0 evaluări0% au considerat acest document util (0 voturi)
31 vizualizări1 pagină
This document contains an exam for a Power Electronics course, with 4 multiple choice questions:
1. The first question involves calculations for a step-down chopper circuit operated at 10 kHz, including the minimum duty ratio for continuous current, duty ratio for 20A average current, and average transistor current for 0.5 duty ratio.
2. The second question involves calculations for a single phase AC voltage regulator with a load of 7.1+j7.1 Ohms, including the power factor angle, RMS output voltage, output power and current for various firing angles.
3. The third question asks to explain the operation of a single phase cycloconverter using sketches and waveforms.
4. The
This document contains an exam for a Power Electronics course, with 4 multiple choice questions:
1. The first question involves calculations for a step-down chopper circuit operated at 10 kHz, including the minimum duty ratio for continuous current, duty ratio for 20A average current, and average transistor current for 0.5 duty ratio.
2. The second question involves calculations for a single phase AC voltage regulator with a load of 7.1+j7.1 Ohms, including the power factor angle, RMS output voltage, output power and current for various firing angles.
3. The third question asks to explain the operation of a single phase cycloconverter using sketches and waveforms.
4. The
This document contains an exam for a Power Electronics course, with 4 multiple choice questions:
1. The first question involves calculations for a step-down chopper circuit operated at 10 kHz, including the minimum duty ratio for continuous current, duty ratio for 20A average current, and average transistor current for 0.5 duty ratio.
2. The second question involves calculations for a single phase AC voltage regulator with a load of 7.1+j7.1 Ohms, including the power factor angle, RMS output voltage, output power and current for various firing angles.
3. The third question asks to explain the operation of a single phase cycloconverter using sketches and waveforms.
4. The
INTERNAL EXAMINATIONS: MID II B.Tech EEE - III Year I SEM
OCT - 2015
Max Marks: 10 M
ACAD YEAR: 2015 - 16
Time: 60mins
Subject: POWER ELECTRONICS
Answer any TWO questions
2 X 5 = 10 M
All questions carry equal marks
1. The step-down chopper shown below is operated at the switching frequency fs = 10 kHz. (a) Find the minimum value of the duty ratio k so that the load current io is continuous. (b) Find the duty ratio k so that the average load current is 20 A. (c) Find the average value of the transistor current for k = 0.5.
2. If the load of the 50 Hz 240V single phase ac voltage regulator is Z = 7.1+j7.1 ,
calculate the load natural power factor angle, . Then calculate (a) The R.M.S output voltage (b) The output power and R.M.S current, whence input power factor for i. = /6 ii. = /3 3. Explain with neat sketches and waveforms the complete operation of bridge configuration of single phase cyclo converter. 4. A single-phase full bridge inverter with square wave pole voltages is connected to a dc input voltage of 600 volts. What maximum rms load voltage can be output by the inverter? How much will be the corresponding rms magnitude of 3rd harmonic voltage (a) Approximately 270 volts of fundamental and 30 volts of 3rd harmonic voltage (b) Approx. 480 volts fundamental and 160 volts of 3rd harmonic voltage (c) Approx. 540 volts fundamental and 180 volts of 3rd harmonic voltage (d) Approx. 270 volts fundamental and 90 volts of 3rd harmonic voltage