Documente Academic
Documente Profesional
Documente Cultură
C - SPECIFICATIONS - 4.3L' '1998 ENGINE PERFORMANCE General Motors Corp. - Service & Adjustment
Specifications 4.3L
C - SPECIFICATIONS - 4.3L
1998 ENGINE PERFORMANCE General Motors Corp. - Service & Adjustment Specifications
4.3L
INTRODUCTION
Use this article to quickly find specifications related to servicing and on-vehicle adjustments. This article may
be used for quick reference when you are familiar with proper adjustment procedures and only need a
specification.
MODEL IDENTIFICATION
Vehicle model is identified by fifth character of Vehicle Identification Number (VIN). VIN is stamped on metal
pad on top of left end of instrument panel, near windshield.
CAPACITIES
BATTERY SPECIFICATIONS
Series Cold Crank Amps @ 0°F (-18°C) Reserve Capacity (Minutes)
S/T 525 90
S/T 690 90
(1) Fluid capacities listed are approximate. Always fill to FULL mark with Dexron-III.
(2) Drain and refill capacity only. Does not include torque converter, unless specified otherwise.
QUICK-SERVICE
SERVICE INTERVALS & SPECIFICATIONS
REPLACEMENT INTERVALS
Component Interval (Miles)
Accessory Drive Belt (1)
60,000
Air Cleaner 30,000
Engine Coolant 150,000
Fuel Filter 30,000
Oil & Filter 3000
Spark Plugs 100,000
(1) Inspect and replace as necessary.
MECHANICAL CHECKS
ENGINE COMPRESSION
COMPRESSION SPECIFICATIONS
Application Specification
Compression Ratio 9.2:1
Normal Compression Pressure (1)
(1) Lowest compression reading should not be less than 70 percent of highest compression reading. No
cylinder compression reading should be less than 100 psi 7 kg/cm2 ).
VALVE CLEARANCE
ESYPRO
Jueves, 17 de Septiembre de 2009 11:28:00 p.m. Page 2 © 2005 Mitchell Repair Information Company, LLC.
1998 Chevrolet Blazer
C - SPECIFICATIONS - 4.3L' '1998 ENGINE PERFORMANCE General Motors Corp. - Service & Adjustment
Specifications 4.3L
IGNITION SYSTEM
HIGH TENSION WIRE RESISTANCE
SPARK PLUGS
FIRING ORDER
ESYPRO
Jueves, 17 de Septiembre de 2009 11:28:00 p.m. Page 3 © 2005 Mitchell Repair Information Company, LLC.
1998 Chevrolet Blazer
C - SPECIFICATIONS - 4.3L' '1998 ENGINE PERFORMANCE General Motors Corp. - Service & Adjustment
Specifications 4.3L
IGNITION TIMING
ESYPRO
Jueves, 17 de Septiembre de 2009 11:28:00 p.m. Page 4 © 2005 Mitchell Repair Information Company, LLC.
1998 Chevrolet Blazer
C - SPECIFICATIONS - 4.3L' '1998 ENGINE PERFORMANCE General Motors Corp. - Service & Adjustment
Specifications 4.3L
All models are equipped with an electronic computer-controlled ignition system. Timing on this system is not
adjustable.
FUEL SYSTEM
FUEL PUMP
INJECTOR RESISTANCE
Idle mixture on fuel injected models is controlled by PCM and is not adjustable. Controlled idle speed and IAC
count can be checked using scan tool. See CONTROLLED IDLE SPEED & IAC COUNT table. For controlled
idle speed adjustment procedures, see D - ADJUSTMENTS article.
ESYPRO
Jueves, 17 de Septiembre de 2009 11:28:00 p.m. Page 5 © 2005 Mitchell Repair Information Company, LLC.