Documente Academic
Documente Profesional
Documente Cultură
XXXX.001
sacinp.inp
Precede
Checkbox
Checklist Items
Description
Basic Geometry
Check
Basic Loading
Check
Member Properties ___*Use the Labeling Options command to display yield stre
and verify
___*Check effective lengths for critical members
___*Check member releases, especially wishbone members
___*Check member offsets (for tubulars d/4 criteria)
Joint Properties
Plate Properties
Check Model
Command
Precede Checklist
Required Reference Material (If Available)
asic geometry using structural drawings; render model Structural Drawings, Inspection
Reports (damage), Mill Certs
Labeling Options command to display all fixities and Structural Drawings, Inspection
Reports (damage), etc.
partial models, make sure that the proper boundary
nd fixities are applied where connected steel is not
Model Engineer:
Checking Engineer:
Date of Model Review:
Comments
EDG
EDG
6/20/2016
Project Information
Model Engineer:
Checking Engineer:
Date of Model Review:
XXXX.001
0
sacinp.inp
Postvue Checklist
Checkbox
Checklist Items
Description
Unity Checks
Reactions
Deflected Shape
Maximum
Deflection
Comments
EDG
EDG
6/20/2016
Project Information
Checkbox
XXXX.001
0
sacinp.inp
Checklist Items
Description
Basic Loading
Check
Member Unity
Ratios
Plate Stress Ratios Check Plate Unity Check Range Summary in the
output list file to ensure that all plate stress ratios fall
below unity; if not check justification(s).
Pile Penetration
Check the Pile Axial Capacity Summary to verify that
Minimum Factors of pile safety factors meet the minimum values of 1.5 for
Safety
storm cases and 2.0 for operating cases. Look at soil
report to determine actual capacities in tension and
compression. Ensure that a justification calculation is
provided if necessary.
Minimum Factors of pile safety factors meet the minimum values of 1.5 for
Safety
storm cases and 2.0 for operating cases. Look at soil
report to determine actual capacities in tension and
compression. Ensure that a justification calculation is
provided if necessary.
Pile Unity Ratios
Pile Capacity
Plot out the capacity curves for piles. Compare this curve
to the ultimate pile capacity curve provided as a part of
the soil report (model engineer to provide). This could be
mulitple curves depending on the different pile sizes used.
Comments
Step No.
Max Moment
(kips)
(in-kip) or
OPERATING CASE
0
45
90
135
180
225
270
315
Wave
Dir.
Max Shear
Step No.
(ft-kip)
Max Moment
(kips)
Step No.
(in-kip) or
STORM CASE
0
45
90
135
180
225
270
315
Step No.
(ft-kip)
Max BS
Max OTM
Storm
Compression
Pile
Operating
Compression
Tension
Tension
nts
Model Engineer:
Checking Engineer:
Date of Model Review:
EDG
EDG
6/20/2016