Sunteți pe pagina 1din 3

Mark: You may have to disable driver signature verification in windows

Please recover the firmware with the following steps:


1, Install this first:

install driver SPCA6350_v1001.exe from

folder 1
2, install driver SPCA6350_v1001.exe from folder 1
3, Open the FRM recover software located in folder 2 in the :

folder

* You will get a notice USB device not connected . (see underneath, dont worry

4, Set the software parameters as in the picture below :

5Press and hold the upper button (top button on the side of your camera), then plug
in the USB cable,at the first upgrade you will find new hardware, click automatically
install then is OK
6Click the ISP or F5 to start the recovery

7, The recovery is finished

S-ar putea să vă placă și