Documente Academic
Documente Profesional
Documente Cultură
14. Who
a.
b.
c.
d.
21. An employer purchase an Outside LEVL III Agency Services. Then who
is responsible for the outside agency services are in accordance with
the written practice of the employer
a. Employer of the out side Agency
b. Level III of the outside agency
c. Employee of the outside agency
d. All
e. None
22. How Many Limited certification Techniques are in the Electro magnetic
testing
a. 1
b. 2
c. 3
d. 4
e. None
23. How Many Limited certification Techniques are in the Leak testing
a. 1
b. 2
c. 3
d. 4
e. None
24. As per SNT-TC-1A 2006 , a man doing the UT B Scan Can be qualified &
Certified
a) Yes By the Limited Certification
b) Yes after getting prior permission from ASNT
c) Whether any NDT personnel should be qualified and certified depends
solely upon the need of the employer and the need of the employers
customer or clients
d) No, Cannot be qualified as it is not covered in SNT-TC-1A -2006
25. Which LEVEL II Certification Has Lowest umber of Minimum Specific
Question
a. BLT
b. Neutron Radiography testing
c. UT A Scan Thickness gauging
d. All
e. None
for LEVEL II
36. In accordance with which of the SNT-TC-1A 2006 following is true for a
Level III
a. On the basis of demonstrated ability, achievement, experience and
education. The employer may waive examination for the Level III
individual
b. The employer may delete the specific examination if the candidate has
a valid ASNT NDT Level III certificate in the method and if documented
evidence of experience exists.
c. The employer shall recognize only the ASNT Level III certificate holder
d. All of the above
37. Establishing a written practice for control and administration of NDT
personnel, Training, examination and certification:
a. Is the sole responsibility of the employer
b. Is basically the responsibility of the NDT Level III as per SNT-TC-1A
c. Shall be as dictated by the customer
d. Shall be in accordance with the guidelines given by an appropriate
Regulatory authority
38. The responsibility of each level of certification for determining the
acceptability of material:
a. Shall be in accordance with the applicable codes, standards,
specification, and procedures
b. Should be in accordance with customers requirements
c. Should be described in employers written practice under all
circumstances
d. Should be described in employers written practice only if customer
calls for it.
39. In accordance with SNT-TC-1A 2006 is it implied that an individual at
maximum could be qualified only 4 methods?
a. Yes, because the individual requires to spend at least 25% of this work
time on each method
b. No, the candidate may be qualified in as many methods as desired.
The 25% work time experience only applies for initial qualification in
each level for each method.
c. The 25% work experience is not applicable and is not required for the
individual to remain qualified in a particular method at a specific
qualification Level.
d. Both a and b
40. In preparing for qualification, the training times recommended for Level
I in Magnetic Particle Testing are greater than Level II, why?
a. Some NDT methods require more initial training at Level I because of
difference in complexity and manipulative skills.
b. Candidates for Level I generally have less formal education than those
for Level II
c. No, the candidate should always receive more training for Level II
regardless of NDT method.
d. Both a and b
41. In accordance with SNT-TC-1A it is recommended that a training
program for qualification and certification purposes should include:
a. Organized training to become thoroughly familiar with the principles
and practices of the specified test method relates to the level of
certification desired.
b. Training applicable to the practices to be used and products to be
tested.
c. Sufficient examination to assure that the necessary information has
been comprehended.
d. All of the above
e. Only b and c
42. If an employer performs NDT to multiple codes, specification and
acceptance standards in this specific examination can he select
questions from the code standard and a specifications?
a. No, the level III examiner can select & Approve the question from the
code, standard and specification
b. Yes, it is the intent of SNT-TC-1A that specific examination covers all
the codes, specifications and acceptance criteria applicable to the
employers activities
c. May be selected based upon differing job requirements of individual
candidates
d. Both b and c
43. As recommended in SNT-TC-1A the physical examination requirements
are intended to:
a. Assured natural of corrected near distances acuity in at least one eye
such that the applicant is capable of reading minimum of Jaeger
Number 2 on a standard Jaeger Test Chart.
b. Each employers specific needs
c. Meet specific sections of ASME code
d. Both a and b
49. A man has finished Fifth Standard Only .Can he Be qualified to LEVEL I
a. Yes
b. No
c. If NDT LEVEL III Approves , it is OK
d. Yes If so mentioned in Written Practice
50. A Man with Eng Degree was Initially quailed as ET LEVEL II. Now he
wants to be qualified LEVEL II in Remote field . So how much minimum
training hours he has to meet as per SNT-TC-1A 2006 ?
a. 40 hours
b. 30hoours
c. 20 hours
d. 16 hours
51. A Man with Eng Degree was Initially quailed as ET LEVEL II. Now he
wants to be qualified in Remote field . So how much minimum
experience he is supposed to have in that method SNT-TC-1A 2006?
a. 1000 hours
b. 12000hours
c. 600 hours
d. 315 hours
e. All
52. Which of the following statements is true with respect to SNT-TC-1A?
a. This document specifies the requirements for establishment
qualification and examination program.
b. This document provides guidelines for the establishment
qualification and certification program.
c. This document specifies the requirements for establishment of
qualification and certification program.
d. This document provides guidelines for the establishment
qualification and examination program
53. Written testimony of qualification is termed:a. Documentation
b. Certification
c. Testimonial
d. Authentication
54. Certifying agency is defined as:a. The Employer
b. The Outside Agency
c. The ASNT Level III
d. Both The Employer and the ASNT Level III
10
of
of
a
of
55. Which of the following NDT Levels should be qualified to set up and
calibrate equipment and to interpret and evaluate results with respect to
applicable codes, standards and specifications?
a. Level I
b. Level II
c. Level III
d. Level II and Level III
56. Which of the following statements is false with respect to the Written
Practice?
a. The employer shall establish a written practice.
b. The written practice should describe levels of responsibility.
c. The written practice shall be submitted to clients for acceptability.
d. The written practice shall be maintained on file.
57. When carrying out practical examination at NDT Level III how many
check points are necessary to confirm an understanding of NDT
variables and the employers procedural requirements?
a. One
b. None
c. Ten
d. Two
58. A candidate for re-examination must wait a minimum of:a. 30 days
b. Receive suitable additional training as determined by NDT Level III
before examination
c. 30 Days and receive suitable additional training as determined by NDT
Level III before examination
d. 30 Days or receive suitable additional training as determined by NDT
Level III before examination
59. A candidate is required to be examined directly to Level II in Penetrant
Inspection. How many months experience must the candidate have?
a. 1
b. 2
c. 3
d. 6
60. Color contrast differentiation should be conducted upon initial
certification and then:a. Annually
b. At 2 year intervals
c. At 3 year intervals
d. At 5 year intervals
11
12
13
2006 SNT-TC-1A
Benchmark Questionnaire (State True or False)
1. SNT-TC-1A is a strict specification.
[T/F]
[T/F]
[T/F]
[T/F]
[T/F]
[T/F]
11. In SNT-TC-1A a person having ASNT Level III certificate can work
as a Level III because this exam takes care of specific [T/F]
examination.
12. SNT-TC-1A calls for General, Specific and Practical exam for
[T/F]
Level III.
13. The training hours required for BLT are more than MSLT.
[T/F]
14
[T/F]
[T/F]
The
[T/F]
[T/F]
15
16