Documente Academic
Documente Profesional
Documente Cultură
1. repower device, monitor the boot sequence for the following message:
"Autoboot to default partition in 3 seconds.
2. Select m to boot to maintenance partition
3. From the maint partition select 'factory reset".
4. At this point you will be prompted for a password, enter "MA1NT"
6. You must allow the device to complete the boot sequence
Select any version other than 3.0.6 and "Factory Reset", then enter.
Note: Do Not choose the scrub option unless instructed to do so. It will
wipe out all data including the PANOS and will require the RMA of the
device. Scrubbing will sanitize all sensitive configuration and log data that is
stored on the hard disk (this data is not stored elsewhere on the firewall).
(Note: Once you do that, the default username / password will be: admin /
admin)
Reset the device from the console port by logging in and entering command
"request restart system".
Reboot the device and monitor the boot sequence for the message "Autoboot
to default partition in 4 seconds".