Documente Academic
Documente Profesional
Documente Cultură
SERVICE MANUAL
US Model
Canadian Model
AEP Model
E Model
PHOTO : ECM-T115
PHOTO : ECM-T145
SPECIFICATIONS
SERVICE NOTE
Notes on Chip Component Replacement
Never reuse a disconnected chip component.
Notice that the minus side of a tantalum capacitor may be
damaged by heat
SECTION 1
GENERAL
ECM-T115/T145
SECTION 2
DIAGRAMS
LITHIUM BATTERY
%
: indicates tolerance.
C : panel designation.
Signal path.
F : MIC
ECM-T115/T145
UNIT BOARD
UNIT BOARD
MIC1
(SIDE A)
MIC1
(SIDE B)
D10
MIC
OUT
D10
MINI
PLUG
T145 MODEL
C10
1-671-999-
11
11
(11)
1-671-999-
MINI
PLUG
(MIC OUT)
(11)
T115 MODEL
J1
MIC IN
R13
BATTERY
CHECK
LAMP
D2
S1
S1
POWER
D1
JC1
D3
ON
LITHUM
BATTERY
CR-2025
3V
R3
OFF
C1
C2
C14
R1
11
11
(11)
1-672-000-
1-672-000-
(11)
16
(MIC OUT)
MINI
PLUG
Semiconductor
Location
Ref. No.
Location
D1
D2
D3
D10
F-2
F-2
D-2
B-4, A-6
: Through hole.
b : Pattern from the side which enables seeing.
Caution:
Pattern face side:
(SIDE B)
Parts face side:
(SIDE A)
SECTION 3
EXPLODED VIEWS
NOTE:
-XX, -X mean standardized parts, so they may have some differences
from the original one.
Items marked * are not stocked since they are seldom required for
routine service. Some delay should be anticipated when ordering these
items.
6
7
8
9
10
1
11
#1
Ref. No.
1
2
3
4
5
* 6
7
Part No.
Description
1-790-104-11
2-545-592-01
2-545-593-01
X-2542-165-1
2-545-588-01
Remarks
12
Ref. No.
Part No.
Description
8
9
10
11
12
2-545-590-01
2-545-599-01
2-545-586-01
2-545-587-01
2-545-601-01
TERMINAL, MINUS
SHEET, BLIND
CASE (LOWER), BATTERY
HOLDER, BATTERY
LABEL, MODEL NUMBER (T115)
12
#1
Remarks
58
not supplied
57
56
MIC1
59
not supplied
55
54
52
53
51
Ref. No.
Part No.
Description
51
52
53
54
* 55
1-790-102-11
X-2542-079-1
3-704-197-72
2-545-584-01
4-916-272-01
Remarks
Ref. No.
Part No.
Description
56
57
58
* 59
MIC1
2-543-437-01
3-309-597-31
2-545-583-01
1-671-999-11
8-814-294-00
REGISTER
SCREW (1.4), TAPPING,PRECISION
COVER, MICROPHONE
UNIT BOARD
MICROPHONE CAPSULE C-1053
Remarks
105
103
106
107
108
not supplied
MIC1
101
D10
109
102
110
111
104
112
Ref. No.
Part No.
Description
101
102
103
104
105
A-4540-185-A
X-2542-079-1
3-704-197-12
3-309-597-51
X-2542-166-1
106
107
Remarks
Ref. No.
Part No.
Description
108
109
110
111
112
2-545-596-01
2-536-803-01
2-545-592-01
2-545-591-01
1-790-103-11
SPACER
STOPPER
BUSHING
CASE, BUSHING
CORD, MICROPHONE (1 CORE)
D10
MIC1
Remarks
SECTION 4
ELECTRICAL PARTS LIST
NOTE:
Due to standardization, replacements in the
parts list may be different from the parts
specified in the diagrams or the components
used on the set.
-XX, -X mean standardized parts, so they
may have some difference from the original
one.
Items marked * are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when
ordering these items.
Ref. No.
Part No.
CAPACITORS:
uF: F
RESISTORS
All resistors are in ohms.
METAL: metal-film resistor
METAL OXIDE: Metal Oxide-film resistor
F: nonflammable
COILS
uH: H
Description
Remarks
8-719-072-95 DIODE
8-719-064-07 LED
D3
8-719-056-29 DIODE
33uF
47uF
0.22uF
20%
20%
4V
4V
25V
Part No.
Description
Remarks
10%
50V (T115)
D10
8-719-056-29 DIODE
015AZ4.7-TPL3 (T115)
************************************************************
015AZ3.9-X-TPL3
SML-310LTT86
(BATTERY CHECK LAMP)
015AZ4.7-TPL3
MISCELLANEOUS
***************
1
1-790-104-11 CORD, MICROPHONE (1 CORE)
51
1-790-102-11 CORD, MICROPHONE (1 CORE) (T115)
112
1-790-103-11 CORD, MICROPHONE (1 CORE) (T145)
D10
8-719-056-29 DIODE 015AZ4.7-TPL3 (T145)
MIC1
8-814-294-00 MICROPHONE CAPSULE C-1053
************************************************************
SEMICONDUCTORS
In each case, u: , for example:
uA...: A... , uPA... , PA... ,
uPB... , PB... , uPC... , PC... ,
uPD..., PD...
C10
UNIT
Ref. No.
AMP
5%
1/16W
10K
220
3.9K
5%
5%
5%
1/16W
1/16W
1/16W
S1
1-692-397-21 SWITCH, SLIDE (POWER)
************************************************************
ECM-T115/T145
Sony Corporation
9-924-973-11
10
99B1677-1
Printed in Japan 1999.2
Published by Quality Engineering Dept.
(Shinagawa)