG4
200-EG6

EG-C2
1552269
PK-14
BK-14

1
2

801-EG3
200-EG5
200-EG7

EG-C3
1552267
PK-14
BK-14
BK-14

A
B
C

MOTOR

GN-18
GN-18

AUTOLUBE PUMP
304-4264

AUTOLUBE SOL
304-4277

E
SECONDARY STEER LEFT SOL
254-3414

SECONDARY STEER RIGHT SOL


254-3414

HID SNOW WING LAMP


210-8423

J-C27
3E3364

CONN 26

SNOW WING LAMP2


234-4325

AIR CLEANER MTR


269-3284

1
2

CONN 86

OPEN ROPS BEACON LAMP


235-3937

1
2

J-C21
3E3364

FLOOD LIGHT TOE RH


FLOODS HID LH TOE
U-C57 153-2073
210-8423
3E3364

REAR SOLENOIDS

1
2

YL-18
BK-18

322-U87
200-U99

U-C20
1552269
GY - 18
BK - 18

1
2

CONN 33

WH-18
BK-18

J-C2
3E3364

J-C26
1552269

1
2

U-C15
1552269

J-C4
3E3364

J-C1
1552269

685-U107
200-U98

U-C2
1552269
BR-14
BK - 14

WH-16
WH-16

FRONT SOLENOIDS

925-U68
YL - 18
925-U69
YL - 18
H861-U66 PU- 18
H861-U67 PU- 18
H863-U72 BU- 18
H863-U73 BU- 18
H863-U74 BU- 18
H863-U75 BU- 18
K788-U22
GY- 18
K789-U21
YL - 18
K927-U52
K927-U54
R900-U20
R901-U19
R902-U18
R903-U17
U704-U23
U705-U24
X754-U31
X755-U32

2
3

CENTERSHIFT PIN PULLER SOL


1528346

GN-18
GN-18

WH- 18
BR - 18

M906-U1 BU- 18
M906-U34 BU- 18
PU-18
OR-18
BU-18
GY-18
GN-18
OR-18
BR-18
WH-18
GN-18
GY-18
YL-18

1
4

685-U108
200-U110

U-C56
1552269
BR-14
BK-14

CONN 85

1
2

U700-U7
K952-U56

M906-U34 BU-18
P967-U84
PU- 18
R800-U83
OR- 18
T998-U26
BR-18
U736-U2 YL - 18
U742-U94 WH- 18
X725-U29
GY-18
X725-U30
GY-18
X800-U71
OR-18

BU-18
OR-18

U704-U23
PK-18
U705-U24
PU-18
U736-U2 YL-18
U742-U94
WH-18
U747-U9 OR-18
U748-U10
GY-18
U749-U11
BR-18
U750-U12
PK-18
U751-U16
WH-18
U752-U15
PU-18

RH REAR WORK LAMP HID


289-3820

607-U88
PK - 14
607-U89
PK - 14
607-U105
PK-14
607-U114
PK-14
611-U128
PU-14
617-U125
BR-14
618-U130
YL-14
619-U129
GN-14
685-U90
BR-14
685-U107
BR-14

GY-18
YL-18
GY-18
OR-18

K927-U35

U-C8
1552269
BU- 18
BK - 18

U747-U9 OR- 18
H862-U62
GY- 18

PK-14
PK-14
PK-14
PK-14

H861-U65
H861-U64
H861-U66
H861-U67

F775-U78
200-U79

U-C18
1552269

799-U4 WH-18
801-U117
PK-14
925-U38

WH- 18
PU - 18

BU- 18
BU- 18

PU-14
BR-14
YL-14
GN-14

BR-14

799-U4
WH- 18
A202-U25
BK - 18
X754-U31
GN- 18
X755-U32
WH- 18
925-U38
YL - 18
H764-U82
GY - 18

1
2
3
4
5
6
7
8

607-U105
607-U114
607-U88
607-U89
611-U128
617-U125
618-U130
619-U129

U751-U16
U752-U15

YL-18
GY-18

PK-14

WH- 18

X725-U92

570-U33
570-U27

YL - 18
PK - 18

U703-U6
K927-U53

WH-16
WH-16

1
4
3
2

439-U77
169-U76

U702-U5
K927-U55

YL-18

BU- 18
605-U124
606-U127

U702-U5 GY- 18
U703-U6 YL - 18
U747-U9 OR- 18
U748-U10
GY- 18
U749-U11
BR - 18
U750-U12
PK - 18

RH HEATED MIRROR
259-4759

J-C6
3E3364

J-C3
1552269

MOTOR

U718-CL6
E789-CL3

ID
PART#
J 291-2908
K 276-9014
L 276-9014
Y 235-6175
AE 238-8749
CK 235-6183
CT 238-8813
WA 261-9391

MSS KEYREADER
218-0404

BK - 14
BK - 14

U736-U2
YL - 18
H803-U121
BU-18

CAB FLOOD LAMP SW


249-5480
OFF
ON

BK-14
BK-14
BK-14
BK-14

570-U44

169-U76
PK - 18
439-U77
YL - 18
F775-U78
BU - 18
A847-U122
YL-18
A849-U123
OR-18
322-U102
GY - 18

BK-14
BK-14
BK-14
BK-14

200-U91
200-U104
200-U45
200-U98

439-U77

RH FRONT WORK LAMP1 HID


286-3077

RH FRONT WORK LAMP2


234-4326

J-C16
3E3364

J-C5
1552269

BU - 18
PU - 18

200-U96
200-U111
200-U110
200-U97

CTR SHIFT PIN PULLED SW


3E-3636

U-C9
1552272

K927-U53
BU- 18
K927-U55
BU- 18
K952-U56
BR - 18
K952-U57
BR - 18
K952-U58
BR - 18
K952-U59
BR - 18
M720-U14 BU- 18
M722-U13 OR- 18
U700-U7 WH- 18
U701-U8 GN- 18

PK-18
BK-14

BK-14
BK-14

200-U47
200-U100

ROOF

1
2
3
4
5
6
7
8
9
10

1
2

YL-18
BK - 18

WH-18
BK-18

1
2

1
2

J-C31
1552269
A557-J44
200-J45

680-K1
200-K2

J-C15
1552269

H863-U39
H861-U40

200-U95
200-U101

LH FRONT WORK LAMP2 HID


289-3820

LH REAR WORK LAMP


234-4325

J-C8
3E3364

GY-18
OR-18
BU - 18
BR - 18
GY - 18

169-U76
200-U131

LH FRONT WORK LAMP1 HID


286-3077

K-C2
1552269
GN-14
BK-18

J-C7
1552269

K831-U119
K832-U120
K927-U35
K952-U36
H862-U37

200-U95
200-U113
200-U100

680-L1
200-L2

J-C29
3E3364

GY - 18
YL - 18
WH- 18
GN- 18
OR - 18
GY - 18
BR - 18
PK - 18
OR - 18
BU - 18
PU - 18
WH- 18
OR - 18
GN- 18
GY - 18
BU - 18
YL - 18
GY - 18
PK - 18
PU - 18
BU-18
YL-18
BU - 18
OR - 18
PU - 18
WH-18

607-U28

1
2
3
4
5
6
7
8
9
10
11
12

KEYSWITCH RUN

1
2

J-C28
1552269

U702-U5
U703-U6
U700-U7
U701-U8
U747-U9
U748-U10
U749-U11
U750-U12
M722-U13
M720-U14
U752-U15
U751-U16
R903-U17
R902-U18
R901-U19
R900-U20
K789-U21
K788-U22
U704-U23
U705-U24
M906-U48
H807-U51
570-U44
R800-U83
P967-U84
H808-U118

U-C70
1552252

L-C2
1552269
GN-14
BK-18

1
2

CONN 11

1
2
3
4
5
6
7
8
9
10

BR - 18
PK - 18

CONN 25

LH FRONT WORK LAMP2


234-4326

1
2

C542-J15
GN- 18
200-J6
BK - 18

609-J39
200-J38

J-C32
3E3364

1
2

CONN 12

REAR/BLADE
OFF
BLADE

RS232 PORT1-DCD
RS232 PORT1-GND

LH FRONT WORK LAMP1


290-5749

1
2

CONN 16

609-J18
200-J9

1
2
3
4
5
6
7
8
9
10

169-U76
PK - 18
200-U79
BK - 18
439-U77
YL - 18
F775-U78
BU- 18
H861-U64
PU - 18
H861-U65
PU - 18
H862-U60
GY- 18
H862-U61
GY- 18
H862-U62
GY- 18
H862-U63
GY- 18

FRONT FRAME 1
GROUND

J-C14
3E3364

J-C30
1552269

GN-14
BK-14

J-C11
1552269
GN- 14
BK - 14

OFF
ON

1
2
3
4
5
6
7
8
9
10

RS232 PORT1-RXD
RS232 PORT1-DTR

WH-18
BK-18

1
2

CONN 20

CONN 19

J-C18
3E3364

J-C13
1552269

CONN 13

FLOOD LAMPS SW
249-5488

RS232 PORT1-TXD

LH HEATED MIRROR
259-4759

1
2

CONN 15
C542-J14
C542-J15

CDL HIGH
CDL LOW

LH FWD POSITION LAMP


212-3924

1
2

CONN 22

WH-18

GN- 18

BR-14
BK - 18

J-C9
CONN 18 1552269
680-J20
GN- 14
200-J1
BK - 14

BR - 14
YL - 14

YL-18

J-C20
3E3364

J-C19
1552269

C542-J14
GN- 18
200-J5
BK - 18

BK - 14
BK - 18
BK-14
BK - 14
BK-18

PK - 18

YL-18

617-J17
618-J25

RD- 18
BK - 18
YL - 18
GN- 18
GN- 18
BR - 18
GN- 18
YL - 18

617-J17
200-J8

200-J9
BK - 18
200-J10 BK-14
200-J4
BK-14
200-J8
BK - 18
200-J45
BK-18

BK - 18

BK-18

1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70

TO CAB SCHEMATIC
VOLUME 2 (P-C61)
LOC F-3

BK - 14
BK - 18
BK - 18
BK-14

DIMMER SW
249-5479
1
2
3
4
5
6
7
8
9
10

U-C1
9X4391

CONN 32

CONN 23

AE-C7
2234778

OR- 18
GN- 18

GN-18

CONN 10
170-J11
A295-J24
308-J27
403-J28
893-J29
892-J30
K900-J32
K990-J31

BU- 18

646-AE58
200-AE6
647-AE56
614-AE11
125-AE16
614-AE57
125-AE17
668-AE8
668-AE61
125-AE18

RD-18

LOAD RETURN #01

RD- 18

668-AE4

YL-18

170-WA3

- UNSWITCHED BATTERY

104-AE1
RD- 18
A608-AE2
GY- 18

116-AE23
116-AE30

BR-18
GN-18
GN-18

K900-WA6

CONN 14

116-AE22

OR-18
YL-18

170-WA3 RD-18
308-WA12 YL-18
403-WA14 GN-18
A295-WA16 BK-18
N957-WA19 PK-18
N960-WA18 OR-18
N970-WA20 YL-18
N973-WA21 BR-18
N979-WA17 GN-18

C542-J16

125-AE3

PK-18

170-WA3 RD-18
308-WA12 YL-18
403-WA14 GN-18
A295-WA16 BK-18

A557-J44

RD- 18
WH- 18

GN-18
BR-18

YL-18
YL-18

104-AE1
106-AE45

PRODUCT LINK 300


239-9954
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70

GEN2 RADIO
263-9088
1
2
3
4
5
6
7
8
9
10
11
12

- UNSWITCHED BATTERY

AE-C1
2234778

CONN 87

WA-C2
1552252

CAT DATA LINK HIGH

CK-C2
1471446

WORLD VIEW MAIN (ATCH)


WA-C3
1607690

1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70

YL - 18
OR- 18
WH- 18

12

CAB HARNESS & CABLE CHART 16M


CHG ATCH NOTE(S) LOC SHEET
DESCRIPTION
00 STD
D-6 1
ROOF GROUP
00
F-6 1
RH REAR WORK LAMP
00
F-6 1
LH REAR WORK LAMP
02 ATT
G-11 1
AUX WIPERS
04 STD
I-11 1
B POST LIGHTS
02 I-13 1
IMP SLAVE2 CONTROL
01 ATT
A-7 1
MSS
01 ATT
G-7 1
WORLDVIEW MAIN

ABBREV

COLOR

RD
WH
OR
YL
PK
BK
GY
PU
BR
GN
BU

RED
WHITE
ORANGE
YELLOW
PINK
BLACK
GRAY
PURPLE
BROWN
GREEN
BLUE

SYMBOL

CONN 5
VOLUME 1 (CK-C3)
LOC G-15

1
2
3
4
5
6
7
8
9
10
11
12

CL-C1
1552253
U718-CL6
U717-CL7
U714-CL8
U713-CL9
U715-CL10
U716-CL11
U719-CL12
U720-CL13
E790-CL14
E789-CL5

U718-CL6
U717-CL7
U714-CL8
U713-CL9
WH- 18
OR- 18
PU - 18
PK - 18
BR - 18
BU- 18
GN- 18
GY- 18
PK - 18
PU - 18

E789-CL5

WHORPUPK -

18
18
18
18

E789-CL2
E789-CL1
E789-CL4
E789-CL3

PU- 18

U717-CL7
E789-CL1

PUPUPUPU-

18
18
18
18

WH- 18
PU - 18

OR- 18
PU - 18

U714-CL8
E789-CL4

PU - 18
PU - 18

U713-CL9
E789-CL2

PK - 18
PU - 18

CL-C2
1552269
1
2

CL-C3
1552269
1
2

CL-C4
1552269
1
2

CL-C5
1552269
1
2

CL-C10
3E3364

AUX VALVE 5 PORT A SOLENOID


278-1799

CL-C11
3E3364

AUX VALVE 5 PORT B SOLENOID


278-1799

CL-C12
3E3364

AUX VALVE 3 PORT A SOLENOID


278-1799

CL-C13
3E3364

AUX VALVE 3 PORT B SOLENOID


278-1799

K831-U119
K832-U120
H808-U118
H803-U121
A847-U122
A849-U123

U-C65
1552273
GY-18
OR-18
WH-18
BU-18
YL-18
OR-18

U-C66
3E3382
1
2
3
4
5
6

1
2
3
4
5
6

CY-C1
3E3382
K831-CY1
K832-CY2
H808-CY3
H803-CY4
A847-CY5
A849-CY6

GY-18
OR-18
WH-18
BU-18
YL-18
OR-18

A847-CY5
A849-CY6

CY-C2
1552269
OR-18
WH-18

1
2

R BLADEDWN FORCE OP SOL


278-1799

K831-CY1
H808-CY8

CY-C3
1552269
GY-18
WH-18

1
2

L BLADEDWN FORCE OP SOL


278-1799

A849-CY6
H803-CY9

CY-C4
1552269
OR-18
BU-18

1
2

R BLADEDWN FORCE CONT SOL


278-1799

A847-CY5
H803-CY10

CY-C5
1552269
YL-18
BU-18

1
2

L BLADEDWN FORCE CONT SOL


278-1799

YL-18
OR-18

H808-CY3

WH-18

H808-CY7
H808-CY8

WH-18
WH-18

H803-CY4

BU-18

H803-CY9
H803-CY10

BU-18
BU-18

K831-CY1
K832-CY2

K832-CY2
H808-CY7

GY-18
OR-18

FRONT SOLENOIDS

DESCRIPTION
CIRCUIT CONNECTED

U715-CL10
E790-CL17

BR - 18
PK - 18

CL-C6
1552269
1
2

CL-C14
3E3364

AUX VALVE 4 PORT B SOLENOID


278-1799

CL-C15
3E3364

AUX VALVE 4 PORT A SOLENOID


278-1799

CL-C16
3E3364

AUX VALVE 6 PORT B SOLENOID


278-1799

CL-C17
3E3364

AUX VALVE 6 PORT A SOLENOID


278-1799

CIRCUIT NOT CONNECTED


ELECTRICAL CONNECTION TO
MACHINE STRUCTURE

E790-CL14

INTERNAL ELECTRICAL CONNECTION


TO SURFACE OF COMPONENT

PK - 18
U715-CL10
U716-CL11
U719-CL12
U720-CL13

CONNECTOR
H#

E790-CL17
E790-CL16
E790-CL15
E790-CL18

CIRCUIT GROUPING DESIGNATION

BR BUGNGY-

18
18
18
18

PK PK PK PK -

18
18
18
18

U716-CL11
E790-CL16

BU- 18
PK - 18

U719-CL12
E790-CL18

GN- 18
PK - 18

U720-CL13
E790-CL15

GY- 18
PK - 18

ATCH WIRE, CABLE, COMPONENT


SPLICE

CL-C7
1552269
1
2

CL-C8
1552269
1
2

CL-C9
1552269
1
2

WIRE GROUP COLOR DESCRIPTIONS

REAR SOLENOIDS

BLADE, SPADE, RING OR SCREW


TERMINAL

GROUND CIRCUIT
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON

AUXILIARY VALVES

TRANSMISSION / ENGINE PUMP CONTROL CIRCUIT

SYMBOL

122-Y1
200-Y2
T971-Y7

Y-C1
1552267
BU- 14
BK - 16
OR- 14

A
B
C

1
3
4

L
GND

MOTOR

B+

CONN 1
TO P-HARNESS
VOLUME 2(P-C56)
LOC A-3

1
2
3
4

Y-C3
3E3376
122-Y5
T971-Y7
T972-Y8
200-Y6

BU- 14
OR- 14
GN- 14
BK - 14

BU- 14

122-Y3
122-Y1

BU-14
BU-14

200-Y6

BK - 14

200-Y2
200-Y4

BK-16
BK-16

T971-Y7
T972-Y8

CIRCUIT NOT CONNECTED

GROUND CIRCUIT

VIDEO SIG
VIDEO GND
+ 12 VDC
FEED GND

COAX CORE
COAX SAFEGUARD
RED
WHITE

CABLE AS CAM
251-8248

COAX CORE
COAX SAFEGUARD
RED
WHITE

CABLE AS RAD
251-8248

MACHINE SECURITY CONTROL CIRCUIT

REAR VISION MONITOR


261-3224

CONNECTOR

HEATER AND AIR CONDITIONER CIRCUIT

H#

TURN SIGNAL / WIPER WASHER CIRCUIT


CAT DATA LINK

122-Y3
200-Y4
T972-Y8

OR- 14
GN- 14

Y-C2
1552267
BU- 14
BK - 16
GN- 14

A
B
C

1
3
4
6

L
GND

MOTOR

T
B+

251-4160
251-4163
251-4166

(115 COLOR)
( 78 COLOR)
(115 B/W)

LG
(3m)
(5m)
(11m)
(21m)

RS-232 DATA LINK

SPLICE

IMPLEMENT CONTROL CIRCUIT (1)

BLADE, SPADE, RING OR SCREW


TERMINAL

A
U
AC
AF
AH
AJ
CL
CY
EG
UA
UC
UH

OTHER COLOR DESCRIPTIONS


HIGHWAYS

AUX WIPERS

THIS SCHEMATIC IS FOR THE 16M MOTOR GRADER ELECTRICAL SYSTEM


VOLUME 1 of 3: CAB
MEDIA NUMBER: RENR9024-08
SCHEMATIC PART NUMBER: 267-3908, CHANGE: 01, VERSION: Components are shown installed on a fully operable machine with the key and engine off, transmission shifter
in neutral and with parking brake set.
Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.
Refer to the Parts Manual using a specific serial number prefix in SIS before ordering parts from this schematic.

14

ID

ATCH WIRE, CABLE, COMPONENT

IMPLEMENT CONTROL CIRCUIT (3)

RH SIDE WIPER MOTOR


248-2628

15

CIRCUIT GROUPING DESIGNATION

CAN DATA LINK


CABLE
OPTIONS
261-3223
251-8248
251-4169
251-8249

13

12

11

10

HIGHWAYS

INTERNAL ELECTRICAL CONNECTION


TO SURFACE OF COMPONENT

TRANSMISSION / ENGINE PUMP CONTROL CIRCUIT


VIDEO SIG
VIDEO GND
+12 VDC
FEED GND

OTHER COLOR DESCRIPTIONS

ELECTRICAL CONNECTION TO
MACHINE STRUCTURE

WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON

CONN 82

IMPLEMENT CONTROL CIRCUIT (2)


IMPLEMENT CONTROL CIRCUIT (3)

CIRCUIT CONNECTED

WIRE GROUP COLOR DESCRIPTIONS


WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF

REAR VIEW CAMERA

LH SIDE WIPER MOTOR


260-2577
122-Y5

+V SPLY
GROUND
TRIGGER #1
TRIGGER #2
TRIGGER #3
NO CONN

TURN SIGNAL / WIPER WASHER CIRCUIT


IMPLEMENT CONTROL CIRCUIT (1)

DESCRIPTION

ABBREV

COLOR

RD
WH
OR
YL
PK
BK
GY
PU
BR
GN
BU

RED
WHITE
ORANGE
YELLOW
PINK
BLACK
GRAY
PURPLE
BROWN
GREEN
BLUE

HARNESS & CABLE CHART


CHG ATCH LOC
DESCRIPTION

PART#

236-2335
260-1880
270-3420
270-3422
270-3420
270-3422
260-1882
260-1884
260-1876
278-2529
278-2530
300-7693

01
03
01
01
01
01
02
02
03
00
00
00

ATT
STD
ATT
ATT
STD
ATT
ATT
STD
STD
STD
STD
ATD

H-2
G-6
F-4
F-4
I-3
I-3
C-8
D-5
E-3
G-3
F-3
I-4

COMBINATION HEAD LAMP


FRONT FRAME
RH TANDEM FLOOD
RH FRONT FLOOD
LH TANDEM FLOOD
LH FRONT FLOOD
FRONT HYD ATTACH
BLADE DOWNFORCE SOLENOIDS
AUTOLUBE
LEFT STEER CYLINDER POSITION SENSOR
RIGHT STEER CYLINDER POSITION SENSOR
AIR HORN

THIS SCHEMATIC IS FOR THE 16M MOTOR GRADER ELECTRICAL SYSTEM


VOLUME 1 of 3: CHASSIS
MEDIA NUMBER: RENR9024-08
SCHEMATIC PART NUMBER: 267-3909, CHANGE: 00, VERSION: Components are shown installed on a fully operable machine with the key and engine off, transmission shifter
in neutral and with parking brake set.
Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.
Refer to the Parts Manual using a specific serial number prefix in SIS before ordering parts from this schematic.

Failure Mode Identifiers (FMI)

8V DC Sensor Power Supply

Data valid but above normal operational range.

Component

Schematic
Location

Machine
Location

Data valid but below normal operational range.

Data erratic, intermittent, or incorrect.

Actuator - Water Valve

A-14

10

Relay - Cab Floodlights

E-5

Voltage above normal or shorted high.

Alarm - Action

H-5

Relay - Condenser Fan

B-13

Voltage below normal or shorted low.

Breaker - Fast Speed Blower

B-10

Relay - Condenser Fan 2

B-13

Current below normal or open circuit.

Cluster - Dash

D-5

Relay - Differential Lock

B-5

I-9

Relay - Dimmer

C-5

Parking Brake Switch


Fuel Level Sensor

Current above normal or grounded circuit.

Control - Implement 1

0144

Backup Alarm Relay

Mechanical system not responding properly.

Control - Implement 2

I-10

Relay - Fast Speed

B-14

0168

Electrical System Voltage

Abnormal frequency, pulse width, or period.

Converter - Communications

F-14

Relay - Headlamp

B-5

Abnormal update.

Converter - Entertainment Radio

G-4

Resistor - AccuGrade Can

B-8

Diode - Rear Flood Interlock

F-5

Resistor - Blower

A-14

10

0177

Transmission Oil Temperature Sensor

0247

SAE J1939 Data Link

10

Abnormal rate of change.

0248

Cat Data Link

11

Failure mode not identifiable.

Fuse - Buss (Switched)

C-10

Resistor - Can 2

B-8

Fuse - Buss (Un-Switched)

D-10

Resistor - DC Can 1

D-1

5 Volt Sensor DC Power Supply

12

Bad device or component.

0368

Transmission Auto / Manual Switch

13

Out of calibration.

Ground - Cab 2

A-10

Resistor - DC Can 2

E-5

0420

Secondary Steering Relay

14

Parameter failures.

Ground - Cab 3

A-10

Resistor - Defrost Fan

E-14

0444

Starter Motor Relay

15

Parameter failures.

Ground - Cab 4

A-10

Sensor - Inching Pedal

C-3

0573

Inching Pedal Position Sensor

16

Parameter not available.

Ground - Cab Roof

B-15

Sensor - Left Blade Down Force

I-14

0585

Transmission Output Speed Sensor 1

17

Module not responding.

Indicator - Auto Shift Enabled

G-5

Sensor - Right Blade Down Force

I-14

0588

Monitoring System Display

18

Sensor supply fault.

Indicator - Auxiliary Lever 6 Float

A-2

Sensor - Throttle Position

C-3

Engine ECM

19

Condition not met.

Indicator - CTR Shift Pin Pulled

G-5

Switch - A/C On

B-14

Parameter failures.

Joystick - Left Hand

I-1

Switch - Auto Shift On/Off

B-2

0596

Implement ECM

0615

Machine Articulation Angle Position

20

The FMI is a diagnostic code that indicates what type of failure has occurred.

Joystick - Mini

B-1

Switch - Blade Cushion

B-2

Joystick - Right Hand

C-1

Switch - Blade Force

I-14

0621

Downshift Switch

0622

Upshift Switch

Lamp - Dome

F-14

Switch - Brake Light

C-3

0623

Directional Switch

LED - LH Joystick Illumination

A-14

Switch - Brake Pedal

C-3

0627

Park Brake Pressure Switch

LED - RH Joystick Illumination

B-14

Switch - Center Shift Pin

E-1

0669

Transmission Input Speed Sensor

Lever - Auxiliary 6

A-2

Switch - Compression Brake

H-5

0673

Transmission Output Speed Sensor 3

Lever - Auxiliary 7

A-2

Switch - Defrost Fan

B-3

Messenger

D-1

Switch - Differential Lock Floor

C-3

0674

Transmission Intermediate Speed Sensor 1

0675

Transmission Intermediate Speed Sensor 2

Wire Description
Wire
Number

Wire Color

Description

Wire
Number

Wire Color

Power Circuits

Description

Module - Flasher

Control Circuits (Continued)

0681

Parking Brake Solenoid Valve

101

RD

Battery +24V

J769

YL

Right Side Auto/Manual SW (NC)

0967

Machine Application

103

RD

LH Position Lamps Fuse

J771

BU

Left Side Auto/Manual SW (NC)

1326

Location Code

104

RD

RH Position Lamps Fuse

K722

YL

RT Inc/Dec SW (Dec)

1401

Transmission Clutch Solenoid 1

105

RD

Key Switch Fuse

K723

PU

RT Inc/Dec SW (Inc)

1402

Transmission Clutch Solenoid 2

106

WH

Cab Work Lamps

K737

BR

Engine Brake Cylinders 1 to 4

1403

Transmission Clutch Solenoid 3

108

RD

Dome Lamps

K738

GN

Engine Brake Cylinders 5 & 6

1404

Transmission Clutch Solenoid 4

109

RD

Alternator Breaker

K739

BU

Engine Brake Cylinder Common

1405

Transmission Clutch Solenoid 5

112

PU

Main Power Relay Output

K748

OR

Secondary Steer Motor Relay

1406

Transmission Clutch Solenoid 6

114

RD

Warning Horn (Forward)

K749

WH

Blade Right Lever Pos Sensor

1407

Transmission Clutch Solenoid 7

115

RD

Load Breaker

K750

PU

Blade Left Lever Pos Sensor

1408

Transmission Clutch Solenoid 8

116

BR

Beacon

K758

BU

Articulation Lever Pos Sensor

1471

Steering Control Position Sensor 1

117

RD

Main Breaker

K788

GY

Articulation Right Solenoid

1472

Steering Control Position Sensor 2

118

GY

LH Door Wipers

K789

YL

Articulation Left Solenoid

1473

Steering Control Position Sensor 3

119

PK

RH Door Wipers

L730

OR

+5V Supply (XMSN Cont)

1482

10 Volt Sensor DC Power Supply

120

YL

Front / Rear Wipers

L731

BR

5V Return (XMSN Cont)

1484

Inching Pedal Switch

121

YL

Back Alarm To Lamp

M719

GN

Blade Sideshift Left Pos Sensor

1674

Solenoid Return 1

122

BU

Side Wiper

M720

BU

Circle Sideshift Left Solenoid

1960

Ignition Key Reader

123

WH

Rear Work Lights

M722

OR

Circle Sideshift Right Solenoid

1961

Service Brake Accumulator Pressure

124

GN

HVAC

N707

PU

Fuel Pressure SW Return

2113

Operator Present Switch

125

Secondary Steer Left Solenoid

126

RD

Back Light

RD

N787

Transmission Control Fuse

N788

BU
PK

Hydraulic Filter Bypass Switch Pilot Supply


Not Used

Motor - Blower
Motor - Front Washer

I-5

Switch - Front Wiper

A-13

10

Switch - Hazard

C-13

B
2

Switch - Heated Mirrors

B-2

Switch - Horn

G-5

Motor - LH Door Washer

C-13

C-13

Switch - Inching Pedal

C-3

E-14

Switch - Key

D-4

Motor - Rear Washer

C-13

Switch - LH Auto / Manual

G-1

Motor - Rear Wiper

D-14

Switch - LH Door Wiper

H-14

E-13

11

Switch - LH Offset

H-1

Motor - RH Door Washer

C-13

Switch - Operator Present

B-13

Motor - RH Window Washer

C-13

Switch - Park Brake Up

G-5

Panel - HVAC Operator

D-13

G
C

Switch - RH Auto / Manual

G-1

B-4

Switch - RH Door Wiper

H-14

Relay - Heated Mirror

C-5

Switch - RH Offset

G-1

Relay - Horn

F-5

Switch - Secondary Steer Test

B-5

Relay - LH Position

C-5

Switch - SS Auto / Manual

G-1

Relay - Power Air Cleaner

B-13

Switch - Thermal

A-13

10

E-5

Switch - Throttle Lock Mode

E-1

Relay - RH Position

C-5

Switch - Throttle Set

E-1

Relay - Back Light

C-5

Switch - Turn Signal

H-5

Thermostat

A-13

10

BR

Hydraulic Oil Inlet Temp Sensor

PK

Park Brake Press SW (NO)

2200

Left Steering Cylinder Position Sensor

129

RD

Cigar Lighter

R746

PK

2201

Right Steering Cylinder Position Sensor

130

GN

Waves

R747

GY

Atmospheric Pressure Sensor

Check Part Numbers in the Parts Manuals for your Specific Machine

2252

Machine Articulation Angle Sensor 2

132

RD

Condenser Fan #1

T725

WH

Fuel Pressure SW

Machine locations are repeated for components located close together.

2304

Differential Lock Relay

134

RD

Air Cleaner

U700

WH

Circle Rt Sol

A = Located below or inside of dash.

135

RD

Condenser Fan #2

U701

GN

Circle Lt Sol

BU

Fast Speed Blower Breaker

U702

GY

Aux Valve 1 Sol B

C = Located inside of right console.

141

PK

Defrost Fan

U703

YL

Aux Valve 1 Sol A

D = Located inside or near left console.

BU

Flasher

U704

PK

Aux Valve 2 Sol B

E = Located inside rear cab covered compartment.


F = Located on right hand cab column.

PU

Aux Valve 2 Sol A

0003

Cylinder Injector #3

BR

Aux Lever 1 Pos Sensor

0004

Cylinder Injector #4

146

GY

Blade Work Light #2

U707

BU

Aux Lever 2 Pos Sensor

Cylinder Injector #5

150

RD

Engine Control Fuse

U708

OR

Aux Lever 3 Pos Sensor

0006

Cylinder Injector #6

152

RD

AccuGrade Fuse

U709

WH

Aux Lever 4 Pos Sensor

0041

8 Volt DC Supply

155

RD

AWD Control (Not used 14M)

U710

GN

Aux Lever 5 Pos Sensor

0091

Throttle Position Sensor

156

YL

Sensor Power

U711

GY

Aux Lever 6 Pos Sensor

160

PU

Heated Mirrors

U712

YL

Aux Lever 7 Pos Sensor

0094

Fuel Delivery Pressure Sensor

0100

Engine Oil Pressure Sensor

165

YL

Differential Lock

U713

PK

Aux Valve 3 Sol B

0110

Engine Coolant Temperature Sensor

169

PK

Center Shift / Blade Cushion

U714

PU

Aux Valve 3 Sol A

0168

Electrical System Voltage

170

RD

Product Link

U715

BR

Aux Valve 4 Sol B

0172

Intake Manifold Air Temperature Sensor

171

RD

Implement Control #1

U716

BU

Aux Valve 4 Sol A

0174

Fuel Temperature Sensor

172

RD

Implement Control #2

U717

OR

Aux Valve 5 Sol B

0190

Engine Speed Sensor

176

RD

Communication Radio Converter

U718

WH

Aux Valve 5 Sol A

0253

Personality Module

179

RD

Entertainment Radio Converter

U719

GN

Aux Valve 6 Sol B

RD

Implement Control Main

U720

GY

Aux Valve 6 Sol A

RD

Steering Valve

U723

PU

Fuel Level Sender

0261

Engine Timing

180

0262

5 Volt Sensor DC Power Supply

199

0267

Remote Shutdown

U724

WH

XMSN Filter Bypass SW

U725

GN

Auto Shift SW (NC)

Programmed Parameter
Sensor Power Supply

210

BK

Ent Radio Converter Output (24/12 Volt)

U726

GY

Auto Shift SW (NO)

0274

Atmospheric Pressure Sensor

229

BK

Engine Control Gnd

U727

WH

Inching Pedal (NO)

0291

Engine Cooling Fan

A201

BK

Not Used

U728

PK

Serv Brake Accum Charge Press Sensor

Transmission Control

A202

BK

Trans & Chassis Control

U734

GN

Park Brake SW (Off)

0297

All Wheel Drive Control

A210

BK

Not Used

U735

GY

Park Brake SW(On)

BK

Cab Gnd

U736

YL

Steering Valve Signal

BK

AccuGrade Gnd

U739

BR

Steering Lever Pos 1


Steering Lever Pos 2

0342

Secondary Engine Speed Sensor

A250

0549

Throttle Lock Switch

A274

0588

Monitoring System Display

A295

BK

Implement Control Ground

U740

BU

Implement Control

A296

BK

Implement 1 Control Ground

U741

OR

Steering Lever Pos 3

A297

BK

Implement 2 Control Ground

U742

WH

Steer Valve Error Signal

304

WH

0791

Compression Brake Low/High Solenoid


Compression Brake Medium/High Solenoid

1551

Cooling Fan Calibrate

1589

Turbocharger Inlet Air Pressure Sensor

306

1627

Fuel Pump Relay

307

1639

Machine Security System Module

308

1785

Intake Manifold pressure Sensor

2417

Ether Injection Control Solenoid

2770
2771

Basic Machine Circuits

U743

GY

Wheel Lean Input Pos Sensor

U744

OR

Auto Neutral Art Sw (NO)

GN

Starter Motor Relay Output

U745

PK

Auto Neutral Art Sw (NC)

OR

Key Switch Start

U747

OR

Wheel Lean Sol Left

YL

Main Power Relay Coil

U748

GY

Wheel Lean Sol Right

320

OR

Horn Relay Coil To Switch

U749

BR

Blade Sideshift Sol Right

321

BR

Backup Alarm

U750

PK

Blade Sideshift Sol Left

Throttle Lock Resume/Decel Switch

322

GY

Warning Horn (Forward)

U751

WH

Blade Pitch Sol Fwd

Throttle Lock Set/Accel Switch

365

YL

Fuel Priming Pump Relay

U752

PU

Blade Pitch Sol Reverse

U753

BR

Sec Steer Request Sig

CID
0041

Component
8 VDC Sensor Power Supply

GN

Alternator (r) Term.

U760

PK

Optional Float Ind 1

YL

Center Shift Pin Pulled Indicator

U761

PU

Optional Float Ind 4

C491

PU

Park Brake Pressure SW (NC)

U762

GN

Optional Float Ind 6

F421

YL

Fuel Supply Temp

U763

BU

Circle Drive Lever Pos Sensor

Electrical System Voltage

G434

BU

Not Used

U764

GY

Blade Pitch Input Pos Sensor

H414

YL

Action Alarm

U765

WH

Circle Sideshift IP Pos Sensor

0248

Cat Data Link

Accessory Circuits

U766

BR

Op Seat Sw (NO)

0262

5 Volt Sensor DC Power Supply

Implement Pilot Pressure Supply Solenoid

0490

Hydraulic Lockout Switch

0588

Monitoring System Display

BR

Wiper - Front (Park)

U767

BU

Op Seat Sw (NC)

GN

Wiper - Front (Low)

U768

BU

Art Angle Pos Sensor 2

502

OR

Wiper - Front (Hi)

U769

OR

Aux Valve 7 Sol B

503

BR

Wiper - Rear (Park)

U770

WH

Aux Valve 7 Sol A

504

YL

Wiper - Rear (Low)

X725

GY

Steering Signal To Controller

505

BU

Wiper - Rear (Hi)

X754

GN

Sec Steer Left Solenoid

X755

WH

Sec Steer Right Solenoid

0597

Main Hydraulic Pump Discharge Pressure

507

WH

Washer - Rear

Y787

YL

PHS Can (+) (Not Used)

0600

Hydraulic Oil Temperature Sensor

508

PU

Radio Speaker - Left

Y788

GN

PHS Can (-) (Not Used)

Location Code

1471

Steering Control Position Sensor 1

509

WH

Radio Speaker - Left (Common)

801

PK

Autolube Solenoid & Pump Motor

BR

Radio Speaker - Right

843

WH

Not Used

512

GN

Radio Speaker - Right (Common)

844

GN

Not Used

GY

Blower Motor (Hi)

849

YL

Not Used

516

GN

Blower Motor (Medium)

850

PU

Not Used

1472

Steering Control Position Sensor 2

517

BU

Blower Motor (Low)

892

BR

Cat Data Link (-)

1473

Steering Control Position Sensor 3

518

OR

+24V Flasher Input

893

GN

Cat Data Link (+)

10 Volt Sensor DC Power Supply

519

PK

Thermostat To Refrigerant Press. SW

A847

YL

Left Blade Down Force Pro Valve

520

WH

Opr A/C SW To Thermostat

A849

OR

Right Blade Down Force Pro Valve

2113

Operator Present Switch

521

YL

A/C SW To Refrigerant SW

A893

OR

Fuel Prime SW To Fuel Prime Pump

2143

Electronic Implement Control 3

522

WH

A/C Clutch To Thermostat SW

F843

YL

Inching Pedal Pos Sensor

2146

Articulation Lever Position Sensor

523

BR

Wiper - Left (Park)

F846

PU

MSS Status LED

524

BU

Wiper - Left (Low)

G826

WH

Fuel Press Sensor (+5V)

2147

Automatic Neutral Articulation Switch

525

GY

Wiper - Left (Hi)

G827

GN

Fuel Press Sensor (Gnd)

2150

Blade Left Lift Lever Position Sensor

526

YL

Wiper - Right (Park)

G828

WH

+5V Supply 1 (Eng Cont)

2151

Blade Right Lift Lever Position Sensor

527

GN

Wiper - Right (Low)

G829

GN

5V Return (Eng Cont)

2152

Wheel Lean Control Position Sensor

528

PK

Wiper - Right (Hi)

G833

PK

Temp Sensor Return

2153

Blade Pitch Control Position Sensor

529

WH

Washer Left

G856

WH

TDC Service Probe (+)

2154

Blade Sideshift Lever Position Sensor

530

OR

Washer Right

G857

YL

TDC Service Probe (-)

538

BR

Dash Flasher Indicator Output

H803

BU

Proportional Driver Return (9-12) (Imp Cont1)

Circle Drive Lever Position Sensor

539

BU

Turn Signal Indicator Right

H807

YL

Load Return 1 (Imp Cont)

540

WH

Turn Signal Indicator Left

H808

WH

Load Return 1 (Imp Cont2)


Proportional Driver Return (1-4) (Imp Cont)

2160

Blade Left Raise Solenoid Valve

556

WH

Differential Lock

H861

PU

2161

Blade Right Raise Solenoid Valve

567

WH

A/C SW To Condenser Fan Relays

H862

GY

Proportional Driver Return (5-8) (Imp Cont)

2162

Blade Left Lower Solenoid Valve

570

BU

Blade Cushion Sol

H863

BU

Proportional Driver Return (9-12) (Imp Cont)


Not Used

2163

Blade Right Lower Solenoid Valve

581

GY

Left Rear Turn Flasher

H864

GN

2165

Blade Sideshift Left Solenoid Valve

582

PK

Right Rear Turn Flasher

J844

GY

+8 Volt Supply (Eng Cont)

592

BU

Dc/Dc Converter Power Output

K831

GY

LH Down Force Enable Solenoid


RH Down Force Enable Solenoid

2166

Blade Sideshift Right Solenoid Valve

2167

Circle Left Solenoid Valve

2168

Circle Right Solenoid Valve

2169

593

GN

Condenser Fan Relay To Motors

K832

OR

A504

GN

Rear Defroster Fan (Low)

L854

YL

AccuGrade Can (+)

A507

YL

Rear Defroster Fan (Hi)

L855

GN

AccuGrade Can (-)

Circle Sideshift Left Solenoid Valve

A513

PK

Dc/Dc Converter Memory Output

R800

OR

+8V Sensor Power (Imp Cont)

2170

Circle Sideshift Right Solenoid Valve

A514

YL

Heated Mirror Power

R818

YL

Transmission Oil Temp Sensor

2171

Articulation Left Solenoid Valve

A524

BR

Temp Potentiometer Pos 2

T858

GY

Injector 1 & 2 High Side

2172

Articulation Right Solenoid Valve

A557

WH

Precleaner Blower +B

T859

WH

Injector 3 & 4 High Side

2173

Wheel Lean Left Solenoid Valve

A572

PK

Comm Converter 12V Output

T860

OR

Injector 5 & 6 High Side

2174

Wheel Lean Right Solenoid Valve

14

F-3

CONN 37

D-15

CONN 38

D-14

CONN 39

E-14

CONN 40

E-14

CONN 41

B-14

CONN 42

F-14

CONN 43

G-14

CONN 44

G-14

CONN 45

A-13

CONN 46

A-13

CONN 47

E-13

CONN 48

G-13

CONN 49 AccuGrade

A-5

CONN 50 Service Tool

A-5

CONN 51 Air / Heated Seat

A-5

CONN 52

I-4

CONN 53

I-4

CONN 54

A-2

CONN 55

A-2

CONN 56

G-2

CONN 57

H-2

16M Motor Grader


Electrical System
B9H1-750

Printed in U.S.A.

Temperature
Symbol

Level
Symbol

2181

Blade Pitch Forward Solenoid Valve

2182

GN

Autolube Pressure Sensor Signal

X800

OR

+8V Sensor Return (XMSN Cont)

GN

Heated Mirror Power

900

PU

XMSN Shift Sol 4

C546

WH

Blower Fast Speed Relay

901

WH

XMSN Shift Sol 6

Blade Pitch Backward Solenoid Valve

C558

BU

Condenser Fan 2 Relay Out

902

BR

XMSN Shift Sol 7

2200

Left Steering Cylinder Position Sensor

C568

WH

Blower Motor (Max)

903

GY

XMSN Shift Sol 8

2201

Right Steering Cylinder Position Sensor

E529

YL

Power Air Cleaner Relay Coil

921

WH

XMSN Sol Return

2202

Steering Valve Control Module

E554

PK

A/C Cont To A/C Comp Clutch

922

BR

XMSN Sol Return

2203

Steering Valve Control Module Spool Position Sensor

Sender: A component that is used with a temperature or pressure gauge. The sender
measures the temperature or pressure. Its resistance changes to give an indication to
the gauge of the temperature or pressure.
Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity.
It has a coil that makes an electromagnet when current flows through it. The
electromagnet can open or close the switch part of the relay.
Solenoid: A solenoid is an electrical component that is activated by electricity. It has a
coil that makes an electromagnet when current flows through it. The electromagnet
can open or close a valve or move a piece of metal that can do work.

Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is


activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)
that make electromagnet when current flows through them. It also has an internal switch that places
the latch coil circuit open at the time the coil latches.

14

Harness and Wire Symbols

6
3
C

Wire,
Cable,
or
Harness
Assembly Identification: Includes
Harness Identification Letters and
Harness Connector Serialization
Codes (see sample).

Harness Identification Letter(s):


(A, B, C, ..., AA, AB, AC, ...)

L-C12
3E-5179

AG-C4
111-7898

Part Number: for Connector Receptacle

Plug

Receptacle
Pin or Socket Number

1
2

Deutsch connector: Typical representation


of a Deutsch connector. The plug contains all
sockets and the receptacle contains all pins.

1
2

Sure-Seal connector: Typical representation


of a Sure-Seal connector. The plug and receptacle
contain both pins and sockets.

Event Codes
Engine Control
3

Event Code

E096

Fuel Pressure Is High

E172

Inlet Air Is Restricted

7
8

A
C
D
14

1
E
10

E194

Exhaust Temperature Is High

E265

Shutdown (Ground Level)

E360

Oil Pressure Is Low

E361

Coolant Temperature Is High

E362

Engine Overspeeds

E363

Fuel Temperature Is High

E390

Fuel Filter Is Restricted

E441

Idle Speed Is High

E539

B
12

Condition

Intake Manifold Air Temperature Is High

Transmission / Chassis Control

YL

XMSN Sol Shift 1

994

GY

Engine Oil Pressure Sensor

Event Code
Low Brake Pressure

Transmission Filter Plugged

Auxiliary Lever 2 Position Sensor

2206

Auxiliary Lever 3 Position Sensor

2207

Auxiliary Lever 4 Position Sensor

2208

Auxiliary Lever 5 Position Sensor

609

YL

2209

Auxiliary Lever 6 Position Sensor

610

OR

2210

Auxiliary Lever 7 Position Sensor

611

PU

Head Lamp Hi

2211

Auxiliary Valve 1 - Port B Solenoid

614

PU

Backlight Relay Input

2212

Auxiliary Valve 1 - Port A Solenoid

2213

Auxiliary Valve 2 - Port B Solenoid

2214

Auxiliary Valve 2- Port A Solenoid

2215

11

Condition

604

OR

Stop Lamp

995

BU

Engine Coolant Temperature

0284

605

YL

Turn Lamp - Left

997

OR

Analog Sensor Power (+ 5V)(Imp Cont)

0329

606

GY

Turn Lamp - Right

998

BR

5V Return (Imp Cont)

0490

Parking Brake ON

607

PK

Blade Floods #2

A975

BU

Differential Lock Relay

0627

Parking Brake Abuse

Snow Wing Lamps

C967

BU

Intake Manifold Air Temp

Head Lamp Relay Out

C978

BR

Set Throttle SW (NC)

C979

OR

Resume Throttle SW (NO)

C981

GN

Compression Brake

617

BR

Tail/Position Lamp - Left

C991

PK

0795

Machine Speed Excessive For Machine Articulation Angle

0877

High Transmission Oil Temperature

Implement Control

Fuel Pressure Sensor

Event Code

Steering System Malfunction

Condition

618

YL

Tail/Position Lamp - Right

E900

WH

XMNS Output Spd (-)

0192

619

GN

Head Lamp Lo

E901

GN

XMNS Output Spd (+)

0256

Steering Output Detected In The Wrong Direction

626

BU

Backlight Relay Out

E902

PU

XMNS Intermediate Spd (-)

0257

Steering Output Detected With No Command

Auxiliary Valve 3 - Port B Solenoid

645

PK

Headlamp Relay Coil

E903

YL

XMNS Intermediate Spd (+)

0258

No Steering Detected With Command Given

2216

Auxiliary Valve 3 - Port A Solenoid

646

OR

Rear Flood Relay Coil

E904

BR

XMNS Intermediate Spd (-)

2217

Auxiliary Valve 4 - Port B Solenoid

647

GN

Blade Flood Relay Coil

E905

BU

XMNS Intermediate Spd (+)

2218

Auxiliary Valve 4 - Port A Solenoid

660

PU

Ind Lamp - Auto Shift 1st Gear

E906

OR

XMNS Trans Output Spd (-)

2219

Auxiliary Valve 5 - Port B Solenoid

668

BU

Backlight Relay Out

E907

GY

XMNS Trans Output Spd (+)

2220

Auxiliary Valve 5 - Port A Solenoid

680

GN

Cab Floodlights Relay Out

E908

BR

XMNS Trans Input Spd (-)

683

PU

Rear Flood Relay Out

E909

WH

XMNS Trans Input Spd (+)

684

OR

Cab Flood Relay Input

E929

GY

Articulation Angle Pos Sensor

0263

Low Main Pump Pressure

0455

Hydraulic Pilot Supply Filter Plugged

0560

Secondary Steer Pump No Response

0562

Steering Lever Has Not Been Aligned To Wheel Steering


Angle

0598

Steering Limited Due To Cold Hydraulic Oil

2221

Auxiliary Valve 6 - Port B Solenoid

2222

Auxiliary Valve 6 - Port A Solenoid

2223

Auxiliary Valve 7 - Port B Solenoid

695

OR

Left Turn Lamp Relay Coil

E964

WH

Engine Speed Sensor (+)

2224

Auxiliary Valve 7 - Port A Solenoid

696

GN

Right Turn Lamp Relay Coil

E965

BU

Sec Engine Speed Sensor (-)

0796

Machine Articulation Angle Limited Due To Machine Speed

2252

Machine Articulation Angle Sensor 2

A608

GY

Dimmer Relay Coil

E966

YL

Sec Engine Speed Sensor (+)

0861

Clock Manual Alignment Required

2650

Steering Valve Control Module Power Supply

E974

GN

Inching Pedal SW (NC)

0878

High Hydraulic Oil Temperature

709

OR

+10V Supply (Imp Cont)

F916

GN

Backup Alarm Relay

2085

Invalid Articulation Response Detected

727

GN

Sec Steer Test SW

G946

OR

Throttle Set SW (NO)

751

GN

XMSN Shift Sol 3

G953

BU

Impl Pilot Supply Solenoid

752

YL

XMSN Shift Sol 2

G965

PU

Load Return 2 (Imp Cont)

685

BR

Blade Floods

E963

Control Circuits

The CID is a diagnostic code that indicates which circuit is faulty.


The MID is a diagnostic code that indicates which electronic control module
diagnosed the fault.

BK

Engine Speed Sensor (-)

754

BU

XMSN Shift Sol 1

K900

YL

J1939 Data Link +

755

OR

XMSN Shift Sol 5

K927

BU

PWM Driver Return (5-8) (Imp Cont1)

799

WH

+10V Supply (XMSN Cont)

K952

BR

PWM Driver Return (1-4) (Imp Cont1)

Resistor, Sender and Solenoid Specifications - Volume 2


Component Description
Defrost Fan

125-9740

Resistor:

Blower

134-2540

Resistor:

Can / AccuGrade Can

At room temperature unless otherwise noted.

0599

Gear Too High For Steering With Cold Oil

0795

Machine Speed Excessive For Articulation Angle

Title

10 0.5
A-C: 2 0.1
B-C: 1 0.05
C-D: 0.36 0.018
120 12

MACHINE HARNESS CONNECTOR AND COMPONENT LOCATIONS

Related Electrical Service Manuals

Resistance (Ohms)

Off-Machine Switch Specification


Part No.
3E-5464

Function
Thermostat

Actuate

Deactuate

Contact Position

-1.1 0.8C
(30 1.4F)

2.2 0.8C
(36 1.4F)

Normally Closed

9X-1123

Component
Part Number

325-AG135 PK-14
Harness identification code:
This example indicates wire group 325,
wire 135 in harness "AG".

925

2205

5A
Fuse (5 Amps)

Rotary Beacon

Auxiliary Lever 1 Position Sensor

Harness Connector Serialization Code:


The "C" stands for "Connector" and the
number indicates which connector in the
harness (C1, C2, C3, ...).

L-C12
3E-5179

Lighting Circuits

2204

Circuit Breaker
Symbol

Ground (Wired): This indicates that the component is connected to a grounded wire. The
grounded wire is fastened to the machine.

C532

PK

Flow
Symbol

Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
No circle indicates that the wire cannot be disconnected from the component.

C542

603

H-2

CONN 32

Electrical Implement Control 2

Circle Sideshift Control Position Sensor

CONN 25

Part Number: for Connector Plug

1482

2155

11

1558

2156

F-3

Fuse: A component in an electrical circuit that will open the circuit if too much current flows
through it.

511
515

CONN 24

Pressure
Symbol

10

Washer - Front

1326

A-14

PU

Machine Articulation Angle Position Sensor

A-14

CONN 9

506

Machine Application

CONN 8

2015 Caterpillar, All Rights Reserved

Engine Electronic Control Module

0615

12

500
501

0590

0967

A-5

403
439

SAE J1939 Data Link

0358

CONN 7

Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.

0168

Transmission / Chassis ECM

D-3
G-14

Ground (Case): This indicates that the component does not have a wire connected to ground.
It is grounded by being fastened to the machine.

0247

0296

CONN 3
CONN 6

Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
circle indicates that the component has screw terminals and a wire can be disconnected from it.

Cranking Motor

Monitoring Circuits

Symbols and Definitions

0296

0792

D-3

Main Chassis

0269

A-3

CONN 2

Symbols

Ground Circuits

0268

CONN 1

Harness And Wire Electrical Schematic Symbols

BK

200

Machine
Location

Volume 2 of 3: Cab

142

U705

Electronic Implement Control (MID No. 082)


Electronic Implement Control 2 (Mid No. 147)

E
G

140

U706

0596

E-4
E-5

B = Located inside or near fuse panel.

Blade Work Lights

0005

Relay - Blade Flood


Relay - Blade Flood 2

Schematic
Location

The connectors shown in this chart are for harness to harness connectors.
Connectors that join a harness to a component are generally located at or near
the component. See the Component Location Chart.

Relay - Rear Flood

R732

Seat

B-1

R736

BR

H-14

Port - 12 Volt Auxiliary

Monitoring

GN

Switch - Rear Wiper

Pod - Auxiliary Control

Autolube

143

Motor - RH Door

PK

144

Motor - LH Window Washer

RD

Cylinder Injector #1

D-1

Motor - Rear Defroster

127

Cylinder Injector #2

Switch - Implement Lockout

Connector Number

12

128

0001

F-1

F-14

Secondary Steering Request Signal Line From Implement ECM

0002

E-13

Secondary Steer Right Solenoid

Component

F-1

Motor - Front Wiper

2199

CID

G-14

Motor - LH Door

2176

Intake Manifold Press Sensor

Switch - Head / Tail Lamps

Connector Location - Volume 2

0590

Engine Control System


(MID No. 036)

Resistor:

Component

0070

2175

7T-4003

Machine
Location

0096

0262

Part No.

Schematic
Location

Form Number

Alternator:

235-7133

SENR4130

Electric Starting Motor:

207-1556

SENR3581

Engine Control:

RENR9344

Implement Control:

RENR9013

Transmission / Chassis Control:

RENR9004

Wire Gauge
Wire Color

(Dimensions: 48 inches x 35 inches)

Component

Component Location - Volume 2 (Cab)

Failure Description

36 Page,

0041

FMI No.

RENR9024-08 VOL 2 of 3

Component Identifiers (CID)


Module Identifier (MID)
Electronic Transmission/Chassis Control System
(MID No. 027)
CID

RENR9024-08
June 2015

(Dimensions: 48 inches x 35 inches)

14

108-P617
108-P627
108-P663
108-P664

108-P244 RD-14

RD-16
RD-18
RD-18
RD-18

118-P239 GY-14

118-P614 GY-14
118-P587 GY-14
118-P588 GY-14

119-P232 PK-14

119-P599 PK-14
119-P600 PK-14
119-P613 PK-14
120-P611 YL-14
120-P582 YL-14
120-P581 YL-14

120-P235 YL-14
120-P642 YL-14

120-P605 YL-14
120-P612 YL-14
120-P606 YL-14
124-P652 GN-14

36 Page,

RENR9024-08 VOL 2 of 3

15

124-P677 GN-18
124-P309 GN-14
130-P103
134-P689
140-P661
156-P535
156-P536
170-P388
176-P387

200-P181 BK-18
200-P688
200-P135
200-P445
200-P444
200-P589

BK-18
BK-18
BK-18
BK-18

200-P317 BK-18
200-P710 BK-12
200-P621 BK-18

200-P634 BK-12

BK-18
BK-18
BK-18
BK-18
BK-18

200-P718
200-P631
200-P709
200-P635
200-P687

BK-18
BK-14
BK-18
BK-14
BK-18

200-P633
200-P717
200-P601
200-P569
200-P300
200-P35

BK-18
BK-18
BK-18
BK-14
BK-18
BK-18

200-P123 BK-18
200-P159 BK-14

200-P638
200-P607
200-P583
200-P654

200-P589 BK-18
200-P352 BK-18

200-P636
200-P630
200-P639
200-P629
200-P379
200-P711

G
200-P35
200-P123
200-P300
200-P620
200-P628
200-P637
200-P644
200-P654

108-P663 RD-18
J710-P662 BR-18
668-P645 BU-18
108-P664 RD-18

BK-18
BK-18
BK-18
BK-18

BK-18
BK-18
BK-18
BK-14
BK-18
BK-14

BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18

P-C119
1552267
156-P535 YL-18
P967-P538 PU-18
H786-P539 YL-18
P-C117
1552267
156-P536 YL-18
P967-P537 PU-18
H787-P492 GN-18

403-P288
506-P231
507-P233
529-P240
530-P241

120-P581
120-P582
200-P583
505-P584
504-P585
503-P586
507-P233

118-P587
118-P588
200-P379
525-P590
524-P591
523-P592
529-P240

P-C100
1552264
GY-14
GY-14
BK-18
GY-14
BU-14
BR-14
WH-14

119-P599
119-P600
200-P601
528-P602
527-P603
526-P604
530-P241

P-C101
1552264
PK-14
PK-14
BK-18
PK-14
GN-14
YL-14
OR-14

P-C102
1552264
YL-14
YL-14
BK-18
OR-14
GN-14
BR-14
PU-14

120-P605
120-P606
200-P607
502-P608
501-P609
500-P610
506-P231

614-P715
614-P719
617-P421
618-P423

PU-18
PU-18
BR-14
YL-14

668-P227 BU-18
668-P454 BU-18

P-C104
1779654
176-P387 RD-12
200-P615 BK-12
A572-P616 PK-14

H786-P539
H787-P492
J710-P662
K900-P646
K990-P648
N935-P519
N936-P534
P967-P537
P967-P538

108-P617 RD-16
200-P618 BK-18

501-P609
120-P612
500-P610
502-P608

GN-14
YL-14
BR-14
OR-14

A504-P234

GN-16

A507-P237
A507-P619

YL-16
YL-16

YL-18
YL-18
YL-18

P-C115
1552273
200-P638 BK-18
527-P603
119-P613
526-P604
528-P602

GN-14
PK-14
YL-14
PK-14

P-C116
1552273
200-P637 BK-18

P-C112
1552269
A572-P616 PK-14
200-P629 BK-14

BU-14
GY-14
BR-14
GY-14

YL-14
YL-14
BR-14
BU-14

P-C109
1552264
509-P578 WH-18
508-P577 PU-18
200-P651 BK-18

A513-P398
592-P595
512-P580
511-P579
200-P35
200-P123
200-P159
200-P300
200-P569
200-P629
200-P633
200-P654
200-P710
200-P711
200-P35
200-P123
200-P159
200-P300
200-P569
200-P629
200-P633
200-P654
200-P710
200-P711

BR-14
GN-14
OR-14
BR-14
YL-14
BU-14
PU-18
WH-18
BR-18
GN-18
BR-14
BU-14
GY-14
YL-14
GN-14
PK-14
WH-18
WH-16
BR-14
GN-14
OR-14
BR-14
YL-14
BU-14
PU-18
WH-18
BR-18
GN-18
BR-14
BU-14
GY-14
YL-14
GN-14
PK-14
WH-18
WH-16

200-P569 BK-14
200-P710 BK-12
200-P711 BK-14
200-P159 BK-14
200-P615 BK-12
CAB ROOF GND
GND

WIPER B+
WASHER B+
GROUND
HIGH
LOW
PARK
WASH
UNUSED

RD-14
RD-18
BK-18
WH-14
YL-14
BU-14
BR-18

WIPER B+
WASHER B+
GROUND
HIGH
LOW
PARK
WASH
UNUSED

P-C85
1907613

RH DOOR WIPER SWITCH


3E-0155
1
2
3
4
5
6
7
8

RD-14
RD-18
BK-18
WH-14
YL-14
BU-14
BR-18

WIPER B+
WASHER B+
GROUND
HIGH
LOW
PARK
WASH
UNUSED

1
2
3
4
5
6
7
8

RD-14
RD-18
BK-18
WH-14
YL-14
BU-14
BR-18

CK-C4
VOLUME 1
LOC I-15

24V SWITCHED IN

P-C86
1552272
AWD OPTION
NOT USED ON 16M

1
2
3
4

893-P665
892-P666
K900-P667
K990-P668
843-P678
844-P679
H864-P452
850-P690
849-P691
N788-P692
M792-P693
A201-P694

1
2
3
4
5
6
7
8
9
10
11
12

AWD OPTION
NOT USED ON 16M

12V MEMORY OUTPUT

172-P279 RD-14
H807-P506 YL-18
P-C69
1030213

K900-P46 YL-18
K990-P47 GN-18
U769-P504 OR-18
U770-P505 WH-18
P-C131
3E5179

P-C132
1552252

WIPER B+
WASHER B+
GROUND
HIGH
LOW
PARK
WASH
UNUSED

P-C68
1552254
308-P276 YL-18
893-P277 GN-18
892-P278 BR-18

1
2
3
4
5
6
7
8
9
10
11
12

CONN 6

FR0NT WIPER SWITCH


3E-0155

GN-18
BR-18
YL-18
GN-18
WH-18
GN-18
GN-18
PU-14
YL-18
PK-18
BU-18
BK-18

CONN 48
TO FP-HARNESS
FP-C1
VOLUME 3
LOC D-15

P-C72
3E3376
1
155-P564 RD-14
2
156-P516 YL-18
3
308-P623 YL-18
4
G434-P626 BU-18

24V POWER
GROUND
12V OUTPUT

RD-18
WH-18
BK-18

DOME LAMP
3E-6389

CONN 42

GND

BK-16

2
1
4
6
3
5

TO FP-HARNESS
FP-C6
VOLUME 3
LOC A-15

MOTOR
T

GN-16
GY-16
BR-16
OR-16

B+

FRONT WIPER MOTOR


295-1120

10

PK-18
BU-18
GN-18
BR-18

REAR DEFROSTER FAN


170-5334

P-C107
3E3364

200-WJ1 BK-14
527-WJ3
119-WJ5
526-WJ2
528-WJ4

GN-14
PK-14
YL-14
PK-14

GN-18
PK-18
GY-18
GN-18
PU-18
GN-14
RD-16
RD-14
WH-18
RD-14
BU-18
GY-14
PK-18

593-P675
520-P418
112-P530
115-P531
105-P369

GN-16
WH-18
PU-4
RD-4
RD-16

A201-P694

BK-18

C558-P390

BU-16

200-WK1 BK-14

2
1
4
6
3
5

527-WK3
119-WK5
526-WK2
528-WK4

P-C114
3E3382
2
BK-16

2
1
4
6
3
5

GN-14
PK-14
YL-14
PK-14

T
B+

RH DOOR MOTOR
266-8921

TO FP-HARNESS
FP-C2
VOLUME 3
LOC B-15

MOTOR H
T
B+

LH DOOR MOTOR
266-8807

MOTOR H
T
B+

P
CG-C2
1728037

REAR WIPER MOTOR


250-5529

CG-C1
3E3388
1
WH/BK-18
2
WH-18
3
BK-18
4
5
6
7
8

1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16

RD-18
YL-18
BK-18

YL-18
RD-18
GY/BK-18
GY-18

GY-18
GY/BK-18
WH-18
WH/BK-18

P-C20
1552252
GN-14
WH-16
WH-14
GN-14
BU-14
YL-18
BK-18
PU-18
BK-18
BU-16
BR-18
BK-18

P-C137
9X1054
BU-12
WH-16
BK-18
GY-12

134-P689 RD-18
200-P687 BK-18
A557-P681 WH-18
E529-P685 YL-18
130-P103 GN-18
200-P317 BK-18

E529-P686 YL-18
567-P682 WH-18

MED-HIGH
P-C59
7T5957
FRONT WASHER MOTOR
7T-8890

MED

1
5
2
4
3

WASHER MOTOR LH DOOR


7T-8890

6
7
8
9
10

P-C120
1552269
614-P715 PU-18
200-P716 BK-18

1
2

614-P714 PU-18
200-P717 BK-18

1
2

P-C125
P-C124
1552252
1642336
1
BR-14
2
YL-14
3
PK-18
CONN 9
4
GN-18
5
BK-18
TO J-HARNESS
6
J-C24
GN-14
7
VOLUME 1
BK-14
LOC F-12
8
YL-18
9
BK-18
10
WH-18
11
BK-14
12

P-C127
1552264
1
2
3
4
5
6
7
8

P-C67
7T5957
MOTOR

1
2

P-C74
7T5957

MOTOR

530-P241 OR-14
200-P145 BK-18

529-P240 WH-14
200-P292 BK-18
P-C75
7T5957
T972-P247 GN-14
200-P442 BK-18

1
2

CM-C3
1779641
515-CM4 GY-12
200-CM1 BK-12

CONN 46

RH JOYSTICK ILLUM LAMP


250-8335

CM-C1
3E3388
516-CM14 GN-14
520-CM9 WH-16
A524-CM12 BR-18
517-CM8 BU-14
592-CM11 BU-18
C568-CM10 WH-14
519-CM2 PK-18

CONN 8

CM-C7
2470281
Vs (+12V)
Vs (GROUND)
SIGNAL

592-CM11 BU-18

A
B
C
D
E
F

124-P677
200-P554
200-P688
506-P231
507-P233
515-P508
516-P507
517-P475
519-P419
520-P418
529-P240
530-P241
567-P553
567-P683
567-P684
593-P675
843-P678
849-P691
850-P690
844-P679
A201-P694
A524-P509
C558-P390
C568-P476
G434-P626
H864-P452
M792-P693
N788-P692

GN-18
BK-18
BK-18
PU-14
WH-14
GY-12
GN-14
BU-14
PK-18
WH-18
WH-14
OR-14
WH-18
WH-18
WH-18
GN-16
WH-18
YL-18
PU-14
GN-18
BK-18
BR-18
BU-16
WH-14
BU-18
GN-18
BU-18
PK-18

1
2
3
4
5
6
7
8

519-CM2 PK-18
520-CM9 WH-16
T

515-CM6 GY-12
BLOWER MOTOR
263-6443

THERMOSTAT
3E-5464
515-CM7 GY-12
THERMAL SWITCH
133-9012

515-CM5 GY-12

MOTOR

200-CM3 BK-12
517-CM8 BU-14
516-CM14 GN-14
C568-CM10 WH-14

200-CM3 BK-12
200-CM13 BK-16
515-CM7 GY-12
515-CM5 GY-12

14

13

K900-P344 YL-18
K990-P345 GN-18
U711-P708 GY-18
171-P33 RD-14
171-P310 RD-14
171-P34 RD-14
K900-P344 YL-18
K990-P345 GN-18
U711-P708 GY-18
892-P25 BR-18
893-P23 GN-18
997-P192 OR-18
998-P188 BR-18
A295-P89 BK-14
A295-P191 BK-14
A295-P204 BK-14
A295-P209 BK-18
A295-P499 BK-18
A295-P532 BK-18

BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-14
OR-16
YL-18
YL-14

E929-P195 GY-18
G953-P186 BU-18
G965-P185 PU-18
H764-P415 GY-18
H765-P213 WH-18
H786-P539 YL-18
H787-P492 GN-18
H807-P506 YL-18
J710-P662 BR-18
K900-P46 YL-18
K900-P297 YL-18
K900-P646 YL-18
K900-P667 YL-18
K990-P47 GN-18
K990-P298 GN-18
K990-P648 GN-18
K990-P668 GN-18
N787-P193 BU-18
N931-P194 GY-18
N935-P519 OR-18
N936-P534 YL-18
P967-P537 PU-18
P967-P538 PU-18
P967-P653 PU-18
R732-P142 BR-18
R800-P389 OR-18
U739-P214 BR-18
U740-P220 BU-18
U741-P219 OR-18
U753-P215 BR-18
U766-P474 BR-18
U767-P471 BU-18
U768-P434 BU-18
U769-P504 OR-18
U770-P505 WH-18

308-P11 YL-18
YL-18
YL-16
YL-18
YL-18

308-P338 YL-16
308-P190 YL-18
403-P288
403-P302
403-P312
556-P166
581-P249
582-P250
592-P511
592-P595
592-P596
614-P714
614-P715
614-P719
617-P420
617-P421
618-P422
618-P423
668-P227
668-P454
680-P173
683-P161
799-P489

GN-18
GN-18
GN-18
WH-18
GY-18
PK-18
BU-18
BU-18
BU-16
PU-18
PU-18
PU-18
BR-14
BR-14
YL-14
YL-14
BU-18
BU-18
GN-14
PU-14
WH-18

892-P514 BR-18
892-P666 BR-18
892-P305 BR-18

892-P331 BR-18
892-P465 BR-18

892-P460 BR-18
892-P278 BR-18

892-P14 BR-18
892-P25 BR-18
892-P428 BR-18

GN-18
GN-18
GN-18
GN-18

103-P308
104-P307
105-P369
126-P299
152-P286
171-P310
200-P121
200-P123
200-P135
200-P143

893-P12 GN-18
893-P429 GN-18
893-P23 GN-18

997-P192 OR-18
998-P188 BR-18
A202-P184 BK-14
A202-P526 BK-18
A295-P89 BK-14
A295-P499 BK-18
A295-P191 BK-14
A295-P204 BK-14
A295-P209 BK-18
A295-P532 BK-18

A296-P13 BK-14

892-P14 BR-18
A296-P15 BK-14
A296-P16 BK-18
A296-P17 BK-18

171-P32 RD-14
A296-P18 BK-18

171-P33 RD-14
171-P34 RD-14

171-P37
171-P38
M720-P6
M722-P5
K952-P10
U701-P4
U700-P3

RD-14
RD-14
BU-18
OR-18
BR-18
GN-18
WH-18

H803-P672 BU-18
A296-P20 BK-14
A296-P19 BK-14
U702-P1 GY-18
U703-P2 YL-18
K927-P9 BU-18
U704-P7 PK-18
U705-P8 PU-18
A847-P673
A849-P674
H747-P101

YL-18
OR-18
BR-18

A296-P21 BK-14

H808-P669
K831-P670
K832-P671

U706-P39
U707-P40
U708-P41
U709-P42

1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70

200-P393
200-P402
200-P413
200-P441
200-P442
200-P444

A296-P36 BK-14

A296-P86 BK-14
A296-P19 BK-14
A296-P21 BK-14
A296-P20 BK-14
BK-14
A513-P398 PK-18
A975-P503 BU-18
C542-P158 GN-18
E716-P294 GY-14
E717-P354 GN-14
E929-P195 GY-18
F846-P236 PU-18
G953-P186 BU-18
G965-P185 PU-18
H747-P101 BR-18
H764-P415 GY-18
H765-P213 WH-18
H786-P539 YL-18
H787-P492 GN-18
H803-P83 BU-18
H807-P506 YL-18
J710-P662 BR-18
K900-P46 YL-18
K900-P297 YL-18
K900-P646 YL-18
K900-P667 YL-18
K990-P47 GN-18
K990-P298 GN-18
K990-P648 GN-18
K990-P668 GN-18
M998-P459 OR-18
N787-P193 BU-18
N931-P194 GY-18
N935-P519 OR-18
N936-P534 YL-18
P967-P537 PU-18
P967-P538 PU-18
P967-P653 PU-18
R732-P142 BR-18
R800-P389 OR-18
T998-P463 BR-18

592-P596
614-P714
614-P715
614-P719
617-P420
617-P421
618-P422
618-P423
668-P227
668-P454

BU-16
PU-18
PU-18
PU-18
BR-14
BR-14
YL-14
YL-14
BU- 18
BU-18

680-P173 GN-14
683-P161 PU-14
799-P489 WH-18
892-P331 BR-18
892-P428 BR-18
892-P465 BR-18
893-P332 GN-18
893-P429 GN-18
893-P466 GN-18
A202-P184 BK-14
A202-P526 BK-18
A513-P398 PK-18
A975-P503 BU-18
C542-P158 GN-18
E716-P294 GY-14
E717-P354 GN-14
F846-P236 PU-18
H803-P83 BU-18
M998-P459 OR-18
T998-P463 BR-18
U734-P380 GN-18
U735-P381 GY-18
X800-P462 OR-18

U734-P380 GN-18
U735-P381 GY-18
BR-18
BU-18
OR-18
BR-18

U766-P472 BR-18
U766-P473 BR-18

U766-P474 BR-18

U767-P208 BU-18
U767-P470 BU-18

BR-18
BU-18
OR-18
WH-18

U710-P43 GN-18
U711-P708 GY-18
U712-P414 YL-18

K900-P344 YL-18
K990-P345 GN-18

CAT DATA LINK HIGH


+5v SUPPLY
STEER VALVE CONT MOD POWER
- UNSWITCHED BATTERY
IMPLEMENT LOCKOUT SW (NC)

- UNSWITCHED BATTERY

CAT DATA LINK LOW

CAT DATA LINK LOW


5v RETURN
HYD OIL INLET TEMP SNS
- UNSWITCHED BATTERY
BACKLIGHT SENSE

- UNSWITCHED BATTERY
ECM LOCATION 0 (GND)
ECM LOCATION 1 (GND)
ECM LOCATION 2 (OPEN)

ECM LOCATION 0 (OPEN)


ECM LOCATION 1 (GND)
ECM LOCATION 2 (OPEN)

HYD PLT SUP FLTR BYP SW


SEC STEERING TEST SW
HYDRAULIC PUMP PRESS SNSR
STEERING VLV SIG
+ UNSWITCHED BATTERY
+ UNSWITCHED BATTERY
STEER VALVE ERROR SIGNAL

+ UNSWITCHED BATTERY
+ UNSWITCHED BATTERY

BU-18
OR-18
WH-18
OR-18

108-P244
112-P530
115-P531
118-P239
119-P232
120-P235
121-P245
124-P309
128-P447
130-P103
132-P676
134-P689
135-P533
140-P661
155-P564

RD-14
PU-4
RD-4
GY-14
PK-14
YL-14
YL-18
GN-14
PK-18
GN-18
RD-16
RD-18
RD-16
BU-12
RD-14

AUX
AUX
AUX
AUX

LEVER
LEVER
LEVER
LEVER

#1
#2
#3
#4

POS
POS
POS
POS

BLADEFORCE IND
R-TERMINAL
LEFT STEER CYL POS SENS
RIGHT STEER CYL POS SENS
ART ANGLE SENSE #2
STER LEVER POS SNSR #1
SEC STER REQUEST SIGNAL
STEERING CONTROL SIGNAL
BACKLIGHT RELAY
DIGITAL RETURN
AUTO NEUTRAL ART SW (NO)
WHEEL LEAN INPUT POS SNSR
BLADE PITCH INPUT POS SNSR
ART LEVER POS SNSR

SNSR
SNSR
SNSR
SNSR

AUX LEVER #5 POS SNSR


AUX LEVER #6 POS SNSR
AUX LEVER #7 POS SNSR

AUTO NEUTRAL ART SW (NC)


BLADE DWNFORCE SW(NO)
BLADE DWNFORCE SW(NC)
CIRC DRIVE LEVER POS SNSR
BLD SIDESHIFT LVR POS SNSR
STEER LEVER POS SNSR #3
BLD RIGHT LIFT LVR POS

ART ANGLE POS SNSR


LEFT BLADE DWNFORCE DIAL
RIGHT BLADE DWNFORCE DIAL
RIGHT INC/DEC SW (NEUTRAL)
RIGHT INC/DEC SW (INC)
RIGHT INC/DEC SW (DEC)
STEER LEVER POS SNSR #2
BLADE LEFT LVR POS SNSR
CIR SIDESHIFT IP POS SNSR
RIGHT AUTO/MAN SW (NO)
RIGHT AUTO/MAN SW (NC)
LEFT INC/DEC SW (NEUTRAL)
LEFT INC/DEC SW (INC)
LEFT
LEFT
LEFT
SIDESHFT
SIDESHFT
PHS CAN HIGH
PHS CAN LOW
PHS CAN SHIELD
J1939 HIGH
J1939 LOW
J1939 SHIELD

200-CM1 BK-12

515-CM4 GY-12

516-CM14 GN-14
517-CM8 BU-14
519-CM2 PK-18
520-CM9 WH-16
592-CM11 BU-18
A524-CM12 BR-18
C568-CM10 WH-14

BR-18
GN-18
YL-18
WH-18
GN-18
YL-18
BU-18
GY-18
PU-18
OR-18
PU-18

ACCUGRADE CAN HIGH


ACCUGRADE CAN LOW
ACCUGRADE CAN SHIELD
J1939 HIGH
J1939 LOW
J1939 SHIELD
J2

P-C41
1471445
1
308-P22 YL-18

2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70

180-P200 RD-18
180-P165 RD-16
180-P88 RD-14
180-P51 RD-14
180-P48 RD-14
180-P31 RD-14
180-P52 RD-14
180-P29 RD-14

893-P23 GN-18
997-P192 OR-18
M906-P702 BU-18
A295-P24 BK-14
G767-P197 WH-18

180-P658 RD-18
180-P311 RD-14
308-P22 YL-18
614-P722 PU-18
626-P713 BU-18

892-P25 BR-18
998-P26 BR-16
R732-P142 BR-18
A295-P27 BK-14
614-P722 PU-18

727-P196
892-P25
893-P23
997-P192

A295-P28 BK-18

180-P29 RD-14
A295-P30 BK-18

A295-P229

A295-P24
A295-P58
A295-P30
A295-P57

R800-P49 OR-16
P967-P50 PU-16
180-P51 RD-14
180-P52 RD-14
U751-P53 WH-18
U752-P54 PU-18
H861-P177 PU-18
K789-P55 YL-18
K788-P56 GY-18

H745-P738

H764-P218

H765-P217

H807-P704

H764-P212 GY-18
H764-P415 GY-18

WH-18

H765-P213 WH-18
H765-P335 WH-18

A295-P229
K900-P498
K990-P501
L854-P746
L855-P747

BK-14
YL-18
GN-18
YL-16
GN-16

K900-P297 YL-18
K900-P483 YL-18

YL-18
YL-18

K900-P695

YL-18

15A

10A

10A

15A

15A

30A

10A

10A

129-P353 RD-16

SPARE

ENT RADIO CONV

179-P394 RD-14

IMP CONT SL1

COMM RADIO CONV

171-P310 RD-14

176-P387 RD-12

HORN

PRODUCT LINK

114-P176 RD-14

170-P388 RD-18

BACKLIGHT

DOMELAMP

125-P127 RD-14

10A

10A

108-P244 RD-14

10

MONITORING

IMP CONT MASTER

127-P280 RD-16

10A

15A

180-P311 RD-14

12

11

AWD CONTROLLER

STEERING VALVE

155-P564 RD-14

15A

10A

199-P364 RD-18

14

13

SPARE

Condenser FAN #2
15A

10A

135-P533 RD-16

16

15

IMP CONT SL2

AIR CLEANER

172-P279 RD-14

17

15A

10A

134-P689 RD-18

18

SPARE

CONDESOR FAN #1
19

30A

10A

BUSS
POINT 2

132-P676 RD-16

20

K900-P667

YL-18

K900-P391

YL-18

K900-P46 YL-18

K900-P498

YL-18

K990-P502

K900-P646

BUSS
1

FRONT/REAR WIPER

120-P235 YL-14

HEATED MIRROR
1

15A

10A

15A

10A

160-P175 PU-16

SIDE WIPER

122-P256 BU-14

AUTOLUBE
3

128-P458 PK-18

RH DOOR WIPER
5

10A

15A

20A

10A

119-P232 PK-14

BACKUP ALARM
8

WAVES

130-P103 GN-18

121-P245 YL-18

CAB WORKLAMPS

10A

15A

15A

10A

10

106-P436 WH-14

124-P309 GN-14

K990-P529

GN-18
K990-P345 GN-18
K990-P696 GN-18

K990-P647

K990-P668

GN-18

BEACON

116-P396 BR-18

K990-P517 GN-18
K990-P501 GN-18

10A

10A

15A

13

14

L854-P748

YL-16

L855-P745
L855-P747

GN-16
GN-16

L855-P749

GN-16

106-P436 WH-14
114-P176 RD-14
116-P396 BR-18
122-P256 BU-14
123-P316 WH-14
125-P127 RD-14
127-P280 RD-16
129-P353 RD-16
141-P228 PK-16
142-P263 BU-18
143-P179 BR-14
144-P439 GN-14
146-P697 GY-14
160-P175 PU-16
165-P138 YL-18
169-P262 PK-18
171-P310 RD-14
179-P394 RD-14
180-P311 RD-14
199-P364 RD-18
200-P87 BK-18
200-P131 BK-18
200-P144 BK-18
200-P205 BK-18
200-P443 BK-18
210-P386 BK-14
A210-P106 BK-14
A250-P303 BK-16
A274-P467 BK-14
A274-P469 BK-14

P967-P495 PU-18
P967-P537 PU-18
P967-P538 PU-18
P967-P653 PU-18
P967-P96 PU-18

P967-P50 PU-16

R732-P142 BR-18
R800-P49 OR-16

16

U711-P708 GY-18
U711-P44 GY-18
U711-P707 GY-18
U736-P211 YL-18

132-P676
134-P689
135-P533
140-P661
155-P564
156-P570
170-P388
172-P279
176-P387
200-P248
200-P712

RD-16
RD-18
RD-16
BU-12
RD-14
YL-18
RD-18
RD-14
RD-12
BK-18
BK-12

17

20A

10A

U740-P202 BU-18

U740-P220 BU-18
U740-P97 BU-18

U741-P201 OR-18

U741-P219 OR-18
U741-P98 OR-18

U742-P207 WH-18
U743-P73 GY-18
U744-P72 OR-18
U745-P76 PK-18
U747-P65 OR-18
U748-P66 GY-18
U749-P64 BR-18
U750-P63 PK-18
U751-P53 WH-18
U752-P54 PU-18
U753-P215 BR-18
U760-P69 PK-18
U761-P70 PU-18

15A

BUSS
POINT 2

15A

U763-P77 BU-18
U764-P74 GY-18
U765-P81 WH-18
U766-P474 BR-18
U767-P471 BU-18
U768-P434 BU-18
U769-P504 OR-18
U770-P505 WH-18
X725-P187 GY-18
Y933-P728 YL-18
Y934-P726 WH-18
Y935-P736 OR-18
Y936-P727 PK-18
Y937-P730 PU-18
Y938-P734 YL-18
P-C53 CAN RESISTOR 2
1552267 134-2540

165-P138 YL-18

18

K900-P498 YL-18
K990-P501 GN-18

118-P239 GY-14

20

A
B
C

P-C87 CTCT CAN RESISTOR 1


1552267 134-2540

22
L854-P746 YL-16
L855-P747 GN-16

112-P530 PU-4

112-P640 PU-12

U762-P659 GN-18
U762-P705 GN-18

U762-P71 GN-18

LH DOOR WIPERS
19

U739-P214 BR-18
U739-P95 BR-18

U739-P203 BR-18

DIFF LOCK

REAR WORKLIGHTS

123-P316 WH-14

RD-14
PU-4
RD-4
GY-14
PK-14
YL-14
YL-18
GN-14
GN-18

BU-18
GY-18
GN-18
OR-18

144-P439 GN-14

BLADE WORKLIGHT 2

146-P697 GY-14

108-P244
112-P530
115-P531
118-P239
119-P232
120-P235
121-P245
124-P309
130-P103

R800-P446 OR-16
R800-P92 OR-18
R800-P389 OR-18

R900-P59
R901-P61
R902-P60
R903-P62

20

A
B
C

140-P661 BU-12

FAST SPEED BLOWER


6T-3644
114-P176
116-P396
120-P235
122-P256
123-P316
124-P309
125-P127
127-P280
130-P103
141-P228
142-P263
143-P179
146-P697
155-P564
171-P310
172-P279

RD-14
BR-18
YL-14
BU-14
WH-14
GN-14
RD-14
RD-16
GN-18
PK-16
BU-18
BR-14
GY-14
RD-14
RD-14
RD-14

ID
P
CG
CM
RF
RG
RH
RM
WJ
WK

200-P712 BK-12
210-P386 BK-14
200-P248 BK-18
200-P443 BK-18
CAB GROUND 4
GND
200-P131 BK-18
200-P87 BK-18

PART#
291-2907
200-5728
276-9015
253-1956
296-1065
296-1066
253-1957
279-1118
279-1118

180-P200 RD-18
709-P90 OR-18
709-P99 OR-18
709-P490 OR-18
709-P660 OR-18
998-P189 BR-18
998-P293 BR-18
A295-P91 BK-16
A295-P100 BK-16
A295-P491 BK-18
A295-P706 BK-18
E745-P731 BU-18
E744-P732 YL-18
H745-P739 BR-18
H745-P740 BR-18
H745-P741 BR-18
H745-P742 BR-18
H745-P743 BR-18
G766-P198 GN-18
G767-P197 WH-18
H764-P212 GY-18
H765-P335 WH-18
H861-P177 PU-18
H862-P182 GY-18
H863-P183 BU-18
J769-P733 YL-18
J771-P729 BU-18
K722-P737 YL-18
K723-P735 PU-18
K749-P79 WH-18
K750-P80 PU-18
K758-P75 BU-18
K788-P56 GY-18
K789-P55 YL-18
M719-P78 GN-18
M906-P702 BU-18
P967-P96 PU-18
P967-P495 PU-18
R800-P92 OR-18
R800-P446 OR-16
R900-P59 BU-18
R901-P61 GY-18
R902-P60 GN-18
R903-P62 OR-18
U711-P44 GY-18
U711-P707 GY-18
U736-P211 YL-18
U739-P95 BR-18
U740-P97 BU-18
U741-P98 OR-18
U742-P207 WH-18
U743-P73 GY-18
U744-P72 OR-18
U745-P76 PK-18
U747-P65 OR-18
U748-P66 GY-18
U749-P64 BR-18
U750-P63 PK-18
U751-P53 WH-18
U752-P54 PU-18
U760-P69 PK-18
U761-P70 PU-18
U762-P659 GN-18
U762-P705 GN-18
U763-P77 BU-18
U764-P74 GY-18
U765-P81 WH-18
X725-P187 GY-18
Y933-P728 YL-18
Y934-P726 WH-18
Y935-P736 OR-18
Y936-P727 PK-18
Y937-P730 PU-18
Y938-P734 YL-18

103-P308 RD-16

104-P307 RD-14

114-P176 RD-14

CAB HARNESS & CABLE CHART 16M


CHG ATCH LOC
DESCRIPTION
01 STD H-10 MAIN CAB
02 ATT D-14 RADIO ADAPTER
01
- A-13 HVAC UNIT HARNESS
00 ATT H-1 LH OFFSET SWITCH
00
G-4 LH OFFSET SW JUMPER
00
F-4 RH OFFSET SW JUMPER
00 ATT G-1 RH OFFSET SWITCH
01
E-14 RH DOOR MOTOR
01
E-14 LH DOOR MOTOR

123-P316 WH-14

125-P127 RD-14
125-P105 RD-18

A274-P467
A274-P469

BK-14
BK-14

125-P313
125-P363
125-P546
125-P549
125-P287

RD-18
RD-18
RD-18
RD-18
RD-18

125-P269
125-P251
125-P370
125-P357
125-P377

RD-18
RD-18
RD-18
RD-18
RD-18

126-P299 RD-18
127-P280 RD-16

127-P242 RD-16
127-P330 RD-18
127-P424 RD-18

128-P371 PK-18
129-P353 RD-16
141-P228 PK-16
142-P263 BU-18

142-P264 BU-18
142-P456 BU-18
142-P265 BU-18

143-P179 BR-14

143-P162 BR-14
143-P163 BR-18

144-P439 GN-14
146-P697 GY-14

146-P698 GY-18
146-P699 GY-14

152-P286 RD-14

160-P175 PU-16
165-P138
169-P262
179-P394
180-P165
180-P658
199-P364

K900-P427
K900-P483
K990-P426
K990-P484
L854-P748
L855-P749

YL-18
YL-18
GN-18
GN-18
YL-16
GN-16

892-P25 BR-18
893-P23 GN-18
997-P192 OR-18
998-P188 BR-18
A295-P89 BK-14
A295-P191 BK-14
A295-P204 BK-14
A295-P209 BK-18
A295-P499 BK-18
A295-P532 BK-18
E929-P195 GY-18
G953-P186 BU-18
G965-P185 PU-18

200-P87 BK-18
200-P637 BK-18
200-P205 BK-18
200-P628 BK-18
200-P102 BK-18
200-P131 BK-18

YL-18
PK-18
RD-14
RD-16
RD-18
RD-18
200-P407
200-P132
200-P366
200-P266

BK-18
BK-18
BK-18
BK-18

200-P133 BK-18
200-P267 BK-18
200-P136 BK-18
200-P254 BK-18
200-P134 BK-18

200-P144
200-P644
200-P292
200-P145
200-P413

200-P440 BK-18

BK-18
BK-18
BK-18
BK-18
BK-18

200-P121
200-P123
200-P135
200-P352
200-P393
200-P402
200-P444
200-P445
200-P654
210-P386
229-P382
307-P315
308-P190
308-P351
308-P395

H764-P415 GY-18
H765-P213 WH-18
H786-P539 YL-18
H787-P492 GN-18
H807-P506 YL-18
J710-P662 BR-18
K900-P46 YL-18
K900-P297 YL-18
K900-P344 YL-18
K900-P646 YL-18
K900-P667 YL-18
K990-P47 GN-18
K990-P298 GN-18
K990-P345 GN-18

160-P156 PU-18
160-P174 PU-16

200-P441 BK-18
200-P143 BK-18
200-P620 BK-18

200-P442 BK-18
200-P443 BK-18

308-P11 YL-18
308-P338 YL-16
308-P22 YL-18

200-P425
200-P107
200-P724
200-P723

BK-18
BK-18
BK-18
BK-18

BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-14
BK-14
OR-16
YL-18
YL-18
YL-14
308-P481
308-P485
308-P373
308-P482

YL-18
YL-18
YL-16
YL-18

403-P288 GN-18
403-P312 GN-18
403-P302 GN-18

GN-18
GN-18
BU-18
GY-18
OR-18
YL-18
PU-18
PU-18
PU-18
BR-18
OR-18

556-P166 WH-18

556-P167 WH-18
556-P261 WH-18

581-P249 GY-18
582-P250 PK-18
592-P596 BU-16
592-P595 BU-18
592-P511 BU-18

592-P512 BU-14

611-P336 PU-14
611-P339 PU-18
611-P341 PU-14

U711-P708 GY-18
BR-18
BU-18
OR-18
BR-18
BR-18
BU-18
BU-18
OR-18
WH-18

614-P714 PU-18
614-P715 PU-18
614-P719 PU-18

614-P722 PU-18
617-P420 BR-14
617-P421 BR-14

103-P308
104-P307
105-P369
126-P299
152-P286
171-P310
200-P121
200-P123
200-P135
200-P143
200-P145
200-P292
200-P352
200-P393
200-P402
200-P413
200-P441
200-P442
200-P444
200-P445
200-P620

RD-16
RD-14
RD-16
RD-18
RD-14
RD-14
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18

200-P628 BK-18
200-P637 BK-18
200-P644 BK-18
200-P654 BK-18
229-P382 BK-14
307-P315 OR-16
308-P11 YL-18
308-P190 YL-18
308-P338 YL-16
308-P351 YL-18
308-P395 YL-14
403-P288
403-P302
403-P312
556-P166
581-P249
582-P250
592-P511
592-P595
592-P596

GN-18
GN-18
GN-18
WH-18
GY-18
PK-18
BU-18
BU-18
BU-16

614-P714
614-P715
614-P719
617-P420
617-P421
618-P422
618-P423
668-P227
668-P454
680-P173
683-P161

PU-18
PU-18
PU-18
BR-14
BR-14
YL-14
YL-14
BU-18
BU-18
GN-14
PU-14

799-P489 WH-18
892-P331 BR-18
892-P428 BR-18
892-P465 BR-18
893-P332 GN-18
893-P429 GN-18
893-P466 GN-18
A202-P184 BK-14
A202-P526 BK-18
A513-P398 PK-18
A975-P503 BU-18
C542-P158 GN-18
E716-P294 GY-14
E717-P354 GN-14
F846-P236 PU-18
H803-P83 BU-18
M998-P459 OR-18
T998-P463 BR-18
U734-P380 GN-18
U735-P381 GY-18
X800-P462 OR-18
106-P436
114-P176
116-P396
122-P256
123-P316
125-P127
127-P280
128-P371
129-P353

WH-14
RD-14
BR-18
BU-14
WH-14
RD-14
RD-16
PK-18
RD-16

141-P228 PK-16
142-P263 BU-18
143-P179 BR-14
144-P439 GN-14
146-P697 GY-14
160-P175 PU-16
165-P138 YL-18
169-P262 PK-18
171-P310 RD-14
179-P394 RD-14
180-P311 RD-14
199-P364 RD-18
200-P87 BK-18
200-P131 BK-18
200-P144 BK-18
200-P205 BK-18
200-P443 BK-18
210-P386 BK-14
A210-P106 BK-14
A250-P303 BK-16
A274-P469 BK-14
A274-P467 BK-14

CAB GROUND 2
GND
BK-14
BK-16

114-P146 RD-14
114-P147 RD-18

123-P451 WH-18
123-P230 WH-14

200-P205 BK-18
200-P144 BK-18

A210-P106
A250-P303

RD-18
RD-14
RD-14
RD-18

116-P396 BR-18
122-P256 BU-14

K900-P427
K900-P483
K990-P426
K990-P484
L854-P748
L855-P749

U739-P214
U740-P220
U741-P219
U753-P215
U766-P474
U767-P471
U768-P434
U769-P504
U770-P505

104-P160
104-P285
104-P114
104-P153

106-P436 WH-14

180-P165 RD-16
180-P311 RD-14
180-P658 RD-18
308-P22 YL-18
614-P722 PU-18
626-P713 BU-18
727-P196 GN-18
A295-P367 BK-18
H807-P703 YL-18

K990-P648
K990-P668
N787-P193
N931-P194
N935-P519
N936-P534
P967-P537
P967-P538
P967-P653
R732-P142
R800-P389

103-P116 RD-16
103-P725 RD-14
103-P438 RD-18

106-P112 WH-14
106-P108 WH-18
106-P117 WH-18

180-P165 RD-16
180-P311 RD-14
180-P658 RD-18
308-P22 YL-18
614-P722 PU-18
626-P713 BU-18
727-P196 GN-18
A295-P367 BK-18
H807-P703 YL-18
YL-18
YL-18
GN-18
GN-18
YL-16
GN-16

Y934-P726
H745-P742
Y936-P727
Y933-P728

P-C25
1552272
142-P264 BU-18
200-P267 BK-18
538-P275 BR-18

105-P369 RD-16

618-P423 YL-14
618-P422 YL-14

M719-P78 GN-18
M906-P702 BU-18
N787-P193 BU-18
N931-P194 GY-18
N935-P519 OR-18
N936-P534 YL-18

SEAT
15

GN-18

YL-16
YL-16

156-P570 YL-18

DEFROST FAN

141-P228 PK-16

K990-P648

L854-P744
L854-P746

SENSOR POWER
10A

GN-18

K990-P47 GN-18

169-P262 PK-18

12

GN-18
GN-18

K990-P85 GN-18

CNTRSFT/BLADE CUSH
11

YL-18

GN-18
K990-P426
K990-P515

128-P447 PK-18

21 POINT

YL-18

K900-P93 YL-18

128-P458 PK-18
P-C3
2509819

K900-P528

K990-P484 GN-18
K990-P298 GN-18

128-P371 PK-18
22

YL-18

YL-18

115-P531 RD-4

CIGAR LIGHTER

K900-P427

K900-P344

BUSS
21 POINT 1
SPARE

YL-18
YL-18

K900-P84 YL-18

K900-P84 YL-18
K990-P85 GN-18

BK-14
YL-18
GN-18
YL-16
GN-16

H807-P506
H807-P703

YL-18

K900-P486

U765-P81 WH-18
Y938-P734 YL-18
J769-P733 YL-18
Y936-P727 PK-18
Y934-P726 WH-18

P-C39
1471446
A295-P229
K900-P498
K990-P501
L854-P746
L855-P747

BR-18
BR-18
BR-18
BR-18
BR-18

GY-18

K900-P392

Y935-P736 OR-18
K723-P735 PU-18
K722-P737 YL-18
U740-P202 BU-18
K750-P80 PU-18

YL-16
GN-16

H745-P743
H745-P741
H745-P739
H745-P742
H745-P740

H861-P177 PU-18
H862-P182 GY-18
H863-P183 BU-18
J710-P662 BR-18
J769-P733 YL-18
J771-P729 BU-18
K722-P737 YL-18
K723-P735 PU-18
K749-P79 WH-18
K750-P80 PU-18
K758-P75 BU-18
K788-P56 GY-18
K789-P55 YL-18

E929-P195 GY-18
H786-P539 YL-18
H787-P492 GN-18

L854-P744
L855-P745

YL-18
BU-18
GY-18
GN-18
WH-18
BU-18
PU-18

H786-P539 YL-18
H787-P492 GN-18

U763-P77 BU-18
M719-P78 GN-18
U741-P201 OR-18
K749-P79 WH-18

YL-18
PU-18
BU-18
YL-18
BU-18

A295-P216 BK-14
A295-P491 BK-18
A295-P532 BK-18
A295-P367 BK-18

BR-18

U745-P76 PK-18
N935-P519 OR-18
N936-P534 YL-18

Y933-P728
Y937-P730
J771-P729
E744-P732
E745-P731

A295-P209 BK-18
A295-P499 BK-18
A295-P706 BK-18
A295-P91 BK-16
A295-P100 BK-16

BK-14
BK-14
BK-18
BK-14

E744-P732
E745-P731
E929-P195
G766-P198
G767-P197
G953-P186
G965-P185

G953-P186 BU-18
G965-P185 PU-18
U760-P69 PK-18
U761-P70 PU-18
U762-P71 GN-18

GY-18
WH-18
BU-18
BR-18
BR-18
GY-18
BU-18
BR-18
OR-18
GY-18
GY-18
BU-18

BK-14

A295-P68 BK-14
A295-P28 BK-18
A295-P27 BK-14
A295-P229 BK-14

G766-P198 GN-18
U769-P504 OR-18
U770-P505 WH-18
H807-P704 YL-18

H764-P218
H765-P217
U768-P434
U739-P203
U753-P215
X725-P187
626-P713
H745-P738
U744-P72
U743-P73
U764-P74
K758-P75

998-P188 BR-18
998-P189 BR-18
998-P293 BR-18

A295-P89 BK-14
A295-P204 BK-14
A295-P191 BK-14

H862-P182 GY-18
A295-P57 BK-14
A295-P58 BK-14
R900-P59 BU-18
R902-P60 GN-18
H863-P183 BU-18
R901-P61 GY-18
R903-P62 OR-18
U766-P474 BR-18
U767-P471 BU-18
U750-P63 PK-18
U749-P64 BR-18
U747-P65 OR-18
U748-P66 GY-18
709-P67 OR-18
A295-P68 BK-14

BR-18

OR-18
OR-18
OR-18
OR-18

GN-18
BR-18
GN-18
OR-18

998-P26 BR-16

N787-P193 BU-18
727-P196 GN-18
N931-P194 GY-18
U736-P211 YL-18
180-P31 RD-14
180-P48 RD-14
U742-P207 WH-18

J710-P662

709-P490
709-P660
709-P90
709-P99

709-P67 OR-18

P-C1
2509819

143-P179 BR-14

J844-P289 GY-18
L731-P94 BR-18
L914-P359 BU-18
R908-P453 YL-18
T971-P246 OR-14
T972-P247 GN-14
U723-P180 PU-18
U725-P403 GN-18
U726-P404 GY-18
U727-P323 WH-18
X755-P384 WH-18
X754-P385 GN-18

12

INC/DEC SW (DEC)
AUTO/MAN SW (NO)
AUTO/MAN SW (NC)
AUTO/MAN SW (NO)
AUTO/MAN SW (NC)

J2

200-P35 BK-18
200-P181 BK-18
200-P300 BK-18
603-P243 PK-18
604-P410 OR-18
609-P268 YL-18
609-P449 YL-18
801-P497 PK-14
925-P383 YL-18
A504-P234 GN-16

F781-P225
F783-P111
F784-P128
F785-P110
F787-P324
F843-P322
G750-P124
G755-P113
G763-P172
G946-P326
J766-P290

IMPLEMENT PLT SUPPLY SOL


LOAD RETURN #2
OPT LEVER #1 FLOAT IND
OPT LEVER #4 FLOAT IND
OPT LEVER #6 FLOAT IND

LOAD RETURN #2

P-C27
1471446

142-P263 BU-18

RD-18
RD-14
RD-12
BK-18
BK-12

YL-16
PK-18
BU-18
GY-18
BR-18
GN-18
BR-18
OR-18
GN-18
GN-18

IMPLEMENT LOCKOUT SW (NO)


AUX VALVE #7 SOL #1
AUX VALVE #7 SOL #2
LOAD RETURN #01

LOAD RETURN #01


LEFT BLADE DWNFORCE ON VLV
RIGHT BLADE DWNFORCE ON VLV

156-P570 YL-18

A507-P237
A755-P430
A756-P329
A757-P411
A758-P328
C532-P457
C978-P327
C979-P431
E974-P325
F702-P409

PWM DR RETURN 11-12


PWM DR RETURN 9-12
- UNSWITCHED BATTERY
- UNSWITCHED BATTERY
BLADE LEFT RAISE SOL
BLADE RIGHT RAISE SOL
PWM DR RETURN 5-8
BLADE LEFT LOWER SOL
BLADE RIGHT LOWER SOL
OPERATOR SEAT SW (NC)
OPERATOR SEAT SW (NO)
BLADE SIDESHIFT LEFT SOL
BLADE SIDESHIFT RIGHT SOL
WHEEL LEAN LEFT SOL
WHEEL LEAN RIGHT SOL
+10v SUPPLY
- UNSWITCHED BATTERY

- UNSWITCHED BATTERY

BLADE WORKLIGHTS

U768-P434
U769-P504
U770-P505
X800-P462

170-P388
172-P279
176-P387
200-P248
200-P712

+8v SUPPLY
8v RETURN
+ UNSWITCHED BATTERY
+ UNSWITCHED BATTERY
BLADE PITCH FORWARD SOL
BLADE PITCH BACKWARD SOL
PWM DR RETURN 1-4
ARTICULATE LEFT SOLENOID
ARTICULATE RIGHT SOLENOID

+8v SUPPLY
8v RETURN
+ UNSWITCHED BATTERY
+ UNSWITCHED BATTERY
CIRCLE SIDESHIFT LEFT SOL
CIRCLE SIDESHIFT RIGHT SOL
PWM DR RETURN 1-4
CIRCLE LEFT SOLENOID
CIRCLE RIGHT SOLENOID
NO CONNECTION
PWM DR RETURN 11-12
PWM DR RETURN 9-12
- UNSWITCHED BATTERY
- UNSWITCHED BATTERY
AUX VALVE #1 SOL B
AUX VALVE #1 SOL A
PWM DR RETURN 5-8
AUX VALVE #2 SOL B
AUX VALVE #2 SOL A
NO CONNECTION
NO CONNECTION
LEFT BLADE DWNFORCE PRO VLV
RIGHT BLADE DWNFORCE PRO VLV

FLASHER

U767-P471 BU-18

156-P536 YL-18
156-P535 YL-18
156-P516 YL-18

+ UNSWITCHED BATTERY
ECM LOCATION ENABLE (GND)

+ UNSWITCHED BATTERY
ECM LOCATION ENABLE (GND)

HVAC

GN-14
WH-18
BR-18
BU-14
BU-18
WH-14
PK-18

BK-18
BK-18
BK-18
BK-18
BK-18
BK-18

200-P445 BK-18
200-P620 BK-18
200-P628 BK-18
200-P637 BK-18
200-P644 BK-18
200-P654 BK-18
229-P382 BK-14
307-P315 OR-16
308-P11 YL-18
308-P190 YL-18
308-P338 YL-16
308-P351 YL-18
308-P395 YL-14
403-P288 GN-18
403-P302 GN-18
403-P312 GN-18
556-P166 WH-18
581-P249 GY-18
582-P250 PK-18
592-P511 BU-18
592-P595 BU-18

A296-P18 BK-18
A296-P13 BK-14

U739-P214
U740-P220
U741-P219
U753-P215

RD-16
RD-14
RD-16
RD-18
RD-14
RD-14
BK-18
BK-18
BK-18
BK-18

CAT DATA LINK HIGH

1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70

WH-18
GY-18
OR-18

J1
KEY SWITCH - RUN

J1
KEY SWITCH - RUN

200-P145 BK-18
200-P292 BK-18
200-P352 BK-18
A296-P17 BK-18
A296-P15 BK-14
A296-P16 BK-18

A296-P104

893-P12 GN-18

IMPLEMENT CONTROL
262-1408

IMPLEMENT CONTROL #2
262-1408

893-P332 GN-18
893-P466 GN-18

893-P277 GN-18

BLOWER RESISTOR
125-9740

15

171-P32 RD-14
171-P33 RD-14
171-P34 RD-14
171-P37 RD-14
171-P38 RD-14
308-P11 YL-18
892-P14 BR-18
893-P12 GN-18
A296-P13 BK-14
A296-P15 BK-14
A296-P16 BK-18
A296-P17 BK-18
A296-P18 BK-18
A296-P19 BK-14
A296-P20 BK-14
A296-P21 BK-14
H747-P101 BR-18

RD-16
RD-14
RD-16
RD-18
RD-14

200-P121
200-P123
200-P135
200-P143
200-P145
200-P292
200-P352
200-P393
200-P402
200-P413
200-P441
200-P442
200-P444
200-P445
200-P620
200-P628
200-P637
200-P644
200-P654
229-P382
307-P315
308-P351
308-P395

P-C138
1779646
515-P508 GY-12
200-P712 BK-12
P-C16
1552264
516-P507
520-P418
A524-P509
517-P475
592-P511
C568-P476
519-P419

A847-P673 YL-18
A849-P674 OR-18
H803-P672 BU-18
H808-P669 WH-18
K831-P670 GY-18
K832-P671 OR-18
K927-P9 BU-18
K952-P10 BR-18
M720-P6 BU-18
M722-P5 OR-18
U700-P3 WH-18
U701-P4 GN-18
U702-P1 GY-18
U703-P2 YL-18
U704-P7 PK-18
U705-P8 PU-18
U706-P39 BR-18
U707-P40 BU-18
U708-P41 OR-18
U709-P42 WH-18
U710-P43 GN-18
U712-P414 YL-18

171-P32 RD-14
171-P37 RD-14
171-P38 RD-14

893-P513
893-P665
893-P304
893-P464

CONN 53

171-P45 RD-14

308-P276
308-P283
308-P301
308-P623

10
P-C45
1471445
308-P11 YL-18

103-P308
104-P307
105-P369
126-P299
152-P286

200-CM13 BK-16
A524-CM12 BR-18

WATER VALVE ACTUATOR


245-1596

TO J-HARNESS
J-C25
VOLUME 1
LOC E-12

1
2

CONN 45

LH JOYSTICK ILLUM LAMP


250-8335

GN-18
BK-18
BK-18
PU-14
WH-14
GY-12
GN-14
BU-14
PK-18
WH-18
WH-14
OR-14
WH-18
WH-18
WH-18
GN-16
WH-18
GN-18
YL-18
PU-14
BK-18
BR-18
BU-16
WH-14
BU-18
GN-18
BU-18
PK-18

506-P231 PU-14
200-P413 BK-18

WASHER MOTOR RH WINDOW


1
7T-8890 MOTOR
2
P-C6
7T5957
1
T971-P246 OR-14
WASHER MOTOR LH WINDOW MOTOR
2
7T-8890
200-P441 BK-18
P-C55
7T5957
1
507-P233 WH-14
REAR WASHER MOTOR MOTOR
2
7T-8890
200-P143 BK-18
FAST SPD RLY
PWR AIR CLEANER RLY
P-C2
P-C140
3E-5239
3E-5239
1552267
9X1054
30
30
1
A
134-P689 RD-18
A295-P209 BK-18
86
86
5
B
E529-P685 YL-18
U766-P473 BR-18
2
C
200-P687 BK-18
U767-P208 BU-18
85
85
4
A557-P681 WH-18
OPERATOR PRESENT SWITCH
87
87
3
216-0814
87a
87a
CONDENSER FAN RELAY
P-C147
3E-5239
9X1054
30
P-C128 P-C129
1
132-P676 RD-16
86 5
1552273
3E3382
567-P683 WH-18
1
2
200-P688 BK-18
CONNECTOR FOR
85
2
4
WAVES SYSTEM
593-P675 GN-16
CONDENSER FAN2 RELAY
87
P-C139
3
3
3E-5239
AC ON SW
87a
9X1054
P-C118 251-1196
CONN 41
4
30
2234778
1
5
135-P533 RD-16
86 5
1
6
567-P553 WH-18
2
2
200-P554
BK-18
85 4
3
OFF
C558-P390 BU-16
87
3
4
87a
5
AC ON

668-P624 BU-18

170-P388
A295-P499
308-P597
403-P288
893-P513
892-P514
K990-P648
K900-P646

1
2

MOTOR

WASHER MOTOR RH DOOR


7T-8890

108-P627 RD-18

P-C126
1950534
RD-18
BK-18
YL-18
GN-18
GN-18
BR-18
GN-18
YL-18

799-P489 WH-18
A202-P526 BK-18
R732-P142 BR-18
P967-P653 PU-18
801-P497 PK-14
T998-P463 BR-18
A296-P86 BK-14
F702-P409 GN-18
G946-P326 OR-18
C978-P327 BR-18
A755-P430 PK-18
H864-P452 GN-18
C979-P431 OR-18
A758-P328 BR-18
850-P690 PU-14
A756-P329 BU-18
A296-P104 BK-14
849-P691 YL-18
R800-P389 OR-18
229-P382 BK-14
N788-P692 PK-18
G434-P626 BU-18
A757-P411 GY-18
M792-P693 BU-18
103-P308 RD-16
104-P307 RD-14
105-P369 RD-16
112-P530 PU-4
115-P531 RD-4
124-P677 GN-18
128-P447 PK-18
152-P286 RD-14
155-P564 RD-14
156-P516 YL-18
172-P279 RD-14
308-P276 YL-18
308-P623 YL-18
403-P312 GN-18
519-P419 PK-18
520-P418 WH-18
567-P684 WH-18
593-P675 GN-16
843-P678 WH-18
844-P679 GN-18
849-P691 YL-18
850-P690 PU-14
892-P666 BR-18
892-P278 BR-18
893-P277 GN-18
893-P665 GN-18
A201-P694 BK-18
A201-P694 BK-18
C558-P390 BU-16
E716-P294 GY-14
E717-P354 GN-14
G434-P626 BU-18
H807-P506 YL-18
H864-P452 GN-18
J766-P290 PU-18
J844-P289 GY-18
K900-P46 YL-18
K900-P667 YL-18
K990-P47 GN-18
K990-P668 GN-18
L914-P359 BU-18
M792-P693 BU-18
N788-P692 PK-18
U769-P504 OR-18
U770-P505 WH-18

1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24

PARK LIGHTS
KEY SWITCH ON
POWER ANTENNA
DIM
BATTERY
GROUND
RR SPEAKER (+)
RR SPEAKER (-)
RF SPEAKER (+)
RF SPEAKER (-)
LF SPEAKER (+)
LF SPEAKER (-)
LR SPEAKER (+)
LR SPEAKER (-)

P-C121
1552269

A295-P204 BK-14
A295-P89 BK-14
683-P161 PU-14
844-P679 GN-18

ENT RADIO AM FM WBAND


200-5729 AM/FM CASSETTE

LO

617-P421
618-P423
603-P243
C542-P158
200-P709
680-P173
200-P635
609-P268
200-P636
A557-P681
200-P631

997-P192 OR-18
998-P188 BR-18
N931-P194 GY-18
R908-P453 YL-18
A295-P191 BK-14
E929-P195 GY-18
A202-P184 BK-14
L731-P94 BR-18
200-P248 BK-18
307-P315 OR-16
G953-P186 BU-18
G965-P185 PU-18
C532-P457 GN-18
F783-P111 GN-18
604-P410 OR-18
618-P422 YL-14
582-P250 PK-18
617-P420 BR-14
581-P249 GY-18
U768-P434 BU-18
G755-P113 GY-18
A975-P503 BU-18
U766-P472 BR-18
843-P678 WH-18
X800-P462 OR-18
F846-P236 PU-18
H764-P415 GY-18
H765-P213 WH-18
U739-P214 BR-18
G750-P124 BU-18
U741-P219 OR-18
F784-P128 YL-18
U734-P380 GN-18
E974-P325 GN-18
F843-P322 YL-18
U740-P220 BU-18
G763-P172 PU-18
F781-P225 BR-18
U735-P381 GY-18
U727-P323 WH-18
F787-P324 GN-18
U726-P404 GY-18
U725-P403 GN-18
893-P304 GN-18
892-P305 BR-18

HIGH
1
2
3
4
5
6
7
8
9
10
11
12

11

124-P677
200-P554
200-P688
506-P231
507-P233
515-P508
516-P507
517-P475
519-P419
520-P418
529-P240
530-P241
567-P553
567-P683
567-P684
593-P675
843-P678
844-P679
849-P691
850-P690
A201-P694
A524-P509
C558-P390
C568-P476
G434-P626
H864-P452
M792-P693
N788-P692

U723-P180 PU-18
121-P245 YL-18
M998-P459 OR-18
609-P449 YL-18
H747-P101 BR-18
H803-P83 BU-18
F785-P110 WH-18
K990-P298 GN-18
K900-P297 YL-18
556-P166 WH-18
126-P299 RD-18
U753-P215 BR-18
X754-P385 GN-18
X755-P384 WH-18
308-P301 YL-18
U767-P470 BU-18
403-P302 GN-18
925-P383 YL-18
N787-P193 BU-18

1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70

HVAC OPERATOR PNL


248-4220

BK-18
BK-18
BK-14
BK-18
BK-14
BK-14
BK-18
BK-18
BK-12
BK-14

140-P661
C546-P632
200-P644
515-P508

CONN 47

GND

BK-16
GN-16
GY-16
BR-16
OR-16

P-C71
9X0145

MOTOR H

GND

GN-16
GY-16
BR-16
OR-16

P-C110
3E3388

GN-16
GY-16
BR-16
OR-16

GND

BK-16

WK-C2
1552273

BK-18
BK-18
BK-14
BK-18
BK-14
BK-14
BK-18
BK-18
BK-12
BK-14

124-P652
C546-P632
C568-P476
516-P507
517-P475
E529-P680
200-P628
614-P719
200-P718
592-P596
A524-P509
200-P630

2
1
4
6
3
5

WK-C1
3E3382

1
2
3
4
5
6
7
8

124-P677
519-P419
J844-P289
403-P312
J766-P290
E717-P354
103-P308
104-P307
567-P684
152-P286
L914-P359
E716-P294
128-P447

WJ-C2
1552273

2
1
4
6
3
5

1
4
6
3
5

1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25

P-C70
8N1517

WH/RD-14 MOTOR
BK-14

1
2

WJ-C1
3E3382

CONN 38

500-P610
501-P609
502-P608
503-P586
504-P585
505-P584
508-P577
509-P578
511-P579
512-P580
523-P592
524-P591
525-P590
526-P604
527-P603
528-P602
A557-P681
C546-P632

REAR WIPER SWITCH


3E-0155
RD-14
RD-18
BK-18
WH-14
YL-14
BU-14
BR-18

1
2
3
4
5
6
7
8

CONN 39

CONN 37

500-P610
501-P609
502-P608
503-P586
504-P585
505-P584
508-P577
509-P578
511-P579
512-P580
523-P592
524-P591
525-P590
526-P604
527-P603
528-P602
A557-P681
C546-P632

RADIO SPEAKER RH
6T-7695

LH DOOR WIPER SWITCH


3E-0155

CONN 40

504-P585
120-P611
503-P586
505-P584

RADIO SPEAKER LH
6T-7695

1
2
3
4
5
6
7
8

P-C106
1552269
A507-P619 YL-16
200-P620 BK-18

YL-18
GN-18
BR-18
YL-18
GN-18
OR-18
YL-18
PU-18
PU-18

+12 VOLTS
GROUND
SIGNAL

OR-18
BK-18
WH-18

DEFROST FAN RES


7T-4003

P-C113
1552273
200-P639 BK-18

1
2

R BLADEDWN FORCE CONT


219-2392
A
B
C

P-C99
3E3388

A
B
C

P-C108
1552273
200-P621 BK-18

524-P591
118-P614
523-P592
525-P590

P-C111
3E3364
COMM RADIO
CONNECTION

P-C149
3E3370

P-C105
1552267

GN-14
BR-18
GN-18
BK-18
BK-18
GN-16
YL-16
PK-18
BR-18
GN-18
WH-14
E529-P686
E529-P680
E529-P685

+12 VOLTS
GROUND
SIGNAL

OR-18
BK-18
WH-18

COMM CONVERTER
184-3579

668-P624 BU-18
668-P645 BU-18

680-P173
892-P514
893-P513
A295-P499
A295-P532
A504-P234
A507-P237
A513-P398
A524-P509
C542-P158
C568-P476

A
B
C

A
B
C

1
2
3
4
5
6

308-P598 YL-16

567-P682 WH-18
BU-18
BU-16
PK-18
YL-18
PU-18

A
B
C

L BLADEDWN FORCE CONT


219-2392

+
-

P-C73
1552264
YL-14
YL-14
BK-18
BU-14
YL-14
BR-14
WH-14

517-P475 BU-14
516-P507 GN-14
515-P508 GY-12

592-P595
592-P596
603-P243
609-P268
614-P714

P-C148
3E3370

P-C103
1552273

GN-18
PU-14
WH-14
WH-14
OR-14

567-P553 WH-18
567-P683 WH-18
567-P684 WH-18

OFF

+
-

308-P597 YL-18
308-P598 YL-16

308-P351 YL-18
308-P395 YL-14
308-P283 YL-16

ON

1
2
3
4
5
6
7
8
9
10

511-P579 BR-18
512-P580 GN-18

200-P651
200-P618
200-P716
200-P633

200-P121 BK-18
200-P554 BK-18
200-P634 BK-12

N936-P534
A295-P532
N935-P519

12
108-P244 RD-14
118-P239 GY-14
119-P232 PK-14
120-P235 YL-14
124-P309 GN-14
124-P677 GN-18
130-P103 GN-18
134-P689 RD-18
140-P661 BU-12
156-P535 YL-18
156-P536 YL-18
170-P388 RD-18
176-P387 RD-12
200-P35 BK-18
200-P121 BK-18
200-P123 BK-18
200-P135 BK-18
200-P181 BK-18
200-P300 BK-18
200-P352 BK-18
200-P393 BK-18
200-P402 BK-18
200-P444 BK-18
200-P445 BK-18
200-P554 BK-18
200-P620 BK-18
200-P628 BK-18
200-P637 BK-18
200-P644 BK-18
200-P654 BK-18
200-P688 BK-18
308-P283 YL-16
308-P351 YL-18
308-P395 YL-14
403-P288 GN-18
506-P231 PU-14
507-P233 WH-14
515-P508 GY-12
516-P507 GN-14
517-P475 BU-14
529-P240 WH-14
530-P241 OR-14
567-P553 WH-18
567-P683 WH-18
567-P684 WH-18
592-P595 BU-18
592-P596 BU-16
603-P243 PK-18
609-P268 YL-18
614-P714 PU-18
614-P715 PU-18
614-P719 PU-18
617-P421 BR-14
618-P423 YL-14
668-P227 BU-18
668-P454 BU-18
680-P173 GN-14
892-P514 BR-18
893-P513 GN-18
A295-P499 BK-18
A295-P532 BK-18
A504-P234 GN-16
A507-P237 YL-16
A513-P398 PK-18
A524-P509 BR-18
C542-P158 GN-18
C568-P476 WH-14
H786-P539 YL-18
H787-P492 GN-18
J710-P662 BR-18
K900-P646 YL-18
K990-P648 GN-18
N935-P519 OR-18
N936-P534 YL-18
P967-P537 PU-18
P967-P538 PU-18

BLADE FORCE SW
278-4210

508-P577 PU-18
509-P578 WH-18

GN-18
RD-18
BU-12
YL-18
YL-18
RD-18
RD-12

200-P393 BK-18
200-P402 BK-18

P-C122
2234778
YL-18
BK-18
OR-18

13

614-P455
614-P152
614-P222
614-P721
614-P720

PU-18
PU-18
PU-18
PU-18
PU-18

617-P432 BR-14
617-P150 BR-14
618-P433 YL-14
618-P151 YL-14

626-P713 BU-18
646-P129 OR-18
646-P140 OR-18
646-P126 OR-18

668-P227 BU-18

668-P454 BU-18

647-P700
647-P130
647-P141
647-P125

GN-18
GN-18
GN-18
GN-18

668-P122
668-P361
668-P374
668-P566
668-P349
668-P565

BU-18
BU-18
BU-18
BU-18
BU-18
BU-18

668-P272 BU-18
668-P343 BU-18
668-P562 BU-16
668-P334 BU-18
668-P435 BU-18
668-P346 BU-18

103-P116
104-P114
104-P285
105-P369
106-P112
114-P146
114-P147
123-P230
123-P451

RD-16
RD-14
RD-14
RD-16
WH-14
RD-14
RD-18
WH-14
WH-18

125-P251
125-P269
125-P546
125-P549
125-P287
125-P313
125-P363
125-P370
126-P299
127-P242
127-P424
128-P371
142-P264
142-P265
142-P456
143-P162
143-P163
144-P439
146-P698
146-P699
152-P286
160-P156
165-P138
179-P394

RD-18
RD-18
RD-18
RD-18
RD-18
RD-18
RD-18
RD-18
RD-18
RD-16
RD-18
PK-18
BU-18
BU-18
BU-18
BR-14
BR-18
GN-14
GY-18
GY-14
RD-14
PU-18
YL-18
RD-14

200-P107
200-P121
200-P123
200-P133
200-P134
200-P135
200-P136
200-P267
200-P366
200-P393
200-P402
200-P407
200-P425
200-P440
200-P723
200-P724
210-P386
307-P315

BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK- 18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-14
OR-16

308-P190
308-P373
308-P395
308-P481
308-P482
308-P485
322-P149
518-P273
538-P275
556-P167
556-P261
581-P249
582-P250
592-P512

YL-18
YL-16
YL-14
YL-18
YL-18
YL-18
GY-18
OR-14
BR-18
WH-18
WH-18
GY-18
PK-18
BU-14

605-P223
606-P224
607-P701
611-P339
611-P341
614-P152
614-P719
614-P720
614-P721
617-P150

YL-18
GY-18
PK-14
PU-18
PU-14
PU-18
PU-18
PU-18
PU-18
BR-14

618-P151
619-P170
626-P713
645-P154
646-P126
646-P129
647-P125
647-P130
647-P700
668-P122
668-P272
668-P343
668-P346
668-P435
668-P562
668-P565
680-P173
683-P161
684-P139
685-P164

YL-14
GN-14
BU-18
PK-18
OR-18
OR-18
GN-18
GN-18
GN-18
BU-18
BU-18
BU-18
BU-18
BU-18
BU-16
BU-18
GN-14
PU-14
OR-18
BR-14

727-P196
799-P489
892-P428
892-P465
893-P429
893-P466
A202-P274
A202-P295
A202-P368
A202-P526
A210-P340
A210-P342
A274-P467
A274-P469
A295-P367
A513-P401
A514-P157
A608-P168
A975-P503

GN-18
WH-18
BR-18
BR-18
GN-18
GN-18
BK-18
BK-18
BK-16
BK-18
BK-16
BK-18
BK-14
BK-14
BK-18
PK-14
YL-18
GY-18
BU-18

P-C24
1552252

518-P273
539-P271
605-P223
606-P224
581-P249
582-P250

RD-18
BU-18
BU-18
RD-18
P-C36
1552269
H414-P169 YL-18
A210-P342 BK-18

10

CTR SHIFT PIN PULLED


250-2299

RD
BK

PARK BRAKE OP SW
222-7890

P-C77
2234778
GN-18
BK-16
GY-18

RD-18
BU-18
BU-18
RD-18

OFF

BK-16
BK-14
BK-14
BK-18
A513-P401 PK-14
A513-P400 PK-16

C542-P493 GN-18
C542-P563 GN-18

F712-P478 GN-18
F712-P480 GN-18
F712-P348 GN-18
PU-18
BU-18
YL-18
YL-18
YL-18
GN-18
GN-18
YL-16
GN-16
OR-18
BR-18
GN-18
GY-18
OR-18
322-P149
518-P273
538-P275
605-P223
606-P224
607-P701
619-P170
645-P154
668-P272
668-P435
684-P139
A514-P157
A608-P168

GY-18
OR-14
BR-18
YL-18
GY-18
PK-14
GN-14
PK-18
BU-18
BU-18
OR-18
YL-18
GY-18

322-P149
518-P273
538-P275
605-P223
606-P224
607-P701
619-P170
645-P154
668-P272
668-P435
684-P139
A514-P157
A608-P168

GY-18
OR-14
BR-18
YL-18
GY-18
PK-14
GN-14
PK-18
BU-18
BU-18
OR-18
YL-18
GY-18

HORN SWITCH
P-C44 170-1821
3E3364
1
2

114-P146
114-P147
320-P148
322-P149

125-P546 RD-18
125-P549 RD-18
128-P371 PK-18
439-P257 YL-18
614-P719 PU-18
668-P346 BU-18
668-P372 BU-18
668-P527 BU-18
668-P562 BU-16
668-P565 BU-18
668-P655 BU-18
799-P489 WH-18
A202-P274 BK-18
A202-P526 BK-18
F711-P347 YL-18
F712-P348 GN-18
F775-P258 BU-18
F775-P258 BU-18
H803-P83 BU-18
T998-P463 BR-18
X800-P462 OR-18

1
5
2
4
3

BK-18
BK-18

HORN RELAY
3E-5239
30
86
85

87
87a

320-P148
439-P257
539-P271
540-P270
610-P155
668-P372
668-P527
668-P655
695-P252
696-P253
C981-P115
F775-P258
H414-P169

OR-18
YL-18
BU-18
WH-18
OR-14
BU-18
BU-18
BU-18
OR-18
GN-18
GN-18
BU-18
YL-18

320-P148
439-P257
539-P271
540-P270
610-P155
668-P372
668-P527
668-P655
695-P252
696-P253
C981-P115
F775-P258
H414-P169

OR-18
YL-18
BU-18
WH-18
OR-14
BU-18
BU-18
BU-18
OR-18
GN-18
GN-18
BU-18
YL-18

P-C9
1552269
1
2

P-C14
3E3364

BLADE FLOOD RELAY2


3E-5239
30
86

1
5
2
4
3

WH-14
WH-18
OR-18
PU-14
BR-14
BR-18
GN-18
BR-14

106-P112
684-P139
200-P123
680-P173

P-C66
9X1054
WH-14
OR-18
BK-18
GN-14

1
5
2
4
3

85

87
P-C35
87a 9X1054

CAB FLOODLIGHTS RLY


3E-5239
30
86
85

87
87a

611-P339 PU-18

YL-18
GN-18

626-P713
614-P152
200-P121
668-P122

103-P438
103-P725
104-P153
104-P160
106-P108
106-P117
116-P396
122-P256
125-P357
125-P377
127-P330
129-P353
141-P228
160-P174
169-P262
180-P165
180-P658
199-P364
200-P132
200-P254
200-P266

RD-18
RD-14
RD-18
RD-18
WH-18
WH-18
BR-18
BU-14
RD-18
RD-18
RD-18
RD-16
PK-16
PU-16
PK-18
RD-16
RD-18
RD-18
BK-18
BK-18
BK-18

200-P352
200-P444
200-P445
200-P654
229-P382
308-P351
322-P149
518-P273
538-P275
605-P223

BK-18
BK-18
BK-18
BK-18
BK-14
YL-18
GY-18
OR-14
BR-18
YL-18

606-P224
607-P701
611-P336
614-P222
614-P455
614-P714
614-P715
617-P432
618-P433
619-P170
645-P154
646-P140
647-P141
668-P334
668-P349
668-P361
668-P374
668-P566
684-P139
685-P109
685-P171
892-P331
893-P332
A202-P355
A202-P358
A202-P360
A202-P378
A202-P437
A250-P303
A513-P400
A514-P157
A608-P168
C542-P563
H807-P703

GY-18
PK-14
PU-14
PU-18
PU-18
PU-18
PU-18
BR-14
YL-14
GN-14
PK-18
OR-18
GN-18
BU-18
BU-18
BU-18
BU-18
BU-18
OR-18
BR-14
BR-14
BR-18
GN-18
BK-18
BK-18
BK-18
BK-18
BK-18
BK-16
PK-16
YL-18
GY-18
GN-18
YL-18

85

87
87a P-C31
9X1054

87
87a

104-P285
645-P154
200-P136
610-P155

165-P138
A975-P503
200-P107
556-P261

85

1
5
2
4
3

1
5
2
4
3

85

P-C81
3E3382

OFF
TEST

609-P449 YL-18
609-P268 YL-18

893-P429 GN-18
892-P428 BR-18
K990-P426 GN-18
K900-P427 YL-18

1
2
3
4
5
6
7
8

DESCRIPTION
CIRCUIT CONNECTED
CIRCUIT NOT CONNECTED
ELECTRICAL CONNECTION TO
MACHINE STRUCTURE
INTERNAL ELECTRICAL CONNECTION
TO SURFACE OF COMPONENT
CONNECTOR

H#

CIRCUIT GROUPING DESIGNATION


ATCH WIRE, CABLE, COMPONENT
SPLICE
BLADE, SPADE, RING OR SCREW
TERMINAL

E974-P325
F702-P409
F781-P225
F783-P111
F784-P128
F785-P110
F787-P324
F843-P322
G750-P124
G755-P113

CONN 50
SERVICE TOOL
CONNECTOR

ACCUGRADE ARO CONNECTOR


(ACCUGRADE SHOWN ON
SEPARATE SCHEMATIC)
KENR6663

998-P189
F781-P225
F783-P111
F784-P128
F785-P110
G750-P124
G755-P113
G763-P172
K750-P80
K758-P75
L731-P94
P967-P96
R800-P446
T998-P408
U739-P95
U740-P97
U741-P98
U743-P73
U744-P72
U745-P76
X800-P488

COLOR

RD
WH
OR
YL
PK
BK
GY
PU
BR
GN
BU

RED
WHITE
ORANGE
YELLOW
PINK
BLACK
GRAY
PURPLE
BROWN
GREEN
BLUE

LH JOYSTICK
271-5479

128-P371
169-P259
199-P364
322-P149
439-P257
570-P333
607-P701
685-P109
801-P497
998-P293
A202-P358
A250-P303
A847-P673
A849-P674
C532-P457
F775-P258
H765-P335

P-C50
1030213
128-P371 PK-18
U702-P1 GY-18
U703-P2 YL-18
U700-P3 WH-18
U701-P4 GN-18
U747-P65 OR-18
U748-P66 GY-18
U749-P64 BR-18
U750-P63 PK-18
M722-P5 OR-18
M720-P6 BU-18
U752-P54 PU-18
U751-P53 WH-18
R903-P62 OR-18
R902-P60 GN-18
R901-P61 GY-18
R900-P59 BU-18
K789-P55 YL-18
K788-P56 GY-18
U704-P7 PK-18
U705-P8 PU-18
M906-P702 BU-18
H807-P703 YL-18
570-P333 BU-18
R800-P92 OR-18
P967-P495 PU-18
H808-P669 WH-18

PK-18
PK-18
RD-18
GY-18
YL-18
BU-18
PK-14
BR-14
PK-14
BR-18
BK-18
BK-16
YL-18
OR-18
GN-18
BU-18
WH-18

H803-P672 BU-18
H803-P83 BU-18

K831-P670 GY-18
K832-P671 OR-18
K927-P9 BU-18
K952-P10 BR-18
H862-P182 GY-18

H803-P82 BU-18

H807-P703 YL-18
H808-P669 WH-18
H861-P177 PU-18
H862-P182 GY-18
H863-P183 BU-18
K788-P56 GY-18
K789-P55 YL-18
K831-P670 GY-18
K832-P671 OR-18
K927-P9 BU-18
K952-P10 BR-18
M720-P6 BU-18
M722-P5 OR-18
M906-P702 BU-18
P967-P495 PU-18
R800-P92 OR-18
R900-P59 BU-18
R901-P61 GY-18
R902-P60 GN-18
R903-P62 OR-18
T998-P238 BR-18
U700-P3 WH-18
U701-P4 GN-18
U702-P1 GY-18
U703-P2 YL-18
U704-P7 PK-18
U705-P8 PU-18
U723-P180 PU-18
U736-P211 YL-18
U742-P207 WH-18
U747-P65 OR-18
U748-P66 GY-18
U749-P64 BR-18
U750-P63 PK-18
U751-P53 WH-18
U752-P54 PU-18
X725-P187 GY-18
X800-P487 OR-18

H863-P183 BU-18
H861-P177 PU-18
607-P701 PK-14
169-P259 PK-18
439-P257 YL-18
F775-P258 BU-18
A847-P673 YL-18
A849-P674 OR-18
322-P149 GY-18
A250-P303 BK-16
199-P364 RD-18
H765-P335 WH-18
U736-P211 YL-18
H803-P82 BU-18
685-P109 BR-14
U723-P180 PU-18
A202-P358 BK-18
X725-P187 GY-18
U742-P207 WH-18
801-P497 PK-14
C532-P457 GN-18
998-P293 BR-18
T998-P238 BR-18
X800-P487 OR-18

K750-P80 PU-18
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70

K758-P75
U743-P73
U744-P72
U745-P76
F785-P110
F783-P111
F781-P225
F784-P128
G750-P124
G763-P172
G755-P113

P-C61
1950534
605-P223
617-P432
606-P224
611-P336
619-P170
618-P433
685-P171
200-P132
125-P546
125-P549
103-P725
104-P153
125-P350
125-P576
127-P330
169-P260
180-P200
200-P352
200-P654
229-P382
308-P351
518-P273
614-P222
538-P275
614-P714
614-P715
614-P719
645-P154
668-P226
668-P334
668-P349
668-P372
668-P527
668-P555
668-P556
668-P556
668-P557
668-P558
668-P559
668-P562
668-P568
668-P655
668-P657
892-P331
893-P332
A756-P329
A757-P411
A758-P328
C978-P327
F711-P347
F712-P348
F775-P258
G766-P198
G767-P197
G946-P326

YL-18
BR-14
GY-18
PU-14
GN-14
YL-14
BR-14
BK-18

P-C136
1552264
1
2
3
4
5
6
7
8

CONN 32
U-C68
VOLUME 1
LOC G-8
CHASSIS SCHEMATIC

Y933-RF3 YL-18

Y934-RG1
H745-RG2
Y936-RG3
Y933-RG4

RG-C2
1552264
WH-18
BR-18
PK-18
YL-18

J771-RG5 BU-18
Y937-RG6 PU-18
H745-RG7 BR-18

RH-C2
1552253
BU-18
YL-18
BR-18
YL-18
YL-18
BR-18

K723-RH7 PU-18
H745-RH8 BR-18
Y935-RH9 OR-18
K722-RH10 YL-18

CONN 24
TO U-C70
U HARNESS
VOLUME 1 LOC G-8

1
2

CONN 3

GN-18

P-C83
1552267
103-P438 RD-18

P-C135
1552252

604-P410 OR-18

P-C84
1552272
E974-P325 GN-18
A202-P437 BK-18
U727-P323

WH-18

P-C40
1552267
T998-P412 BR-18
X800-P291 OR-18
F843-P322 YL-18

BK-18
RD-18
WH-18

PK-16
YL-16
RD-16
BU-18
BU-18
RD-16

BK-18
RD-18

1
2
3
4

WH-18

RD-18
PK-18
RD-18
BK-18
BK-18

4
1

OR-18
BK-18
WH-18

+8 VOLTS
GROUND
SIGNAL

DEFROST FAN SW
236-4611
1
2
3
4
5
6
7
8
9
10

FAST
OFF
SLOW

570-P333 BU-18

614-P544 PU-18
614-P543 PU-18

614-P714 PU-18
614-P715 PU-18

614-P118 PU-18

668-P527
668-P655
668-P372
668-P562
668-P226

BU-18
BU-18
BU-18
BU-16
BU-18

668-P334
668-P556
668-P349
668-P568

BU-18
BU-18
BU-18
BU-18

668-P560 BU-18
668-P561 BU-18

668-P558
668-P557
668-P555
668-P657
668-P346
668-P559

BU-18
BU-18
BU-18
BU-18
BU-18
BU-18

122-P256
T971-P246
T972-P247
200-P266

P-C56
1552272
BU-14
OR-14
GN-14
BK-18

P-C89
CONN
3E3376
1
TO Y-HARNESS
2
Y-C3
3
VOLUME 1
4
LOC B-15

CONN 2

WIRE GROUP COLOR DESCRIPTIONS


GROUND CIRCUIT
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON

TRANSMISSION AND CHASSIS CONTROL CIRCUIT


ENGINE CONTROL CIRCUIT
HEATER AND AIR CONDITIONER CIRCUIT
TURN SIGNAL / WIPER WASHER CIRCUIT
CAT DATA LINK
CAN DATA LINK
IMPLEMENT CONTROL CIRCUIT (1)
IMPLEMENT CONTROL CIRCUIT (2)
ACCUGRADE DATA LINK
GAGE CLUSTER CAN DATA LINK

OTHER COLOR DESCRIPTIONS

4
5
6
7
8
9
10

P-C92
1552267
F711-P319 YL-18
F712-P518 GN-18

GY-18
BR-18
BR-18

GN-18

F712-P362
F712-P518

GN-18
GN-18

A
B
C

P-C94
2234778

P-C93
1552264
1
2
3
4
5
6
7
8

GN-18
RD-18
WH-18
RD-18
BU-18
BU-18
RD-18

P-C47
1552253

INCHING PEDAL SW
171-3759
NOTE D

125-P573
200-P300
668-P565
570-P572

RD-18
BK-18
BU-18
BU-18

HEATED MIRROR SW
236-4630

P-C98
2305010
CONN 55
709-P660 OR-18
A295-P706 BK-18
U712-P414 YL-18

P-C143
CONN 54
2397352
709-P490 OR-18
A295-P491 BK-18
U711-P707 GY-18

OFF
ON

1
2
3
4
5
6
7
8
9
10

125-P574 RD-18
200-P181 BK-18
668-P568 BU-18
C542-P563 GN-18

106-P117 WH-18
660-P399 PU-18
125-P576 RD-18
200-P35 BK-18
668-P566 BU-18
660-P399 PU-18

OFF
ON

P-C49
1552254
709-P99 OR-18
U706-P39 BR-18
A295-P100 BK-16
180-P165 RD-16
U708-P41 OR-18
U709-P42 WH-18
U707-P40 BU-18
U760-P69 PK-18
U761-P70 PU-18
U762-P659 GN-18
U710-P43 GN-18
U711-P44 GY-18

+ BATTERY
- BATTERY
KEY SWITCH
DIMMER
CAT DATA LINK
CAT DATA LINK
Gauge CLUSTER
Gauge CLUSTER

LOW
HIGH
CAN HIGH
CAN LOW

1
2
3
4
5
6
7
8
9
10
11
12

J1
+V1
BLADE LIFT SNSR
GROUND 1
+V2
BLADE SIDESHFT SNSR
GROUND 2
CIRCLE DRIVE SNSR
BLADE PITCH SNSR
CIRCLE SIDESHFT SNSR

J2
THROTTLE RES
THROTTLE RES
DIFF LOCK SW
DIFF LOCK SW

(N/O)
(N/C)
(N/O)
(N/C)

AUX CONT POD


238-8756
1
2
3
4
5
6
7
8
9
10
11
12

J1
PRIMARY POWER
PWM #1
PRIMARY GND
LED PWR
PWM #3
PWM #4
PWM #2
LED #1
LED #2
LED #3
MINI AXIS 1
MINI AXIS 2

J2

AUTOSHIFT ON OFF SW
249-5478

PRIMARY PWR
MINI AXIS1
GND
PRIMARY PWR
MINI AXIS 2
GND

OFF
ON

1
2
3
4
5
6
7
8
9
10

MESSENGER
239-5025

RH JOYSTICK
233-3118
1
2
3
4
5
6
7
8
9
10
11
12

U765-P81 WH-18

1
2
3
4
5
6
7
8
9
10

OFF
PULL

UNLOCK
LOCK

1
2
3
4
5
6
7
8
9
10

799-P494 WH-18
M719-P78 GN-18
A202-P575 BK-18
U763-P77 BU-18
U764-P74 GY-18

169-P356 PK-18
570-P571 BU-18

CENTERSHIFT PIN SW
280-4244

IMPLEMENT LOCKOUT SW
251-1197

709-P90 OR-18
K749-P79 WH-18
A295-P91 BK-16

BLADE CUSHION SW
249-5487

DC CAN RESISTOR 1
134-2540

892-P331 BR-18
893-P332 GN-18
F711-P320 YL-18
F712-P362 GN-18

BU-18
GN-18
WH-18
OR-18

THROTTLE LOCK MODE SW


249-5493
MAN
OFF
AUTO

1
2
3
4
5
6
7
8
9
10

127-P330 RD-18
200-P654 BK-18
308-P351 YL-18

G766-P198
180-P200
G767-P197
125-P552
668-P657
668-P559
125-P656

P-C95
2234778

TAIL
OFF
HEAD/TAIL

P-C91
2234778

668-P561 BU-18

F712-P348

F775-P258
G766-P198
G767-P197
G946-P326

HEAD TAIL LAMPS SW


249-5486

125-P551 RD-18

YL-18
YL-18

P-C141
2304011
180-P658 RD-18
U762-P705 GN-18

RH OFFSET SW
249-5483
1
2
3
4
5
6
7
8
9
10

169-P260 PK-18
F775-P258 BU-18

BU-18
BU-18
BU-18
BU-18
BU-18

F711-P319
F711-P320

P-C97
2234778
U725-P403 GN-18
A202-P355 BK-18
U726-P404 GY-18

660-P399 PU-18

2
4

BK-18
BU-18
RD-18
BU-18
BU-18
RD-18
P-C90 THROTTLE SET SW
2234778 229-2580
1
SET/ACCEL
C978-P327 BR-18
2
229-P314 BK-18
3
NO CHANGE
G946-P326 OR-18

668-P555 BU-18

YL-18

160-P174 PU-16
A514-P157 YL-18

668-P565 BU-18
668-P566 BU-18
668-P568 BU-18
709-P490 OR-18
709-P660 OR-18
A202-P355 BK-18
A295-P491 BK-18
A295-P706 BK-18
A514-P157 YL-18
C542-P563 GN-18
U711-P707 GY-18
U712-P414 YL-18
U725-P403 GN-18
U726-P404 GY-18
U762-P705 GN-18

RH AUTO MAN SW
253-1789

1
2
3
4
5
6
7
8
9
10

229-P296
A756-P329
125-P547
668-P558
668-P557
125-P550

125-P548 RD-18

F711-P347

P-C96
2234778

570-P571 BU-18
570-P572 BU-18

1
3

WH-18
BR-18
BK-18

P-C60
2234778

A758-P328 BR-18
229-P306 BK-18
A757-P411 GY-18

C979-P431 OR-18
A755-P430 PK-18
R908-P453 YL-18

160-P174 PU-16
169-P356 PK-18
180-P658 RD-18
200-P35 BK-18
200-P181 BK-18
200-P300 BK-18

STARTING CIRCUIT

200-P352 BK-18

BRAKE LIGHT SW
189-0135

125-P573 RD-18
125-P574 RD-18

RD-16
RD-16
RD-16
RD-18

VOLTAGE CONVERTER OUTPUT CIRCUIT

538-P275 BR-18

229-P306 BK-18
229-P296 BK-18
229-P314 BK-18

BRAKE PEDAL SW
171-3759
NOTE D

2
4

OFF
ON

1
2
3
4
5
6
7
8
9
10

103-P725 RD-14
518-P273 OR-14

+ 8 VOLTS
GROUND
SIGNAL

106-P117 WH-18
125-P576 RD-18

125-P350
125-P337
125-P375
125-P357

RD-18
PK-18
PU-18
RD-18
PU-18
RD-18
BU-18
BU-18
RD-18
HAZARD SW
P-C54 236-4616
2234778

RD-18
RD-18
RD-18
RD-18
RD-18
RD-18

THROTTLE POSITION SENSOR


160-2443

4
1

A
B
C

1
2
3
4
5
6
7
8
9
10

104-P153
645-P154
614-P544
125-P546
614-P543
125-P549
668-P556
668-P560
125-P545

125-P552 RD-18

614-P719 PU-18
614-P222 PU-18

TO AE-HARNESS
AE-C3
VOLUME 1
LOC D-15

INCHING PEDAL SENSOR


160-2443
A
B
C

P-C8
2234778
A504-P234 GN-16
141-P643 PK-16
141-P228
A507-P237
125-P375
668-P374
668-P361
125-P337

RM-C3
2234778
K723-RM4 PU-18
H745-RM2 BR-18
E772-RM12 GN-18
Y935-RM1 OR-18

P-C46
1552252

RD-18
BK-18
WH-18

A
B
C

RM-C2
1552267
J769-RM7 YL-18
Y938-RM5 YL-18
H745-RM6 BR-18

DIFF LOCK FLOOR SW


147-1380

1
2
3
4

1
3

WH-18
BR-18
BK-18

A
B
C

P-C7
2234778

P-C82
1552272

F787-P324

RM-C4
3E5179
1
2
3
4
5
6
7
8
9
10
11
12

RD-14
RD-18
RD-18
RD-18

TO AE-HARNESS
AE-C2
VOLUME 1 LOC D-15

OR-18
BK-18
WH-18

LH AUTO MAN SW
253-1789

SS AUTO MAN SW
253-1789
NOTE: SS AUTO MAN SW ONLY
INCLUDED WITH CD700 DISPLAY

BK-18
BK-18

A
B
C

2
4

RH SWITCH MODULE

A757-P411
A758-P328
C978-P327

1
2
3
4
5
6

1
3

WH-18
BR-18
BK-18

K722-RM3 YL-18

668-P657 BU-18
892-P331 BR-18
893-P332 GN-18
A756-P329 BU-18

P-C134
1552273

A
B
C

RM-C1
1552267
E745-RM10 BU-18
E744-RM8 YL-18
H745-RM9 BR-18

668-P555
668-P556
668-P557
668-P558
668-P559

P-C23
1552267
J844-P289 GY-18
J766-P290 PU-18
F702-P409 GN-18

BK-18

RF-C1
1552267
J771-RF5 BU-18
Y937-RF7 PU-18
H745-RF6 BR-18

LH SWITCH MODULE

645-P154 PK-18

L914-P359 BU-18
A202-P360 BK-18

A202-P378

RF-C3
3E3388
1
2
3
4
5
6
7
8

308-P351 YL-18
518-P273 OR-14
538-P275 BR-18

P-C58
3E3382
A608-P168 GY-18
668-P226 BU-18
614-P455 PU-18
609-P397 YL-18
603-P243 PK-18
684-P139 OR-18
P-C123
1552269

1
2
3
4
5
6
7
8
9
10

CONN 57

229-P382 BK-14

106-P108 WH-18

LH OFFSET SW
249-5483

RF-C2
2234778
WH-18
BR-18
BU-18
PK-18

Y934-RF2
H745-RF4
E771-RF8
Y936-RF1

127-P330
169-P260
180-P200
200-P352
200-P654

BR-18
RD-18
OR-18
GN-18
BK-18
RD-18

J3
STRG SENSOR #3
+V2
GROUND 4

1
2
3
4

TO U-C1
U HARNESS
VOLUME 1
LOC H-8

125-P656
125-P545
125-P551
125-P547
125-P548
125-P550

1
2
3
4
5
6
7
8
9
10
11
12

J2
ARTICULATION SNSR
WHL LEAN SNSR
NEUT ART SW (N/O)
NEUT ART SW (N/C)
UPSHIFT SW (N/O)
UPSHIFT SW (N/C)
DWNSHIFT SW (N/O)
DWNSHIFT SW (N/C)
FNR FORWARD
FNR NEUTRAL
FNR REVERSE

1
2
3
4
5
6
7
8
9
10
11
12

125-P350 RD-16
125-P576 RD-18
125-P641 RD-16

P-C130
3E5179

CONN 25

103-P725
104-P153
125-P546
125-P549

180-P165 RD-16
709-P90 OR-18
709-P99 OR-18
799-P494 WH-18
A202-P575 BK-18
A295-P91 BK-16
A295-P100 BK-16
A755-P430 PK-18
C979-P431 OR-18
K749-P79 WH-18
M719-P78 GN-18
R908-P453 YL-18
U706-P39 BR-18
U707-P40 BU-18
U708-P41 OR-18
U709-P42 WH-18
U710-P43 GN-18
U711-P44 GY-18
U760-P69 PK-18
U761-P70 PU-18
U762-P659 GN-18
U763-P77 BU-18
U764-P74 GY-18
U765-P81 WH-18

BLADE LIFT SNSR

P-C150
1552272

E745-RH1
E744-RH2
H745-RH3
J769-RH4
Y938-RH5
H745-RH6

RD-18
RD-18
RD-14
RD-18
RD-16
RD-18
RD-18
PK-18
RD-18
BK-18
BK-18
BK-14
YL-18
OR-14
PU-18
BR-18
PU-18
PU-18
PU-18
PK-18
BU-18
BU-18
BU-18
BU-18
BU-18
BU-18
BU-18
BU-18
BU-18
BU-18
BU-18
BU-16
BU-18
BU-18
BU-18
BR-18
GN-18
BU-18
GY-18
BR-18
BR-18
YL-18
GN-18
BU-18
GN-18
WH-18
OR-18

116-P396
125-P377
646-P140
647-P141
200-P254
104-P160

BU-18
GY-18
OR-18
PK-18
WH-18
GN-18
BR-18
YL-18
BU-18
PU-18
GY-18

U741-P98 OR-18
T998-P408 BR-18
998-P189 BR-18

P-C151
1642336
1
2
3
4
5
6
7
8
9
10
11
12

STRG SENSOR #2
GROUND 3

P-C52
1552253

CONN 56

799-P496 WH-18
A202-P567 BK-18
X754-P385 GN-18
X755-P384 WH-18
925-P383 YL-18
H764-P212 GY-18

J1
+V1
STRG SENSOR #1
GROUND 1
GROUND 2

1
2
3
4
5
6
7
8
9
10
11
12

U740-P97 BU-18
P967-P96 PU-18

HIGHWAYS

R800-P446 OR-16
U739-P95 BR-18
L731-P94 BR-18
X800-P488 OR-18

BR-18
BR-18
GN-18
YL-18
WH-18
BU-18
GY-18
PU-18
PU-18
BU-18
BR-18
PU-18
OR-16
BR-18
BR-18
BU-18
OR-18
GY-18
OR-18
PK-18
OR-18

4
ABBREV

2
P-C51
1552252

GN-18
GN-18
BR-18
GN-18
YL-18
WH-18
GN-18
YL-18
BU-18
GY-18

G763-P172 PU-18
G946-P326 OR-18
J766-P290 PU-18
J844-P289 GY-18
L731-P94 BR-18
L914-P359 BU-18
R908-P453 YL-18
T971-P246 OR-14
T972-P247 GN-14
U723-P180 PU-18
U725-P403 GN-18
U726-P404 GY-18
U727-P323 WH-18
X754-P385 GN-18
X755-P384 WH-18

CONN 49

5
SYMBOL

609-P397 YL-18

801-P497 PK-14
925-P383 YL-18
A504-P234 GN-16
A507-P237 YL-16
A755-P430 PK-18
A756-P329 BU-18
A757-P411 GY-18
A758-P328 BR-18
C532-P457 GN-18
C978-P327 BR-18
C979-P431 OR-18

CONN 51

A
B
C
D
E
F
G
H
J

1
2

200-P35 BK-18
200-P181 BK-18
200-P300 BK-18
603-P243 PK-18
604-P410 OR-18

SEC STEER TEST SW


236-4615

AIR & HEATED SEAT


CONNECTOR
P-C21
9W1951

127-P424 RD-18
200-P425 BK-18

P-C38
7T5957
A513-P400 PK-16
200-P444 BK-18

MSS
CT-C4
VOLUME 1
LOC C-12
P-C10
3E3364

RD-16
RD-16
RD-16
RD-18
BU-18
BU-18
BU-18
BU-18
BU-18
BU-18
BU-18
BU-18
BU-18

87
87a

CONN 7

1
2
3
4
5
6

RD-16
RD-16
RD-16
RD-18
BU-18
BU-18
BU-18
BU-18
BU-18
BU-18
BU-18
BU-18
BU-18

12V AUX PORT


117-2311

1
2
3
4
5
6
7
8
9
10

668-P372 BU-18

P-C64
1552264
BK-14
RD-14
BK-14
BR-18
GN-18
GN-16
YL-16
YL-18

85

87
87a

125-P370 RD-18

1
2

125-P337
125-P350
125-P375
125-P576
570-P333
668-P226
668-P555
668-P556
668-P557
668-P558
668-P559
668-P568
668-P657

HEADLAMP RELAY
3E-5239
30
86

DIFF LOCK RLY


3E-5239
30
86

727-P196 GN-18
A295-P367 BK-18

P-C22
1552269
144-P439 GN-14
200-P440 BK-18

125-P337
125-P350
125-P375
125-P576
570-P333
668-P226
668-P555
668-P556
668-P557
668-P558
668-P559
668-P568
668-P657

87a
30

87
P-C32
87a 9X1054

P-C4
2234778

308-P482
200-P366
K900-P483
K990-P484
308-P485
F846-P236

87
87a

DIMMER RELAY
3E-5239
30
86

1
5
2
4
3

P-C37
3E5519
YL-18
BU-18
BK-18
WH-18

129-P353 RD-16
200-P445 BK-18

HEATED MIRROR RLY


297-0760
86

6
5
2
4
3
1

RD-14
PK-18
BK-18
OR-14

P-C80
1552273
YL-18
BK-18
YL-18
GN-18
YL-18
PU-18

85

P-C33
1918332

160-P156 PU-18
A514-P157 YL-18
200-P135 BK-18
C542-P493 GN-18

610-P155
A608-P168
200-P133
611-P341
619-P170

KEY SWITCH
110-7887

RH POSITION RELAY
3E-5239
30
86

1
5
2
4
3

169-P259 PK-18
169-P356 PK-18
169-P260 PK-18

180-P165 RD-16
180-P658 RD-18
199-P364 RD-18
200-P132 BK-18
200-P254 BK-18
200-P266 BK-18
200-P352 BK-18
200-P654 BK-18
229-P382 BK-14
308-P351 YL-18
322-P149 GY-18
518-P273 OR-14
538-P275 BR-18
605-P223 YL-18
606-P224 GY-18
607-P701 PK-14
611-P336 PU-14
614-P222 PU-18
614-P455 PU-18
614-P714 PU-18
614-P715 PU-18
617-P432 BR-14
618-P433 YL-14
619-P170 GN-14
645-P154 PK- 18
646-P140 OR-18
647-P141 GN-18
668-P334 BU-18
668-P349 BU-18
668-P361 BU-18
668-P374 BU-18
668-P566 BU-18
684-P139 OR-18
685-P109 BR-14
685-P171 BR-14
892-P331 BR-18
893-P332 GN-18
A202-P355 BK-18
A202-P358 BK-18
A202-P360 BK-18
A202-P378 BK-18
A202-P437 BK-18
A250-P303 BK-16
A514-P157 YL-18
A608-P168 GY-18
C542-P563 GN-18
H807-P703 YL-18
CIGAR LIGHTER
9W-0335

C OFF
S ON
B ST

LH POSITION RELAY
3E-5239
30
86

RD-18
RD-14
RD-18
RD-18
WH-18
WH-18
BR-18
BU-14
RD-18
RD-18
RD-18
PK-16
PU-16

169-P262 PK-18

R
YL-16
PU-16
OR-16
BR-16

BACKLIGHT RELAY
3E-5239
30
86

P-C63
3E5519
OR-14
GY-18
BK-18
PU-14
GN-14

87
87a

ACTION ALARM
KEY SWITCH

1
5
2
4
3

85

85

Gauge CLUSTER CAN HIGH


Gauge CLUSTER CAN LOW

RD-14
PU-18
BK-18
YL-14

1
5
2
4
3

BLADE FLOOD RELAY


3E-5239
30
86

HIGH BEAM
DIMMER

1
2
3
4

P-C19
9X1054
RD-16
PU-18
BK-18
BR-14

103-P438
103-P725
104-P153
104-P160
106-P108
106-P117
116-P396
122-P256
125-P357
125-P377
127-P330
141-P228
160-P174

LEFT HAND TURN


RIGHT HAND TURN

P-C48
1552272

P-C62
9X1054
BU-18
PU-18
BK-18
BU-18

A202-P575 BK-18
A202-P567 BK-18

X800-P462 OR-18

DIFFERENTIAL LOCK

308-P373 YL-16

104-P114
614-P721
200-P723
618-P151

799-P496 WH-18
799-P494 WH-18

X800-P291 OR-18
X800-P487 OR-18
X800-P488 OR-18

+ BATTERY (24V)
- BATTERY

1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24

540-P270 WH-18
539-P271 BU-18

103-P116
614-P720
200-P724
617-P150

RD-18
RD-18
PK-18
YL-18
PU-18
BU-18
BU-18
BU-18
BU-16
BU-18
BU-18

T998-P412 BR-18
T998-P238 BR-18
T998-P408 BR-18

A
B
C

DASH CLUSTER
287-3252

556-P167 WH-18

1
5
2
4
3

PU-18
BR-18
OR-18
YL-18

T998-P463 BR-18

DC CAN RESISTOR 2
134-2540

P-C78
1552267

F711-P477 YL-18
F712-P478 GN-18
P-C79
7X6222
127-P242 RD-16
A210-P340 BK-16

87
87a

REAR FLOOD RELAY


3E-5239
30
86

1
5
2
4
3

143-P162
143-P163
647-P130
685-P164

85

BU-18
YL-18
BR-18
YL-18
YL-18
BR-18

F711-P347 YL-18
F712-P348 GN-18
F775-P258 BU-18
F775-P258 BU-18
H803-P83 BU-18

DIODE REAR FLOOD INTERLOCK


189-3158

GY-14
GY-18
GN-18
PK-14

F711-P479
F712-P480

K723-RH7
H745-RH8
Y935-RH9
K722-RH10

A202-P274 BK-18
A202-P526 BK-18

P-C34
9X1054
123-P230
123-P451
646-P129
683-P161

7
8
9
10
11
12

125-P549
125-P546
128-P371
439-P257
614-P719
668-P346
668-P372
668-P527
668-P562
668-P565
668-P655

P-C145
9X1054
146-P699
146-P698
647-P700
607-P701

RH-C1
3E5179
1
E745-RH1
2
E744-RH2
3
H745-RH3
4
J769-RH4
5
Y938-RH5
6
H745-RH6

799-P489 WH-18

646-P126 OR-18
647-P125 GN-18

C542-P493 GN-18
E716-P294 GY-14
E717-P354 GN-14
F711-P347 YL-18
F711-P477 YL-18
F711-P479 YL-18
F712-P348 GN-18
F712-P478 GN-18
F712-P480 GN-18
F846-P236 PU-18
H803-P83 BU-18
K900-P427 YL-18
K900-P483 YL-18
K990-P426 GN-18
K990-P484 GN-18
L854-P748 YL-16
L855-P749 GN-16
M998-P459 OR-18
T998-P463 BR-18
U734-P380 GN-18
U735-P381 GY-18
X800-P462 OR-18

J771-RG5 BU-18
Y937-RG6 PU-18
H745-RG7 BR-18

A847-P673 YL-18
A849-P674 OR-18
H803-P672 BU-18
H808-P669 WH-18
K831-P670 GY-18
K832-P671 OR-18
K927-P9 BU-18
K952-P10 BR-18
M720-P6 BU-18
M722-P5 OR-18
U700-P3 WH-18
U701-P4 GN-18
U702-P1 GY-18
U703-P2 YL-18
U704-P7 PK-18
U705-P8 PU-18
U706-P39 BR-18
U707-P40 BU-18
U708-P41 OR-18
U709-P42 WH-18
U710-P43 GN-18
U712-P414 YL-18

ON

1
2
3
4
5
6
7
8
9
10

P-C42
1552269

A274-P467
152-P286
A274-P469
892-P465
893-P466
L855-P749
L854-P748
308-P190

P-C76
3E3364

320-P148 OR-18
200-P134 BK-18

CAB GROUND 3
GND

11

AUTOSHIFT ENABLED
250-2299

RD
BK

1
2

P-C18
9X1054
RD-14
RD-18
OR-18
GY-18

+24V UNSWITCHED
+24V SWITCHED
GROUND
+12V UNSWITCHED
+12V SWITCHED
GROUND

VOLTAGE CONV ENT RADIO


209-0381

P-C57
3E3364
1
2

439-P257 YL-18
200-P407 BK-18

BK-18
BK-18
BK-18
BK-18
BK-18

F711-P477 YL-18
F711-P479 YL-18
F711-P347 YL-18

171-P310 RD-14
180-P311 RD-14

1
2
3
4
5
6

P-C15
1552269

A202-P355 BK-18
A202-P368 BK-16
A202-P360 BK-18

E716-P294 GY-14
E717-P354 GN-14

171-P310 RD-14
180-P311 RD-14

P-C30
1552273

307-P315 OR-16
105-P369 RD-16

A975-P503 BU-18

F846-P236
H803-P83
H807-P703
K900-P427
K900-P483
K990-P426
K990-P484
L854-P748
L855-P749
M998-P459
T998-P463
U734-P380
U735-P381
X800-P462

BK-18
PK-18

RD-14
YL-14
BK-18
PK-14
BU-14
BK-14

H414-P169 YL-18
308-P481 YL-18

A210-P106 BK-14

C542-P158 GN-18

1
2

126-P299 RD-18
M998-P459 OR-18

A210-P340 BK-16
A210-P342 BK-18

A513-P398 PK-18

ACTION ALARM
3E-6328

P-C13
1552269

A202-P526 BK-18

A250-P303
A274-P467
A274-P469
A295-P367

ON

1
2
3
4
5
6
7
8
9
10

125-P313
668-P272
668-P343
125-P287

5
6
7
8

WH-18
BR-18
PK-18
YL-18

180-P200 RD-18
709-P90 OR-18
709-P99 OR-18
709-P490 OR-18
709-P660 OR-18
998-P189 BR-18
998-P293 BR-18
A295-P91 BK-16
A295-P100 BK-16
A295-P491 BK-18
A295-P706 BK-18
G766-P198 GN-18
G767-P197 WH-18
H764-P212 GY-18
H765-P335 WH-18
H861-P177 PU-18
H862-P182 GY-18
H863-P183 BU-18
K749-P79 WH-18
K750-P80 PU-18
K758-P75 BU-18
K788-P56 GY-18
K789-P55 YL-18
M719-P78 GN-18
M906-P702 BU-18
P967-P96 PU-18
P967-P495 PU-18
R800-P92 OR-18
R800-P446 OR-16
R900-P59 BU-18
R901-P61 GY-18
R902-P60 GN-18
R903-P62 OR-18
U711-P44 GY-18
U711-P707 GY-18
U736-P211 YL-18
U739-P95 BR-18
U740-P97 BU-18
U741-P98 OR-18
U742-P207 WH-18
U743-P73 GY-18
U744-P72 OR-18
U745-P76 PK-18
U747-P65 OR-18
U748-P66 GY-18
U749-P64 BR-18
U750-P63 PK-18
U751-P53 WH-18
U752-P54 PU-18
U760-P69 PK-18
U761-P70 PU-18
U762-P659 GN-18
U762-P705 GN-18
U763-P77 BU-18
U764-P74 GY-18
U765-P81 WH-18
X725-P187 GY-18

TURN SIGNAL SW
249-5482
LEFT
OFF
RIGHT

695-P252 OR-18
142-P265 BU-18
696-P253 GN-18

125-P269
668-P655
668-P527
125-P251

PU-18
BR-18
OR-18
YL-18

OFF

1
2
3
4
5
6
7
8
9
10

P-C43
2234778

U734-P380
A202-P368
U735-P381

K723-P735
H745-P739
Y935-P736
K722-P737

COMPRESSION BRAKE SW
278-8040

142-P456 BU-18
C981-P115 GN-18
125-P363 RD-18
200-P402 BK-18
668-P435 BU-18
C981-P115 GN-18

GN-18
WH-18
BR-18
BR-18
BR-18
GN-18
GN-18
GN-18

A202-P358
A202-P274
A202-P295
A202-P378
A202-P437

+24V Hazard INPUT


RIGHT TURN DASH OUT
LEFT FRNT TURN OUT
RIGHT FRNT TURN OUT
LEFT REAR TURN OUT
RIGHT REAR TURN OUT
GROUND
GROUND

GN-14
BK-18
GY-14

179-P394
308-P395
200-P393
A513-P401
592-P512
210-P386

E745-P731
E744-P732
H745-P743
J769-P733
Y938-P734
H745-P741

P-C29
1552253
BU-18
YL-18
BR-18
YL-18
YL-18
BR-18

CONN 52

LEFT TURN INPUT


RIGHT TURN INPUT
LEFT TURN DASH OUT

P-C146
2234778

685-P164 BR-14
685-P109 BR-14
685-P171 BR-14

A202-P184 BK-14
A202-P206 BK-14

1
2
3
4
5
6
7
8
9
10
11
12

OR-14
BU-18
YL-18
GY-18
GY-18
PK-18

E717-P354
A202-P295
E716-P294

680-P173 GN-14
683-P161 PU-14

727-P196
799-P489
892-P331
892-P428
892-P465
893-P332
893-P429
893-P466

+24V SWITCHED
GROUND
DASH Hazard OUT

P-C88
3E5179

695-P252 OR-18
696-P253 GN-18
540-P270 WH-18

RG-C1
3E3388
1
Y934-RG1
2
H745-RG2
3
Y936-RG3
4
Y933-RG4

J771-P729 BU-18
Y937-P730 PU-18
H745-P740 BR-18

FLASHER MODULE
252-5224

P-C26
3E3376
1
2
3
4

3
P-C28
1552264
WH-18
BR-18
PK-18
YL-18

1
2
3
4
5
6

MINI JOYSTICK
233-3147
JOYSTICK
FORE/AFT SNSR
J2

+7V - 13V SUPPLY


PWM 5
GROUND #1
+7V - 13V SUPPLY
PWM 6
GROUND #1

JOYSTCK LH/RH SNSR

P-C142
2304012
1
2

AUX LEVER #6 FLOAT IND


279-5308

RD
BK

P-C133
2305011
1
2
3
4
5
6

1
2
3
4
5
6

P-C144
2397353
1
2
3
4
5
6

1
2
3
4
5
6

AUX LEVER #7
247-0740
OR-18
BR-18
YL-18
VT-18
VT-18
VT-18

+ 10V
GROUND
AUX LEVER #7

AUX LEVER #6
279-9675
OR-18
BR-18
YL-18
VT-18
VT-18
VT-18

+ 10V
GROUND
AUX LEVER #6

A
NOTE A: POWER LEAD FROM VOLTAGE CONVERTER TO 2-WAY
COMMUNICATIONS RADIO SHOULD BE 12 AWG OR LARGER.
NOTE B: REPLACE 4 AWG STRAP WITH 00 AWG CABLE ON MACHINES
WITH SECONDARY STEERING ATTACHMENT
NOTE D: BRAKE PEDAL AND INCHING PEDAL CONTACTS
1 TO 2 OPEN ON PEDAL ACTUATION

THIS SCHEMATIC IS FOR THE 16M MOTOR GRADER ELECTRICAL SYSTEM


VOLUME 2 of 3: CAB
MEDIA NUMBER: RENR9024-08
SCHEMATIC PART NUMBER: 267-3908, CHANGE: 01, VERSION: Components are shown installed on a fully operable machine with the key and engine off, transmission shifter
in neutral and with parking brake set.
Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.
Refer to the Parts Manual using a specific serial number prefix in SIS before ordering parts from this schematic.

Description

Wire Color

Power Circuits
101

RD

Description

Control Circuits (Continued)

Battery +24V

J769

YL

Right Side Auto/Manual SW (NC)

Component Identifiers (CID)


Module Identifier (MID)
Electronic Transmission/Chassis Control System
(MID No. 027)

103

RD

LH Position Lamps Fuse

J771

BU

Left Side Auto/Manual SW (NC)

CID

104

RD

RH Position Lamps Fuse

K722

YL

RT Inc/Dec SW (Dec)

0041

105

RD

Key Switch Fuse

K723

PU

RT Inc/Dec SW (Inc)

106

WH

Cab Work Lamps

K737

BR

Engine Brake Cylinders 1 to 4

Component

Component Location - Volume 3 (Engine and Chassis)


Schematic
Location

Component

Machine
Location

Component

Schematic
Location

Machine
Location

Alarm - Backup

H-9

55

Sensor - Atmospheric Pressure

F-6

71

8V DC Sensor Power Supply

Alternator

C-8

65

Sensor - Engine Oil Pressure

F-6

73

0070

Parking Brake Switch

Battery 1

H-3

48

Sensor - Engine Speed (Cam)

E-6

70

0096

Fuel Level Sensor

Battery 2

H-2

48

Sensor - Engine Speed (Crank)

E-6

69

108

RD

Dome Lamps

K738

GN

Engine Brake Cylinders 5 & 6

0144

Backup Alarm Relay

Block - Power

H-2

Sensor - Fuel Pressure

F-5

51

109

RD

Alternator Breaker

K739

BU

Engine Brake Cylinder Common

0168

Electrical System Voltage

Block - Relay & Fuse

G-2

Sensor - Fuel Temperature

F-5

51

112

PU

Main Power Relay Output

K748

OR

Secondary Steer Motor Relay

0177

Transmission Oil Temperature Sensor

Breaker - Alternator

H-4

Sensor - Hydraulic Oil Cooler Inlet Temp

H-9

55

114

RD

Warning Horn (Forward)

K749

WH

Blade Right Lever Pos Sensor

0247

SAE J1939 Data Link

Breaker - Load

H-4

Sensor - Inlet Air Pressure

D-8

78

115

RD

Load Breaker

K750

PU

Blade Left Lever Pos Sensor

0248

Cat Data Link

Breaker - Main

H-4

Sensor - Intake Manifold Air Pressure

E-6

75

116

BR

Beacon

K758

BU

Articulation Lever Pos Sensor

0262

5 Volt Sensor DC Power Supply

117

RD

Main Breaker

K788

GY

Articulation Right Solenoid

Buss - Bar 1 (Breakers)

H-4

Sensor - Main Hydraulic Pump Discharge

C-9

61

0368

Transmission Auto / Manual Switch

118

GY

LH Door Wipers

K789

YL

Articulation Left Solenoid

Control - Engine ECM

I-8

66

Sensor - Service Brake Accumulator Press

H-10

48

0420

Secondary Steering Relay

119

PK

RH Door Wipers

L730

OR

+5V Supply (XMSN Cont)

Control - Transmission & Chassis

I-13

Sensor - Transmission Input Speed

I-14

80

0444

Starter Motor Relay

120

YL

Front / Rear Wipers

L731

BR

5V Return (XMSN Cont)

Diode - Differential Lock Solenoid

E-10

47

Sensor - Transmission Int Speed 1

H-14

80

121

YL

Back Alarm To Lamp

M719

GN

Blade Sideshift Left Pos Sensor

Diode - Starter

F-1

Sensor - Transmission Int Speed 2

H-14

80

122

BU

Side Wiper

M720

BU

Circle Sideshift Left Solenoid

123

WH

Rear Work Lights

M722

OR

Circle Sideshift Right Solenoid

124

GN

HVAC

N707

PU

Fuel Pressure SW Return

125

RD

Back Light

N787

BU

Hydraulic Filter Bypass Switch Pilot Supply

126

RD

Transmission Control Fuse

N788

PK

Not Used

0573

Inching Pedal Position Sensor

0585

Transmission Output Speed Sensor 1

Fuse - AccuGrade

G-1

Sensor - Transmission Oil Temperature

G-15

0588

Monitoring System Display

Fuse - Autolube

G-15

Sensor - Transmission Out Speed 1

H-14

46

0590

Engine ECM

Fuse - Engine Control

E-1

Sensor - Transmission Out Speed 2

H-14

46

0596

Implement ECM

Fuse - Key Switch

F-2

Solenoid - A/C Clutch

D-8

65

0615

Machine Articulation Angle Position

Fuse - LH Position Lamps

F-2

Solenoid - Attachment Brakes 1 thru 6

C-4

68

Downshift Switch

Fuse - RH Position Lamps

F-2

Solenoid - Attachment Injectors 1 thru 6

B-4

68

Upshift Switch

Fuse - Transmission Control

F-2

Solenoid - Cylinder 1 thru 6 Injectors

D-4

68

127

RD

Monitoring

R732

BR

Hydraulic Oil Inlet Temp Sensor

0621

128

PK

Autolube

R736

PK

Park Brake Press SW (NO)

0622

129

RD

Cigar Lighter

R746

PK

Intake Manifold Press Sensor

0623

Directional Switch

Ground - Engine Block

C-8

66

Solenoid - Differential Lock

E-10

47

130

GN

Waves

R747

GY

Atmospheric Pressure Sensor

0627

Park Brake Pressure Switch

Ground - Frame

B-8

62

Solenoid - Ether Aid

G-7

52

132

RD

Condenser Fan #1

T725

WH

Fuel Pressure SW

0669

Transmission Input Speed Sensor

Ground - Frame (Service Center)

H-3

61

Solenoid - Fan Control

H-10

48

134

RD

Air Cleaner

U700

WH

Circle Rt Sol

0673

Transmission Output Speed Sensor 3

Ground - Rear Frame

E-13

62

Solenoid - Implement Pilot Supply

C-9

61
47

135

RD

Condenser Fan #2

U701

GN

Circle Lt Sol

0674

Transmission Intermediate Speed Sensor 1

Ground - Rear Frame 2

E-13

62

Solenoid - Park Brake

G-15

140

BU

Fast Speed Blower Breaker

U702

GY

Aux Valve 1 Sol B

0675

Transmission Intermediate Speed Sensor 2

Ground - Secondary Steer Engine Block

I-5

53

Solenoid - Transmission 1

H-15

141

PK

Defrost Fan

U703

YL

Aux Valve 1 Sol A

0681

Parking Brake Solenoid Valve

Lug - Alternator Isolation

I-4

Solenoid - Transmission 2 (Fwd Low)

I-15

142

BU

Flasher

U704

PK

Aux Valve 2 Sol B

0967

Machine Application

143

BR

Blade Work Lights

U705

PU

Aux Valve 2 Sol A

Lug - Battery

H-1

Solenoid - Transmission 3 (Reverse)

I-15

1326

Location Code

Motor - Condenser Fan 1

E-12

95

Solenoid - Transmission 4 (2nd)

I-15

144

GN

Seat

U706

BR

Aux Lever 1 Pos Sensor

1401

Transmission Clutch Solenoid 1

146

GY

Blade Work Light #2

U707

BU

Aux Lever 2 Pos Sensor

Motor - Condenser Fan 2

D-12

95

Solenoid - Transmission 5 (3rd)

H-15

1402

Transmission Clutch Solenoid 2

150

RD

Engine Control Fuse

U708

OR

Aux Lever 3 Pos Sensor

Motor - Cranking

E-5

50

Solenoid - Transmission 6 (1st)

H-15

1403

Transmission Clutch Solenoid 3

152

RD

AccuGrade Fuse

U709

WH

Aux Lever 4 Pos Sensor

Motor - Fuel Priming Pump

H-5

51

Solenoid - Transmission 7 (Low Range)

I-15

155

RD

AWD Control (Not used 14M)

U710

GN

Aux Lever 5 Pos Sensor

1404

Transmission Clutch Solenoid 4

Motor - Secondary Steer

I-5

53

Solenoid - Transmission 8 (High Range)

I-15

156

YL

Sensor Power

U711

GY

Aux Lever 6 Pos Sensor

160

PU

Heated Mirrors

U712

YL

Aux Lever 7 Pos Sensor

165

YL

Differential Lock

U713

PK

Aux Valve 3 Sol B

1405

Transmission Clutch Solenoid 5

Relay - A/C Clutch

F-2

Suppressor - A/C Diode

D-8

65

1406

Transmission Clutch Solenoid 6

Relay - Autolube

G-2

Suppressor - Secondary Steer Diode

I-4

64

1407

Transmission Clutch Solenoid 7

Relay - Backup Alarm

F-2

Switch - A/C Hi/Low Pressure

D-8

65

1408

Transmission Clutch Solenoid 8

Relay - Fuel Pump

E-2

Switch - A/C Low Pressure

D-8

65

1471

Steering Control Position Sensor 1

Relay - Main

H-2

Switch - Disconnect

H-3

61
72

169

PK

Center Shift / Blade Cushion

U714

PU

Aux Valve 3 Sol A

170

RD

Product Link

U715

BR

Aux Valve 4 Sol B

171

RD

Implement Control #1

U716

BU

Aux Valve 4 Sol A

1472

Steering Control Position Sensor 2

Relay - Secondary Steer

G-2

Switch - Engine Coolant Temperature

E-6

Steering Control Position Sensor 3

Relay - Secondary Steer Motor

I-5

53

Switch - Fuel Pressure

F-5

51

10 Volt Sensor DC Power Supply

Relay - Starter Motor

I-2

Switch - Ground Level Shutdown

G-9

60

G-10

46

172

RD

Implement Control #2

U717

OR

Aux Valve 5 Sol B

1473

176

RD

Communication Radio Converter

U718

WH

Aux Valve 5 Sol A

1482

179

RD

Entertainment Radio Converter

U719

GN

Aux Valve 6 Sol B

1484

Inching Pedal Switch

Resistor - A/C Thermostat Pull-Down

F-10

65

Switch - Hydraulic Pilot Supply Filter By-Pass

180

RD

Implement Control Main

U720

GY

Aux Valve 6 Sol A

1674

Solenoid Return 1

Resistor - Can 1

G-10

50

Switch - Intake Manifold Air Temperature

199

RD

Steering Valve

U723

PU

Fuel Level Sender

1960

Ignition Key Reader

Sender - Fuel Level

C-9

97

Ground Circuits

U724

WH

XMSN Filter Bypass SW

1961

Service Brake Accumulator Pressure

Sensor - Articulation Angle C1 Position

A-12

64

Main Chassis

U725

GN

Auto Shift SW (NC)

2113

Operator Present Switch

Sensor - Articulation Angle Position

A-12

64

200

BK

210

BK

Ent Radio Converter Output (24/12 Volt)

U726

GY

Auto Shift SW (NO)

2175

Secondary Steer Left Solenoid

229

BK

Engine Control Gnd

U727

WH

Inching Pedal (NO)

2176

Secondary Steer Right Solenoid

A201

BK

Not Used

U728

PK

Serv Brake Accum Charge Press Sensor

2199

Secondary Steering Request Signal Line From Implement ECM

A202

BK

Trans & Chassis Control

U734

GN

Park Brake SW (Off)

2200

Left Steering Cylinder Position Sensor

2201

Right Steering Cylinder Position Sensor

2252

Machine Articulation Angle Sensor 2

2304

Differential Lock Relay

A210

BK

Not Used

U735

GY

Park Brake SW(On)

A250

BK

Cab Gnd

U736

YL

Steering Valve Signal

A274

BK

AccuGrade Gnd

U739

BR

Steering Lever Pos 1

A295

BK

Implement Control Ground

U740

BU

Steering Lever Pos 2

BK

Implement 1 Control Ground

U741

OR

Steering Lever Pos 3

BK

Implement 2 Control Ground

U742

WH

Steer Valve Error Signal

U743

GY

Wheel Lean Input Pos Sensor

CID

304

WH

Cranking Motor

U744

OR

Auto Neutral Art Sw (NO)

0001

306

GN

Starter Motor Relay Output

U745

PK

Auto Neutral Art Sw (NC)

0002

Cylinder Injector #2

307

OR

Key Switch Start

U747

OR

Wheel Lean Sol Left

0003

Cylinder Injector #3

YL

Main Power Relay Coil

U748

GY

Wheel Lean Sol Right

0004

Cylinder Injector #4

OR

Horn Relay Coil To Switch

U749

BR

Blade Sideshift Sol Right

0005

Cylinder Injector #5

BR

Backup Alarm

U750

PK

Blade Sideshift Sol Left

GY

Warning Horn (Forward)

U751

WH

Blade Pitch Sol Fwd

365

YL

Fuel Priming Pump Relay

U752

PU

Blade Pitch Sol Reverse

U753

BR

Sec Steer Request Sig

Monitoring Circuits
403

GN

Alternator (r) Term.

U760

PK

Optional Float Ind 1

439

YL

Center Shift Pin Pulled Indicator

U761

PU

Optional Float Ind 4

0006

Cylinder Injector #6

0041

8 Volt DC Supply

0091

Throttle Position Sensor

0094

Fuel Delivery Pressure Sensor

0100

Engine Oil Pressure Sensor

0110

Engine Coolant Temperature Sensor

C491

PU

Park Brake Pressure SW (NC)

U762

GN

F421

YL

Fuel Supply Temp

U763

BU

Circle Drive Lever Pos Sensor

0168

Electrical System Voltage

G434

BU

Not Used

U764

GY

Blade Pitch Input Pos Sensor

0172

Intake Manifold Air Temperature Sensor


Fuel Temperature Sensor
Engine Speed Sensor

H414

YL

Optional Float Ind 6

47

Switch - Transmission Filter Bypass

H-14

46

U765

WH

Circle Sideshift IP Pos Sensor

Accessory Circuits

U766

BR

Op Seat Sw (NO)

0190

500

BR

Wiper - Front (Park)

U767

BU

Op Seat Sw (NC)

0253

Personality Module

GN

Wiper - Front (Low)

U768

BU

Art Angle Pos Sensor 2

0261

Engine Timing

502

OR

Wiper - Front (Hi)

U769

OR

Aux Valve 7 Sol B

0262

5 Volt Sensor DC Power Supply

503

BR

Wiper - Rear (Park)

U770

WH

Aux Valve 7 Sol A

0267

Remote Shutdown

504

YL

Wiper - Rear (Low)

X725

GY

Steering Signal To Controller

0268

Programmed Parameter

Connector Number

Machine
Location

A-15

96

CONN 42

0269

Sensor Power Supply

CONN 47

B-15

96

0274

Atmospheric Pressure Sensor

CONN 48

D-15

96

507

WH

Washer - Rear

Y787

YL

PHS Can (+) (Not Used)

0291

Engine Cooling Fan

CONN 58

E-15

58

508

PU

Radio Speaker - Left

Y788

GN

PHS Can (-) (Not Used)

0296

Transmission Control

509

WH

Radio Speaker - Left (Common)

801

PK

Autolube Solenoid & Pump Motor

CONN 59

E-15

58

0297

All Wheel Drive Control

511

BR

Radio Speaker - Right

843

WH

Not Used

CONN 60

E-15

56

512

GN

Radio Speaker - Right (Common)

844

GN

Not Used

515

GY

Blower Motor (Hi)

849

YL

Not Used

0342

Secondary Engine Speed Sensor

CONN 61

F-15

56

0549

Throttle Lock Switch

CONN 63

F-15

57

0588

Monitoring System Display

CONN 64

F-15

57

516

GN

Blower Motor (Medium)

850

PU

Not Used

517

BU

Blower Motor (Low)

892

BR

Cat Data Link (-)

518

OR

+24V Flasher Input

893

GN

Cat Data Link (+)

519

PK

Thermostat To Refrigerant Press. SW

A847

YL

Left Blade Down Force Pro Valve

0792

Compression Brake Medium/High Solenoid

CONN 67

A-14

54

520

WH

Opr A/C SW To Thermostat

A849

OR

Right Blade Down Force Pro Valve

1551

Cooling Fan Calibrate

CONN 68

H-13

54

521

YL

A/C SW To Refrigerant SW

A893

OR

Fuel Prime SW To Fuel Prime Pump

1589

Turbocharger Inlet Air Pressure Sensor

CONN 69

I-13

54
54

0596

Implement Control

CONN 65

G-15

59

0791

Compression Brake Low/High Solenoid

CONN 66

G-15

59

522

WH

A/C Clutch To Thermostat SW

F843

YL

Inching Pedal Pos Sensor

1627

Fuel Pump Relay

CONN 70

G-13

523

BR

Wiper - Left (Park)

F846

PU

MSS Status LED

1639

Machine Security System Module

CONN 71

A-12

524

BU

Wiper - Left (Low)

G826

WH

Fuel Press Sensor (+5V)

1785

Intake Manifold pressure Sensor

CONN 72

C-12

525

GY

Wiper - Left (Hi)

G827

GN

Fuel Press Sensor (Gnd)

2417

Ether Injection Control Solenoid

CONN 73

D-12

526

YL

Wiper - Right (Park)

G828

WH

+5V Supply 1 (Eng Cont)

2770

Throttle Lock Resume/Decel Switch

CONN 74

A-10 , I-1

527

GN

Wiper - Right (Low)

G829

GN

5V Return (Eng Cont)

2771

Throttle Lock Set/Accel Switch

CONN 75 Snow Wing Lamp

A-10

63

528

PK

Wiper - Right (Hi)

G833

PK

Temp Sensor Return

529

WH

Washer Left

G856

WH

TDC Service Probe (+)

Electronic Implement Control (MID No. 082)


Electronic Implement Control 2 (Mid No. 147)

530

OR

Washer Right

G857

YL

TDC Service Probe (-)

538

BR

Dash Flasher Indicator Output

H803

BU

Proportional Driver Return (9-12) (Imp Cont1)

CID

539

BU

Turn Signal Indicator Right

H807

YL

Load Return 1 (Imp Cont)

0041

Component
8 VDC Sensor Power Supply

540

WH

Turn Signal Indicator Left

H808

WH

Load Return 1 (Imp Cont2)

0168

Electrical System Voltage

556

WH

Differential Lock

H861

PU

Proportional Driver Return (1-4) (Imp Cont)

0247

SAE J1939 Data Link

567

WH

A/C SW To Condenser Fan Relays

H862

GY

Proportional Driver Return (5-8) (Imp Cont)

570

BU

Blade Cushion Sol

H863

BU

Proportional Driver Return (9-12) (Imp Cont)

581

GY

Left Rear Turn Flasher

H864

GN

Not Used

582

PK

Right Rear Turn Flasher

J844

GY

+8 Volt Supply (Eng Cont)

OR

RH Down Force Enable Solenoid

L854

YL

AccuGrade Can (+)

A507

YL

Rear Defroster Fan (Hi)

L855

GN

AccuGrade Can (-)

A513

PK

Dc/Dc Converter Memory Output

R800

OR

+8V Sensor Power (Imp Cont)

0248

Cat Data Link

0262

5 Volt Sensor DC Power Supply

0296

Transmission / Chassis ECM

0358
0490

Hydraulic Lockout Switch

0588

Monitoring System Display

0590

Engine Electronic Control Module

A514

YL

Heated Mirror Power

R818

YL

Transmission Oil Temp Sensor

0597

Main Hydraulic Pump Discharge Pressure

BR

Temp Potentiometer Pos 2

T858

GY

Injector 1 & 2 High Side

0600

Hydraulic Oil Temperature Sensor

A557

WH

Precleaner Blower +B

T859

WH

Injector 3 & 4 High Side

0615

Machine Articulation Angle Position Sensor

A572

PK

Comm Converter 12V Output

T860

OR

Injector 5 & 6 High Side

0967

Machine Application

C532

GN

Autolube Pressure Sensor Signal

X800

OR

+8V Sensor Return (XMSN Cont)

C542

GN

Heated Mirror Power

900

PU

XMSN Shift Sol 4

1326

Location Code
Steering Control Position Sensor 1

C546

WH

Blower Fast Speed Relay

901

WH

XMSN Shift Sol 6

1471

C558

BU

Condenser Fan 2 Relay Out

902

BR

XMSN Shift Sol 7

1472

Steering Control Position Sensor 2

C568

WH

Blower Motor (Max)

903

GY

XMSN Shift Sol 8

1473

Steering Control Position Sensor 3

E529

YL

Power Air Cleaner Relay Coil

921

WH

XMSN Sol Return

1482

10 Volt Sensor DC Power Supply

E554

PK

A/C Cont To A/C Comp Clutch

922

BR

XMSN Sol Return

925

YL

XMSN Sol Shift 1

603

PK

Rotary Beacon

994

GY

Engine Oil Pressure Sensor

604

OR

Stop Lamp

995

BU

Engine Coolant Temperature

1558

Electrical Implement Control 2

2113

Operator Present Switch

2143

Electronic Implement Control 3

605

YL

Turn Lamp - Left

997

OR

Analog Sensor Power (+ 5V)(Imp Cont)

2146

Articulation Lever Position Sensor

606

GY

Turn Lamp - Right

998

BR

5V Return (Imp Cont)

2147

Automatic Neutral Articulation Switch

607

PK

Blade Floods #2

A975

BU

Differential Lock Relay

2150

Blade Left Lift Lever Position Sensor

609

YL

Snow Wing Lamps

C967

BU

Intake Manifold Air Temp

610

OR

Head Lamp Relay Out

C978

BR

Set Throttle SW (NC)

611

PU

Head Lamp Hi

C979

OR

Resume Throttle SW (NO)

2151

Blade Right Lift Lever Position Sensor

2152

Wheel Lean Control Position Sensor

614

PU

Backlight Relay Input

C981

GN

Compression Brake

2153

Blade Pitch Control Position Sensor

617

BR

Tail/Position Lamp - Left

C991

PK

Fuel Pressure Sensor

2154

Blade Sideshift Lever Position Sensor

2155

Circle Drive Lever Position Sensor

618

YL

Tail/Position Lamp - Right

E900

WH

XMNS Output Spd (-)

619

GN

Head Lamp Lo

E901

GN

XMNS Output Spd (+)

626

BU

Backlight Relay Out

E902

PU

XMNS Intermediate Spd (-)

CONN 76

C-10

96

CONN 77

D-10

65

CONN 78

D-6 , C-6

68

CONN 79 TDC Service Probe

E-6

76

CONN 80

F-6

77

CONN 81

I-6

96

CONN 82

G-4

2156

Circle Sideshift Control Position Sensor

2160

Blade Left Raise Solenoid Valve

YL

XMNS Intermediate Spd (+)


XMNS Intermediate Spd (-)

2161

Blade Right Raise Solenoid Valve

647

GN

Blade Flood Relay Coil

E905

BU

XMNS Intermediate Spd (+)

2162

Blade Left Lower Solenoid Valve

2163

Blade Right Lower Solenoid Valve

Event Code

2165

Blade Sideshift Left Solenoid Valve

E096

Fuel Pressure Is High

2166

Blade Sideshift Right Solenoid Valve

E172

Inlet Air Is Restricted

XMNS Trans Output Spd (-)

GY

XMNS Trans Output Spd (+)

680

GN

Cab Floodlights Relay Out

E908

BR

XMNS Trans Input Spd (-)

683

PU

Rear Flood Relay Out

E909

WH

XMNS Trans Input Spd (+)

OR

Cab Flood Relay Input

E929

GY

Articulation Angle Pos Sensor

2167

Circle Left Solenoid Valve

E194

Exhaust Temperature Is High

BR

Blade Floods

E963

BK

Engine Speed Sensor (-)

2168

Circle Right Solenoid Valve

E265

Shutdown (Ground Level)

695

OR

Left Turn Lamp Relay Coil

E964

WH

Engine Speed Sensor (+)

2169

Circle Sideshift Left Solenoid Valve

E360

Oil Pressure Is Low

696

GN

Right Turn Lamp Relay Coil

E965

BU

Sec Engine Speed Sensor (-)

Dimmer Relay Coil

E966

YL

Sec Engine Speed Sensor (+)

Circle Sideshift Right Solenoid Valve

Coolant Temperature Is High

GY

2170

E361

A608

2171

Articulation Left Solenoid Valve

E362

Engine Overspeeds
Fuel Temperature Is High

GN

Inching Pedal SW (NC)

709

OR

+10V Supply (Imp Cont)

F916

GN

Backup Alarm Relay

2172

Articulation Right Solenoid Valve

E363

727

GN

Sec Steer Test SW

G946

OR

Throttle Set SW (NO)

2173

Wheel Lean Left Solenoid Valve

E390

Fuel Filter Is Restricted

751

GN

XMSN Shift Sol 3

G953

BU

Impl Pilot Supply Solenoid

2174

Wheel Lean Right Solenoid Valve

E441

Idle Speed Is High

752

YL

XMSN Shift Sol 2

G965

PU

Load Return 2 (Imp Cont)

754

BU

XMSN Shift Sol 1

K900

YL

J1939 Data Link +

755

OR

XMSN Shift Sol 5

K927

BU

PWM Driver Return (5-8) (Imp Cont1)

799

WH

+10V Supply (XMSN Cont)

K952

BR

PWM Driver Return (1-4) (Imp Cont1)

Failure Mode Identifiers (FMI)


FMI No.

Failure Description

Data valid but above normal operational range.

Data valid but below normal operational range.

2181

Blade Pitch Forward Solenoid Valve

2182

Blade Pitch Backward Solenoid Valve

E539

Event Code

Steering Valve Control Module

0329

Transmission Filter Plugged

2203

Steering Valve Control Module Spool Position Sensor

0490

Parking Brake ON

2204

Auxiliary Lever 1 Position Sensor

0627

Parking Brake Abuse

2205

Auxiliary Lever 2 Position Sensor

0795

Machine Speed Excessive For Machine Articulation Angle

2206

Auxiliary Lever 3 Position Sensor

0877

High Transmission Oil Temperature

2207

Auxiliary Lever 4 Position Sensor


Event Code
0192

2210

Auxiliary Lever 7 Position Sensor

0256

Steering Output Detected In The Wrong Direction

2211

Auxiliary Valve 1 - Port B Solenoid

0257

Steering Output Detected With No Command

Auxiliary Valve 1 - Port A Solenoid

0258

No Steering Detected With Command Given

Auxiliary Valve 2 - Port B Solenoid

0263

Low Main Pump Pressure

2214

Auxiliary Valve 2- Port A Solenoid

0455

Hydraulic Pilot Supply Filter Plugged

Auxiliary Valve 3 - Port B Solenoid

0560

Secondary Steer Pump No Response

0562

Steering Lever Has Not Been Aligned To Wheel Steering


Angle

0598

Steering Limited Due To Cold Hydraulic Oil


Gear Too High For Steering With Cold Oil

Auxiliary Valve 4 - Port B Solenoid

2219

Auxiliary Valve 5 - Port B Solenoid

0599

Auxiliary Valve 5 - Port A Solenoid

0795

Machine Speed Excessive For Articulation Angle

2221

Auxiliary Valve 6 - Port B Solenoid

0796

Machine Articulation Angle Limited Due To Machine Speed

Auxiliary Valve 6 - Port A Solenoid

0861

Clock Manual Alignment Required


High Hydraulic Oil Temperature
Invalid Articulation Response Detected

Abnormal update.

10

Abnormal rate of change.

2222

11

Failure mode not identifiable.

2223

Auxiliary Valve 7 - Port B Solenoid

0878

12

Bad device or component.

2224

Auxiliary Valve 7 - Port A Solenoid

2085

2252

Machine Articulation Angle Sensor 2


Steering Valve Control Module Power Supply

15

Parameter failures.

16

Parameter not available.

17

Module not responding.

18

Sensor supply fault.

19

Condition not met.

20

Parameter failures.

The FMI is a diagnostic code that indicates what type of failure has occurred.

Deutsch connector: Typical representation


of a Deutsch connector. The plug contains all
sockets and the receptacle contains all pins.

1
2

Sure-Seal connector: Typical representation


of a Sure-Seal connector. The plug and receptacle
contain both pins and sockets.

Component
Part Number

9X-1123

Fuse (5 Amps)

Harness identification code:


This example indicates wire group 325,
wire 135 in harness "AG".

Wire Gauge
Wire Color

96
50

64

80
T
47

53

Resistor, Sender and Solenoid Specifications - Volume 3


Part No.

Component Description

Resistance (Ohms)

134-2540

Resistor:

Can

120 12

183-5106

Solenoid:

A/C Clutch

17.60.6

189-8627

Solenoid:

Hydraulic Fan

252-0741

Solenoid:

Implement Pilot Supply

5 0.3
26.96 1.35

239-1134

Solenoid:

Ether Aid

240-7193

Resistor:

A/C Thermostat

500 25

20

244-3114

Solenoid:

XMSN 1 thru 8

8.7 0.4

245-3555

Solenoid:

Differential Lock

30 1.5

248-5523

Solenoid:

Parking Brake

30 1.5

277-6993

Sender:

Empty Stop = 239 - 255


Full Stop = 25 - 29

Fuel

Off Machine Switch Specification - Engine and Chassis


Part No.
114-5333

Function
Switch - A/C Refrigerant Pressure

Actuate
Low:
High:

149-6371

Switch - A/C Low Pressure

229-1537

Parking Brake Pressure Switch

275-1253

Fuel Pressure Switch

275 kPa
(40 psi)
2800 140 kPa
(406 20.3 psi)

Deactuate
Low:
High:

170 55 kPa
(25 8 psi)
1750 200 kPa
(254 29 psi)

Contact Position
Normally Closed

103.4 13.8 kPa


(15 2 psi)

34.5 7 kPa
(5 1.01 psi)

Normally Open

2100 kPa MAX


(304.5 psi MIN)

1750 108 kPa


(253.8 15.6 psi)

A-C Normally Closed


A-B Normally Open

103.4+20.7 / -13.8 kPa @ 403C 69 kPa MIN @ -40C to +121C


(10 psi MIN) @ -40F to 250F
(14.99+3 / -2 psi) @ 1045.4F

Normally Closed

With increasing pressure the closed condition can be maintained up to 2800 kpa (405 psi), with decreasing pressure the closed condition can be maintained
down to 170 kpa (25psi).
Contact position at the contacts of the harness connector.

The CID is a diagnostic code that indicates which circuit is faulty.


The MID is a diagnostic code that indicates which electronic control module
diagnosed the fault.

5A

63

MACHINE HARNESS CONNECTOR AND COMPONENT LOCATIONS

Auxiliary Valve 4 - Port A Solenoid

2650

Receptacle
Pin or Socket Number

Steering System Malfunction

2212

Out of calibration.

Part Number: for Connector Receptacle

1
2

Condition

2213

Parameter failures.

At room temperature unless otherwise noted.

Auxiliary Lever 5 Position Sensor


Auxiliary Lever 6 Position Sensor

13

L-C12
3E-5179

Implement Control

2208

14

L-C12
3E-5179

Harness Connector Serialization Code:


The "C" stands for "Connector" and the
number indicates which connector in the
harness (C1, C2, C3, ...).

78
65

62

2209

2220

Harness Identification Letter(s):


(A, B, C, ..., AA, AB, AC, ...)

51

95

46

2217

Abnormal frequency, pulse width, or period.

Harness and Wire Symbols

AG-C4
111-7898

54

2218

E
63

Wire,
Cable,
or
Harness
Assembly Identification: Includes
Harness Identification Letters and
Harness Connector Serialization
Codes (see sample).

55

Current below normal or open circuit.


Current above normal or grounded circuit.

78

57

Voltage below normal or shorted low.

Mechanical system not responding properly.

65
60

60

5
6

80
46

58

95

Condition

2202

Auxiliary Valve 3 - Port A Solenoid

Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is


activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)
that make electromagnet when current flows through them. It also has an internal switch that places
the latch coil circuit open at the time the coil latches.

64
53

48

Transmission / Chassis Control


Low Brake Pressure

2216

97

47

97

Intake Manifold Air Temperature Is High

0284

Voltage above normal or shorted high.

61

56

Left Steering Cylinder Position Sensor

54

52

Right Steering Cylinder Position Sensor

Data erratic, intermittent, or incorrect.

50

61

2200

52

59

2201

2215

62
T

Solenoid: A solenoid is an electrical component that is activated by electricity. It has a


coil that makes an electromagnet when current flows through it. The electromagnet
can open or close a valve or move a piece of metal that can do work.

96

51

Condition

684

E974

59

Event Codes
Engine Control

685

Control Circuits

Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity.


It has a coil that makes an electromagnet when current flows through it. The
electromagnet can open or close the switch part of the relay.

325-AG135 PK-14

BR
OR

57

Plug

E904
E906

E903

E907

Sender: A component that is used with a temperature or pressure gauge. The sender
measures the temperature or pressure. Its resistance changes to give an indication to
the gauge of the temperature or pressure.

Part Number: for Connector Plug

Rear Flood Relay Coil

Backlight Relay Out

Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.

56

Headlamp Relay Coil

Ind Lamp - Auto Shift 1st Gear

Ground (Case): This indicates that the component does not have a wire connected to ground.
It is grounded by being fastened to the machine.

58

PK

BU

Circuit Breaker
Symbol

Flow
Symbol

Ground (Wired): This indicates that the component is connected to a grounded wire. The
grounded wire is fastened to the machine.

48

OR
PU

Level
Symbol

Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
No circle indicates that the wire cannot be disconnected from the component.

55

646
660

Temperature
Symbol

Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
circle indicates that the component has screw terminals and a wire can be disconnected from it.

The connectors shown in this chart are for harness to harness connectors.
Connectors that join a harness to a component are generally located at or near
the component. See the Component Location Chart.

645

668

Printed in U.S.A.

Fuse: A component in an electrical circuit that will open the circuit if too much current flows
through it.

Implement Pilot Pressure Supply Solenoid

A524

Lighting Circuits

ENGINE HARNESS CONNECTOR AND COMPONENT LOCATIONS

Symbols and Definitions

Schematic
Location

Sec Steer Right Solenoid

K832

Left Side View

Connector Location - Volume 3

Sec Steer Left Solenoid

Condenser Fan Relay To Motors

Front View

Pressure
Symbol

GN

Rear Defroster Fan (Low)

50

Symbols

WH

GN

69

Harness And Wire Electrical Schematic Symbols

X754

GN

B9H1-750

2015 Caterpillar, All Rights Reserved

X755

593

66

Volume 3 of 3: Engine and Chassis

Wiper - Rear (Hi)

A504

73

T = Located on the transmission control valve .

Washer - Front

LH Down Force Enable Solenoid

16M Motor Grader


Electrical System

70

E = Located inside of Rear Cab Covered Compartment.

BU

GY

76

H = Located inside of Service Center.

PU

K831

77

71

Check Part Numbers in the Parts Manuals for your Specific Machine

505

Dc/Dc Converter Power Output

65

Machine locations are repeated for components located close together.

506

BU

74
72

Action Alarm

0174

501

592

72

Component

308
321

H-15

75

Cylinder Injector #1

320
322

74

Switch - Parking Brake Pressure

67

Engine Control System


(MID No. 036)

A296
A297

Basic Machine Circuits

E-6

68

Related Electrical Service Manuals


Title

Form Number

Alternator:

235-7133

SENR4130

Electric Starting Motor:

207-1556

SENR3581

Engine Control:

RENR9344

Implement Control:

RENR9013

Transmission / Chassis Control:

RENR9004

(Dimensions: 48 inches x 35 inches)

Wire Color

Wire
Number

36 Page,

Wire Description
Wire
Number

RENR9024-08 VOL 3 of 3

RENR9024-08
June 2015

1
2

XMSN SOL 7 (LOW RANGE)


244-3114
1
2

XMSN SOL 2 (FWD LOW)


244-3114

T-C5
1552269
903-T16 GY-16
922-T17 BR-16

T-C4
1552269
752-T3 YL-16
921-T4 WH-16

1
2

T-C2
1552269
751-T5 GN-16
921-T6 WH-16

1
2

T-C6
1552269
900-T7 PU-16
921-T8 WH-16

1
2

T-C8
1552269
755-T9 OR-16
922-T11 BR-16

1
2

T-C7
1552269
901-T12 WH-16
922-T13 BR-16

XMSN SOL 3 (REVERSE)


244-3114

XMSN SOL 4 (2ND)


244-3114

XMSN SOL 5 (3RD)


244-3114

XMSN SOL 6 (1ST)


244-3114

XMSN SOL 1
244-3114
1
2

T-C9
1552269
754-T14 BU-16
922-T15 BR-16

921-T6 WH-16
921-T8 WH-16
921-T2 WH-16
921-T4 WH-16
922-T15 BR-16

AN-C13
1552267
A202-AN2 BK-18
R736-AN1 PK-18
C491-AN8 PU-18
PARK BRAKE PRESS SW
229-1537
AN-C14
2304011
1
BK
R818-AN3 YL-18
T 1K
2
BK
A202-AN4 BK-18

V-C1
1552269
BK-18
WH-18

1
2

BK-18
BK-18

A202-AN2 BK-18
A202-AN4 BK-18

AN-C11
1552269
G730-AN5 PK-16
J765-AN6 BU-16

1
2

CONN 66

G
STOP

LH STOP TAIL LAMP


AG-C30 AG-C24
135-0426
3E3370 1552267
A
RD-18
604-AG33 OR-18
B
BK-18
200-AG35 BK-14
C
WH-18
617-AG36 BR-14

TAIL

CONN 65
AG-C1
3E3364

AG-C2
1552269
683-AG28 PU-14
200-AG27 BK-14

2
FLOODS HID LH RIPPER
283-8145
FLOODS LH RIPPER
147-0319

LH STOP TAIL LAMP2


135-0426

AG-C4 AG-C3
3E3370 1552267

604-AG9 OR-18
200-AG12 BK-14
617-AG10 BR-14

A
B
C

TAIL

CONN 63

AG-C5
1552269

AG-C6
3E3364

581-AG11 GY-18
200-AG4 BK-18

1
2

LH TURN LAMP
199-3368

1
2

1
2

A202-AN7 BK-16

C491-AN8 PU-18
G730-AN5 PK-16
J765-AN6 BU-16
R736-AN1 PK-18
R818-AN3 YL-18

200-AG4 BK-18
200-AG34 BK-14
200-AG17 BK-14
200-AG2 BK-14
200-AG7 BK-18
200-AG26 BK-14

R736-AN1
A202-AN7
R818-AN3
C491-AN8
G730-AN5
J765-AN6

CONN 68
V-C5 F-C19
3E5179 1552252
1
E909-F70 WH-18
E909-V1 WH-18
2
E908-F71 BR-18
E908-V2 BR-18
3
E903-F72 YL-18
E903-V3 YL-18
4
E902-F73 PU-18
E902-V4 PU-18
5
E905-F74 BU-18
E905-V5 BU-18
6
E904-F75 BR-18
E904-V6 BR-18
7
E900-F246 WH-18
E900-V7 WH-18
8
A202-F77 BK-18
A202-V13 BK-18
9
E901-F78 GN-18
E901-V9 GN-18
10
E907-F79 GY-18
E907-V10 GY-18
11
U724-F55 WH-18
U724-V11 WH-18
12
E906-V8 OR-18
E906-F247 OR-18

618-AG39 YL-14
618-AG38 YL-14
683-AG30 PU-14
683-AG28 PU-14

R736-F82 PK-18
A202-F83 BK-18
R818-F84 YL-18
C491-F101 PU-18
G730-F86 PK-16
J765-F29 BU-16

200-AG3 BK-14

321-AG8 BR-16

618-AG15 YL-14
582-AG16 PK-18
617-AG20 BR-14
581-AG11 GY-18
683-AG29 PU-14

618-F93
582-F94
617-F95
581-F96
683-F56

YL-14
PK-18
BR-14
GY-18
PU-14

AUTOSHIFT INDICATOR
R - TERMINAL
LEFT STEER CYL POS SENS
RIGHT STEER CYL POS SENS
ART ANGLE POS SENS #2
STEER LVR POS SENSOR #1
AUTO LUBE RELAY
AC CLUTCH SOL RLY
DIR SWITCH (FORWARD)
MACHINE AUTO LUBE PRESS
SEC STEER REQUEST SIGNAL
DIR SWITCH (NEUTRAL)
DIR SWITCH (REVERSE)
UPSHIFT SWITCH (NO)
UPSHIFT SWITCH (NC)

617-AG20 BR-14

STEER LEVER POS SNSR #3


DOWNSHIFT SWITCH
DOWNSHIFT SWITCH
PARKING BRAKE SW
PARKING BRAKE SW

618-AG15 YL-14
683-AG29 PU-14

AG-C11
3E3364
1
2

AG-C7
1552269
321-AG5 BR-16
200-AG1 BK-14

INCHING PEDAL POS SENSOR


SERV BRAKE PEDAL SWITCH
INCHING PEDAL SW (NC)
INCHING PEDAL SW (NO)
AUTOSHIFT SWITCH (NO)
STEER LEVER POS SNSR #2
AUTOSHIFT SWITCH (NC)

DIFF LOCK MODE SW (NO)


COMP BRAKE SEL SW (NO)
COMP BRAKE SEL SW (NC)

AG-C10
CONN 60
1552269
582-AG16 PK-18
200-AG7 BK-18

RH TURN LAMP
AG-C17
199-3368
3E3364
1
2

J1939 HIGH
J1939 LOW
CAN A (J1939) SHIELD

AG-C12
1552269 CONN 59
683-AG30 PU-14
200-AG2 BK-14

J2
A202-F165
A202-F150
A296-F228
A296-F227

FLOODS RH RIPPER
147-0319
FLOODS HID RH RIPPER
283-8145

STOP

FP-C3
1552269
1
C558-FP103 BU-16
2
200-FP104 BK-16

593-FP94 GN-16
200-FP105 BK-16

103-FP90 RD-16
104-FP91 RD-14
105-FP102 RD-16
112-FP96 PU-4
115-FP101 RD-4
121-FP1 YL-18
126-FP10 RD-18
128-FP99 PK-18
124-FP85 GN-18
152-FP93 RD-14
200-FP28 BK-14

FP-C1
9X4391

CONN 48
TO CAB SCHEMATIC
VOLUME 2 (P-C69)
LOC G-13

121-FP1 YL-18
M998-FP2 OR-18

997-FP20 OR-18
998-FP21 BR-18
N931-FP22 GY-18
R908-FP23 YL-18
A295-FP24 BK-14
E929-FP106 GY-18
A202-FP26 BK-14
L731-FP27 BR-18
200-FP28 BK-14
307-FP29 OR-16
G953-FP30 BU-18
G965-FP31 PU-18
C532-FP82 GN-18
F783-FP33 GN-18
604-FP34 OR-18
618-FP35 YL-14
582-FP36 PK-18
617-FP37 BR-14
581-FP38 GY-18
U768-FP19 BU-18
G755-FP40 GY-18
A975-FP41 BU-18
U766-FP42 BR-18

FP-C2
7X6222

B
CONN 47
TO CAB SCHEMATIC
VOLUME 2 (P-C71)
LOC E-13

CONN 42
TO CAB SCHEMATIC
VOLUME 2 (P-C70)
LOC F-13

1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25

799-FP111 WH-18
A202-FP112 BK-18
R732-FP68 BR-18
P967-FP69 PU-18
801-FP100 PK-14
T998-FP3 BR-18
A296-FP71 BK-14
F702-FP72 GN-18
G946-FP73 OR-18
C978-FP74 BR-18
A755-FP75 PK-18
C979-FP76 OR-18
A758-FP77 BR-18

124-FP85 GN-18
519-FP86 PK-18
J844-FP87 GY-18
403-FP88 GN-18
J766-FP89 PU-18
229-FP81 BK-14
200-FP104 BK-16
104-FP91 RD-14
567-FP92 WH-18
A296-FP79 BK-14
103-FP90 RD-16
152-FP93 RD-14
200-FP105 BK-16
A757-FP84 GY-18
A756-FP78 BU-18
520-FP95 WH-18
115-FP101 RD-4
112-FP96 PU-4
105-FP102 RD-16

593-FP94 GN-16
604-FP34 OR-18
617-FP37 BR-14
618-FP35 YL-14
683-FP67 PU-14
799-FP111 WH-18
801-FP100 PK-14
892-FP63 BR-18
893-FP62 GN-18
925-FP17 YL-18

925-FP17 YL-18
N787-FP18 BU-18

1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24

A758-FP77 BR-18
C979-FP76 OR-18

128-FP99 PK-18
121-FP1 YL-18
M998-FP2 OR-18

F785-FP6 WH-18
K990-FP7 GN-18
K900-FP8 YL-18
556-FP9 WH-18
126-FP10 RD-18
U753-FP11 BR-18
X754-FP12 GN-18
X755-FP13 WH-18
308-FP14 YL-18
U767-FP15 BU-18

A756-FP78 BU-18
A757-FP84 GY-18
A758-FP77 BR-18
A975-FP41 BU-18
C532-FP82 GN-18
C558-FP103 BU-16
C978-FP74 BR-18
C979-FP76 OR-18
E716-FP97 GY-14
E717-FP98 GN-14

925-FP17 YL-18
N787-FP18 BU-18
E717-FP98 GN-14
997-FP20 OR-18
998-FP21 BR-18
N931-FP22 GY-18
R908-FP23 YL-18
A295-FP24 BK-14
E929-FP25 GY-18
A202-FP26 BK-14
L731-FP27 BR-18
200-FP28 BK-14
307-FP29 OR-16
G953-FP30 BU-18
G965-FP31 PU-18
L914-FP32 BU-18
F783-FP33 GN-18
604-FP34 OR-18
618-FP35 YL-14
582-FP36 PK-18
617-FP37 BR-14
581-FP38 GY-18
U768-FP39 BU-18
G755-FP40 GY-18
A975-FP41 BU-18
U766-FP42 BR-18
C532-FP82 GN-18
X800-FP43 OR-18
F846-FP44 PU-18
H764-FP45 GY-18
H765-FP46 WH-18
U739-FP47 BR-18
G750-FP48 BU-18
U741-FP49 OR-18
F784-FP50 YL-18
U734-FP51 GN-18
E974-FP52 GN-18
F843-FP53 YL-18
U740-FP54 BU-18
G763-FP55 PU-18
F781-FP56 BR-18
U735-FP57 GY-18
U727-FP58 YL-18
F787-FP59 GN-18
U726-FP60 GY-18
U725-FP61 GN-18
893-FP62 GN-18
892-FP63 BR-18
U736-FP64 YL-18
A295-FP65 BK-14
A295-FP66 BK-14
683-FP67 PU-14

E929-FP107 GY-18
E929-FP25 GY-18

E929-FP106 GY-18
E974-FP52 GN-18
F702-FP72 GN-18
F781-FP56 BR-18
F783-FP33 GN-18
F784-FP50 YL-18
F785-FP6 WH-18
F787-FP59 GN-18
F843-FP53 YL-18
F846-FP44 PU-18
G750-FP48 BU-18
G755-FP40 GY-18
G763-FP55 PU-18
G946-FP73 OR-18
G953-FP30 BU-18
G965-FP31 PU-18
H764-FP45 GY-18
H765-FP46 WH-18
J766-FP89 PU-18
J844-FP87 GY-18
K990-FP7 GN-18
K900-FP8 YL-18
L731-FP27 BR-18
L914-FP32 BU-18
M998-FP2 OR-18
N787-FP18 BU-18
N931-FP22 GY-18
P967-FP69 PU-18
R732-FP68 BR-18
R800-FP80 OR-18
R908-FP23 YL-18
T998-FP3 BR-18

T998-FP4 BR-18
T998-FP70 BR-18

U725-FP61 GN-18
U726-FP60 GY-18
U727-FP58 YL-18
U734-FP51 GN-18
U735-FP57 GY-18
U736-FP64 YL-18
U739-FP47 BR-18
U740-FP54 BU-18
U741-FP49 OR-18
U753-FP11 BR-18

R800-FP80 OR-18
229-FP81 BK-14
A757-FP84 GY-18

U723-F238 PU-18
126-F33 RD-14
A202-F103 BK-18
U724-F55 WH-18
R908-F223 YL-18
R736-F82 PK-18
U728-F100 PK-18
U736-F97 YL-18
126-F112 RD-14
126-F115 RD-14
C491-F101 PU-18

FP-C6
8N1518

U768-FP19 BU-18

A202-F89 BK-18
A202-F106 BK-14
755-F65 OR-16
901-F66 WH-16
922-F69 BR-16
754-F67 BU-16
903-F68 GY-16
U766-F220 BR-18
U767-F211 BU-18
X754-F36
X755-F37
799-F235
A202-F80

1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70

307-F186 OR-16
567-F261 WH-18
799-F235 WH-18
925-F51 YL-18
A295-F205 BK-14
A295-F226 BK-14
A296-F227 BK-14
A296-F228 BK-14
A975-F195 BU-18
C532-F242 GN-18

M998-F154 OR-18
403-F274 GN-18
H764-F127 GY-18
H765-F128 WH-18
U768-F44 BU-18
U739-F129 BR-18
559-F249 YL-18
E554-F269 PK-18

E716-F1 GY-18
E717-F49 GN-18
E929-F38 GY-18
E974-F139 GN-18
F781-F133 BR-18
F783-F184 GN-18
F784-F134 YL-18
F785-F179 WH-18
F787-F138 GN-18
F843-F137 YL-18

G750-F130 BU-18
C532-F242 GN-18
U753-F35 BR-18
G763-F131
G755-F175
F785-F179
F783-F184

F846-F126 PU-18
G750-F130 BU-18
G755-F175 GY-18
G763-F131 PU-18
H764-F127 GY-18
H765-F128 WH-18
L914-F273 BU-18
M998-F154 OR-18
R908-F223 YL-18
T998-F113 BR-18

PU-18
GY-18
WH-18
GN-18

U741-F132 OR-18
F781-F133
F784-F134
U734-F135
U735-F136

BR-18
YL-18
GN-18
GY-18

U725-F143 GN-18
U726-F141 GY-18
U727-F140 YL-18
U734-F135 GN-18
U735-F136 GY-18
U736-F97 YL-18
U739-F129 BR-18
U740-F142 BU-18
U741-F132 OR-18
U753-F35 BR-18

E929-F38 GY-18
F843-F137
F787-F138
E974-F139
U727-F140
U726-F141
U740-F142

126-F33 RD-14
126-F115 RD-14
126-F112 RD-14

YL-18
GN-18
GN-18
YL-18
GY-18
BU-18

U766-F220 BR-18
U767-F211 BU-18
U768-F44 BU-18
X754-F36 GN-18
X755-F37 WH-18
X800-F48 OR-18

U725-F143 GN-18

L914-F273 BU-18

126-F26 RD-18
126-F121 RD-14
126-F120 RD-14

150-F166 RD-14
150-F8 RD-14
150-F245 RD-14

200-F14 BK-12

200-F47 BK-18
200-F58 BK-14
200-F57 BK-18
200-F90 BK-14
229-F229 BK-14

A756-F155 BU-18
520-F265 WH-18
115-F224 RD-4
112-F204 PU-4
105-F180 RD-16
A758-F163 BR-18
C979-F160 OR-18

128-F248 PK-18
121-F27 YL-18
M998-F154 OR-18

F785-F179 WH-18
K990-F32 GN-18
K900-F116 YL-18
556-F20 WH-18
126-F26 RD-18
U753-F35 BR-18
X754-F36 GN-18
X755-F37 WH-18
308-F110 YL-18
U767-F211 BU-18

U768-FP39 BU-18
U768-FP83 BU-18

4
5
6
7
8
9
10
11
12

801-FP100 PK-14
T998-FP70 BR-18
A296-FP71 BK-14
F702-FP72 GN-18
G946-FP73 OR-18
C978-FP74 BR-18
A755-FP75 PK-18
E716-FP97 GY-14

X800-FP43 OR-18
X800-FP16 OR-18

R800-FP80 OR-18
P967-FP69 PU-18
E929-FP107 GY-18

593-FP94 GN-16
520-FP95 WH-18
112-FP96 PU-4
115-FP101 RD-4
105-FP102 RD-16

T998-FP4 BR-18
X800-FP16 OR-18
U768-FP83 BU-18

C558-FP103 BU-16

13

A
B
C

229-F171 BK-14
229-F6 BK-14
229-F172 BK-14

307-F186 OR-16
567-F261 WH-18
799-F235 WH-18
925-F51 YL-18
A295-F205 BK-14
A295-F226 BK-14
A296-F227 BK-14
A296-F228 BK-14
A975-F195 BU-18
C532-F242 GN-18
E716-F1 GY-18
E717-F49 GN-18
E929-F38 GY-18
E974-F139 GN-18
F781-F133 BR-18
F783-F184 GN-18
F784-F134 YL-18
F785-F179 WH-18
F787-F138 GN-18
F843-F137 YL-18

FP-C10
1552267
A
B
C

H746-F152 YL-16
H747-F153 BR-16

HYDRAULIC FAN SOL


SPEED CONT AUTO/MAN (MAN)

TEMP

SPEED CONT AUTO/MAN (OFF)


(+) BATTERY

FAN CONTROL SOL


189-8627

1
2

CAN HIGH
HYDRAULIC FAN SOL RETURN
(+) BATTERY
(+) BATTERY
GND LVL SHUTDOWN (NC)
(+) BATTERY
GND LVL SHUTDOWN (NO)

F-C12
3E3370

L730-F98 OR-18
L731-F222 BR-18
U728-F100 PK-18

OR-18
BK-18
WH-18

A
B
C

F-C2
1740502
A
K990-F31 GN-18
B
K900-F30 YL-18

+5V
GROUND
SIGNAL

SERV CHARGE PRESS SENSE


237-0957

SPEED CONT RES/DECEL (NC)


(-) BATTERY

CAN RESISTOR 1
134-2540

200-F47 BK-18
200-F57 BK-18
K748-F76 OR-18
200-F21 BK-18
F715-F11 PU-16
229-F102 BK-14
F719-F12 BR-16
HYD PILOT SUP FILTER BYP SW
7X-8549

(-) BATTERY
(-) BATTERY
THROTTLE POSITION SNSR
(-) BATTERY

GROUND LVL SD SW
139-2116

F-C7
1552267
A
B
C

BK-18
RD-18
WH-18

A
C

KEYSWITCH RUN

NOT USED

A295-F173 BK-16

NOT USED

ENGINE COOLANT TEMP


NOT USED
INTAKE MANIFOLD PRESS SNSR
5V RETURN #1

403-F190 GN-18

F-C27
1552269
1
520-F208 WH-18
2
A202-F260 BK-18

ENGINE SPEED SNSR (-)


ENGINE SPEED SNSR (+)
BK-18
BK-18

ENGINE OIL PRESS SNSR

AC THERMOSTAT PULLDOWN
240-7193

TEMPERATURE SNSR RETURN

519-F191 PK-18
520-F199 WH-18
520-F265 WH-18

ENGINE SPEED SNSR (+)


ENGINE SPEED SNSR (-)

520-F208 WH-18

522-F237 WH-18

FUEL PRESS SNSR

556-F18 WH-18
556-F19 WH-18

556-F20 WH-18
559-F249 YL-18
581-F96 GY-18
582-F94 PK-18
604-F92 OR-18
617-F95 BR-14
618-F93 YL-14

892-F149 BR-16

893-F144 GN-16
893-F146 GN-18

893-F148 GN-16

A202-F106 BK-14
A202-F105 BK-14
A202-F80 BK-14

556-F18 WH-18
200-F16 BK-18

556-F19 WH-18
200-F17 BK-18

F-C14
1552269

F-C9
1552269
1
2

A202-F239 BK-18

A202-F174 BK-14
A202-F83 BK-18

A755-F168 PK-18
A756-F155 BU-18
A757-F169 GY-18
A758-F163 BR-18
C491-F101 PU-18
C978-F159 BR-18
C979-F160 OR-18
E554-F269 PK-18
E900-F246 WH-18
E901-F78 GN-18
E902-F73 PU-18
E903-F72 YL-18
E904-F75 BR-18
E905-F74 BU-18

K990-F24 GN-18
K990-F118 GN-18

K900-F30 YL-18

CONN 77

F-C25 CF-C1
1552252 3E5179

R997-F197 OR-18
R993-F198 BR-18
F713-F196 OR-18
124-F257
519-F191
124-F264
522-F237
403-F190

GN-18
PK-18
GN-18
WH-18
GN-18

1
2
3
4
5
6
7
8
9
10
11
12

L731-F99 BR-18
L731-F194 BR-18

A202-F221 BK-14
A202-F236 BK-18
A295-F45 BK-14
A755-F168 PK-18
A756-F155 BU-18
A757-F169 GY-18
A758-F163 BR-18
C978-F159 BR-18
C979-F160 OR-18

124-CF6 GN-18
124-CF12 GN-18

522-CF7 WH-18
522-CF13 WH-18

CBL-YJ1 RD-00-HP

CYL 5 & 6 INJ HIGHSIDE

CYL 1 & 2 INJ HIGHSIDE


CYLINDER #6 INJ RETURN
CYLINDER #5 INJ RETURN
CYLINDER #4 INJ RETURN
CYLINDER #3 INJ RETURN

AC LOW PRESS SW
149-6371
CYL 3 & 4 INJ HIGHSIDE
CYLINDER #1 INJ RETURN

BK-18
BK-18

AC HIGH LOW PRESS SW


114-5333
BK-18
BK-18

2
1

CYLINDER #2 INJ RETURN

STRAP 7X-6315
14 AWG

1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70

R997-F197 OR-18
R993-F198 BR-18
J844-F262 GY-18
J766-F263 PU-18
893-F148 GN-16
892-F149 BR-16

F713-F196 OR-18
F710-F52 BR-18
365-F151 YL-18
R941-F53 GY-18
G946-F156 OR-18

K990-F40 GN-18
A756-F155 BU-18

F-C3 CH-C1
1552269 3E3364
1
U723-CH1 PU-18
U723-F238 PU-18
2
A202-CH2 BK-18
A202-F239 BK-18

CH-C2
1552269
1
U723-CH1 PU-18
2
A202-CH2 BK-18

F-C30
1552269
G953-F114 BU-18
G965-F125 PU-18

200-FT3 BK-18
200-FT4 BK-18
K748-FT5 OR-18
K748-FT6 OR-18

OR-18
BK-18
WH-18

308-F170 YL-16
365-F151 YL-18
892-F149 BR-16
893-F148 GN-16
A755-F168 PK-18
A756-F155 BU-18
A757-F169 GY-18
A758-F163 BR-18
A893-F25 OR-14

SEC STEER ARC SUPPRESSOR


189-3158

892-F149 BR-16
893-F148 GN-16
A755-F168 PK-18
A756-F155 BU-18
A757-F169 GY-18
A758-F163 BR-18
C978-F159 BR-18
C979-F160 OR-18
F702-F164 GN-18
F713-F196 OR-18

H746-F152 YL-16
A758-F163 BR-18
A757-F169 GY-18
150-F166 RD-14
K900-F54 YL-18
H747-F153 BR-16
150-F8 RD-14
150-F10 RD-14
F719-F12 BR-16
150-F9 RD-14
F715-F11 PU-16
A755-F168 PK-18
229-F4 BK-14

CBL-JJ1 RD-00-HP

306-R17 GN-16
J765-R18 BU-16

101-PP1 RD-8

CBL-LL1 BK-00
SEC STEER
ENGINE BLOCK GND

150A

CBL-NN1 RD-00-HP

80A

229-F59 BK-14
304-F250 WH-8
A893-F25 OR-14

229-F59 BK-14
A893-F25 OR-14

BUS BAR 1
288-5526

FUEL PRIMING PUMP


AM-C5 162-2211
1552269
1
A893-AM2 OR-14
MOTOR
2
229-AM1 BK-14

F-C18 AM-C1
1552269 3E3364
1
229-AM1 BK-14
229-F59 BK-14
2
A893-F25 OR-14
A893-AM2 OR-14

3
4
5
6
7
8
9
10
11
12

559-F249 YL-18
T969-F28 YL-18
128-F248 PK-18
J765-F87 BU-16
J765-F200 BU-16
F916-F124 GN-18
365-F151 YL-18
105-F180 RD-16
A893-F25 OR-14

1
2

DISCONNECT SW
7N-0718

K737-E4 BR-16-HV

E-C6 INTAKE AIR PRESS


1552267 239-5674
OR-18 +5 VOLTS
A
G828-E39 WH-18
BK-18 GROUND
B
G829-E41 GN-18
WH-18 SIGNAL
C
R746-E20 PK-18

G833-E47 PK-18
994-E10 GY-18
995-E12 BU-18
C967-E15 BU-18
C991-E33 PK-18
E963-E27 BK-18
E964-E26 WH-18
E965-E48 BU-18
E966-E49 YL-18
F421-E13 YL-18
G828-E39
G828-E38
G828-E35
G828-E40

WH-18
WH-18
WH-18
WH-18

G829-E2 GN-18
G829-E3 GN-18

G833-E47 PK-18

G828-E1 WH-18

F421-E13
G833-E46
T725-E32
N707-E31
G828-E35
G829-E36
C991-E33

E-C10 G-C1
1552264 3E3388
1
F421-G4
YL-18
2
G833-G5
PK-18
3
T725-G6
WH-18
4
N707-G7
PU-18
5
G828-G1
WH-18
6
G829-G2
GN-18
7
C991-G3
PK-18
8

G829-E42 GN-18
G829-E43 GN-18

C967-E15 BU-18
R747-E6 GY-18

T725-E32 WH-18

ENGINE OIL PRESS SNS


239-2396
OR-18 +5 VOLTS
BK-18 GROUND
YL-18 SIGNAL

G833-E45 PK-18
G833-E44 PK-18
G833-E46 PK-18

E-C11
1552269
1
995-E12 BU-18
2
G833-E44 PK-18

YL-18
PK-18
WH-18
PU-18
WH-18
GN-18
PK-18

R746-E20 PK-18
R747-E6 GY-18
T725-E32 WH-18
T858-E23 GY-18-XLPE
T859-E37 WH-18-XLPE
T860-E34 OR-18-XLPE
T957-E16 PU-18-XLPE
T958-E17 YL-18-XLPE
T959-E18 BR-18-XLPE
T960-E19 BU-18-XLPE
T961-E28 GN-18-XLPE
T962-E29 WH-18-XLPE

N707-E31 PU-18

E-C9
1552269
1
C967-E15 BU-18
2
G833-E45 PK-18

101-YL1 RD-4
J765-R24 BU-16
306-R23 GN-16
200-R30 BK-18

101-YL1 RD-4

BAT (+) UNSWITCHED

86

R-C6
1733139
J765-R13 BU-16
126-R8 RD-14
128-R11 PK-18
559-R9 YL-18
801-R41 PK-14
T969-R12 YL-18
K748-R6 OR-18

85
A
B
C
D
E
F
G
H

30

85-2
30-2
85-1
86-1

87

87-1
86-2
87-2

85

86

87A

1
AUTOLUBE

30

15A

AUTOLUBE RLY
ACCUGRADE
20A

R-C7
1733141
A
152-R10 RD-14
B
J765-R24 BU-16
C
F916-R15 GN-18
D
121-R19 YL-18
E
J765-R20 BU-16
F
321-R14 BR-16
G
306-R23 GN-16

G-C4
2304011
1
F421-G4 YL-18
2
G833-G5 PK-18

105-R37 RD-16
103-R40 RD-16
126-R38 RD-14

BK-18
BK-18

G-C3
2304012
1
T725-G6 WH-18
2
N707-G7 PU-18

BK-18
BK-18

G-C2
3E3370
A
G828-G1 WH-18
B
G829-G2 GN-18
C
C991-G3 PK-18

FUEL PRESS SNSR


239-2396
OR-18 +5 VOLTS
BK-18 GROUND
YL-18 SIGNAL

FUEL PRESS SW
275-1253

87
85
30
86
87

86

87A
85

STARTER
DIODE

30

BACKUP ALM RLY

15A

R-C8
1791312

LH POS LAMPS
15A

XMSN CONT

A
B
C
D
E
F
G
H

104-R39 RD-14

15A

SPARE
15A

BRAKE RETRACT
30A

A/C CLUTCH RLY


87

86

87A
S

MOTOR

R-C9
1791311
124-R28 GN-18
522-R29 WH-18
200-R30 BK-18
E554-R31 PK-18
365-R34 YL-18
A893-R35 OR-14
150-R36 RD-12
229-R33 BK-18

CRANKING MTR
207-1556
CBL-EE1 BK-00-HP

INTAKE MANIFOLD AIR TEMP


274-7395

85

BAT MTR

BK-18
BK-18

RH POS LAMPS
15A

BLUE

30

FUEL PUMP RLY


A
B
C
D
E
F
G
H

85-1
30-1
87-1
86-1
86-2
87-2

87
87A

86

85

85-2

30

25A

ENGINE CONT

GREEN
ENGINE GROUND

SPD/TMG CAM
239-2397

CBL-TT1 BK-00-HP

BK-18
BK-18

SERVICE CENTER

REAR FRAME GROUND


CBL-HH1 RD-00-HP

BK-18
BK-18

CBL-HH1 RD-00-HP

SPD/TMG CRANK
230-7149
JACKET WATER HEATER
239-7342

E-C12 E-C13
1552269 3E3364
1
G856-E22 WH-18
TDC PROBE
2
G857-E30 YL-18

BK-16
BK-16
GN-16

JACKET WATER
HEATER CORD
7X-6312

T860-E34 OR-18-XLPE

AL-C2
7E6513

T858-AL1 GY-16-NW
T957-AL13 PU-16-NW

T858-E23 GY-18-XLPE
T962-E29 WH-18-XLPE
T959-E18 BR-18-XLPE
T961-E28 GN-18-XLPE
T960-E19 BU-18-XLPE

CONN 78
E-C2 AL-C1
1552252 3E7990
T860-E34 OR-18-XLPE 1 T860-AL8 OR-16-NW
T962-E29 WH-18-XLPE 2 T962-AL16 WH-16-NW
3
K737-E4 BR-16-HV
4
K738-E5 GN-16-HV
5
K739-E7 BU-16-HV
T859-AL9 WH-16-NW
T859-E37 WH-18-XLPE 6
T961-E28 GN-18-XLPE 7 T961-AL15 GN-16-NW
T957-E16 PU-18-XLPE 8 T957-AL13 PU-16-NW
T858-E23 GY-18-XLPE 9 T858-AL7 GY-16-NW
T958-E17 YL-18-XLPE 10 T958-AL14 YL-16-NW
T959-E18 BR-18-XLPE 11 T959-AL18 BR-16-NW
T960-E19 BU-18-XLPE 12 T960-AL17 BU-16-NW

T859-E37 WH-18-XLPE
T957-E16 PU-18-XLPE
T958-E17 YL-18-XLPE

J2

1
2

INJECTOR 1
249-0713

1
2

INJECTOR 2
249-0713

AL-C3
7E6513

T858-AL7 GY-16-NW

T858-AL1 GY-16-NW
T858-AL2 GY-16-NW

T859-AL9 WH-16-NW

T859-AL3 WH-16-NW
T859-AL4 WH-16-NW

AL-C4
7E6513
1
T859-AL3 WH-16-NW
2
T959-AL18 BR-16-NW

INJECTOR 3
249-0713

T860-AL8 OR-16-NW

T860-AL6 OR-16-NW
T860-AL5 OR-16-NW

AL-C5
7E6513
1
T859-AL4 WH-16-NW
2
T960-AL17 BU-16-NW

INJECTOR 4
249-0713

AL-C6
7E6513
1
T860-AL5 OR-16-NW
2
T961-AL15 GN-16-NW

INJECTOR 5
249-0713

AL-C7
7E6513
1
T860-AL6 OR-16-NW
2
T962-AL16 WH-16-NW

INJECTOR 6
249-0713

T957-AL13 PU-16-NW
T958-AL14 YL-16-NW
T959-AL18 BR-16-NW
T960-AL17 BU-16-NW
T961-AL15 GN-16-NW
T962-AL16 WH-16-NW

ENGINE BLOCK

T858-AL2 GY-16-NW
T958-AL14 YL-16-NW

ID
E
F
G
R
T
V
AG
AK
AL
AM
AN
CF
CH
FP
FT
PP
RR
YL

ALT
+

12V BATTERY2
153-5710

AK-C1
3E7990
1
T860-AK8 OR-16-NW
2
T962-AK16 WH-16-NW
3
K737-AK19 BR-16-NW
K738-AK20 GN-16-NW
CONN 78 45
K739-AK21 BU-16-NW
CONNECTS TO E-C2 6
T859-AK9 WH-16-NW
7
T961-AK15 GN-16-NW
8
T957-AK13 PU-16-NW
9
T858-AK7 GY-16-NW
10
T958-AK14 YL-16-NW
11
T959-AK18 BR-16-NW
12
T960-AK17 BU-16-NW

FUEL LEVEL SENDER


277-6993
PK-18
BK-18

22 -255

KEY SWITCH

BK-18
BK-18

CONN 79

103-R40 RD-16
104-R39 RD-14
121-R19 YL-18
124-R28 GN-18
150-R36 RD-12
152-R10 RD-14
229-R33 BK-18
321-R14 BR-16
522-R29 WH-18
801-R41 PK-14
E554-R31 PK-18

BLACK

FUEL TEMP SENS


234-5013

ENGINE COOLANT TEMP


274-7396

E-C8
1552269
1
E963-E27 BK-18
2
E964-E26 WH-18

POS

E-C7
1552269
1
E965-E48 BU-18
2
E966-E49 YL-18

NEG

87A

G856-E22 WH-18
G857-E30 YL-18
K737-E4 BR-16-HV
K738-E5 GN-16-HV
K739-E7 BU-16-HV
N707-E31 PU-18

POS

CBL-HH1 RD-00-HP

GRAY

CONN 80

G829-E41 GN-18
G829-E36 GN-18

F421-E13 YL-18

E-C4
3E3370
A
G828-E38 WH-18
B
G829-E43 GN-18
C
994-E10 GY-18

NEG

CBL-JJ1 RD-00-HP

CBL-MM1 RD-00-HP

87

128-R11 PK-18
365-R34 YL-18
559-R9 YL-18
A893-R35 OR-14
F916-R15 GN-18
J765-R13 BU-16
J765-R20 BU-16
K748-R6 OR-18
T969-R12 YL-18

995-E12 BU-18
K739-E7 BU-16-HV
R746-E20 PK-18

994-E10 GY-18

CBL-AA1 RD-00-HP

BATTERY LUG
272-7239
CBL-CC1 RD-00-HP

SEC STEER INT RLY

126-R26 RD-14

E963-E27 BK-18
G856-E22 WH-18

CBL-NN1 RD-00-HP

101-YL1 RD-4

121-R19 YL-18
124-R28 GN-18
150-R36 RD-12
152-R10 RD-14
200-R30 BK-18
229-R33 BK-18
306-R23 GN-16
321-R14 BR-16
522-R29 WH-18
801-R41 PK-14
E554-R31 PK-18
J765-R24 BU-16

112-R5 PU-4

COOPER BUSSMAN 2
270-5321
"RELAY-FUSE BLOCK"

103-R40 RD-16
104-R39 RD-14

TO REAR MAIN
HARNESS F
CONNECTOR F-C41
LOC A-10

BK-18
BK-18

FRAME
GROUND

559-R9 YL-18
T969-R12 YL-18
128-R11 PK-18
J765-R13 BU-16
J765-R20 BU-16
F916-R15 GN-18
365-R34 YL-18
105-R37 RD-16
A893-R35 OR-14

CONN 74

200-R27 BK-16
200-R30 BK-18
MAIN RELAY
241-8368

101-YL1 RD-4
CBL-CC1 RD-00-HP
POWER BLK
8C-6358

12V BATTERY1
153-5710

126-R8 RD-14
126-R38 RD-14

ATMOSPHERIC PRESS
239-2395
OR-18 +5 VOLTS
BK-18 GROUND
YL-18 SIGNAL

R-C2
3E3364
1
308-R21 YL-16
2
200-R32 BK-16

CBL-FF1 BK-00-HP

LOAD BREAKER
171-2210

CONN 82

E-C5
3E3370
A
G828-E40 WH-18
B
G829-E42 GN-18
C
R747-E6 GY-18

124-R28 GN-18

117-RR1 RD-4

306-R23 GN-16
306-R17 GN-16
306-R22 GN-16

115-R7 RD-4

F-C1 R-C1
1552252 3E5179
1
K748-R6 OR-18
K748-F76 OR-18
2
126-R26 RD-14
126-F122 RD-14

ETHER AID SOL


239-1134

G829-E2 GN-18

J765-R25 BU-16

STRAP 134-3355

304-F250 WH-8

F-C4
1552269

112-R5 PU-4
115-R7 RD-4
E554-R31 PK-18

200-R32 BK-16

117-RR1 RD-4
115-R7 RD-4

117-RR1 RD-4

80A

J765-R24 BU-16

10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25

308-R21 YL-16

J765-R18 BU-16
J765-R24 BU-16
J765-R25 BU-16
CBL-NN1 RD-00-HP

101-PP1 RD-8

STRAP 287-6152

R997-F197 OR-18

G828-E1 WH-18

104-R39 RD-14
229-R33 BK-18
150-R36 RD-12

304-R16 WH-8

522-R29 WH-18

ALTERNATOR BREAKER 1
171-2215

105-R37 RD-16

E966-E49 YL-18
E965-E48 BU-18

BK-18
BK-18

121-R19 YL-18

308-F170 YL-16
E-C1
2274002
J2
K738-E5 GN-16-HV

C991-E33 PK-18

STARTER MOTOR RELAY


118-3534

1
2

ALT ISOLATION LUG


272-7239
CBL-YJ1 RD-00-HP

229-F2 BK-14
F702-F164 GN-18
229-F5 BK-14

E964-E26 WH-18
G857-E30 YL-18

R-C4
1552269

CBL-JJ1 RD-00-HP

SEC STEER RELAY


179-0006

229-F3 BK-14

1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
100
101
102
103
104
105
106
107
108
109
110
111
112
113
114
115
116
117
118
119
120

R-C5
8N1517
1
304-R16 WH-8
2
J765-R25 BU-16
3
200-R27 BK-16
4
308-R21 YL-16
5
306-R22 GN-16
6
103-R40 RD-16
7
152-R10 RD-14
8
321-R14 BR-16
9
801-R41 PK-14

115-R7 RD-4
306-R22 GN-16
306-R23 GN-16

CBL-KK1 RD-00-HP

F715-F11 PU-16
F719-F12 BR-16
G946-F156 OR-18
H746-F152 YL-16
H747-F153 BR-16
J766-F263 PU-18
J844-F262 GY-18
K900-F54 YL-18
K990-F40 GN-18
R993-F198 BR-18

R941-F53 GY-18
F710-F52 BR-18

1
2

MAIN BREAKER
171-2210
C978-F159 BR-18
C979-F160 OR-18

101-PP1 RD-8

AK-C8
1539693

K737-AK22 BR-16-NW
K739-AK10 BU-16-NW

K739-AK12 BU-16-NW
K739-AK11 BU-16-NW
K739-AK10 BU-16-NW

K737-AK23 BR-16-NW
K737-AK22 BR-16-NW

T858-AK1 GY-16-NW
T957-AK13 PU-16-NW

K737-AK19 BR-16-NW

BRAKE CYL 1 2
267-3089

1
2

BRAKE CYL 3 4
267-3089

1
2

BRAKE CYL 5 6
267-3089

AK-C10
1539693

K737-AK23 BR-16-NW
K739-AK12 BU-16-NW

K739-AK21 BU-16-NW

1
2

AK-C9
1539693

K738-AK20 GN-16-NW
K739-AK11 BU-16-NW

K738-AK20 GN-16-NW

AK-C2
7E6513
1
2

INJECTOR 1 ATT
249-0713

1
2

INJECTOR 2 ATT
249-0713

1
2

INJECTOR 3 ATT
249-0713

1
2

INJECTOR 4 ATT
249-0713

1
2

INJECTOR 5 ATT
249-0713

1
2

INJECTOR 6 ATT
249-0713

AA
CC
EE
FF
HH
JJ
KK
LL
MM
NN
TT
YJ
YK

T858-AK7 GY-16-NW

+5V
GROUND
SIGNAL

T858-AK1 GY-16-NW
T858-AK2 GY-16-NW

T858-AK2 GY-16-NW
T958-AK14 YL-16-NW

T859-AK9 WH-16-NW

FRAME GROUND

T859-AK3 WH-16-NW
T859-AK4 WH-16-NW

T859-AK3 WH-16-NW
T959-AK18 BR-16-NW

T860-AK6 OR-16-NW
T860-AK5 OR-16-NW
T860-AK8 OR-16-NW
T957-AK13 PU-16-NW
T958-AK14 YL-16-NW
T959-AK18 BR-16-NW
T960-AK17 BU-16-NW
T961-AK15 GN-16-NW
T962-AK16 WH-16-NW

C978-F159 BR-18
C979-F160 OR-18
F702-F164 GN-18
F713-F196 OR-18
F715-F11 PU-16
F719-F12 BR-16
G946-F156 OR-18
H746-F152 YL-16
H747-F153 BR-16
J844-F262 GY-18

F702-F164 GN-18
G946-F156 OR-18
G953-F114 BU-18
G965-F125 PU-18
J766-F263 PU-18
J844-F262 GY-18
K900-F116 YL-18
K990-F32 GN-18
L731-F194 BR-18
N787-F39 BU-18

MOTOR

HYD PUMP PRESS SENSE


237-0957

F-C32
3E3370
A
997-F41 OR-18
B
998-F42 BR-18
C
N931-F43 GY-18

FT-C2
1552269

SEC STER MTR


117-3915

IMPLEMENT PILOT SUPPLY SOL


252-0741

1
2

4
K748-FT6 OR-18
200-FT4 BK-18
200-FT3 BK-18
K748-FT5 OR-18

CONN 81

F-C5 FT-C1
3E3364 1552269
1
200-F57 BK-18
200-F46 BK-18
200-FT1 BK-18
2
K748-F76 OR-18
K748-FT2 OR-18

150-F8 RD-14
150-F9 RD-14
150-F10 RD-14
150-F166 RD-14
229-F2 BK-14
229-F3 BK-14
229-F4 BK-14
229-F5 BK-14
308-F170 YL-16
365-F151 YL-18

CBL-YK1 BK-00-HP

CONN 76

150-F8 RD-14
150-F9 RD-14
150-F10 RD-14
150-F166 RD-14
229-F2 BK-14
229-F3 BK-14
229-F4 BK-14
229-F5 BK-14
229-F59 BK-14
304-F250 WH-8

AC CLUTCH SOL
183-5106

403-CF11 GN-18
ALTERNATOR
272-1889
(150A)

F713-CF5 OR-18
R993-CF4 BR-18
R997-CF3 OR-18

G953-F114 BU-18
G965-F125 PU-18
N931-F43 GY-18

N787-F39 BU-18
N931-F43 GY-18
R732-F162 BR-18
R736-F82 PK-18
R818-F84 YL-18
T969-F28 YL-18
U723-F238 PU-18
U724-F55 WH-18
U728-F100 PK-18

CF-C5
1552269
521-CF9 YL-18 1
2
519-CF10 PK-18

+BATTERY
GROUND
SIGNAL

AC CLUTCH DIODE
189-3158

BK-18
BK-18

CF-C4
1552269
1
124-CF8 GN-18
2
521-CF9 YL-18

124-CF8 GN-18
403-CF11 GN-18
519-CF10 PK-18

K990-F40 GN-18

L731-F222 BR-18

CF-C3
1552269
1
124-CF6 GN-18
2
522-CF7 WH-18

124-CF8 GN-18
519-CF10 PK-18
124-CF14 GN-18
522-CF15 WH-18
403-CF11 GN-18

522-CF15 WH-18

INLET PRESS SENS


194-6722

OR-18
BK-18
YL-18

CF-C6
1552269
1
124-CF12 GN-18
2
522-CF13 WH-18

R997-CF3 OR-18
R993-CF4 BR-18
F713-CF5 OR-18

124-CF14 GN-18

997-F41 OR-18
998-F42 BR-18

L730-F98 OR-18

CF-C8
3E3370
A
R997-CF3 OR-18
B
R993-CF4 BR-18
C
F713-CF5 OR-18

CBL-YJ1 RD-00-HP

K900-F34 YL-18
K900-F54 YL-18

K990-F31 GN-18

FUEL PRESSURE SW RETURN

A893-F25 OR-14
F916-F124 GN-18
J765-F200 BU-16
J765-F87 BU-16
K748-F76 OR-18
T969-F28 YL-18

J765-F87 BU-16
J765-F29 BU-16
J765-F185 BU-16

J766-F263 PU-18
J844-F262 GY-18

K990-F32 GN-18

FUEL PRESSURE SW

105-F180 RD-16
CBL-YJ1 RD-00-HP
126-F122 RD-14
128-F248 PK-18
365-F151 YL-18
559-F249 YL-18

E906-F247 OR-18
E907-F79 GY-18
E908-F71 BR-18
E909-F70 WH-18
F702-F164 GN-18
F916-F124 GN-18
G730-F86 PK-16
G946-F156 OR-18
G953-F114 BU-18
G965-F125 PU-18

K900-F116 YL-18

DIFF LOCK SOL


245-3555

YL-18
YL-18

A202-F260 BK-18
A202-F77 BK-18

A295-F203 BK-16
A295-F173 BK-16

K900-F117 YL-18

FUEL SUPPLY TEMPERATURE

A202-F182 BK-14

A295-F45 BK-14
A295-F202 BK-14

J765-F200 BU-16
J765-F200 BU-16

INTAKE MANIFOLD AIR TEMP


ATMOSPHERIC PRESS SNSR

DIFF LOCK SOL DIODE


189-3158

1
2

+5V SUPPLY #1

A202-F236 BK-18
A202-F81 BK-14
A202-F104 BK-18
A202-F103 BK-18
A202-F89 BK-18
A202-F150 BK-14

SECONDARY ENGINE SP SNSR (+)


SECONDARY ENGINE SP SNSR (-)

683-F56 PU-14
683-F183 PU-14

892-F145 BR-16
892-F147 BR-18

582-F94 PK-18
604-F92 OR-18
617-F95 BR-14
618-F93 YL-14
683-F210 PU-14
801-F253 PK-14
892-F147 BR-18
893-F146 GN-18
997-F41 OR-18
998-F42 BR-18

T859-AK4 WH-16-NW
T960-AK17 BU-16-NW
T860-AK5 OR-16-NW
T961-AK15 GN-16-NW

J766-F263 PU-18
K900-F54 YL-18
K990-F40 GN-18
R993-F198 BR-18

T860-AK6 OR-16-NW
T962-AK16 WH-16-NW

AK-C3
7E6513
AK-C4
7E6513

AK-C5
7E6513
AK-C6
7E6513

AK-C7
7E6513

PART#

219-7461
288-5511
276-3091
288-5525
253-5323
253-5306
288-5514
267-3089
230-0960
263-6888
253-5323
260-1868
263-6889
288-5510
288-5512
WIRE / STRAP
288-5527
288-5522
288-5521
CABLE AS.
236-2340
260-1888
8Y-9603
260-1889
288-5523
283-5827
283-5828
268-6609
263-6886
288-5528
288-5524
288-5520
266-9357

JACKET WATER
HEATER GP
249-5516
ATCH

HARNESS & CABLE CHART


CHG ATCH LOC
DESCRIPTION
05
01
00
00
01
02
00
00
01
01
01
00
02
01
00

STD
STD
STD
STD
STD
STD
ATT
ATT
STD
STD
STD
ATT
ATT
STD
STD

E-7
E-11
F-6
G-2
I-14
H-14
F-14
C-5
D-5
H-6
G-14
D-9
C-9
C-14
I-5

ENGINE
REAR MAIN FRAME
ENGINE FUEL
RELAY BOX
TRANSMISSION SOL
TRANSMISSION SPEED SENSOR
RADIATOR GRILL
ATTACHMENT FUEL INJECTORS
FUEL INJECTORS
FUEL PRIMING
TRANSMISSION OIL TEMP PARK BRAKE
FUEL LEVEL SENDER
LICENSE PLATE
REAR MAIN FRAME
SECONDARY STEER RELAY

00
00
00

STD
STD
STD

I-3
H-3
H-2

BUSS BAR TO STARTER RELAY


FROM MAIN BREAKER TO MAIN RELAY
FROM BAT+ JUNCTION BLOCK TO RELAY FUSE BOX B+

01
02
01
02
00
00
00
01
00
00
00
00
01

STD
STD
STD
STD
STD
ATT
ATT
ATT
ATT
ATT
STD
STD
STD

H-2
Y-2
E-4
H-3
H-1
I-1
I-5
I-5
H-2
H-3
E-4
I-4
C-8

BATT 1 POS TO BATT 2 NEG


POWER JUNCTION BLOCK TO BATTERY PASS-THRU LUG
STARTER GROUND TO ENGINE GROUND STUD
BATT 1 NEG TO DISCONNECT SWITCH
BATTERY PASS-THRU TO STARTER
BATTERY PASS-THRU TO SEC STEER RLY
SEC STEER RLY TO SEC STEER MTR
SEC STEER MTR TO GND
BATTERY 2 POSITIVE TO POWER JUNCTION BLOCK
FROM BAT (+) JUNCTION BLOCK TO BUSS BAR
STARTER GROUND STUD TO REAR FRAME GROUND
ALTERNATOR (B+) POST TO ALTERNATOR PASS-THRU
ALTERNATOR TO FRAME GROUND

R997-F197 OR-18

N931-F43 GY-18
304-F250 WH-8
J765-F185 BU-16
200-F187 BK-16
308-F188 YL-16
306-F189 GN-16
103-F178 RD-16
152-F225 RD-14
321-F91 BR-16
801-F253 PK-14
104-F177 RD-14
229-F22 BK-18
150-F23 RD-12
121-F27 YL-18
112-F204 PU-4
115-F224 RD-4
E554-F269 PK-18

ARTICULATION ANGLE POS SENS


160-2443
+V
GROUND
SIGNAL

124-F268 GN-18
522-F237 WH-18

ARTICULATION ANGLE POS SENS C1


160-2443

F-C41
8N1518

1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25

SYMBOL

11

10

WIRE GROUP COLOR DESCRIPTIONS

DESCRIPTION

CONN 74

CIRCUIT CONNECTED

TO POWER BOX
HARNESS R
CONNECTOR R-C5
LOC I-1

CIRCUIT NOT CONNECTED


ELECTRICAL CONNECTION TO
MACHINE STRUCTURE
INTERNAL ELECTRICAL CONNECTION
TO SURFACE OF COMPONENT
CONNECTOR
H#

CIRCUIT GROUPING DESIGNATION


ATCH WIRE, CABLE, COMPONENT
SPLICE

F-C16 F-C24
CONN 75
1552269 3E3364
1
683-F183 PU-14
CUSTOMER SUPPLIED REAR LIGHTS
2
200-F85 BK-14
(TWO 60W LAMPS MAX)

+V
GROUND
SIGNAL

12

SPEED CONT SET/ACCEL (NC)


SPEED CONT RES/DECEL (NO)

F-C39 HYD OIL COOLER INLET


1552269 264-4297
1
OR-18 SIGNAL
R732-F162 BR-18
2
BK-18 GROUND
A295-F203 BK-16

F-C31
1552269

J765-F201 BU-14
J765-F123 BU-14
J765-F88 BU-14

200-F47 BK-18
200-F57 BK-18
200-F90 BK-14
229-F6 BK-14
308-F110 YL-18
403-F275 GN-18
519-F191 PK-18
520-F265 WH-18
556-F20 WH-18
581-F96 GY-18

BACKUP ALARM
F-C38
213-9100
1552269
321-F13 BR-16 1 BK-18
2
BK-18
200-F58 BK-14

308-F170 YL-16
308-F188 YL-16

403-F275 GN-18
403-F274 GN-18

801-F253 PK-14
T998-F113 BR-18
A296-F227 BK-14
F702-F164 GN-18
G946-F156 OR-18
C978-F159 BR-18
A755-F168 PK-18
E716-F1 GY-18

RD-18
BK-18
YL-18

BK-14
BK-14
BK-14
BK-14
BK-14

321-F15 BR-16
321-F91 BR-16
321-F13 BR-16

U725-F143 GN-18
U726-F141 GY-18
U727-F140 YL-18
U734-F135 GN-18
U735-F136 GY-18
U736-F97 YL-18
U739-F129 BR-18
U740-F142 BU-18
U741-F132 OR-18
U753-F35 BR-18

103-F178 RD-16
104-F177 RD-14
105-F180 RD-16
112-F204 PU-4
115-F224 RD-4
121-F27 YL-18
124-F256 GN-18
126-F26 RD-18
128-F248 PK-18
152-F225 RD-14

CAN LOW
SPEED CONT AUTO/MAN (AUTO)

229-F59 BK-14
229-F22 BK-18
229-F5 BK-14

308-F110 YL-18
308-F111 YL-16

F846-F126 PU-18
G750-F130 BU-18
G755-F175 GY-18
G763-F131 PU-18
H764-F127 GY-18
H765-F128 WH-18
L914-F273 BU-18
M998-F154 OR-18
R908-F223 YL-18
T998-F113 BR-18

U766-F220 BR-18
U767-F211 BU-18
U768-F44 BU-18
X754-F36 GN-18
X755-F37 WH-18
X800-F48 OR-18

SPEED CONT SET/ACCEL (NO)

306-F189 GN-16

A202-F165 BK-14
A202-F221 BK-14

925-F51 YL-18
N787-F39 BU-18
E717-F49 GN-18
997-F41 OR-18
998-F42 BR-18
N931-F43 GY-18
R908-F223 YL-18
A295-F45 BK-14
E929-F38 GY-18
A202-F221 BK-14
L731-F194 BR-18
200-F90 BK-14
307-F186 OR-16
G953-F114 BU-18
G965-F125 PU-18
L914-F273 BU-18
F783-F184 GN-18
604-F92 OR-18
618-F93 YL-14
582-F94 PK-18
617-F95 BR-14
581-F96 GY-18
U768-F44 BU-18
G755-F175 GY-18
A975-F195 BU-18
U766-F220 BR-18
C532-F242 GN-18
X800-F48 OR-18
F846-F126 PU-18
H764-F127 GY-18
H765-F128 WH-18
U739-F129 BR-18
G750-F130 BU-18
U741-F132 OR-18
F784-F134 YL-18
U734-F135 GN-18
E974-F139 GN-18
F843-F137 YL-18
U740-F142 BU-18
G763-F131 PU-18
F781-F133 BR-18
U735-F136 GY-18
U727-F140 YL-18
F787-F138 GN-18
U726-F141 GY-18
U725-F143 GN-18
893-F146 GN-18
892-F147 BR-18
U736-F97 YL-18
A295-F205 BK-14
A295-F226 BK-14
683-F210 PU-14

RD-18
BK-18
YL-18

229-F3
229-F2
229-F4
229-F209
229-F102

900-F63 PU-16
901-F66 WH-16
902-F60 BR-16
903-F68 GY-16
921-F64 WH-16
922-F69 BR-16
997-F41 OR-18
998-F42 BR-18

A295-F205 BK-14
A295-F226 BK-14
A295-F202 BK-14
200-F58 BK-14
200-F14 BK-12
229-F171 BK-14
229-F172 BK-14

SWITCH RETURN
FUEL PRIME PUMP RELAY
ETHER RELAY

N787-F39 BU-18

751-F62 GN-16
752-F61 YL-16
754-F67 BU-16
755-F65 OR-16
801-F253 PK-14

F-C21
1471446

124-F256 GN-18
519-F191 PK-18
J844-F262 GY-18
403-F275 GN-18
J766-F263 PU-18
229-F6 BK-14
200-F57 BK-18
104-F177 RD-14
567-F261 WH-18
A296-F228 BK-14
103-F178 RD-16
152-F225 RD-14
200-F47 BK-18
A757-F169 GY-18

150-F23 RD-12
150-F10 RD-14
150-F9 RD-14

200-F16 BK-18
200-F17 BK-18
200-F21 BK-18
200-F85 BK-14
200-F187 BK-16

683-F210 PU-14

K900-F117 YL-18
K990-F118 GN-18

MOTOR

126-F119 RD-14

128-F248 PK-18

E716-F1 GY-18
E717-F49 GN-18

CONDENSER FAN MTR#2


166-5816

126-F122 RD-14

152-F225 RD-14

307-F186 OR-16
T969-F28 YL-18
A975-F195 BU-18
J765-F123 BU-14
F916-F124 GN-18
G730-F86 PK-16
306-F189 GN-16
J765-F88 BU-14
F846-F126 PU-18

TURBO INLET PRESS SNSR

321-F13 BR-16
200-F58 BK-14
R732-F162 BR-18
A295-F203 BK-16

124-F257 GN-18
124-F268 GN-18
124-F264 GN-18

124-F256 GN-18

FP-C5 F-C23
1552252 3E5179
1
799-FP111 WH-18
799-F235 WH-18
2
A202-FP112 BK-18
A202-F236 BK-18
3
R732-F162 BR-18
R732-FP68 BR-18

FP-C9
1552267

14

U723-F238 PU-18
U724-F55 WH-18
U728-F100 PK-18

GN-18
WH-18
WH-18
BK-14

CAT DATA LINK HIGH


CAT DATA LINK LOW

C491-F101 PU-18
E900-F246 WH-18
E901-F78 GN-18
E902-F73 PU-18
E903-F72 YL-18
E904-F75 BR-18
E905-F74 BU-18
E906-F247 OR-18
E907-F79 GY-18
E908-F71 BR-18

103-F178 RD-16
104-F177 RD-14
105-F180 RD-16
112-F204 PU-4
115-F224 RD-4
121-F27 YL-18

J1 F-C17
1607689

ANALOG SENSOR PWR


ANALOG SENSOR RETURN
DIGITAL SNSR PWR
DIGITAL SNSR RET

E909-F70 WH-18
G730-F86 PK-16
J765-F29 BU-16
R736-F82 PK-18
R818-F84 YL-18
U724-F55 WH-18

CONN 71

X754-FP12 GN-18
X755-FP13 WH-18
X800-FP5 OR-18

1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25

G730-F86 PK-16
J765-F88 BU-14
J765-F123 BU-14
K900-F117 YL-18
K990-F118 GN-18
L730-F98 OR-18
L731-F99 BR-18
R736-F82 PK-18
R818-F84 YL-18
T969-F28 YL-18

ENGINE ECM
242-1265

754-F67 BU-16
755-F65 OR-16
900-F63 PU-16
901-F66 WH-16
902-F60 BR-16
903-F68 GY-16
921-F64 WH-16
922-F69 BR-16
A202-F77 BK-18
A202-F83 BK-18

CBL-YJ1 RD-00-HP
304-F250 WH-8
365-F151 YL-18
A893-F25 OR-14
F713-F196 OR-18
F715-F11 PU-16
F719-F12 BR-16
H746-F152 YL-16
H747-F153 BR-16
K748-F76 OR-18
R993-F198 BR-18
R997-F197 OR-18

BK-18
BK-18
BK-14
BK-14
BK-14
BK-14
BK-14
PU-18
PK-18
WH-18

E901-F78 GN-18
E902-F73 PU-18
E903-F72 YL-18
E904-F75 BR-18
E905-F74 BU-18
E906-F247 OR-18
E907-F79 GY-18
E908-F71 BR-18
E909-F70 WH-18
F916-F124 GN-18

925-F51 YL-18

MOTOR

1
2

A202-F103
A202-F104
A202-F105
A202-F106
A202-F150
A202-F165
A295-F202
C491-F101
E554-F269
E900-F246

T998-F113 BR-18
X800-F48 OR-18
126-F121 RD-14
126-F120 RD-14
902-F60 BR-16
752-F61 YL-16
921-F64 WH-16
751-F62 GN-16
900-F63 PU-16

CONDENSER FAN MTR#1


166-5816

FP-C8
1552269

893-F144 GN-16
900-F63 PU-16
901-F66 WH-16
902-F60 BR-16
903-F68 GY-16
921-F64 WH-16
922-F69 BR-16
A202-F80 BK-14
A202-F81 BK-14
A202-F89 BK-18

A202-F104 BK-18

200-F90 BK-14
321-F15 BR-16
581-F96 GY-18
582-F94 PK-18
604-F92 OR-18
617-F95 BR-14
618-F93 YL-14
683-F56 PU-14
751-F62 GN-16
752-F61 YL-16

CBL-YJ1 RD-00-HP
304-F250 WH-8
365-F151 YL-18
A893-F25 OR-14
F713-F196 OR-18
F715-F11 PU-16
F719-F12 BR-16
H746-F152 YL-16
H747-F153 BR-16
K748-F76 OR-18
R993-F198 BR-18
R997-F197 OR-18

308-F111 YL-16
403-F274 GN-18
520-F199 WH-18
559-F249 YL-18
751-F62 GN-16
752-F61 YL-16
754-F67 BU-16
755-F65 OR-16
892-F145 BR-16

BR-16
BR-18
YL-18
BK-14
WH-18

200-F21 BK-18
200-F47 BK-18

R732-F162 BR-18

U766-FP42 BR-18
U767-FP15 BU-18

15

892-F145
L731-F99
R818-F84
A202-F81
567-F261

10

126-F33 RD-14
126-F112 RD-14
126-F115 RD-14
126-F120 RD-14
126-F121 RD-14
200-F14 BK-12
200-F58 BK-14
229-F171 BK-14
229-F172 BK-14
306-F189 GN-16

YL-16
WH-18
BR-18
YL-18
PU-18
BU-18
BR-18

A202-F105 BK-14
520-F199 WH-18
E901-F78 GN-18
E900-F246 WH-18
E907-F79 GY-18
E906-F247 OR-18

FP-C4 F-C22
CONN 72 1607689
2144208

997-FP20 OR-18
998-FP21 BR-18
A202-FP26 BK-14
A202-FP112 BK-18
A295-FP24 BK-14
A295-FP65 BK-14
A295-FP66 BK-14
A296-FP71 BK-14
A296-FP79 BK-14
A755-FP75 PK-18

A756-FP78 BU-18
A296-FP79 BK-14

124-FP85 GN-18
519-FP86 PK-18
J844-FP87 GY-18
403-FP88 GN-18
J766-FP89 PU-18
E717-FP98 GN-14
103-FP90 RD-16
104-FP91 RD-14
567-FP92 WH-18
152-FP93 RD-14
L914-FP32 BU-18
E716-FP97 GY-14
128-FP99 PK-18

1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70

11

893-F144 GN-16
L730-F98 OR-18

FP-C7 F-C35
8N1518 8N1517

CONN 73

229-FP81 BK-14
307-FP29 OR-16
308-FP14 YL-18
403-FP88 GN-18
519-FP86 PK-18
520-FP95 WH-18
556-FP9 WH-18
567-FP92 WH-18
581-FP38 GY-18
582-FP36 PK-18

F785-FP6 WH-18
K990-FP7 GN-18
K900-FP8 YL-18
556-FP9 WH-18
126-FP10 RD-18
U753-FP11 BR-18
X754-FP12 GN-18
X755-FP13 WH-18
308-FP14 YL-18
U767-FP15 BU-18

X800-FP5 OR-18
F846-FP44 PU-18
H764-FP45 GY-18
H765-FP46 WH-18
U739-FP47 BR-18
G750-FP48 BU-18
U741-FP49 OR-18
F784-FP50 YL-18
U734-FP51 GN-18
E974-FP52 GN-18
F843-FP53 YL-18
U740-FP54 BU-18
G763-FP55 PU-18
F781-FP56 BR-18
U735-FP57 GY-18
U727-FP58 YL-18
F787-FP59 GN-18
U726-FP60 GY-18
U725-FP61 GN-18
893-FP62 GN-18
892-FP63 BR-18
U736-FP64 YL-18
A295-FP65 BK-14
A295-FP66 BK-14
683-FP67 PU-14

F-C20
1471445
308-F111
E909-F70
E908-F71
E903-F72
E902-F73
E905-F74
E904-F75

1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70

REAR FRAME GND 2

TAIL

1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70

BK-14
BK-14
BK-14
BK-14

REAR FRAME GND

CONN 58

RH STOP TAIL LAMP


AG-C25 AG-C13
135-0426
3E3370 1552267
A
RD-18
604-AG32 OR-18
B
BK-18
200-AG34 BK-14
C
WH-18
618-AG39 YL-14

(NO)
(NC)
(NO)
(NC)

ART ANGLE POS SENS #1

AG-C9 AG-C8
3E3370 1552267
A
604-AG14 OR-18
200-AG17 BK-14
CONN 61 B
C
618-AG38 YL-14

TAIL

SOL
SOL
10V
(-)

RH BACKUP LAMP
261-1502

RH STOP TAIL LAMP2


135-0426
RD-18
BK-18
WH-18

+8v SUPPLY
8v RETURN
BATTERY #5 (+)
BATTERY #3 (+)
TRANS SOLENOID #7
TRANS SOLENOID #2
PWM DR RETURN 1-4
TRANS SOLENOID #3
TRANS SOLENOID #4

KEY SWITCH - START


SEC STR/PRELUBE/EVAC RLY
DIFF LOCK RELAY
DRIVER RETURN
BACKUP ALARM RELAY
PARK BRAKE SOLENOID
STARTER RELAY
DRIVER RETURN
MACHINE SEC SYSTEM IND

AG-C20 F-C29
1552252 3E5179
1
200-AG3 BK-14
200-F90 BK-14
2
321-F15 BR-16
321-AG8 BR-16
3
604-AG31 OR-18
604-F92 OR-18
4
5
6
7
8
9
10
11
12

BATTERY #1 (+)
ECM LOC ENABLE (GND)
PWT FLTR BYPASS SW
DIFF LOCK (NO)
PARK BRAKE PRESS SW (NO)
SERV BRAKE CHG PRESS SNS
STEERING VLV SIG
BATTERY #4 (+)
BATTERY #2 (+)
PARK BRAKE PRESS SW (NC)

LEFT SECOND STEER


RIGHT SECOND STEER
SENSOR SUPPLY +
BATTERY #04

LH BACKUP LAMP
261-1502
AG-C18
1552269
1
321-AG6 BR-16
2
200-AG26 BK-14

STOP

BATTERY #01 (-)


AC REFRIG MONITORING
XMSN OUT SPEED SNS 1+
XMSN OUT SPEED SNS 1XMSN OUT SPEED SNS 2+
XMSN OUT SPEED SNS 2-

PWM DR RETURN 11-12


PWM DR RETURN 9-12
BATTERY #05 (-)
BATTERY #03 (-)
TRANS SOLENOID #5
TRANS SOLENOID #6
PWM DR RETURN 5-8
TRANS SOLENOID #1
TRANS SOLENOID #8
OP PRESENT SW (NC)
OP PRESENT SW (NO)

CONN 67
AN-C12 F-C28
3E3382 1552273
1
PK-18
2
BK-16
3
YL-18
4
PU-18
5
PK-16
6
BU-16

200-AG37 BK-14

321-AG5 BR-16
321-AG6 BR-16

CDL HIGH
+5v SUPPLY

CDL LOW
5v RETURN
TRANS OIL TEMP SENSOR
BATTERY #2 (-)
CAB AC SW

CONN 70

200-AG1 BK- 14
200-AG35 BK-14
200-AG12 BK-14
200-AG27 BK-14

J1
RUN
(+)
(-)
(+)
(-)
(+)
(-)

ECM LOCATION 0 (GND)


ECM LOCATION 1 (OPEN)
ECM LOCATION 2 (OPEN)
FUEL LEVEL SENSOR

V-C6
1552269
U724-V11 WH-18
A202-V13 BK-18

617-AG10 BR-14
617-AG36 BR-14

BR-16
YL-16
GN-16
PU-16
WH-16
OR-16
WH-16
BU-16
GY-16
BR-16

E908-V2 BR-18
E909-V1 WH-18

582-AG16 PK-18
581-AG11 GY-18
604-AG33 OR-18
604-AG31 OR-18
604-AG32 OR-18
604-AG14 OR-18
604-AG9 OR-18

CONN 64

RD-18
BK-18
WH-18

STOP

11
12

XMSN INPUT SPEED SENSOR


191-8304
V-C2
1552269
BK-18 1
E902-V4 PU-18
WH-18 2
E903-V3 YL-18
XMSN INT SPEED SENSOR 1
191-8304
V-C3
1552269
BK-18 1
E904-V6 BR-18
WH-18 2
E905-V5 BU-18
XMSN INT SPEED SENSOR 2
191-8304
V-C7
1552269
BK-18 1
E900-V7 WH-18
WH-18 2
E901-V9 GN-18
XMSN OUT SPEED SENSE2
191-8303
V-C8
1552269
BK-18 1
E906-V8 OR-18
WH-18 2
E907-V10 GY-18
XMSN OUT SPEED SENSE1
191-8303

XMSN OIL TEMP SENSE


238-0112

BK-18
BK-18

922-T19 BR-16

751-T5 GN-16
752-T3 YL-16
754-T14 BU-16
755-T9 OR-16
900-T7 PU-16
901-T12 WH-16
902-T1 BR-16
903-T16 GY-16

A
B
C

PARK BRAKE SOL


248-5523

T-C10 F-C15
3E5179 1552252
1
902-F60
902-T1 BR-16
2
752-F61
752-T3 YL-16
3
751-F62
751-T5 GN-16
4
900-F63
900-T7 PU-16
5
921-F64
921-T18 WH-16
6
755-F65
755-T9 OR-16
7
901-F66
901-T12 WH-16
8
754-F67
754-T14 BU-16
9
903-F68
903-T16 GY-16
10
922-F69
922-T19 BR-16

KEY SWITCH INPUT SPD SNSR


INPUT SPD SNSR
INT SPD SNSR 1
INT SPD SNSR 1
INT SPD SNSR 2
INT SPD SNSR 2

TRANS
TRANS
TRANS
TRANS
TRANS
TRANS

CONN 69

921-T18 WH-16

922-T17 BR-16
922-T11 BR-16
922-T13 BR-16

XMSN FILTER BYPASS SW


164-7577

BK-18
RD-18
BU-18

12
XMSN & CHASSIS ECM
262-1408

T-C3
1552269
902-T1 BR-16
921-T2 WH-16

1
2

13

304-F250 WH-8

(Dimensions: 48 inches x 35 inches)

14

XMSN SOL 8 (HIGH RANGE)


244-3114

36 Page,

RENR9024-08 VOL 3 of 3

15

BLADE, SPADE, RING OR SCREW


TERMINAL

ABBREV

COLOR

RD
WH
OR
YL
PK
BK
GY
PU
BR
GN
BU

RED
WHITE
ORANGE
YELLOW
PINK
BLACK
GRAY
PURPLE
BROWN
GREEN
BLUE

NOTE A:

GROUND CIRCUIT
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON
STARTING CIRCUIT
START AID CIRCUIT
TRANSMISSION AND CHASSIS CONTROL CIRCUIT
ENGINE CONTROL CIRCUIT

NOTE B: STD TWO SPEED WIPERS


NOTE D: REPLACE 4 AWG STRAP WITH 00 AWG CABLE ON MACHINES
WITH SECONDARY STEERING ATTACHMENT

THIS SCHEMATIC IS FOR THE 16M MOTOR GRADER ELECTRICAL SYSTEM


VOLUME 3 of 3: ENGINE AND CHASSIS
MEDIA NUMBER: RENR9024-08
SCHEMATIC PART NUMBER: 267-3909, CHANGE: 00, VERSION: -

HEATER AND AIR CONDITIONER CIRCUIT


TURN SIGNAL / WIPER WASHER CIRCUIT
CAT DATA LINK
CAN DATA LINK
IMPLEMENT CONTROL CIRCUIT (1)

OTHER COLOR DESCRIPTIONS

Components are shown installed on a fully operable machine with the key and engine off, transmission shifter
in neutral and with parking brake set.
Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.
Refer to the Parts Manual using a specific serial number prefix in SIS before ordering parts from this schematic.

HIGHWAYS

TWISTED PAIRS WIRES MUST BE AT LEAST 1 TURN PER 25 MM

S-ar putea să vă placă și