Documente Academic
Documente Profesional
Documente Cultură
afa the formatting you can do it from command prompt using DiskPart.
1. Go in Start > write cmd > right-click the Windows Command Prompt and choose to run it as
an Administrator.
2. At the prompt, enter DISKPART to launch Microsofts disk management utility. It will take
a second until it loads and when ready it will read DISKPART>.
3. Type in list disk to show a list of all disk drives. If your USB key is plugged into your PC, it
should be listed here, along with other drives. Note the USB keys disk number you can pick it
out by looking at the disk capacity.
4. Type select disk n" (whatever is your USB disk number in place of "n").
5. Type clean for the utility to clean the disk, which DiskPart will confirm.
6. Create a new partition by entering create partition primary.
7. Choose this partition with select partition 1", and then mark it as active by typing active.
8. Format the key by inputting format fs=fat32". This should take a few minutes, and DiskPart
will display a progress percentage.
9. Lastly, type assign to give this USB key a drive letter and exit to exit DiskPart.
My System Specs