0 evaluări0% au considerat acest document util (0 voturi)
63 vizualizări2 pagini
The document provides instructions for programming the device ID on a ResponseCard RF and ResponseCard RF LCD. It describes a 5-step process to set a new 6-digit device ID between 000001-999999 or reset to the factory ID. The steps include pressing specific buttons in sequence while the LED flashes different colors to confirm each step is completed correctly before moving to the next within 5 seconds.
The document provides instructions for programming the device ID on a ResponseCard RF and ResponseCard RF LCD. It describes a 5-step process to set a new 6-digit device ID between 000001-999999 or reset to the factory ID. The steps include pressing specific buttons in sequence while the LED flashes different colors to confirm each step is completed correctly before moving to the next within 5 seconds.
The document provides instructions for programming the device ID on a ResponseCard RF and ResponseCard RF LCD. It describes a 5-step process to set a new 6-digit device ID between 000001-999999 or reset to the factory ID. The steps include pressing specific buttons in sequence while the LED flashes different colors to confirm each step is completed correctly before moving to the next within 5 seconds.
Programming ResponseCard to a NEW Device ID Note: There is a maximum of 5 seconds to complete each step before the programming process will time out and you must restart from step 1.
1) Press Ch button. The LED will flash green and red.
2) Press ? button, the LED will flash green and red at a slower rate. 3) Enter the new six digit device ID using keys 0 to 9 (valid IDs are 000001 to 999999). Each time a button is pressed the LED will flash yellow. (RCRF-LCD: Confirmation of the numbers entered will appear on the LCD). 4) After entering the new ID number, Press ? button, the LED will turn yellow. 5) Press Ch button, the LED will turn green to indicate the device ID has been successfully set to a new ID. AUSTRALIA NEW ZEALAND SINGAPORE JAPAN - EUROPE
www.keepad.com - support@keepad.com
Device ID Programming on the ResponseCard RF
and ResponseCard RF LCD Resetting ResponseCard to the FACTORY Device ID Note: There is a maximum of 5 seconds to complete each step before the programming process will time out and you must restart from step 1.
1) Press Ch button. The LED will flash green and red.
2) Press ? button, the LED will flash green and red at a slower rate. 3) Press the 0 button six times. Each time a button is pressed the LED will flash yellow. (RCRF-LCD: Confirmation of the numbers entered will appear on the LCD). 4) After entering 000000, Press ? button, the LED will turn yellow. 5) Press Ch button, the LED will turn green to indicate the device ID has been successfully reset to the factory ID which is on the back of the keypad. AUSTRALIA NEW ZEALAND SINGAPORE JAPAN - EUROPE