Documente Academic
Documente Profesional
Documente Cultură
Normally if an SDR BTS is running with IP over E1 and there is congestion in voice or data
traffic we may need to add another E1 resource to it. We can connect one more E1 to add more
resources to avoid congestion.
For making it possible we need to do some mandatory changes in OMCR (IP parameters) &
OMCB configuration. For OMCB configuration we can directly upload a template with the new
configurations to the BTS or can directly change the transmission parameters of NE in OMCB.
The process of connecting SDR BTS from second E1 is given belowExample: Chiredzi Main (MVO0005-RN-IMG1)
1. Choose SDTB board and go to board propriety and select PCM information
2. Select PCM type as Type of EUIP and Frame mode as Multiframe. Highlight the PCM
you are going to use and then move it to the right pane of the window
IP Related Configuration
5. In IPRelatedConfig on No change will be in Interface configuration-, take note of the
port Number (or referred to as MP Number in PPP Configuration)
6. Choose the EUIP board for which DT PCM and EUIP 2MHW TS mapping was done in
board configuration.
7. Configure or set HDLC and port numbers
9. In IP Abis Bandwith resource pool, edit the UL and DL bandwidths according to the
formula:
1.5*E1 bandwidth(=2048MBps)*Number of E1s.
OMCB Configuration
Follow the steps shown here below