[ieee OO EE
B.Tech, DEGREE EXAMINATION, NOVEMBER 2012
Seventh Semester
‘M0405 - DESIGN OF TRANSMISSION SYSTEMS
(Forth candles mite from he ear 207-2008 onwards)
(Ce ofoprored Design Data ook permite. sume state da
whrewe neces)
‘Time: Three hours Max. Marks: 100
Answer ALL Questions
PART- A (10x 2=20 Marks)
‘Why V-bets are more powerful than at bets?
‘What are Fong lay and regular lay ropes?
Define Pressure angle ofa gear.
‘Why pinion is made harder than gear?
List the types of bevel geats.
‘Why are V-threads not used in power screws?
What is Sommerfeld number? Give is significance.
What are the forces acting ona key?
‘What are overlapping gear boxes?
Define Progression rato.
PART ~B (6x 16= 80 Marks)
Design a fabric belt to transmit 10 KW at 450 pm from an
engine to a tine shaft at 1200 rpm. The diameter of the
‘engine pulley is 600 ram and the distance ofthe shaft fom
the engine is 1.8m.
(oR)
Design a chain drive for a blower which is to run at
{600 fpm. Power available fom a 20 kW motor st 1450
pm. The motor ean be located at a distance not less than
700 mmmDesign a spur gear drive for the following requirements
Power = 36.5 kW; i=5;Pinion speed = 750 sm.
(oR)
Design a helical gear drive forthe given specifications
Power —40 kW @ 1500rpm of pinion
Gear ratio= i= 4.25,
Helix angle = 8 = 20°,
Design a cast iron grade 35 bevel gear transmiting 10 KW.
fom motor running at 1200 rpm to compressor at 780 rpm.
‘The axes are perpendicular to each other.
(oR)
Design a worm gear drive with standard centre distance to
transmit 7.5KW from a worm rotating at 1440 rpm to a
Wheel running at 20 rpm,
A joumal bearing is proposed for a steam engine. The load
(nthe joumal is 3kN, diameter SOmm, length 75 mm,
speed 1600 rpm, diametral clearance 0.001 mm, ambient
temperature 155°C oil SAEIO is used and film
‘temperature is 60°C. Design the bearing
(oR)
Find the diameter of shaft made of ductile material with
fatigue strength (complete stress reversal), 0, ~ 265 MPa,
tensile yield strength 350 MPa. The shaft is subjected to
varying axial load Wye = 300 KN to Win = 700 EN. Use
factor of safety n= 2 and stress concentration factor = 1.8,
15.a, Ina milling machine 18 different speeds in the range of
35 rpm and 650 ppm are required. Design a three stage gear
box with & standard step ratio. Caleulate no, of teth in
cach gear,
(or)
Design a nine speed gear box to provide speed ranging
from 200 rpm to 1000 ep. The input is from a motor of
KW at 1440 mpm. Draw the kinematic arrangement of
gearbox and calculate no. of teeth in goa.