Documente Academic
Documente Profesional
Documente Cultură
Objectives
Configure CUCME to enable the DHCP Server for IP Phones in each of the
POD.
Equipment Requirements
Cisco Unified Communication Manager Express (CUME)
b. Enter the command ip dhcp pool CMEVoiceX (where X is the pod number) to
name the DHCP pool and begin configuration of the parameters that will be
served to remote devices.
CMERouterX(config)# ip dhcp pool CMEVoiceX
e. Enter option 150 ip 192.168.2X.1 to assign the TFTP server address as the
CUME router. The Cisco IP phone downloads the image configuration files
from this address (the router).
CMERouterX(dhcp-config)# option 150 ip 192.168.2X.1
______________________________
______________________________
______________________________
______________________________
______________________________
______________________________
Note: With CallManager Express, the IP phones receive their initial configuration information
and phone firmware from the TFTP server associated with the CME router. The phones usually
get the IP address of their TFTP server using the DHCP option 150 command. When using
CME, the TFTP server address obtained by the phone should point to the CME router IP
address.