Documente Academic
Documente Profesional
Documente Cultură
ar Burglar Alarm timer alarm system circuit , model to economize. This circuit convenients for to set up in an
automobile. usually switch at set up keep with automobile door will the circuit closes. But in case of car owner opens in
and out while note as a result have no result anything , because of the transistor model PNP to still dont work. Because
of 9 pin have high voltage. But when switch the door any one open the circuit exceed time delay keep 5 pin of IC NE556
have low voltage to fully drive transistor circuit give relay work. The system will order to give the horn a car talks at one
time to come to immediately. But if we shut the door a car or close S1 system stop work again.
The output of IC 555 is triggered by a positive voltage on pin 2,when all switches are connected together.When the
something switch is cut off pin 2, it will be negative voltage and the trigger IC 555 will stop. The C1, C4 to protects a
noise signal from either switch, which may cause the alarm to be up. This circuit can be used with power supply from 5V
to 15V depending on relay sure enough.