Documente Academic
Documente Profesional
Documente Cultură
1) A 440 V/110 V transformer has 1000 turns on the primary winding. The number of
turns on the secondary is:
2) A step-up transformer has a turn’s ratio of 10. If the output current is 5 A, the input
Current is
(c) Both eddy current and hysteresis losses d) the resistance of the primary and
secondary windings
(a) increasing the armature current (b) decreasing the field current
(c) Decreasing the applied voltage (d) increasing the field current
5) The armature resistance of a d.c. motor is 0.5, the supply voltage is 200V and the
armature current is
(a) hysteresis and friction losses (b) hysteresis, eddy current and brush con tact losses
(c) hysteresis and eddy current losses (d) hysteresis, eddy current and copper Losses
7) The effect of inserting a resistance in series with the field winding of a shunt motor
is to
(a) Increase the magnetic field (b) increase the speed of the motor
(c) decrease the armature current (d) reduce the speed of the motor
(a) armature current (b) supply voltage (c) mechanical load (d) eddy currents
(a) Is zero until the rotor moves and then rises slightly?
(b) Is 100 per cent until the rotor moves and then decreases slightly?
(c) Is 100 per cent until the rotor moves and then falls to a low value?
(d) Is zero until the rotor moves and then rises to 100 per cent?
14) A 4-pole three-phase induction motor has a synchronous speed of 25 rev/s. The
frequency of the supply to the stator is:
16) The power input to a mains transformer is 200 W. If the primary current is 2.5 A,
the secondary voltage is 2 V and assuming no losses in the transformer, the turn’s ratio
Is:
(a) 40:1step down (b) 40:1 step up
(c) 80:1 step down (d) 80:1 step up