Documente Academic
Documente Profesional
Documente Cultură
In this tutorial, you will create the model shown in Figure A. This model is the Upper
Housing of a motor blower assembly. Figure B shows the left-side view of the top view,
top view, front view, and the sectioned left-side view of the model. All dimensions are in
inches.
1.
Create the base feature that is extruded symmetrically on both sides of the front plane,
refer to Figures C and D.
Figure E Sketch
of the path
Figure F Profile
plane at the end
of the path
3.
Create rounds of radii 1.5 and 0.5 on the swept protrusion feature, refer to Figure P
through S.
5.
6.
Mirror the previous protrusion feature to the left side of the model, refer to Figure AA.
8.
9.