Documente Academic
Documente Profesional
Documente Cultură
The programming cable is intended to be used with a computer RS-232 port for
programming radios and other devices. The main goal of this cable schematics is
the invertion of signal levels. That is because the COM port's logic one is a low
voltage level, logic zero is a high voltage level. Another goal is the correct voltage
level transformation with regard to the real radio programming circuits. And nothing
must get burnt...
Schematic diagram
Connection circuits (jacks for mobile radios are shown as they are plugged
into sockets)
VT1, VT3, VT4 transistors may be BC847 or similar (i.e. BC547B, etc.), VT2 may be
BC857 or similar (i.e. BC557B, etc.). Fast silicon diodes of any type will do, for
example 1N4148 or LL4148 in MiniMELF case. LP2950 is replaceable with LM2951
with appropriate resistors, 78L05 is the worst choice due to it's own high current
consumption. It may fail to work in some cases. Use 78L05 with an external power
source.
Cable for RRxD and RTxD connections should be shielded. Multiwire cable with low
mutual capacitance among wires is also applicable. Otherwise TxD to RxD
interference will result in programming failure. It is important for some KENWOOD
radios.
It is convenient to use an additional connector to attach particular radio jacks to the
programming cable. DB9 is recommended as a highly reliable one.
Cable connection to KENWOOD portable radios has a specific feature. Radio sockets
have prominent rubber rings, thus standard stereo jacks cannot be plugged in
firmly. The jack flanges should be ground off till 5 mm in diameter. The jack cases
should be cut accordingly.
TK-353 radios are put in the program mode by holding the side button below PTT
and C button while powering the radio on. Hold the buttons until "--PC--" appears
on its display. TK-250 enters programming mode by pressing Lamp and Lo buttons
while turning the radio on.
In MOTOROLA GP300 connector use 2 Ampere diode if you intend to transmit with
the cable connected or 1 Ampere diode otherwise. In MOTOROLA P040-P080
connector grind off the jack flange until the jack can be seated firmly. This
connector does not need an external power supply if it is provided from the port by
a programming software.
MOTOROLA mobile CM series radios are programmed through the rear accessory
connector. The programming cable is not powered from the port. The power supply
can be taken from the radio power supply or the accessory connector if available.
The corresponding programming cable connector was designed by Vadim UA9MIR
MOTOROLA mobile CM series radios may be also programmed through the front mic
socket. The programming cable is powered from the radio socket. The
corresponding programming cable connector was designed and tested by Belu
Daniel (Romania).
Alexander 'Gulliver' has proposed the connector for the VECTOR VT-44 MILITARY
portable LPD radio.
Roman RN3ADR with the author's participance has designed the connector for
SIMOCO SRM-9000 series radios. Before programming the radio must be turned on.
To do so push and hold SW1 button until HL1 LED switches on. After programming
turn the radio off by holding the button until the LED switches off. Now you may
disconnect the programming cable from the radio.
Valery UA9MRQ has proposed the connector for the russian GRANIT 2P-21 mobile
radio.
Yury US5IVZ has proposed the connector for ALAN HM-200 radio.
Georgy RN3ZNL and Dmitry RN3ZQL have tested the programming cable
attached to a computer via a COM - USB2.0 converter with the appropriate
driver under Windows XP. In this case a DOS programming software seems to work
correctly with the emulated serial port (various DOS softwares for MOTOROLA
mobile radios were tested). Also the data exchange speed for DOS programs via the
emulated port is notably higher then via the standard serial port under Windows XP.
Modern high speed computers vere used in those tests.
A connection to devices with a non-standard processor supply voltage (cordless
and cellular phones) requiers a special connector. A TxD key power is taken from
the phone, so the input logic levels cannot exceed the processor supply voltage. For
example SENAO SN-258 is attached by its test connector in this way: TxD - cont. 1,
RxD - cont. 2, GND - cont. 3, Vbat - cont. 5. R1 resistor may be omitted because
the phone RxD circuit has an inner 47 kOhm resistor to the ground.
The cellular phones connector can be used for applying AT-commands or firmware
replacement. There are no hardware flow control circuits in the connector. The
Siemens specific connector is shown. Use it for AT-commands with the switch
turned off, for firmware downloading with the switch turned on. The Siemens phone
socket pinout is from www.pinouts.ru. For more information please search specific
cell phone sites.
The programming cable printed circuit board (97.2 kB) was designed by Valery
UA6LPG with non-chip components. In order to print it save the GIF image to disk.
Then open the GIF file with Adobe Photoshop (or any other editor) and change the
image resolution to 600 dpi (look for at Image/Image size). Print it, it will be of the
right size.
Please note that Rind resistor and a LED are used just to indicate the power supply
voltage. You can omit R12, Rind and a LED, the circuit will work. Some words are in
Russian, the most significant words are translated. The recommended value of Rind
is 4.3 kOhm to minimize the current consumption, the LED will glow slightly.
The programming cable was tested with 336 device types, i.e.
Device (radio)
type
Checked by
Recommended
software
Connector
KEN-1A
KENWOOD
TM-V7
Igor RA0FMF
TK-250
KEN-2
TK-259
Robert PE1CWU
KPG-32D
KEN-2
TK-260G
KPG-56D
KEN-2
TK-270
KEN-2
TK-270G
KPG-56D
KEN-2
TM-271
MCP-1A
KEN-1B
TK-272
KPG-27D
KEN-2
TK-272G
KPG-56D
KEN-2
TK-278
KEN-2
TK-350
KEN-2
TK-353
the author
KPG-26D
KEN-2
TK-360
the author
KPG-27D
KEN-2
TK-360G
KPG-56D
KEN-2
TK-370
KPG-27D
KEN-2
TK-370G
KPG-56D
KEN-2
TK-372
KPG-27D
KEN-2
(Uruguay)
TK-372G
KPG-56D
KEN-2
TK-378
KEN-2
TM-471
Marat (Dushanbe)
MCP-1A
KEN-1B
TK-480
Alexander UA9CEE
KPG-35D
KEN-4
TKR-750
KEN-1B
TK-752E
KPG-28D
KEN-1A
TK-759
Alexander 'Gulliver'
KPG-28D
KEN-1A
TK-760
KEN-1A
TK-760G
KEN-1B
TK-760G 5-tone
KPG-67D
KEN-1B
TK-760H
KEN-1A
TK-760HG-1
KEN-1B
TK-762G 5-tone
KPG-67D
KEN-1B
TK-768
KEN-1A
TK-768G
Albina Luchaninova
KPG-56D
KEN-1B
TK-768H
KEN-1A
TK-809
Alexander 'Gulliver'
KPG-20D
KEN-1A
TK-840
KPG-25D
KEN-1A
TKR-850
KPG-66D, KPG-91D
KEN-1B
TK-860
KPG-29D
KEN-1A
TK-860G-1
KEN-1B
TK-860H
the author
KPG-29D
KEN-1A
TK-862G-1 5-tone
Ramunas Majauskas
KPG-67D
KEN-1B
TK-868
KPG-29D
KEN-1A
Nesterov
TK-880
Serguey Bunin
KPG-49D
KEN-1B
TK-880-3 (MT)
the author
KPG-60D
KEN-1B
TK-890
Alexander 'Gulliver'
KPG-44D
KEN-3
TK-2102
KPG-55D
KEN-2
TK-2106Z
Alexander Ivanov
KPG-55D
KEN-2
TK-2107
KEN-2
TK-2118
Alexander 'Gulliver'
KPG-69D
KEN-2
TK-2160
KEN-2
TK-2170
KPG-101D
KEN-2
TK-2200
Serguey Bunin
KPG-88D
KEN-2
TK-2202
KPG-87D
KEN-2
TK-2202L
KPG-87D v.2.3
KEN-2
TK-2206
KEN-2
TK-2207
KEN-2
TK-2212
KPG-100D
KEN-2
TK-3101
Alexander 'Gulliver'
KPG-48D
KEN-2
TK-3102
KPG-55D
KEN-2
TK-3107
KEN-2
TK-3118
Alexander 'Gulliver'
KPG-69D
KEN-2
TK-3160
KPG-82D
KEN-2
TK-3168
Serguey Bunin
KPG-82D
KEN-2
TK-3170
KPG-101D
KEN-2
TK-3200
Serguey Bunin
KPG-88D
KEN-2
TK-3202
KEN-2
TK-3202L
KPG-87D v.2.3
KEN-2
TK-3206
KPG-87D
KEN-2
TK-3207
KPG-87D
KEN-2
TK-3212
KPG-100D
KEN-2
TK-3217
Alexander Nesterov
KPG-100D
KEN-2
TK-7100
KPG-80D
KEN-1B
TK-7102
Zinnur Nigmatulin
KPG-70D
KEN-1B
TK-7108
KPG-70D
KEN-1B
TK-7160
KPG-99D
KEN-1B
TK-8102
KPG-70D
KEN-1B
TK-8108
KPG-70D
KEN-1B
TK-8160
KPG-99D
KEN-1B
TK-8160H
the author
KPG-99D
KEN-1B
TK-8162E
KPG-99D(E)
KEN-1B
TK-8180
KPG-89D
KEN-1B
KPG-55D
KEN-2
Ukrainian KENWOOD
TK-2170 (the same
as TK-2107)
Roman UT5ERP
KEN-2
KEN-1B
KPG-70D
KEN-1B
Alexander Nesterov
KPG-56D
KEN-1B
Alexander Nesterov
KPG-99D
KEN-1B
PT-2208S
Vladimir Vashchenko,
Nikolay aka 'KOKA'
KSP-11
KEN-2
PT-3208S
Vladimir Vashchenko,
ALEKSEY30, Nikolay aka
'KOKA'
KSP-11
KEN-2
PT-3209
Vladimir Vashchenko,
ALEKSEY30
KSP-11
KEN-2
PT-3288S
Vladimir Vashchenko
KEN-2
TA-240
Viacheslav UR5ROZ,
Alexander Nesterov
KEN-2
TC-268 (Eclipse)
KEN-2
TC-268S (Eclipse)
KEN-2
TC-270
KEN-2
TC-368 (Eclipse)
KEN-2
TC-368S (Eclipse)
KEN-2
TC-370
KEN-2
TC-500
TC-700
Vladislav Bashaev
HT700E
KIRISUN
HYT
HYT-1
TITAN
RN-102
KEN-2
MCP-318
KEN-2
MCP-318
KEN-2
TWR
DJ-344KU
LINTON
LT-2188
SKY-COM
SC-R706
Serguey Bunin
SCR706
KEN-2
Vladimir RV6AMF
KPG-55D
KEN-2
SOONTONE
ST-518
AJETRAYS
AJ-344V
Valery UA9MRQ
KEN-2
YAESU / VERTEX
VX-1R
Yevgueny RA9MHL,
Alexander 'Gulliver'
VX1
Y/V-1B
VX-2R
VX2, VX2
commander
Y/V-1B
VX-5R
VX5
Y/V-1B
VX-6R
RV9CT
VX6
Y/V-1B
VX-7R
VX7
Y/V-1B
FT-10R
Y/V-1B
VX-10
Y/V-1B
FT-11R
Igor Marzaganov
WFT11
Y/V-1A
FT-40R
WFT40
Y/V-1B
FT-41R
the author
WFT41
Y/V-1A
FT-50R
WFT50
Y/V-1B
FT-51R
WFT51
Y/V-1B
FT-60R
Y/V-1B
VX-160
Y/V-1B
VX-160E
CE51
Y/V-1B
VX-180
CE44, CE51
Y/V-1B
VX-180E
Ramil Yunusov
CE51
Y/V-1B
VX-200
Yevgueny RA9MHL,
Yevgueny RU6AI, Alexander CE9
Ivanov, RV9CT
Y/V-1B
VX-210A
CE45
Y/V-1B
VX-210
Vladimir Vashchenko,
Alexander Ivanov, Serguey
Bunin, the author, Igor
RA0FMF
CE29
Y/V-1B
VX-300
Y/V-1B
VX-400
CE24
Y/V-1B
VX-414
Roman RN3ADR
CE64
Y/V-1B
VX-417
Serguey Bunin
CE64
Y/V-1B
VX-420
Igor RA0FMF
CE64
Y/V-1B
VX-500
Yevgueny RA9MHL,
Alexander 'Gulliver',
CE6
Alexander Nesterov, Roman
RV3SBQ, Andrey Andrianov
Y/V-1B
VX-800
Vladimir Vashchenko
Y/V-3
FT-857D
Y/V-4
FT-897
Y/V-4
VX-1000
Valery UA6LPG
FTL-1011
Y/V-2
FTL-1014
Alexander 'Gulliver'
Y/V-2
VX-1700
CE77
Y/V-4
VX-2000
Y/V-2
FTH-2008
CE2
Y/V-1C
FTH-2009
Victoria Chernigovskaya
CE2
Y/V-1C
FTH-2010
CE2
Y/V-1C
FTL-2011
CE49
Y/V-2
Y/V-2
CE82
Y/V-2
VX-2200
CE82
Y/V-2
VX-2500
CE63
Y/V-2
VX-3000
CE19
Y/V-2
VX-3200
CE52
Y/V-2
VX-4000
Y/V-3
VX-4107
Y/V-2
VXR-5000
Y/V-2
VX-6000
Vladimir Vashchenko
CE49
Y/V-3
VXR-7000
Alexander Tataurov (a
computer with the i80486
processor), Vladislav
Bashaev
CE27
Y/V-2
FTH-7008
Ramunas Majauskas
CE2
Y/V-1C
FTL-7011
Y/V-2
FTL-7014
CE5
Y/V-2
FT-8500
Alexander RA1AGA
WFT8500
Y/V-2
FT-8800R
FTB8800
Y/V-2
M10
Alexander Nesterov
GM300 R04.00.00
MOT-3
P020
MOT-2
R05.04
MOT-2
CE59
MOTOROLA
CP040
Valery UA6LPG
R02.02.00
MOT-2
P040
MOT-2
P080
MOT-2
GP68
MOT-1
GP88
GP300 R01.00.00
MOT-1
M100 RADIUS
Radius Mobile
R08.00.00
MOT-3
M110
MOT-3
P110
MOT-1
M120
MOT-3
M130
MOT-3
CM-140
GM300 R04.00.00
MOT-5A,
MOT-5B
MOT-3,
MOT-5B
CP-140
MOT-2
CM-160
MOT-5A,
MOT-5B
GM-160
R04.00.00, R06.04
MOT-3
CP-160
Ramil Yunusov
R05.01
MOT-2
CP-180
R05.00
MOT-2
EM-200
CPS V5.05
MOT-5B
M208
MOT-3
M216
MOT-3
GM-300
GP-300
RADMBL
GP300 R07.00.00,
GP-300IVG
MOT-1
MOT-1
MOT-6
GM-320
Andrey Shunko
R03.07.04
MOT-3
GP-320
R03.03.00 rus +
Tuner for
Professional Radios
(R02.00.03),
R03.07.04
MOT-4
ZR320 interface
Anton UA6JHM
GM300 R05.00.00
MOT-3,
MOT-5B
GP-340
R03.01.00,
D03.02.01,
R03.03.00 rus,
R03.07.04
MOT-4
CM-340
GM-340
R03.01.00,
D03.02.01,
R03.03.00 rus,
R03.00.01
MOT-5A,
MOT-5B
MOT-3
GM-350
R03.00.08,
R03.01.06,
R03.01.09,
R03.01.08
MOT-3
CM-360
R04.00, R05.04
MOT-5A,
MOT-5B
GP-360
MOT-4
GM-360
MOT-3
GP-380
Oleg RN3AUM
R03.07.04
MOT-4
EM-400
CPS V5.05
MOT-5B
EP-450
CPS V5.05
MOT-2
GM-600
R02.00.20
MOT-3
GP-600
Igor Saprykin
R03.03.09,
R02.00.20
MOT-1
GM-640
Oleg RN3AUM
R00.07.04
MOT-3
GP-640
R00.07.04
MOT-4
GM-660
Oleg RN3AUM
R00.07.04
MOT-3
GP-660
Oleg RN3AUM
R00.07.04
MOT-4
GM-680
Oleg RN3AUM
R00.07.04
MOT-3
GP-680
R00.05.02
MOT-4
GM-950
MOT-5B
GM-1200E
Roman RN3ADR
R00.01.05
MOT-5B
HT-1250
Oleg RN3AUM
R06.08.05
MOT-4
GM-1280
R00.04.04,
R00.07.04
MOT-3
GP-1280
Alexander 'Gulliver'
R00.07.04
MOT-4
HT-1550
Oleg RN3AUM
R06.08.05
MOT-4
HT-1550XS
Oleg RN3AUM
R06.08.05
MOT-4
LTS 2000
MOT-3
MAXTRAC
R07.02.00A
MOT-3
MaxTrac Trunked
Mobile R05.02.00
MOT-3
MAXTRUNK (trunked
Belu Daniel (Romania)
MAXTRAC)
PRO3100
Professional Radio
CPS R6.09.06
MOT-3
PRO3150
MOT-2
PRO5100
Professional Radio
CPS R6.09.06
MOT-3
PRO5150
Professional Radio
CPS R6.09.06
MOT-4
PRO7100
Professional Radio
CPS R6.09.06
MOT-3
PRO5150
Professional Radio
CPS R6.09.06
MOT-4
VOLNA
Volna-101
MOT-3
Volna-201
MOT-3
Volna-302
MOT-2
Alexander UA4LOR
ALTAVIA v2.01
ALT-1
Granit-202
Valery UA6LPG
2P-21
Valery UA9MRQ
2P-23
GRA-1
KLYON
Alexey EW7AT
R23M10
GRA-1
MOTOROLA
R03.01.00,
D03.02.01
ALTAVIA
Altavia 301M
GRANIT
GRA-2
ICOM
IC-T2
CST2
ICO-2
IC-F3
CSF3
ICO-2
IC-F3GS
CSF3G
ICO-2
IC-F3GT
CSF3G
ICO-2
IC-F4
ICO-2
IC-F4GS
ICO-2
IC-F4GT
CSF3G
ICO-2
IC-R5 scanner
UR5WKB
CSR5
ICO-2
IC-T7
Ramil Yunusov
CST7
ICO-2
IC-V8
CSV8
ICO-2
IC-F10
Pavel UA1ZCC
CSF10
ICO-2
IC-R10 scanner
Alexander Nesterov
CSR10
ICO-2
IC-F11
CSF11
ICO-2
IC-F14
CSF14
ICO-2
IC-F16
ICO-2
IC-F21
ICO-2
Ramil Yunusov
CSF14
ICO-2
IC-F26
CSF14
ICO-2
IC-F30
Roman RN3ADR
EX-1489
ICO-4
IC-F30LT
EX-1489
ICO-4
IC-W31N
Andrey UA3USQ
IC-F40LT
EX-1489
ICO-4
IC-F41GT
Vladislav Bashaev
CSF40G
ICO-5
IC-M45EURO
Igor UR5YEI
CSM45
ICO-2
IC-F50
Ramil Yunusov
CSF50
ICO-2
IC-F60
Ramil Yunusov
CSF50
ICO-2
IC-A110
Valery UA9MRQ
CSA110
ICO-2
IC-F110
ICO-3
IC-F110S
Vladimir Vashchenko,
Alexander Nesterov, Dmitry
Kosolap, Nikolay UT5VF,
Alexander UR5TID, Albina
Luchaninova, Zinnur
Nigmatulin, Victoria
Chernigovskaya
ICO-3
IC-F111
Alexander UA4LOR,
ALEKSEY30, MALE aka
Dmitry, Andrey Kolennikov,
Alexander Nesterov, Roman
RV3SBQ, Alexander
UA9CEW, Roman RN3ADR,
CSF100
Ramil Yunusov, Serguey
Olar, Zinnur Nigmatulin,
Alexander UR5TID, Albina
Luchaninova, Serguey
Cherkasov
ICO-3
IC-F111S
Serguey RX6LRE,
ALEKSEY30, Alexander
Nesterov, Roman RV3SBQ,
Albina Luchaninova, Mikhail
aka Neptun
CSF100S
ICO-3
IC-F121
CSF100, CSF121clo
v1.7
ICO-3
IC-F121S
CSF100S
ICO-3
IC-F210
CSF100 ver.1.5
ICO-3
CSF100S
Oleg RA9JM
IC-F211
ICO-3
IC-F211S
CSF100S
ICO-3
IC-F310
CSF300
ICO-1
IC-F310S
ICO-1
IC-F320
ICO-1
IC-F320S
ICO-1
IC-F410
CSF300
ICO-1
IC-F410S
Alexander Nesterov
CSF300S
ICO-1
IC-F420
CSF300
ICO-1
IC-F420S
CSF300S
ICO-1
IC-F520
Roman RN3ADR
CSF500
ICO-3
IC-F521
Roman RV3SBQ
CSF500
ICO-3
IC-F621
the author
CSF500
ICO-3
IC-M710
Igor RA0FMF
Ex1726
ICO-1
IC-F1010
EX1764
ICO-1
IC-F1020
EX1764
ICO-1
IC-F2010
Serguey Bunin
EX1764
ICO-2
IC-F2020
EX1764
ICO-2
IC-FR3000
CSFR3000
ICO-1
IC-FR4000
Ramil Yunusov
CSFR3000
ICO-1
IC-V8000
Igor RA0FMF
CSV8000
ICO-2
ALINCO
CSF100S
ICO-3
DR-B1
DRB1
ICO-2
DR-130
Ramil Yunusov
DR130
ICO-2
DR-135
ICO-2
DR-135F
ICO-2
DR-140
DR140
ICO-2
DJ-190
Ramil Yunusov
DJ190
ICO-2
DJ-191
ICO-2
DJ-193
Alexander Nesterov
DJ195
ICO-2
DJ-195
DJ195
ICO-2
DR-235
Vladimir Vashchenko
DR135
ICO-2
DR-430
Ramil Yunusov
DR130
ICO-2
DR-435
DR135
ICO-2
DR-440
Ramil Yunusov
DR140
ICO-2
DJ-490
Ramil Yunusov
DJ190
ICO-2
DJ-491
DJ191
ICO-2
DJ-495
Ramil Yunusov
DJ195
ICO-2
DR-605
Ramil Yunusov
DR605
ICO-2
Alexander Nesterov
T2000 Conventional
Programming
Application
TAI-1, TAI1A
Alexander Nesterov
SL500
MAX-1
TAIT
T2010
MAXON
SL500
STANDARD
HX-190
Alexander 'Gulliver'
STA-1
GX-2000U
Alexander UA9CEE
PPS2000
STA-1
SYTCOM 38
DRA-1
VT-44H
RV9CT
VT-44H
KEN-2
VT-44 MASTER
KEN-2
VT-44 Military
Alexander 'Gulliver'
WPG-46A
VEC-1
VT-44 PRO
KEN-2
Roman RN3ADR
FPP v.5.32
SIM-1
H200
ALA-1
DRAGON
SY-5430 (3 ch.
programmable)
VECTOR
SIMOCO
SRM-9030
ALAN
HM-200
FAKE RADIOS
Pseudo-ICOM IC-F21
KEN-2
Pseudo-KENWOOD
TK-2107
Alexander Nesterov (a
computer with the iCeleron
700 MHz processor),
Serguey Olar, Alexander
UR5TID
KPG-55D
KEN-2
Pseudo-KENWOOD
TK-2107L
PGM_v1.0,
PGM_v1.02
(Windows XP)
KEN-2
Pseudo-KENWOOD
TK-2170
KPG-101D
KEN-2
Pseudo-KENWOOD
YQ 3000(2)
KEN-2
Pseudo-KENWOOD
TK-3107
Alexander RA0CGP
KEN-2
Pseudo-KENWOOD
KPG-55D
KEN-2
TK-3108
itself as KIRISUN)
Pseudo-KENWOOD
TK-3207
KEN-2
Pseudo-KENWOOD
TK-3260
Valery Babiy
KPG-87D
KEN-2
Pseudo-MOTOROLA
GP-327
KPG-87D
KEN-2
Pseudo-MOTOROLA
GP-680
Valery UA9MRQ
R00.05.02
MOT-4
Pseudo-MOTOROLA
T5930
Alexander Nesterov,
Alexander 'Gulliver'
(KENWOOD portables
connector, reports itself as
KENWOOD TK-3107 !)
KPG-55D
KEN-2
Pseudo-KENWOOD
TK-7020-1
Alexander UR5TID
KPG-80D
KEN-1B
the author's
Y/V-1A
CI-V interface
OPTOELECTRONICS
the author
DC440 decoder
SIEMENS cellular phones
A35
Freia, etc.
PHO-3
C35i
Hyper Terminal,
c3i_xxxx, ...
PHO-3
M35
Hyper Terminal,
c35i_xxxx, ...
PHO-3
S35
Hyper Terminal,
Winswup32,
PHO-3
ZeeSiemensG3,
S35C35M35 Explorer
ME45
PHO-3
S45
Hyper Terminal
PHO-3
SL45i
Hyper Terminal
PHO-3
C60
Hyper Terminal
PHO-3
The correctly assembled programming cable needs no adjustment. But... Let's see
the troubleshooting technique if the cable does not work..
1. Check the assembly carefully. Check the component correspondence
with the schematic diagram. Here are the most common errors in the
programming cable assembly.
Sometimes the VT2 PNP transistor is replaced with an NPN transistor.
Obviously it will not work.
Some people try to use any awailable transistors instead of denoted. In this
case the work is not guaranteed.
Sometimes the prescribed voltage regulator is replaced with 78L05, even
with 7805. In this case the cable can not be powered from the port reliably.
Those regulator ICs should be used with the external power supply only with
the appropriate C4 capacitance.
Some people try to use different resistor values. They think it will do. No, it
will not.
VD1, VD2, VD5, VD6, VD8 diodes should be low power fast silicon ones.
Power rectifier diodes and germanium diodes will not work.
Some guys think the more is the C4 capacitance the better. That is wrong. If
the LP2950 is used C4 should be 1.0... 4.7 uF.
2. Make sure no wires are broken and all contacts are reliable, especially in
a connection to the radio. Broken wires are the frequent reason of malfunction.
Please note ! Connection to the radio must be reliable. Round stereo jacks must be
plugged in firmly until stop. Their flanges may be ground off if needed. RJ-11 and
RJ-45 connectors get oxidized easily. Socket contacts may be cleaned with an
erasor scrap. Jack contacts may be cleaned with a thick needle.
3. Make sure the regulator output voltage is 5V +/- .1V. The wrong voltage
may occur due to assembling defects or bad serial port extension pieces. Please
note: the serial port may power up the circuit only while accessing the radio. Some
software (especially made by Motorola) gives no power from the port, so external
power is needed.
4. Make sure the software and operational system are correct. The most
common mistake is running DOS programs under Windows. Port accessing
technique under Windows is different, DOS programs access ports incorrectly. Use
MS DOS or Windows'98 in DOS mode for such programs.
5. Make sure the radio is powered correctly, is turned on and functions
properly. Uncareful trunking board removing or burning radio inner circuits with
the bad programming cable makes the radio unprogrammable. The battery of a
portable radio must be charged completely. A mobile radio must be powered with
an appropriate power supply.
6. Consider the specific features of the radio being programmed. Most radios
are put in programming (cloning) mode automatically. Some radios are put in
programming (cloning) mode manually by pressing a specific set of buttons while
turning on. Some radios need pressing specified buttons to start data upload or
download. Some radios may be locked to prevent reading or writing data.
Refer to radio manuals or search the web for information.
The author especially appreciates the active participance of Sergey UA9UDQ,
Yevgueny RA9MHL, Valery UA6LPG, Alexander 'Gulliver', Vladimir Vashchenko,
Sergey Bunin, Pavel RA0SJB, MALE aka Dmitry, Alexander Nesterov, Nikolay aka
'KOKA', Belu Daniel, Norman Miller, Roman RN3ADR, Roman RV3SBQ, Ramil
Yunusov, Albina Luchaninova, Oleg EX8MLT, Alexander Ivanov, Alexander UA9CEE,
Yuri US5IVZ, Valery UA9MRQ, Victoria Chernigovskaya. Special thanks to Valery
UA6LPG for the updated PCB design. Special thanks to Gyula HA7JCA for the
14.06.2010 21:37 ...
--
14.06.2010 21:33 ...
--
13.06.2010 13:32 Sergeyye ! - , ?
... -- ...
12.06.2010 11:45 , 2...
--
11.06.2010 11:25 KENWOOD TK-3107 .
KPG-... -- Sergeyye
08.06.2010 09:10 KPG 29 D... -- cvmjl,
07.06.2010 21:57 ic-F110... -- US8IDO
07.06.2010 21:51 110... -- us8ido
07.06.2010 20:57 , YAESU
FTH-... -- rk3dim
07.06.2010 18:21 , ! (-35) ... -delta777
04.06.2010 15:31 . - V...
--
04.06.2010 10:09
MOTOROLL... -- bakesha
28.05.2010 21:31 ALINCO DJ-344 MCP-318... -6
27.05.2010 19:21 radar55719 CLONE NG, ...
--
27.05.2010 18:17 Icom IC-F210 "LONE NG" , ...
-- radar55719
24.05.2010 21:32 , - Motorola cm34...
-- Ivan
24.05.2010 16:36 ! ...
-24.05.2010 10:27 bonjour svp . je cherche le soft pour programmer les motorola ... -- soltani
23.05.2010 17:59 . - V...
--
22.05.2010 17:33 101-23
(G... -- ru6fb
20.05.2010 18:36 gm160... -- wesam
18.05.2010 22:48 ... -- lausov
18.05.2010 17:50 lausov , ... -USER
18.05.2010 00:38 vertex vx 417 ... --
lausov
17.05.2010 20:45 tidak ada... -- daeng gassing...
17.05.2010 18:18 VX-500. "---...
--
17.05.2010 08:33 vertex vx 417 ... -lausov
14.05.2010 09:14 motorola p020 ... -- Andrei
12.05.2010 17:00 , KPG-8OD ...
-- !
12.05.2010 15:12 . otorola GM DATABOX... -
12.05.2010 11:52 ID KPG-101d... -12.05.2010 09:57 ! , , ... - ...
11.05.2010 16:03 ! , - . ...
--
11.05.2010 15:58 ! , - ...
--
11.05.2010 07:50 ! ...
-- ...
10.05.2010 15:47 ! , , ...
--
10.05.2010 15:07 ! , , ...
--
10.05.2010 15:03 ! , , ...
--
08.05.2010 21:13 !
KENWOOD TK-7100. ... -- !
07.05.2010 17:07 ! GP340 ...
-- ...
07.05.2010 17:03 RadioAmateur ! , , ,... - ...
07.05.2010 14:43 , . ,...
-- Radio...
07.05.2010 09:28 , !... --
07.05.2010 09:25 ! ...
--
04.05.2010 22:06 , , .... ...... ... -MgHerz
02.05.2010 19:25 . ...
-- RA0LHI...
24.04.2010 18:14 , , . ...
-- , 3726
23.04.2010 23:46 , GP680? / ... -, RA1A...
23.04.2010 21:24 GP-340 R03.07.04... --
23.04.2010 18:53 GP-340 R03.07.04 ... -- vladimirovich60...
22.04.2010 21:44 dfhh... -- fgjrj
21.04.2010 17:03 programas ... -- anderson
21.04.2010 12:55 Hi Im from Poland I looking for software R03.02.07 to motorola ... -- gomens
21.04.2010 07:49 ! , ...
-- ...
21.04.2010 07:48 ra0lhi ! - - ... - ...
20.04.2010 15:24 . ...
-- michail
19.04.2010 17:46 ! , ... -ra0lhi
18.04.2010 10:15 ,
. ... --
-- ru6fb
19.03.2010 15:28 ! . , ,...
-- ...
19.03.2010 14:38 ! Motorola CP140...
-- Radist
19.03.2010 13:45 ! , .
... --
18.03.2010 05:42 SLAVA! motorola gm300 Win ...
-18.03.2010 03:59 tk 2302... -- Swampfox
15.03.2010 19:16 vertex ... -- doblek
15.03.2010 19:15 vertex vx2000u... -- doblek
15.03.2010 17:40 ! : ...
-- SLAVA
14.03.2010 18:57 Serj ! , , . ... - ...
14.03.2010 18:51 ! . , ...
-- ...
14.03.2010 12:13 ! 1.5-2 ...
--
13.03.2010 12:58 ! , ...
-- Serj
07.03.2010 20:49 ! ! , ...
-- ...
07.03.2010 17:46 2 Tevion PMR3000 ...
--
07.03.2010 13:42 , , ...
--
06.03.2010 12:39 (110-130 ) ...
-04.03.2010 20:16 KPG-118D ...
-- McAndy
01.03.2010 16:53 ! ROGER KM1518... -
28.02.2010 13:41 SLAVA ... --
27.02.2010 22:01 ... -- salah
27.02.2010 05:37 ... -- jojo laguisma...
26.02.2010 19:31 !
MOTORO... -- SLAVA
26.02.2010 08:04 Motorola CP-040 ver. r03.00.01 ... -UK8GSA
24.02.2010 16:23 ... -- rada
24.02.2010 16:07 , roger km 1518!... --
24.02.2010 14:15 . , -, ...
--
24.02.2010 00:55 IC- F...
-- vigrin
23.02.2010 16:25 KPG-87D... -- US7IHA
21.02.2010 11:05 VX-2000V . ... -
20.02.2010 22:43 can the icom program for ic-f320-6 be used with win xp pro... -- ve2nwt
20.02.2010 21:02 bzxr... -- koryagen
20.02.2010 08:18 ! -! AR-146 ...
--
19.02.2010 13:49 ! . - ...
-- ...
19.02.2010 13:08 , KENWOOD - 2260 - ...
-- nik13
18.02.2010 16:21 ...
--
vonav... --
27.01.2010 19:14 ! , COM . ... -
26.01.2010 21:41 , VD3 VD4, ...
--
26.01.2010 15:13 KPG KENWOOD, .
... -- McAndy
22.01.2010 12:51 Alan 43 HM. ? ...
--
22.01.2010 11:56 i want software for motorola gp280 16 channel full... -- sami
19.01.2010 08:00 mikolasnn ! , ALINCO DR-130 ...
-- ...
19.01.2010 07:06 Motorola CM160, ...
-- vlad89
19.01.2010 07:01 ALINCO DR-130 ERW-2B DR-130...
-- mikolasnn
18.01.2010 20:09 Motorola CP040... -- pc01
18.01.2010 11:06 KPG 118D, : 1. KPG48D TK-3101/... -nE sPROsTa
18.01.2010 01:26 . ICOM F-320S, 5. ...
-- lirun
17.01.2010 14:27 ICOM IC-F3 ...
-- ,RW4LAF...
17.01.2010 06:32 !!! Kenwood TK-2260-2 ...
--
16.01.2010 10:30 chinese ham... -- veidychen
15.01.2010 21:20 BOA TARDE PRECISO URGENTIMENTE DO PROGRAMA DO SOTWARE
DO VERTEX S... -- ARAGAO
15.01.2010 17:15 Motorola P020 CM140... -- Nikolay
14.01.2010 19:32 ,! , "Roger"...... -barhan070
14.01.2010 09:02 barhan070 ! -. , ... - ...
14.01.2010 08:58 Levo ! . ...
-- ...
13.01.2010 20:22 ! ,, ...
-- barhan070
13.01.2010 10:43 ICOM F310... -- Levo
30.12.2009 23:10 HOLA MUCHO GUSTA QUISIERA QUE ME AYUDARAN TENGO UN RADIO
BASE TK ... -- ALEX
29.12.2009 20:57 ICOM IC F111...
-- gleb
29.12.2009 16:39 otkudo mojno dostat programmu dlya programirovanie icom ic f 16?... -- vigo
29.12.2009 14:45 HYT-620... --
29.12.2009 14:18 ! KPG-89D ...
--
28.12.2009 22:58 -040
13... -- Oleg P
28.12.2009 16:55 , Kenwood TK-3207(1).
... -26.12.2009 12:08 Soft 3207, ?... -26.12.2009 11:05 yebo gogo... -- deskim
26.12.2009 09:21 ICOM IC F16 ICOM IC F111 ...
-- knr
23.12.2009 12:39 dvdfgerfcrfcrcvfgbdfgdfgd... -- dfsdfsdfsd
22.12.2009 08:13 ! . ... - ...
22.12.2009 00:43 Icom F110S, Reset ? ...
--
18.12.2009 21:33 terimakasih... -- yohnny
... -- ...
16.11.2009 11:25 ! kenwood tk-790 ...
-- senseu2008
15.11.2009 11:20 (jamigo) ! 2-21 ... -Slava
15.11.2009 10:54 mikolasnn ! ... -Slava
13.11.2009 14:36 GM-340 , GM-300 . ...
-- mikolasnn
13.11.2009 09:41 mikolasnn ! GM-300 ...
-- ...
12.11.2009 13:58 . GM-300...
-- mikolasnn
12.11.2009 13:52 Motorola GM-300, . ...
-- mikolasnn
05.11.2009 21:55 Alex ! , . ... - ...
05.11.2009 21:53 jamigo ! , , !... -- ...
05.11.2009 19:42 : 278, ... -Alex
05.11.2009 15:10 . .... -- jamigo
05.11.2009 10:16 jamigo ! , ... - ...
04.11.2009 19:53 , ...
-- jamigo
04.11.2009 19:48 .
... -- jamigo
04.11.2009 11:09 motorola cp040 software downlaod... -- baxa
04.11.2009 10:48 gfffffffffffffffffffffffffhhhhhhhhhhhhhhhhh... -- vfcvcxvfff
30.10.2009 19:13 i need download Professional GP300/GM300 Series CPS (R05.08.02_EN...
-- mersad
30.10.2009 15:27 KENWOD TK
220... -- maloyy
30.10.2009 13:57 podskazite kakaia versia CPS nuzna dlia Motorola cm140 ver R04.00... -Real
30.10.2009 13:55 cps
... -- Real
30.10.2009 07:24 maks ! , ...
-- ...
30.10.2009 07:17 vladislav ! - . CM-160 - -... - ...
30.10.2009 07:11 jamigo ! , . ...
-- ...
29.10.2009 18:54 2 kenwwod TK-2206. ...
-- maks
28.10.2009 07:05 Motorola
CM1... -- vladislav
27.10.2009 19:54 , mikoolasnn, !!!...
-- jamigo
27.10.2009 09:42 Motorola CM160? ...
-- vlad_89rus
21.10.2009 08:52 FREDERIC KOUADIO! upload.com.ua/get/900295618... --
21.10.2009 02:40 MOTOROLA CP040 SOFTWARE DOWNLOAD... -- FREDERIC KOUADI...
19.10.2009 20:10 ...
-- lexx 1974
18.10.2009 18:18 C... -- RU9HT
16.10.2009 20:18 ! "" , - ...
-- ...
13.10.2009 18:43 ! 3107
... --
Quinte...
23.09.2009 14:49 Sobesednik ! ...
-- ...
23.09.2009 10:25 , . . . ...
-- Sobesednik
22.09.2009 19:12 jamigo ! (, ), ... - ...
22.09.2009 16:35 jamigo . Icom IC-F11 . ... -mikoolasnn
22.09.2009 11:13 ? 15 !!! ...
--
22.09.2009 11:11 Icom IC-F11 soft CSF11 v1.2. ... -jamigo
21.09.2009 00:11 Sobesednik! hamradio.online.ru/ftp3/dw.php?P_%20... -
20.09.2009 07:04 . CPS R02.02.00 P040. R02...
-- Sobesednik
19.09.2009 02:06 SIMOCO SRP8030/31
.tmcradio.com/... -18.09.2009 12:41 ? 15 !!! ... -17.09.2009 19:39 , rz6aqt! ? KPG49D, ...
--
17.09.2009 14:23 , h t t p://w... -olegscorpion...
17.09.2009 14:08 SIMOCO
SRP8030/31?... -- mikolasnn
17.09.2009 12:14 kenwood tk-280 ver 2.0 ...
-- , rz6aqt...
14.09.2009 15:01 ...
--
14.09.2009 14:53 . . Vertex V...
-- ,ew1ra...
12.09.2009 23:31 tnx. 73... -- TA2DC MEHMET ...
12.09.2009 00:33 ! . ... -
11.09.2009 16:42 ! , - RIB ...
--
11.09.2009 00:29 ! . , ... -
10.09.2009 22:58 ! , COM 9 . ...
--
10.09.2009 20:29 KPG-89D... -10.09.2009 17:53 . -, RIB(... -
09.09.2009 01:14 gp3188... -- rara
08.09.2009 17:46 C-est bon ... -- Cyriaque
03.09.2009 08:11 dmiman! .... --
03.09.2009 07:30 Motorola ...
-- dmiman
02.09.2009 11:03 ! , . ... - ...
02.09.2009 08:14 , . ...
-- ra0fmf/...
31.08.2009 19:08 Sea l05! upload.com.ua/get/900295618 ... --
31.08.2009 17:34 "-140,-360"...... -- Sea l05
31.08.2009 16:01 ! . ...
-- ...
31.08.2009 13:10 , KPG55D
... -- 312095...
30.08.2009 23:32 ( ...
--
30.08.2009 17:09 RA9YON! Motorola MC2100 ...
--
28.08.2009 08:38 Motorola MC2100. Motorola MC2100 ...
-- RA9YON
26.08.2009 02:29 ! forum.cqham.ru/viewtopic.php?t=19939... -
25.08.2009 16:10 motorola CP140 ...
--
21.08.2009 03:09 ua0jii! GM300 batlabs... -
20.08.2009 09:20 gm 300 /.... -20.08.2009 09:16 gm 300... -- ua0jii
20.08.2009 08:36 Motorola GP-227 Motorol... -19.08.2009 18:30 ! Motorola GP-227. ...
-- 312095...
19.08.2009 02:41 RA1WJ upload.com.ua/get/900295618... -
19.08.2009 01:50 muy buen articulo... -- maturino
18.08.2009 23:43 !!! CM-140 CP-140. ... - RA1WJ...
18.08.2009 13:17 KPG-29D . ,
... -- ...
18.08.2009 13:10 , , 768 ! ... -brom
17.08.2009 11:10 -102... -15.08.2009 21:44 ...
-15.08.2009 02:19 saludos a todos..!! necesito el diagrama del programador de la me... -gusy180662
14.08.2009 18:49 tnx... -- james richard...
14.08.2009 16:30 ( $35-... -brom
14.08.2009 12:28 Kenwood 768 . G , ...
-- brom
13.08.2009 20:47 brom! Kenwood 768? ...
--
13.08.2009 18:21 ! ! Kenwood 768.
... -- brom
12.08.2009 15:05 mikolasnn! upload.com.ua/get/900295618... --
12.08.2009 10:40 . Motorola CP-140,... -mikolasnn
12.08.2009 10:40 . Motorola CP-140,... -mikolasnn
12.08.2009 05:00 ! .... --
11.08.2009 20:09 TK-868G W98
... -- ru6fb
11.08.2009 19:52 ,
... -- ru6fb
11.08.2009 14:47 56 win 98. ... -
11.08.2009 12:40 ! TK-868G
... -- ...
11.08.2009 12:36 ELECTRA RU 210 ...
--
11.08.2009 08:42 ! radioscanner.ru/files/download/fi... -
11.08.2009 08:07 768G. ...
--
10.08.2009 14:44 ! TK-768G, TK-768 - ...
-- ...
10.08.2009 14:08 -768 ... -
06.08.2009 18:49 hi... -- hs2qfw
05.08.2009 13:14 ! TK-768G, ...
-- ...
04.08.2009 13:27 please check all connection and communication port setting.... -04.08.2009 12:29 ! ...
-- ...
04.08.2009 08:13 . ...
--
02.08.2009 21:21 soltani ! Cherchez sur le Web. Par exemple, on peut le trouver ic... -Yevgueny Androp...
02.08.2009 17:58 soft pour programmer le tk2160 KPG 82D... -- soltani
02.08.2009 17:57 soft pour programmer le tk2160... -- soltani
01.08.2009 01:08 Ra3vie GM360 R03.01.02 ... -- Alex
30.07.2009 15:20 ! , ...
-- ...
30.07.2009 13:04 / alan 42 !... -- Taksist Ed
30.07.2009 13:00 alan 42 !... -Taksist Ed
29.07.2009 15:40 ! ! 4...
--
29.07.2009 12:46
... -- ievfr
28.07.2009 20:39 ! ...
-- ...
28.07.2009 18:45 Vertex VX-160U. , 44 ...
--
28.07.2009 11:04 !!! TK-7060 ( TK-760G), ... -
24.07.2009 12:04 GP680. ...
-- mif
22.07.2009 18:50 vertex vx-3000 ? ...
--
21.07.2009 15:55 Ra3vie ! , ...
-- ...
21.07.2009 12:53 (R03.09.03) " - ... -Ra3vie
21.07.2009 12:36 Ra3vie ! , . ... - ...
21.07.2009 12:06 ! , - ...
-- Ra3vie
21.07.2009 11:51 Ra3vie ! . - . ...
-- ...
21.07.2009 11:30 ! .. , ... -Ra3vie
21.07.2009 11:15 Ra3vie ! " ...
-- ...
21.07.2009 10:35 RJ-45 -3 ...
-- Ra3vie
19.07.2009 13:55 !!! ...
--
16.07.2009 10:58 , ) ...
--
15.07.2009 17:25 , Icom -f30gt, ...
--
12.07.2009 13:11 ! . . / ., ... - ...
11.07.2009 00:24 ! -2207, . . ... --
06.07.2009 22:19 ! , , ... - ...
06.07.2009 15:45 ! ....
--
04.07.2009 16:02 froes radioscanner.ru/files/download/file8179/tc700.rar... --
04.07.2009 01:45 I need of the software for programing frequency of the HYT TC-700... -froes
03.07.2009 17:15 Rus ! , . ...
-- ...
03.07.2009 12:23 ...
-- Rus
03.07.2009 01:37 -
OPC-... -- Genn
02.07.2009 07:40 Genn! ICOM F-310 ( S ?) IC-F310 ... -02.07.2009 03:46 . . /. ICOM F-310 ... -Genn
01.07.2009 20:04 vertex vx-2000 , vx-3000 ...
--
01.07.2009 11:33 Motorola GP14... --
01.07.2009 01:34 NESECITO EL PROGRAMA KPG-55D... -- TEOTONIO BRANCO...
29.06.2009 22:02 we... -- mei
29.06.2009 22:01 ok... -- Wojtek
26.06.2009 22:13 mastak1972 ! , ...
-- ...
25.06.2009 20:23 test... -- rob
25.06.2009 18:14 mastak1972! "... : ... -
25.06.2009 11:24 ERW-4 Alinco... -
25.06.2009 07:26 : ARXD, .... -mastak1972
25.06.2009 06:55 , , . ...
-- mastak1972
24.06.2009 14:35 mastak1972! Motorolla GM160 "...
--
24.06.2009 14:29 mastak1972! forum.cqham.ru/viewtopic.php?t=16906... --
24.06.2009 10:31 . Motorolla GM-160. ...
-- mastak1972
23.06.2009 18:19 test... -- bob
23.06.2009 04:46 Gracias... -- Edgarin
22.06.2009 22:45 Hi!
Yaesu FT5100.... -- RA3ZOM
19.06.2009 14:41 kenwood -270G. ...
-- Max78
18.06.2009 22:59 download software motorola gp3188... -- odhing
18.06.2009 03:32 filo! upload.com.ua/get/900295618... --
17.06.2009 11:29 softwere for motorola cm160... -- filo
16.06.2009 06:20 rv3sfq! .... --
14.06.2009 21:51 , M44GMC20D3AA R01.01.01
... -- rv3sfq
14.06.2009 17:55 rv3sfq! GM300.... --
14.06.2009 00:45 GM-300.
... -- rv3sfq
11.06.2009 07:46 kaitipi! MOTOROLA GP344 .forum.cqham.ru/viewtopi... -
11.06.2009 06:07 kaitipi! .... --
10.06.2009 22:18 -MOTOROLA- P-020 GP-344.... -- kaitipi
08.06.2009 19:42 qwqwwqwq... -- wsw
... -- ...
08.03.2009 17:34 , . TK-2106Z, TH-3106Z T...
-- ...
08.03.2009 17:27 ! ,
... -- ...
08.03.2009 01:52 ,,
... -- ...
05.03.2009 22:26 , . , ...
-- ...
05.03.2009 22:18 ! Unlock , ...
-- ...
05.03.2009 18:58 ! C CLONE NG ...
--
05.03.2009 17:11 :)... --
05.03.2009 12:32 , -270G , PTT- ... -
05.03.2009 10:27 ! ICOM. ...
-- ...
05.03.2009 10:19 ! . , ...
-- ...
05.03.2009 10:12 RA1AGA ! ,
... -- ...
05.03.2009 07:15 TK-762G? ...
--
05.03.2009 06:28 ! .... --
03.03.2009 23:56 ICOM F4GS. ...
--
03.03.2009 20:36 "" Yaesu FT-8500 ...
-- RA1AGA
03.03.2009 09:20 . "" ...
-- ...
03.03.2009 08:58 , ! ...
-- Vladon79
03.03.2009 04:59 adawt TK-K4AT ... -
02.03.2009 07:58 Vladon79 . ...
--
02.03.2009 07:38 Vladon79 CLONE NG, ...
--
01.03.2009 19:24 RA9C ! , . ...
-- ...
01.03.2009 11:24 140... -
28.02.2009 18:08 Kenwood TK-K4AT 400-470. ...
-- adawt
26.02.2009 20:26 , . USB . ... -RA9C
23.02.2009 13:37 IC-F41GT. CLONE NG.
... -- Vladon79
20.02.2009 13:50 soft Cp040 ver .R03.01.00... -- slawo79
16.02.2009 22:37 , ICOM-F4GT ...
--
16.02.2009 22:32 () ICOM-F4GT...
--
16.02.2009 02:38 KENWOOD TK-280. KPG-49D
... --
15.02.2009 00:33 com1 gm-300... -15.02.2009 00:30 com1... -12.02.2009 22:51 ! ...
--
12.02.2009 22:29 Motorola gm300 for 40> channel modifikasyon? Icom F-2020 rx tx 4... -TA2JU
11.02.2009 00:42 IC-F110S. ...
-- sofrin
08.02.2009 00:35 , ! , Yaesu FTL 2... -Neptun
04.02.2009 21:59 ., . !... --
04.02.2009 21:44 ! kenwood tk-28...
--
03.02.2009 10:01 , Alpha Series Radios CPS R01.07, ... - ...
31.01.2009 20:15 .
... -- ...
31.01.2009 08:49 Egor ! . ...... -- ...
30.01.2009 23:36 ?...
-- Egor
30.01.2009 15:06 - V3.10
... -- Shaun
30.01.2009 15:00 Motorola CP-180... -- ama
29.01.2009 18:43 Hola.Necesito el software KPG 101D con ID europea.Yo podria faci... -Jose
27.01.2009 17:55 ! R4, VD1, C1
... -- ...
25.01.2009 18:49 ! , : ... - ...
24.01.2009 22:37 2 P020, ...
-- Dimon70
24.01.2009 18:58 MOTOROLA CP040(R03.01.02) GP
680(R02.00... -24.01.2009 01:05 ! 2 Motorola P080 R02.... -Alex145
22.01.2009 04:46 MOTOROLA GM-1...
-- taxi
21.01.2009 07:14 hi my name is batbyar Icom cs-2200H adj software help send me?... -batbayar
20.01.2009 09:18 TIALIV, EW7AT ! , ... - ...
19.01.2009 22:08 , ! ""
... -- TIALIV, EW7AT...
19.01.2009 09:33 TIALIV, EW7AT ! - - ...
-- ...
17.01.2009 06:43 , ! IC-F1010( 1764) ...
-- TIALIV, EW7AT...
15.01.2009 10:45 TIALIV, EW7AT ! IC-F1010 ... - ...
13.01.2009 20:21 . Adjust .... -- TIALIV,
EW7AT...
13.01.2009 17:00 . . IC-F1010 , ...
-- TIALIV, EW7AT...
13.01.2009 11:14
... --
12.01.2009 15:52 soft CP160... --
10.01.2009 21:26 TK-2306 ... -- sasha001
10.01.2009 19:37 ras... -- ANDREW
10.01.2009 19:22 KPG-87D kenwood
2260... -- vital
09.01.2009 19:39 VXR-9000 REPEATER VHF VERTEX Service Manual Download... -- sv2jpk
04.01.2009 10:48 Ico... - ...
03.01.2009 13:33 VERTEX STANDRATD VX 2500 V... -- BASKORO
-- ut7gh...
06.05.2008 12:25 i need programing capl for gp328 R04.00.00-LA... -- bg2rov
02.05.2008 00:51 NECESITO SOFTWARE GP-328 ... -- jhonn
30.04.2008 00:15 SOFTWARE VERTEX VX 2200 TKS... -- JRCOMUNICACIONE...
23.04.2008 15:52 Icom Ic-F111, ...
--
22.04.2008 09:57 , GM300 c RADIO
DO... -- CEN
18.04.2008 11:25 ! . ... - ...
17.04.2008 18:15 , DOSBox ...
-- ...
17.04.2008 18:12 e VXR-7000 P-III c WinXP ,! ...
-- ...
17.04.2008 07:24 HOLA, NECESITI EL SOFTWARE PARA PROGRAMAR LOS RADIOS
TH860H Y EL ... -- CARLOS DAMIAN O...
14.04.2008 21:30 Please: Write to english... -- Guillermo Suare...
14.04.2008 03:18 software programacion vertex standar vx 414... -- vertex standar ...
09.04.2008 10:23 "-201", ...
-- RA6FBT
09.04.2008 08:10 , R03.03.00 ? ...
-- Oleg RA9JM
08.04.2008 05:48 , . R03.09.05 Motorol...
--
04.04.2008 14:09 2260... --
04.04.2008 03:09 motorola ...
-- 329
03.04.2008 21:39 olegscorpion@yandex.ru GM-1...
-- olegscorpion...
02.04.2008 06:17 ERGBVERAVGDFVSD... -- ISIDRO GARCIA...
01.04.2008 10:44 ? , Alex- . USB-CO...
-- ...
01.04.2008 10:40 Slava ! IC-F111 CS-F100, CS-F100A...
-- ...
01.04.2008 10:29 salehsamawe ! Use the published cable schematics with the MOT-4 c... -Yevgueny Androp...
01.04.2008 10:20 alex ! , "" MAX232 ...
-- ...
01.04.2008 10:13 UR9QV ! .
... -- ...
01.04.2008 10:09 :DiMA ! TK-2160L - Linton ? ... ... - ...
31.03.2008 21:33 i need programing capl for gp328... -- salehsamawe...
30.03.2008 23:50 MAX232. - -, ... -alex
29.03.2008 23:58 Da li imate software KPG55D ? Pozdrav Lajos... -- Lajos
28.03.2008 13:30 LP2950-5 LP2951(8.-).1-2...
-- ur9qv...
27.03.2008 02:32 I need programming software for Motorola CP200 and Motorola M1225... -Harrison Taylor...
26.03.2008 17:05 LP2950 LM2951.
SMD... -- UR9Q...
26.03.2008 03:22 cp 040... -- leman kurtdogan...
25.03.2008 21:08 cp040... -- pisy74
25.03.2008 17:01 I need software for CP040... -- kasum kadri...
25.03.2008 07:54 . , ...
-- Slava
24.03.2008 17:52 , ...
-- ur9qv ...
24.03.2008 17:42 ! .. Check con... --
:DiMA
24.03.2008 17:26 solicito software vx-2200... -- comtodo
19.03.2008 17:00 Philips FM 1000...
-- ru6fb
18.03.2008 09:50 RA3NY ! , . , ...
-- ...
17.03.2008 19:28 , GP-340,P-040 GP-300
... -- RA3NY...
17.03.2008 11:23 :DiMA ! " " . ...
-- ...
16.03.2008 16:45 cp200 PROGRAMMING SOFTWARE... -- TOM
13.03.2008 17:24 KPG kenwood 3160L.
... -- :DiMA
13.03.2008 13:02 i want sofware gp328... -- benni
12.03.2008 11:09 jlsgcjhc kjashckjsah jk kjsah kjsa... -- fouad
06.03.2008 02:39 software for Icom F3s... -- daryl
29.02.2008 22:59 Looking for software for a motorola cp200 has to be newer, please... -shawn
28.02.2008 10:29 KPG-91D. , : ().30et-054.es/pa...
-- ...
22.02.2008 09:30 ! VPL-1 ...
-- ...
22.02.2008 08:06 Please help me find CPS R05.06.00 for my CP200 radio.... -- Patty Love
21.02.2008 13:43 MOTOROLA CM-140
... -- UA1ON...
21.02.2008 09:35 VPL-1... --
20.02.2008 21:47 Witam. Poszukuje softu do radiotelefonu Kenwood TK-809E UKF.... -m_a_r_e_k1
20.02.2008 14:00 kpg-74d kenwood 3140, ... - rv3dgs...
19.02.2008 17:17 i need the squematic wire programation sorry my english is bad ... -- gabo
18.02.2008 16:18 !!! ,
... --
18.02.2008 15:01 , . ... --
...
18.02.2008 08:22 ! , soft 140, r.a... -
17.02.2008 14:24 Can anybody help with interface for Bantam MX/PX? Email bel1@webm... -QD Bantam MX...
17.02.2008 14:11 ...
--
15.02.2008 12:17 ! "KENWOOD "
... -- ...
15.02.2008 12:01 Icom ic-f110.... --
...
14.02.2008 20:29 Hi, i need the software for cm140. tanks petre... -- romania
14.02.2008 12:51 KPG-22. ...
-- ...
11.02.2008 14:31 , MOTOROLA CP-180 (R03.01.00), GM-340 (...
-- Gevor
11.02.2008 08:16 KPG-22
... -- ...
07.02.2008 16:58 xxxxx... -07.02.2008 16:01 !!! ,
... --
07.02.2008 15:43 KENWOOD TKR750VFM... --
07.02.2008 13:39 KENWOOD TKR-750VFM.
... -- ...
06.02.2008 16:03 need gp 328 service manual urgently... -- rio
06.02.2008 11:23 need gp 328 service manual urgently.please help.e-mail ahamadbokh... -Ahamad bokhari...
05.02.2008 19:57 need gp328 service manual urgently... -- Ahamad bokhari...
05.02.2008 19:03 very need for KPG 99 D(E) for TK 8162 e .please help .zoheir-pion... -zoheir
31.01.2008 12:56 I am looking for gp328 service manual.please send me to the above... -AHAMAD BOKHARI...
31.01.2008 10:43 rw0jc ! 1. ... - ...
30.01.2008 22:43 software for vertex vx 2200... -30.01.2008 17:22 software for vertex vx 2200... -- ariel casteglio...
30.01.2008 14:38 , . ...
-- rw0jc
30.01.2008 09:38 rw0jc ! 1. 2,5 . 2. DR-130 L... - ...
29.01.2008 15:29 . ...
-- rw0jc
29.01.2008 15:27 rw0jc... -- rw0jc
29.01.2008 14:56 iojj;... -29.01.2008 07:29 . ...
-- rw0jc
26.01.2008 17:19 sh... -- ddg
25.01.2008 14:39 i have the kenwood tk 7160 does anyone know where to find the sof... -please help...
24.01.2008 19:16 need kpg 99d(e)(zoheir-pionner@hotmail.fr)... -- zoheir
24.01.2008 17:31 !
... -24.01.2008 17:28 !
... -22.01.2008 19:53 i am hari from india i need icom m502 diagram programmingcable ... -- hari
22.01.2008 17:14 , , OTOROLA CM140...
-- Vova
22.01.2008 14:44 por favor... -- josema122
20.01.2008 22:22 Hello, I am Henry and I need Motorola RSS software for the GM300 ... -Henry
17.01.2008 22:38 / SoonTone. .... -- Slash
16.01.2008 00:45 Motorola
GP360... -- Bass
16.01.2008 00:22 nowy... -- kalemo
15.01.2008 17:10
SARACOM,... -- sprut
14.01.2008 11:56 SeregaDV 140? , ...
--
10.01.2008 18:06 Motorola P 020 ... -04.01.2008 05:20 Motorola CP140...
-- SeregaDV
20.12.2007 20:24 DIAGRAM CABLE PROGRA MMING CM 140 PLEASE SEND ME!... -17.12.2007 00:11 1969 . 60 909. ... -
16.12.2007 23:22 5430... --
13.12.2007 15:55 .
... -- ...
13.12.2007 15:37 Andrey ! F3/F4 New , CSF3...
-- ...
12.12.2007 19:46 ! IC-F3S , DOS ... -12.12.2007 07:02 ! HYT TC700 ...
--
06.12.2007 09:52 Andrey ! -. ...
-- ...
--
04.10.2007 14:58 Hello i m mario... i m radio amator my name it (yo3hma) from euro... -- Mario
04.10.2007 14:57 Hello i m mario... i m radio amator my name it (yo3hma) from euro... -- Mario
04.10.2007 11:46 adj Icom IC-F3... -03.10.2007 23:31 Plyyzzzz Send me email the soft kit Motorola R03.07.06 :-((((... -- Mario
02.10.2007 17:54 vertex ftl 2011... -- Jaime Vilches R...
02.10.2007 13:56 Icom IC-F320S, ... -Oleg_D
29.09.2007 19:05 Hello plyzzz give me the Kit Motorola Gm360 Version R03.07.06 in ... -Mario
27.09.2007 05:17 WERTEX 2000 , . , . ...
-- Johnson, UR5FFM...
25.09.2007 01:08 ./. VERTEX 20...
--
18.09.2007 07:03 ROBINZON24 !... -- -...
17.09.2007 15:44 - 30 ...
-- ROBINZON24
17.09.2007 11:53 ROBINZON24 , , 98. ...
-- -...
17.09.2007 11:53 ROBINZON24 , , 98. ...
-15.09.2007 23:41 necesito el programador de las radios kenwood thk2at`... -- polo
15.09.2007 16:42 programming software kenwood thk2at... -- polo
14.09.2007 19:38 - kpg56d ...
-- ROBINZON24
12.09.2007 14:52 , ... . , ... --...
12.09.2007 14:47 ! (-, ) ...
-- -...
11.09.2007 09:23 romich ! . (...
-- ...
11.09.2007 09:20 ROBINZON24 ! TK-7102
... -- ...
10.09.2007 09:55 -040, , . ... -romich
08.09.2007 19:27 KENWOOD TK-7020 KENWOOD TK-7102 KENWOOD
TK-7108 ... -- ROBINZON24
03.09.2007 11:17 ICOM 420 F, ... ... -01.09.2007 16:03 Please i need schematic Motorola p040... -- winston
31.08.2007 23:35 . " 30... -Veritas
30.08.2007 06:23 I, HAVE CALLME... -- EDGAR MARTIN...
29.08.2007 09:39 ! , ...
-- ...
29.08.2007 06:15 , ... GM-300/G... -
28.08.2007 16:58 ! ...
-- ...
28.08.2007 06:30 . ...
--
27.08.2007 10:36 Motorola GM-360 ver.03.07.06 ...
-- !
26.08.2007 18:30 m25c22 ...
-- ...
25.08.2007 14:20 motorola M120?... --
22.08.2007 03:51 ... -21.08.2007 10:15 ! RJ-45 ...
-- ...
20.08.2007 17:29 ! CE63 VX2500. !7...
-- ,rv3na...
rv3sbq
07.04.2007 09:22 Soft YAESU VX-2000V( soft C...
-- ua1onw
07.04.2007 02:43 IC-110 IC-111. IC-110 ... -
06.04.2007 21:36 MOTOROLA CP-140 ver.no:r03.00.0...
-- un7iax
03.04.2007 19:20 Dobrogo vremenji sutok! Vertex standart VXA 300 (aviacionnij di... -- oktava
03.04.2007 00:27 tk-250 250(e) 2. tk-35... -01.04.2007 23:44 ...
--
31.03.2007 17:42 Sergey. C icom-f50, OPC... -doncamp
31.03.2007 17:29 RA9MHL 020 040.
... -- doncamp
31.03.2007 12:37 ...
--
26.03.2007 13:00 ! , ... -
26.03.2007 11:57 , . (...
--
23.03.2007 15:52 VX-3200?... --
23.03.2007 09:54 ! LCS2000 ...
-- UA1AAM ...
21.03.2007 01:44 icom-f50 .. ...
-- Sergey
20.03.2007 16:14 KENWOOD TK-7108... -
17.03.2007 04:37 KPG ... -16.03.2007 21:51 GP340 DRAGON ALAN
... --
15.03.2007 17:06 KPG-90D... -14.03.2007 09:26 RA9AMJ ! , ....
-- ...
13.03.2007 11:29 , !!! ! ... -, RA9AMJ...
12.03.2007 09:55 RA9AMJ !
... -- ...
12.03.2007 09:41 !!! ...
-- , RA9AMJ...
05.03.2007 09:59 .... -
03.03.2007 16:50 ZZZZ motorola GM1200E jn gm1200
... -- UN7ECY Vlad...
28.02.2007 10:19 . RA9AMJ ! RIB Kenwood : RIB ... - ...
27.02.2007 12:46 !!! - ...
-- . RA9AM...
20.02.2007 02:28 130 ?... --
20.02.2007 02:27 130 ?... --
20.02.2007 02:21 130 ?... --
20.02.2007 02:19 130 ?... --
20.02.2007 02:19 130 ?... --
18.02.2007 17:42 Sker efter hur man programerar en Shinwa SC425YB... -- Dan
15.02.2007 08:24 GM-340. PLIZ...
--
30.01.2007 15:57 - ! GM, ...
-- prepod
25.01.2007 11:14 kpg87d... -- siamak
25.01.2007 05:08
... --
24.01.2007 19:08 - "19 2006 . 18:27 ... --
24.01.2007 05:56 -140 -160... --
22.01.2007 01:01 , ! ...
-- . ...
21.01.2007 18:26 copy of :kPG-60D and kpg-49d ver4.for win tk280/380radios?mail me... -chinon
19.01.2007 22:02 Ewgene .KPG-87D ... --
19.01.2007 21:32 . RZ6LWP " ... -
19.01.2007 20:56 TK-2260 - KPG-87D... -19.01.2007 10:39 TK-2260. ... -Ewgene
16.01.2007 02:18 vx-2r - , ... -15.01.2007 11:20 schemu motorola p040 p080 MOTOROLA ...
--
14.01.2007 21:25 UA1QDJ! loonga@rambler.ru , , ...
-- . ...
14.01.2007 12:17 schemu motorola p040 p080... -- jaskolka
14.01.2007 05:28 andrew@port-aprel.ru... -ex UA1QDJ
14.01.2007 05:26 2 ., < en... MONITOR SCAN , LOW SQL SIG,> -- ex
UA1QDJ
14.01.2007 05:25 2 . RZ6LWP , < , LOW SQL SIG, ,...> -- ex
UA1QDJ
14.01.2007 05:22 2 . RZ6LWP service manual ... -ex UA!QDJ
09.01.2007 19:55 LAY, , , ...
--
09.01.2007 19:55 LAY, , , ...
--
09.01.2007 07:25 yo tambien! necesito el kpg80d... -- Compumam
07.01.2007 21:32 GP68 - ...
-- . ...
03.01.2007 01:35 , YAESU FTH 2010?
... -- . ...
26.12.2006 13:47 Looking for software for the Kenwood TK-3200 (KPG-88D) please re... -Kenwood TK-3200...
19.12.2006 18:27 motorola (140 160) ... -15.12.2006 11:02 - VX-2000? 20 ...
-- ,ur5xez...
14.12.2006 17:32 , , .
... --
13.12.2006 16:37 Disculpame pero no entiendo tu idioma... Pero agradezco la info ... -Marcelo Valenzu...
12.12.2006 10:35 , GM140 http://www.cnham.com/software...
-- US8IKC, ...
12.12.2006 10:26 i-m looking for the software for both the Motorola P020 and CP040... -- Jaco
Le Roux P0...
12.12.2006 10:21 ! . ...
-- US8IKC, ...
12.12.2006 06:13 ! R03.00.05 . ?...
--
11.12.2006 23:07 . ...
-- Us8Ikc? ...
11.12.2006 20:24 GP 340. . ... -
11.12.2006 11:57 , ... , ZZZZZZ......
-- Svyazist
10.12.2006 00:34 DRAGON SY5430(
... -- US5IVZ
09.12.2006 10:00 I need soft for programing motorola cm-140, ... -- I need soft for...
07.12.2006 19:39 necesito el program KPG80D, GRACIAS. I need program KPG80D, THANK...
-- Kris
05.12.2006 11:46 ! CM 140 R03.00.05. ...
--
01.12.2006 10:08 ur5vtp ! . http://forum.cqham.ru/viewtopic.php?t=9558&... -ur5vtp
30.11.2006 05:52 EW8CR! - -140.
... --
29.11.2006 16:26 Kpg99D , kenwood tk 70...
-- ur5vtp
29.11.2006 11:49 CM-140 / CM-160 CP-140 ...
-- EW8CR
27.11.2006 20:03 ICOM F110... -- ua1onw-arx
27.11.2006 20:03 ICOM F110... -- ua1onw-arx
24.11.2006 09:04 -140 -140 . !!!... -UA3ZC
14.11.2006 18:00 software icom f121s software icom f111s atenciozamente tia... -- tiao
garrucha p...
14.11.2006 11:15 looking for cm140 motorola programming software please.... -13.11.2006 13:57
... --
13.11.2006 10:07 tk2107 3107 5118 3118 ... -- siamak
12.11.2006 09:48 ! : http://forum.cqham.ru/vie... - ...
11.11.2006 02:26 . ...
--
09.11.2006 13:29 motorola GM 360 ...
--
07.11.2006 13:26 I NEED TO KPG 87D... -- M CHIANOV
05.11.2006 11:42 . . ...
--
31.10.2006 09:42 , ! ...
-- ...
30.10.2006 09:48 /
... -- ,RA0FMF...
30.10.2006 06:06 schematic kenwood tk-862g-1... -- pablo
29.10.2006 08:50 TK790 Programming ?... -- bg6iaq
29.10.2006 08:43 TK790 Programming ... -- bg6iaq
26.10.2006 09:52 RW6MGO ! "" - ...
-- ...
24.10.2006 23:34 ,
... -- RW6MGO
23.10.2006 10:46 , ...
-- RA9FUE...
18.10.2006 13:03 : http://forum.cqham.ru/viewtopic.php?
t... -- ...
18.10.2006 13:01 TK-862G-1. "check sum", - ... - ...
18.10.2006 12:59 ! ! ...
-- ...
17.10.2006 20:52 ,, . ...
-17.10.2006 14:00 ! - ! : ...
--
16.10.2006 15:19 ! rw9rn@mail.ru... -- RW9RN
12.10.2006 22:43 ! D 03.02.01. G...
--
10.10.2006 14:36 ! , ERROR
T... -- RW9RN
09.10.2006 13:58 -101-4.(422). ...
-- UT5VF
09.10.2006 04:36 necesito el program KPG80D, GRACIAS. I need program KPG80D, THAN...
-- Marcelo Melogno...
05.10.2006 17:27 ...
-- US5MUW Alexey...
05.10.2006 09:56 US5MUW Alexey ! HELP KPG-87D
... -- ...
04.10.2006 13:33 HELP KPG - 87D, ...
-- US5MUW Alexey...
04.10.2006 12:43 .!!! 2260 ... -03.10.2006 16:56 US5MUW Alexey ! , , KPG-87D.
... -- ...
01.10.2006 12:32
KENWOOD 2... -- US5MUW Alexe...
26.09.2006 22:07 RW9RN GP-340
-http://www.ham.dmz.ro/motorola/gp340... -- POMAH
26.09.2006 09:27 ! GM360 GP340!!! ...
-- RW9RN
24.09.2006 16:23 csf14 , ..... --
18.09.2006 23:32 . , ...
-- UR5LIS...
18.09.2006 09:15 RA0FMF. ,
... -- ...
18.09.2006 09:04 FT8800 (soft
FTB8800) ... -- , RA0FMF...
15.09.2006 21:21 YAESU VX-2000U soft CE20.... - ...
14.09.2006 20:17 icom ic-f320... -12.09.2006 20:48 data de tk862g ... -- pablo
11.09.2006 09:39 ! Motorola CP040 , ...
-- ...
10.09.2006 04:41 , , . ...
-- , UA3USQ...
05.09.2006 01:24 maxon sp-120, ...
--
03.09.2006 10:42 ,, .
... -- -UT5VF...
01.09.2006 09:32 ! . ...
-- ...
31.08.2006 12:00 . VX-200, DJ-191, FT-11R. ...
--
31.08.2006 09:25 RN3DD ! VX-210A . ...
-- ...
29.08.2006 10:19 , , VX-2...
-- RN3DD
28.08.2006 09:20 Slaver ! , ...
-- ...
28.08.2006 09:16 RN3DD ! .
... -- ...
25.08.2006 07:06 - ...
-- RN3DD
24.08.2006 14:51 ! STANDARD HX290.
... -- Slaver
16.08.2006 07:02 ! , KPG99D...
--
14.08.2006 02:28 rtyrtytyuytutyuytuy... -- marcos
14.08.2006 02:27 ggdfgdfgfghfdg... -- marcos
-- ...
22.05.2006 09:26 ! . ...
--
22.05.2006 09:11 ICOM-320 CLNG,
EEPROM,... --
22.05.2006 07:55 !!! ??? Icom IC-F320-6 ... -
21.05.2006 21:26 , VERTEX VX-200
... --
19.05.2006 19:27 ! "" ...
--
19.05.2006 12:16 kdg82D? ra4lw@vinf.ru ... -, ra4lw...
19.05.2006 11:25 , ! . . ...
--
19.05.2006 09:35 ! 2-...
-- ...
18.05.2006 14:16 Yaesu FTH-2010
(... --
18.05.2006 09:34 ! ...
-- ...
17.05.2006 20:32 , ...
--
17.05.2006 09:41 ! htt...
-- ...
16.05.2006 19:55 , ... -
15.05.2006 21:26 ! ...
--
12.05.2006 12:36 ! ! 73!... --
12.05.2006 10:14 ! CT-29 , ...
-- ...
12.05.2006 10:05 !
... -- ...
12.05.2006 05:29 CT-29 () ...
--
12.05.2006 03:30 , :) ... - ...
11.05.2006 15:05 ! FTH-2010 - ...
-- ...
11.05.2006 14:56 ! GP-340 ...
-- ...
11.05.2006 13:46 Yaesu FTH-2010!!! . ...
--
11.05.2006 04:56 ! , ...
-- ...
10.05.2006 09:28 ! (3-4) ...
-- ...
07.05.2006 21:29 ! IC-F300/400, ...
-- ...
04.05.2006 10:00 ! IC-F420 , ... - ...
03.05.2006 03:22 Icom, IC-420, ...
-- ...
02.05.2006 09:20 TK-760HG-1. KENWOOD G,
... -- ...
30.04.2006 17:38 como puedo progamar kenwood tk 350 gracias... -- antonio
29.04.2006 10:56 ! ? ...
-29.04.2006 10:53 kenwood tk760hg-1... --
28.04.2006 08:37 hola , me pueden decir de donde bajo la interface de programacio ... -lecue
28.04.2006 07:16 como puedo programarun kenwood tk.860... -27.04.2006 11:45 , CE-63 VX...
--
27.04.2006 11:43 , CE-63 VX...
--
24.04.2006 11:01 ! , ...
-- ...
24.04.2006 10:15 , .
... --
24.04.2006 09:47 .. ! - ...
-- ...
24.04.2006 09:43 Kot33 ! . ...
-- ...
21.04.2006 15:51 GP340. ...
-- ..
21.04.2006 11:42 ...
-- Kot33
21.04.2006 09:24 EU7EA ! . ...
-- ...
20.04.2006 13:21 SP MIC ...
-- EU7EA
13.04.2006 20:00 ! ! / Vertex VX-2500U...
--
13.04.2006 09:36 ! , ...
-- ...
11.04.2006 15:33 ! ...
--
09.04.2006 03:55 Nashla na saite KPG-23D. Spsibo dobrim people kto eto delo organi... -Irina
09.04.2006 02:14 Privet vsem! Kto imeet software KPG-23D i KPG-90D, pros-ba podel... -Irina
06.04.2006 09:30 ! .
... -- ...
05.04.2006 19:33 , ! ...
--
05.04.2006 10:33 YEASU FTH-2010
... --
03.04.2006 09:24 ! .
... -- ...
02.04.2006 21:51 ! ...
--
23.03.2006 14:26 ! ! ...
-- UR8QM
21.03.2006 09:45 UR8QM ! , .
... -- ...
21.03.2006 09:39 EW3BX ! .
KENWOO... -- ...
21.03.2006 09:31 Paolo IW3SQM ! Thanks for testing VX-180 and VX-2500, I will publ... -Yevgueny Androp...
20.03.2006 12:31 . YEASU FTH-2010
... -- UR8QM
20.03.2006 12:27 . YEASU FTH-2010
... -- UR8QM
18.03.2006 23:55 YAESY VX 10,
... -- EW3BX
17.03.2006 23:11 Checked the multipurpose cable, is very good from Vertex VX 180 s... -Paolo iw3sqm...
14.03.2006 09:52 RW6APW ! ICOM M700TY , .
... -- ...
14.03.2006 09:51 Don999 ! . IC-F3 ...
-- ...
13.03.2006 00:27 , IC...
-- RW6APW
11.03.2006 11:22 , ? ...
-- Don999
10.03.2006 09:36 Don999 ! ... ... --
...
09.03.2006 21:00
... -- Don999
09.03.2006 09:28 UA2FBB ! DR-605E , ...
-- ...
05.03.2006 00:14
... -- ua2fbb
02.03.2006 13:15 136-174 Alinco 19... -Serg
01.03.2006 15:31 maxon... -- ungureanu marin...
26.02.2006 09:35 For TK278 use the Fig.1 schematics and "KENWOOD portable" connect... -Yevgueny Androp...
24.02.2006 11:29 Please give me one interfaces for Kenwood TK278(schematics)! Tank... -20.02.2006 09:26 ! !... -- ...
19.02.2006 21:47 (5617 5615) ...
-- ...
19.02.2006 21:45 (5617 5615) ...
-16.02.2006 15:55 your site very good............:....thank you........... -- kerrouche
15.02.2006 16:02 dweer hjjk... -- raman
22.01.2006 10:46 hello i am looking for radio software.... -- mitch
19.01.2006 09:21 SERG ! KPG-80D, .... - ...
17.01.2006 18:56 kpg 80... -- serg
16.01.2006 09:36 ! ...
-- ...
14.01.2006 20:27 ICOM IC-R10 CSR10... --
...
14.01.2006 01:01 YAESU FTH-2010 CE2, IC-...
-- ...
13.01.2006 09:34 DIMAR ! , . ...
-- ...
13.01.2006 02:55 , ...
-- dimar
12.01.2006 09:56 ALEXEY ! ... "". ... - ...
12.01.2006 09:48 OLEG74. . IC-F4 (400-430 ) (136-150 ... - ...
11.01.2006 22:29 !!! kenw...
-- Alexey
11.01.2006 21:27 , IC-F4( 400-430 ) (136-... -oleg74
11.01.2006 09:34 OLEG74. : IC-F4 . ...
-- ...
10.01.2006 23:59 IC-F4... -oleg74
05.01.2006 10:05 Para la programacin VX-210A fabriquen este cable. l t... -- Yevgueny
Androp...
01.01.2006 19:38 390 . ...
-- ru6fb
01.01.2006 18:29 hola amigos.mi pregunta es como puedo programar un standar vx210a... -walter
-- ...
05.10.2005 17:35 , 232 115000 , ...
-- ra9mhl
04.10.2005 09:22 RA9MHL. - ? , ...
-- ...
03.10.2005 19:33 ., Siemens ME45, ...
-- ra9mhl
29.09.2005 19:08 Kenwood TK-3140 KPG-74D. ....
--
05.09.2005 09:25 , . - ...
-- ...
04.09.2005 17:45 Alan HM 43.
... --
01.09.2005 09:53 , , DOS- ...
-- ...
31.08.2005 16:29 VX2000
... --
26.08.2005 10:19 ! . TKR720 ...
-- ...
25.08.2005 21:20 ru6fb . motorol...
-- Oleg ru6fb
10.08.2005 17:42 ATTENTION ! On the GP-340 connector the RTxD contact should be di... -Yevgueny Androp...
10.08.2005 17:33 RU6FB: , , ...
-- ...
10.08.2005 17:03 . . ...
-- ru6fb
10.08.2005 09:18 RU6FB: - . , ...
-- ...
09.08.2005 17:30 ...
-- ru6fb
09.08.2005 09:42 RA1AGG: , . ...
-- ...
08.08.2005 14:57 http://bobjohnson.nm.ru/inf/c55_... -RA1AGG
08.08.2005 13:53 , GP-340 RTxD
... -- ...
28.07.2005 10:59 9- . ...
-- ...
27.07.2005 14:05 . 4 5 ... -
25.07.2005 09:35 : http://hamradio.online.ru/ftp2/f30lt.jpg ... - ...
25.07.2005 08:21 IC-F30/31/40/41 ...
--
22.07.2005 20:33 ICOM F-110- , ...
--
11.07.2005 09:33 () ! , ...
-- ...
05.07.2005 22:52 , ...
-- Eugenie
05.07.2005 11:53 I am looking for Programming soft wear of MCS2000 VU3BIS Anupa... -programming sof...
05.07.2005 11:52 I am looking for Programming soft wear of MCS2000 VU3BIS Anupa... -programming sof...
05.07.2005 11:52 I am looking for Programming soft wear of MCS2000 VU3BIS Anupa... -programming sof...
14.06.2005 10:21 , . ...
-- ...
10.06.2005 21:08 http://www.cqham.ru/unipr... --
alex
06.06.2005 09:41 bg6iaq, !... --
...
03.06.2005 23:20 OK!... -- bg6iaq
30.05.2005 09:38 ICOM IC-F3 . ...
-- ...
28.05.2005 12:09 ICOM F3... -- ua9oai
23.05.2005 10:10 VLAD-. MCS2000 , ...
-- ...
20.05.2005 09:50 EU7SS ! MAXTRAC ,
... -- ...
20.05.2005 04:50 1. MAXTRAC .D34MWA2GF6AK 136-174
... -- eu7ss
19.05.2005 16:19 . MCS2000
... -- vlad
16.05.2005 13:39 , m2...
--
15.05.2005 23:40 . ...
-- EW6OO...
14.05.2005 15:45 TK-2160 qrz.ru hackersrussia.ru... --
...
14.05.2005 15:00 . , ...
-- VINNI
04.05.2005 09:29 , . ...
-- ...
03.05.2005 16:37 .
... -- , UA4L...
03.05.2005 16:36 , ...
-- , UA4L...
11.04.2005 09:47 , ! ?... --
...
11.04.2005 01:16 ....LTS 2000... --
15.01.2005 04:07 .... TK-3101... --
11.01.2005 10:35 , KPG52D -
KENWOOD.... -- ...
11.01.2005 10:35 , KPG52D - ... - ...
06.01.2005 17:16 KPG52... -- Andrey UR5EVE...
06.01.2005 11:15 KPG-46 ,
... -- ...
03.01.2005 20:06 KPG-46 ... -- Slava
15.12.2004 10:09 , !... -- ...
14.12.2004 11:03
... -- US5IVZ...
30.11.2004 09:59 RA9MNL, ! TK-278/378 ...
-- ...
28.11.2004 13:58 TK-278... -- RA9MNL
12.11.2004 16:53 , ,
... -- ...
12.11.2004 15:20 ICOM IC F121S, !... -
11.11.2004 14:58 , Yeasu FTL - 2007?... -- UR3CRV,
...
29.09.2004 10:48 COM-,
... -- ...
28.09.2004 21:42 DJ-191 TK-370 VX-500 ?... -
23.09.2004 10:22 ! DJ-191 ...
-- ...
20.09.2004 02:51 FT10,FT40. DJ191,VX500... --
16.09.2004 10:06 , ( ), ...
-- ...
16.09.2004 01:32 . ...
--
15.09.2004 11:24 EXE- ...
-- ...
15.09.2004 03:09 - ic-f320-6. ic_f3xx.zip ... -
09.09.2004 11:39 , , ,...
-- ...
08.09.2004 01:07 8 2004. 0:58 . ... -
08.09.2004 01:06 8 2004. 0:58 . ... -
07.09.2004 09:38 , kom-inform.euro.ru... - ...
07.09.2004 09:36 / ICOM IC-F3GS, VERTEX VX-5R, KENWOOD TK-370G. ICF3... -- ...
02.09.2004 01:26 , batlabs, (...
--
30.08.2004 10:04 . ...
-- ...
26.08.2004 23:01 Motorola GP300 !!!...
--
19.08.2004 12:46 . . ...
--
28.05.2004 09:43 + +5. ...
-- ...
27.05.2004 10:14 +E ? ... --
27.05.2004 09:36 ? IC-F11 ?... - ...
27.05.2004 00:36 Hi, All. - Icom IC-F21 ? ?... -Alexandr, UN7QA...
09.03.2004 10:02 ra9mhl !... -- ...
08.03.2004 10:54 GP 300... -- ra9mhl
08.03.2004 10:51 ra9mhl@mail.ru... -- ra9mhl
08.03.2004 10:50 Kenwood 278,Yaesu VX1r,Vertex VX500,Moto...
-- ra9mhl
05.03.2004 10:30 Icom 110 , . ...
-- ...
03.03.2004 17:47 110, ?... -- Oleg(EX8MLT)...
19.02.2004 11:44 -- !.. RA9MHL, ...
-- ...
19.02.2004 08:36 ,
,,... -- RA9MHL
10.02.2004 11:04 Icom , , ...
-- ...
27.01.2004 20:06 , Icom 15 ...
-- Oleg(EX8MLT)...
26.11.2003 14:51 .
... -- ...
25.11.2003 18:41 ... -Ihor UR3LCM...