Documente Academic
Documente Profesional
Documente Cultură
User Manual
Speedo Corrector
Module for Cars
AA-0376
Distributed by:
TechBronds by Electus Distribution Pty. Ltd.
320 Victorlo Rd, Rydolmere
NSW 2116 Austrolio
Ph: I 300 738 555
lnt'l: +61 2 BB32 3200
Fox: I 300 /38 500
www.techbronds.com
Technica I SPecifications:
o Powe r: L2VDC
o Dimensions: 63(L) x 46(W) x25(H) mm
lnstructions:
to pull your dash out to locate
the speed input wire to the speedometer, ffiake sure
you're aware of the safety precautions that need to be
taken if the car is equipped with airbags.
o Connect the module according to the wiring diagram
depending on your use of the module. Incorrect wiring
will damage the module and your vehicle if you
connect it in the incorrect polarity:
the sPeedo)
-Set51 to2
-Set52toA
- lnsta ll lin k LK2
- Drive the car for a minute (the speedo will not
work).
- observe that the LED flashes at IHz when the car
itself
is moving. This shows that the module has set
for the type of speedometer signal that is present
andthatitisreceivingaVaIidsigna|.
- lf the LED doesn't flash, install link LK1 (instead of
LK2) and trY again.
-Set52to0
-Set51 to0
the link options LK3, LK4 or LK5 until the
speedo works (the speedo should read as it did with
the car standard).
- Set SLx and 52** to give the required correction.
* Sl- corrects the speedo reading in single units.
* * 52 corrects the speedo output in tens'
e.g. lf the required correction is I8%, set S1 to
'8' and 52 to'L'
- lf the speedo reading needs to be corrected
upwards rather than the default downwa.rds, set 52
to F and then wait for the LED to flash twice. Then
set 52 back to its required correction value. To
return to downwards speed correctiofl, again set 52
back to F and wait for a single flash
- Try
cknowledge ment.
N otes:
&tr
H43
tr4#
S+
;F
qld
b
t,'
nffi.
r-l
iS
i?
*i,
l-::"1
ro
lffi
[:
til$
,ffi
{fr"
ffi
ff
{*
tr
{}
ffi"
FS'
L&*
fs
t?
tr
&fl
ffi
xJ\'*
]4
t-t
d#:
fif ir
(E
L
uo
.g
uo
.I
.I
c
L
--
Hfiffi
*t
Kq
4r@
:3
fnfr
.d*\
ffi
ru
w
93"
&
&
#t
'**
le
:s
t&
tr{
f+
!ry
{f3
1S
g
*i
-*I
&
*-,t
;$
&