Documente Academic
Documente Profesional
Documente Cultură
Model #: PD-42S(PLA-4260)
FAX : +952-975-4059
Top
Confidential
Table of Contents
CONTENTS
PAGE
Sections
1. Features
1-1
2. Specifications
2-1
3. On Screen Display
3-1
4-1
5. Pin Assignment
5-1
6-1
7-1
8-1
9-1
10-1
11-1
Appendix
1. Main Board Circuit Diagram
2. Main Board PCB Layout
3. Assembly Explosion Drawing
Block Diagram
Polaroid
Service Manual
PD-42S (PLA-4260)
Chapter 1
Features
Wall-mountable
New WIDE XGA Plasma Panel:1024 x 768 (H x V)
Piano finish
Removable speaker system
Extremely thin: less than 100 mm
Fan-less
Page 1-1
File No. SG-0159
Chapter 2
Product Specification
21kgs
2. Optical Characteristics
2-1 Viewing Angle > 160 (horizontal) / > 160 (vertical)
2-2 Contrast ratio (panel spec)
(w/glass filter)
3000:1 (Typical)
1500:1 (Typical)
100-240Vac, 50/60Hz
75 20K Hz
15W (max) x2
Page 2-1
File No. SG-0159
6. ENVIRONMENT
a. Operating temperature: 5~35
b. Non-operating temperature: -5~50
c. Operating humidity: 20%~70% RH (No condensation)
d. Non-operating humidity:
module.
9.1 Warning
If you do not consider the following warnings, it could result in death or serious injury.
(1) Do not use any other power supply voltage other than the voltage specified in this
product specifications. If you use power voltage deviated from the specifications, it
could result in product failure.
(2) Do not operate or install under the deviated surroundings from the environmental
specification set for the below; in moisture, rain or near water-for example, bath tub,
laundry tub, kitchen sink; in a wet basement; or near a swimming pool; and also near
fire or heater - for example, near or over radiator or heat resistor; or where it is
exposed to direct sunlight; or somewhere like that. If you use the product/PDP module
in places mentioned above, it could result in electric shock, fire hazard or product
failure.
Page 2-2
File No. SG-0159
(3) If any foreign objects (e.g. water, liquid and metallic chip or dust) entered the
product/PDP module, the power supply voltage to the product/PDP module must be
turned off immediately. Also, never push objects of any kind into the PDP module as
they may touch dangerous voltage point or make short circuits that could result in fire
hazard or electric shock.
(4) If smoke, offensive smell or unusual noise should come from the product/PDP Module,
the power supplymust be turned off immediately. Also, when the screen fails to display
any picture after the power-on or during operation, the power supply must be turned
off immediately. Do not continue to operate the product/PDP module under these
conditions.
(5) The PDP module is controlled by high voltage about 350V. If you need to handle the
module during operation or just after power off, you must take proper precautions
against electric shock and must not touch the drive circuit portion and metallic part
within 5 minutes.
If you need to disconnect or reconnect it, you have to wait at least one minute
Page 2-3
File No. SG-0159
9.2 Caution
If you do not consider the following cautions, it may result in personal injury or damage
(1)Do not set the product/PDP module on an unstable place, vibrating place and inclined
place. The product/PDP module may fall or collapse, and it may cause serious injury
to a person, and serious damage to the product.
(2) If you need to move the product/PDP module to another place, you must turn off the
power supply and detach the interface cable and power cable from the product/PDP
module beforehand.
(4) When you carry the product/PDP module, it should be done by at least two persons in
order to avoid any unexpected accidents.
(5) When you carry the product, do not hold the speaker and the bottom of black front
bezel to avoid any injuries to a person or damage to the product.
(6) When you detach the speaker net, do not hold the net surface to avoid deformation.
Please hold the edges.
(7) The product has a glass filter on it and the PDP module has a glass-plate.
If the
product/PDP module is inflicted with excessive stress for example: excessive shock,
vibration, bending or heat-shock, the glass could be broken.
personal injury.
It may result in a
breakage.
Page 2-4
File No. SG-0159
(10) When the black front bezel of the product is covered with dust, please use a dry cloth
to wipe it off and afterwards may apply water or a natural detergent to a piece of soft
cloth or gauze, and wring the cloth tightly to clean.
9.3 Additional notice to the operation and handling of the PDP module
(1) To prevent defect or failure, please check the cable connections and power-supply
condition before power on.
(2) To ensure reliable operation of the module and to protect it from overheating, do not
wrap or cover it with a cloth or like a sheet during power-on. Also don not place the
module in a confined space or any other places of poor ventilation.
(3) The screen is controlled with the display-data signals and synchronized signals.
If
noise interferes with those signals, the screen could become unstable and in some
case would cause a failure.
Also when
handling the module, you must wear gloves or other hand protection to prevent
injuries that can occur in case the glass is broken.
(4) The glass panel section and drive circuit section of the module are closely connected
and they function as a pair.
disassembled. AmTRAN will not be responsible for the function, quality or operational
integrity of the modified module. Please do not recombine, restructure, or
disassemble it.
(5) To avoid a possible electric shock, you must make sure that the power supply of this
module is turned off before cleaning.
natural detergent to a piece of soft cloth or gauze, and wring the cloth tightly before
wiping the screen.
Page 2-5
File No. SG-0159
(6) When storing the module, you must select an environmentally controlled space.
Avoid any environment in which the temperature or humidity exceeds the
specification values.
recommended that you place the module together with a dehumidifying agent, such
as silica gel, in a moisture-proof bag and keep it in an environmentally controlled
place.
9-4 Notice to handling the glass filter
(1) When the protection film is peeled off, static electricity is generated between the film
and polarizer. This should be peeled off slowly and carefully by people who are
electrically grounded and with wellion-blown equipment or in such a condition, etc.
(2) To clean the glass filter, you may follow the methods of PDP module mentioned
above.
Page 2-6
File No. SG-0159
Chapter 3
On Screen Display
OSD Adjustment
Inputs
PC
DVI-HDCP
VIDEO 1
VIDEO 2
VIDEO 3
VIDEO 4
VIDEO 5
TV
1. VIDEO
A. PICTURE MODE
1. MOVIE
2. STANDARD
3. VIVID
4. SPORTS
B. BRIGHTNESS (0~100) (default:50)
C. CONTRAST (0~100) (default:50)
D. SATURATION (0~100) (default:50)
E. HUE (-50~50) (default:0)
F. SHARPNESS (0~14)
2. PC
A. AUTO( YES/NO)
B. COLOR TEMP (WARM/NORMAL/COOL)
C. CLOCK (0~100)
D. PHASE (0~255)
E. POSITION
1. X (0~100,step 1)
2. Y(0~100,step 1)
CONFIDENTIAL DO NOT COPY
Page 3-1
File No. SG-0159
3. AUDIO
A. BASS
(0~100)
B. TREBLE (0~100)
C. BALANCE (-10~10)
D. SRS TS XT (OFF/ON)
4. PIP
A. PIP POSITION
1. X (0~100, step:1)
2. Y (0~100, step:1)
B. PIP SIZE
1. OFF
2. SMALL
3. MEDIUM
4. PBP
5. TV
A. SYSTEM
1. ANTENNA
2. STANDARD - CABLE
3. HRC - CABLE
4. IRC CABLE
B. CHANNEL EDIT
1. AUTO PROGRAM
2. ADD
3. DELETE
Page 3-2
File No. SG-0159
6. PARENTAL
A. LOCK MENU
B.NEW PASSWORD
C. MPAA RATING (NA/ G/ PG/ PG-13/ R/ NC-17/ X)
D. TV PG RATING
1. NONE
2. TV-Y
3. TV Y7 (F VIOLENCE)
4. TV - G
5. TV PG (VIOLENCE /SEXUAL CONTENT/FOUL LANGUAGE/
SUGGESTIVE DIA)
6. TV 14 (VIOLENCE/ SEXUAL CONTENT/ FOUL LANGUAGE/
SUGGESTIVE DIA)
7. TV-MA (VIOLENCE/ SEXUAL CONTENT/FOUL LANGUAGE)
7. SETTING
A. OSD LANGUAGE (ENGLISH/ FRANAIS/ESPAOL)
B. FIRMWARE VER (Vx.xx)
C. RESTORE DEFAULT (YES/ NO)
D. TRANSPARENCY
E. CC CONTROL (ON/OFF)
F. MODE (CC1/CC2/CC3/CC4/TEXT1/TEXT2/TEXT3/TEXT4)
Page 3-3
File No. SG-0159
Chapter 4
Mode
No.
1
Refresh Horizontal
Resolution
1024x768
Vertical
Rate
Frequency
Frequency
(Hz)
(KHz)
(Hz)
60
48.363
60.004
Horizontal Vertical
Sync
Sync
Polarity Polarity
(TTL)
N
(TTL)
N
Pixel
Rate
Remark
(MHz)
65.000
Windows
Remark: 1. N: negative,
2. This device has no scalars. Some DVI cards will lead to 1 pixel shift even with the
same resolution.
Page 4-1
File No. SG-0159
Chapter 5
Pin Assignment
The plasma monitor uses a 24-pin DVI-D connector as a video input interface while connecting to the
PLA-4260 set-top box with a system cable.
Pin Number
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
Signal Name
RX2RX2+
GND
Reserved 4
Reserved 5
DDC-CLK
DDC-DAT
Reserved 8
RX1RX1+
GND
Reserved 12
Reserved 13
VCCX
GND
SENS
RX0RX0+
GND
Reserved 20
Reserved 21
GND
RXC+
RXC-
Pin Function
TMDS negative differential input, channel 2
TMDS positive differential input, channel 2
Logic Ground
Reserved. No connection
Reserved. No connection
DDC2B Clock
DDC2B Data
Reserved. No connection
TMDS negative differential input, channel 1
TMDS positive differential input, channel 1
Logic Ground
Reserved. No connection
Reserved. No connection
Power
Logic Ground
SENSE Pin, Pull High
TMDS negative differential input, channel 0
TMDS positive differential input, channel 0
Logic Ground
Reserved. No connection
Reserved. No connection
Logic Ground
TMDS positive differential input, reference clock
TMDS negative differential input, reference clock
Page 5-1
File No. SG-0159
The plasma monitor uses a 20-pin DFP connector as an audio input interface and system control while
connecting to the PLA-4260 set-top box with a system cable.
Pin Number
Pin Function
Pin Number
Pin Function
IR
11
Audio_R
Ground
12
N.C
Ground
13
Ground
DB15_Hot Plug
14
+3.3V
+5V
15
+5V
N.C
16
TxD
17
RxD
18
Audio_L
19
Ground
10
N.C
20
Page 5-2
File No. SG-0159
Chapter 6
PDP PANEL
POWER
BOARD
LOGIC
BOARD
LA01
CN9004
J2
W4
W1
IR/LED
BOARD
W2
KEYPAD
BOARD
W3
control
board
CN2
AUDIO
POWER SUPPLY
CN1
EMI
FILTER
J5 J4
W5
SYSTEM
LEFT
W6
DVI_IN
AC
INPUT
RIGHT
SPEAKER
The PDP system block diagram is powered by AC source of 100V~240V AC +/- 10%
@ 50/60 HZ ,another audio power supply that transforms AC source of 100V~240V AC
+/- 10% @ 50/60 HZ into DC 18V source. The DC 18V source supplies the audio AMP
of control board. The digital IC parts of control board is powered by DC 5V from PDP
panel side.
Page 6-1
File No. SG-0159
PDP panel
Block Diagram
Page 6-2
File No. SG-0159
Control board
Block Diagram
DVI
RECEIVER
SIL161
DVI_IN
RGB24BIT
HS/VS/DE
HS/VS/DE
LVDS
TRANSMITTER
DS90C387
PDP
LOGIC
BOARD
CPLD
LC4128V
RS232
SYSTEM_IN
up
SM5964
IR/LED BOARD
KEYPAD
AUDIO_L/R
Audio
amp
TDA8947J
SPEAKER
Page 6-3
File No. SG-0159
Chapter 7
Description
+5VSB_INPUT
+5VSB_INPUT
+5VSB_INPUT
D_GND
D_GND
D_GND
PDP_RELAY_ON
N.C.
Description
+5VSB_OUTPUT
IR_DATA_IN
LED_BLUE
D_GND
LED_RED
N.C.
Pin
Description
POWER_KEY
N.C.
N.C.
VOL-_KEY
GND
VOL+_KEY
CH-_KEY
CH+_KEY
SOURCE
Page 7-1
File No. SG-0159
Pin
Description
D_GND
N.C.
D_GND
N.C.
N.C.
D_GND
D_GND
N.C.
N.C.
10
N.C.
11
N.C.
12
N.C.
13
N.C.
14
D_GND
15
N.C.
16
N.C.
17
TXD+
18
TXD-
19
TXCLK+
20
TXCLK-
21
D_GND
22
TXC+
23
TXC-
24
TXB+
25
TXB-
26
TXA+
27
TXA-
28
D_GND
29
D_GND
30
D_GND
Page 7-1
File No. SG-0159
J2
J4
J5
Description
+18V
+18V
+18V
A_GND
A_GND
A_GND
Description
RIGHT-
RIGHR+
Description
LEFT+
LEFT-
Page 7-1
File No. SG-0159
Chapter 8
Burn-in mode starts. You will see red, green, blue and white screens display.
Keep them displaying at least 8 hours.
Press EXIT key to exit the burn-in mode and check if the mark is still visible. If so,
you may carry on the steps from 10.4.
Page 8-1
File No. SG-0159
Chapter 9
START
AC POWER
input ?
DVI has
signal ?
internal
cable ?
DC
power?
Hsync,
Vsync,DE
have signal?
END
Page 9-1
File No. SG-0159
START
AC POWER
input ?
DVI&
SYSTEM
CABLE OK?
internal
cable ?
DC
power?
Hsync,
Vsync,DE
have
signal?
END
Page 9-2
File No. SG-0159
START
AC POWER
input ?
DVI&
SYSTEM
CABLE OK?
internal
cable ?
DC
power?
speaker
output?
1.check
2.check
3.check
4.check
END
Page 9-3
File No. SG-0159
Start
Yes
N0
Support DDC2B
1.Digital cable ok?
2.Voltage of VCCX ok?
3.Check U32
5.Is compliant protocol?
Yes
END
Page 9-4
File No. SG-0159
DESCRIPTION
LOC
QTY
0185-1402-0003
F1
0420-1002-4611
Q10,Q2
0420-2003-1626
Q1
0430-4009-3109
U8
0430-6005-6004
U2
1801-0117-4010
1925-1000-2150
CUSHION-R (AVC42)
1925-1000-2170
1925-1000-2180
1925-1000-2430
1925-1100-1760
PE BAG (1300.0*1200.0*0.4t)(PD-42S)
1925-1200-6850
1925-1200-7210
1925-1900-0490
1947-1200-0400
1947-1200-2290
Insulator (300*150*0.25t)
1947-1200-2300
Insulator (8*170*0.25t )
1947-1400-0110
1947-1500-2160
1947-1500-2170
1947-1500-2180
SPONGE (PD-42S)
1947-1700-0240
1947-1700-1100
1947-1800-0150
1947-1800-0240
1947-1800-0370
1947-1800-0670
1947-1800-0690
1947-1800-0700
1947-1800-0710
1947-1800-0780
1947-1900-0030
HEATPATH (25x14mm)
REMARK
Page 10-1
File No. SG-0159
PART NO
DESCRIPTION
1947-2400-0010
3842-0012-0154
3842-0012-0307
3842-0022-0156
3842-0032-0189
LOC
QTY
REMARK
Page 10-2
File No. SG-0159
M/S
LOCATION
PART NO.
DESCRPTION
QTY
3842-0022-0301
3842-0022-0303
3842-0022-0312
Page 11-1
File No. SG-0159
3842-0022-0301
ITEM
M/S
LOCATION
PART NO.
DESCRPTION
QTY
1701-0515-1010
1701-1000-0350
1712-0100-6790
1712-1200-0070
BASE
1720-1306-1850
1720-3006-1550
1721-3047-1220
14
1947-1400-0110
1947-2400-0010
Die (PD-42S)
Page 11-2
File No. SG-0159
3842-0022-0303
ITEM
M/S
LOCATION
PART NO.
DESCRPTION
QTY
0213-0420-0967
0220-8020-0881
0260-0000-0210
0460-1006-0202
0460-1009-0411
0460-1106-0160
0460-1211-0020
WH 35572-11P-XH8P 2P 120mm
0460-3430-0540
0500-0502-0030
10
1701-0414-9010
11
1701-0900-1300
12
1701-0900-1350
13
1701-1500-0450
14
1701-1919-1010
15
1712-0100-4590
16
1712-0100-6740
10
17
1712-0100-6750
18
1712-0100-6760
19
1712-0100-6770
20
1712-0100-6780
21
1712-0100-6930
22
1712-0100-6940
23
1712-0100-7480
24
1712-0400-0720
25
1712-1200-0060
Stand
Frame (PD-42S)
26
1720-0003-0620
16
27
1720-0004-1210
12
28
1720-1006-0820
29
1720-1204-0820
30
1720-1503-0620
MAC.SCREW-MPSWF M3.0*6.0L Ni
Page 11-3
File No. SG-0159
ITEM
M/S
LOCATION
PART NO.
DESCRPTION
QTY
31
1720-1505-1550
32
1720-5003-0550
33
1720-7344-0820
34
1721-0003-1050
35
1721-0004-1050
52
36
1721-5003-0520
32
37
1801-0117-4010
38
1812-0100-6690
39
1947-1200-0400
40
1947-1200-2290
Insulator (300*150*0.075t)
41
1947-1200-2300
Insulator (8*170*0.215t)
42
1947-1500-2160
43
1947-1500-2170
44
1947-1500-2180
SPONGE (PD-42S)
45
1947-1700-0240
46
1947-1700-1100
47
1947-1800-0150
48
1947-1800-0240
49
1947-1800-0370
50
1947-1800-0670
51
1947-1800-0690
52
1947-1800-0700
53
1947-1800-0710
54
1947-1800-0780
55
1947-1900-0030
HEATPATH (25x14mm)
56
3842-0012-0154
57
3842-0012-0307
58
3842-0022-0156
59
3842-0032-0189
Page 11-4
File No. SG-0159
3842-0022-0312
ITEM
M/S
LOCATION
PART NO.
DESCRPTION
QTY
1925-1000-2150
CUSHION-R (AVC42)
1925-1000-2170
1925-1000-2180
1925-1000-2430
1925-1100-1760
PE BAG (1300.0*1200.0*0.4t)(PD-42S)
1925-1200-6850
1925-1900-0490
3842-0012-0393
Page 11-5
File No. SG-0159
3842-0012-0154
ITEM
M/S
LOCATION
PART NO.
DESCRPTION
QTY
384200120154A
384200120154M
384200120154S
Page 11-6
File No. SG-0159
3842-0012-0307
ITEM
M/S
LOCATION
PART NO.
DESCRPTION
QTY
0220-6020-0186
0242-0225-1504
0460-1102-0072
0460-1102-0082
Page 11-7
File No. SG-0159
3842-0012-0393
ITEM
M/S
LOCATION
PART NO.
DESCRPTION
QTY
0320-4000-0140
0321-0000-0251
1925-1200-7210
Page 11-8
File No. SG-0159
3842-0022-0156
ITEM
M/S
LOCATION
PART NO.
DESCRPTION
QTY
0170-1740-1182
SWK1
0220-7020-0965
SWK2
0220-7020-0965
SWK3
0220-7020-0965
SWK4
0220-7020-0965
SWK5
0220-7020-0965
SWK6
0220-7020-0965
W1
0451-2000-0766
Page 11-9
File No. SG-0159
3842-0032-0189
ITEM
M/S
LOCATION
PART NO.
DESCRPTION
QTY
384200320189A
384200320189M
384200320189S
Page 11-10
File No. SG-0159
3842-0012-0154A
ITEM
M/S
1
2
LOCATION
C3
SS
PART NO.
DESCRPTION
0102-2102-1212
0103-6102-1212
QTY
1
C5
0103-1471-1211
C50
0102-2102-1312
C54
0103-1220-1511
C56
0103-1229-1511
0101-1229-1511
SS
C57
0102-2221-1311
C68
0103-1101-1211
10
C69
0103-1470-1211
0101-1470-1211
0103-1470-1211
0101-1470-1211
11
SS
12
13
C70
SS
14
C8
0103-1101-1211
15
C84
0103-1470-1211
0101-1470-1211
0103-1470-1211
0101-1470-1211
0103-1470-1211
0101-1470-1211
0390-6002-8272
16
SS
17
18
C85
SS
19
20
21
C86
SS
D22
Page 11-11
File No. SG-0159
3842-0012-0154M
ITEM
LOCATION
M/S
PART NO.
DESCRPTION
QTY
JP1
0455-2540-0479
J2
0451-2500-0616
J4
0451-2500-0216
J5
0451-2500-0216
U8
0430-4009-3109
W1
0451-2500-0816
W2
0451-2000-0606
W3
0451-2000-0906
W5
0303-5000-2004
10
W6
0302-3010-0240
11
Y1
0280-2400-0115
Page 11-12
File No. SG-0159
3842-0012-0154S
ITEM
M/S
LOCATION
PART NO.
DESCRPTION
QTY
0171-2141-0062
CP1
0111-5103-5121
CP2
0111-5103-5121
C100
0112-3471-5106
C101
0112-3471-5106
C102
0112-3471-5106
C21
0112-3104-5116
C22
0112-3106-1614
C23
0112-3150-5106
10
C24
0112-3150-5106
11
C25
0112-3106-1614
12
C26
0112-3104-5116
13
C27
0112-3104-5116
14
C28
0112-3104-5116
15
C29
0112-3104-5116
16
C30
0112-3104-5116
17
C31
0112-3104-5116
18
C32
0112-3104-5116
19
C33
0112-3104-5116
20
C34
0112-3104-5116
21
C35
0112-3104-5116
22
C36
0112-3104-5116
23
C37
0112-3104-5116
24
C40
0112-3101-5106
25
C41
0112-3101-5106
26
C42
0112-3101-5106
27
C43
0112-3101-5106
28
C44
0112-3101-5106
29
C45
0112-3101-5106
30
C49
0112-3104-5116
Page 11-13
File No. SG-0159
ITEM
M/S
LOCATION
PART NO.
DESCRPTION
QTY
31
C53
0112-3474-2515
32
C58
0112-3105-2514
33
C6
0112-3104-5116
34
C65
0112-3104-5116
35
C66
0112-3470-5106
36
C67
0112-3470-5106
37
C7
0112-3104-5116
38
C71
0112-3104-5116
39
C72
0112-3104-5116
40
C73
0112-3104-5116
41
C74
0112-3104-5116
42
C75
0112-3104-5116
43
C76
0112-3104-5116
44
C77
0112-3104-5116
45
C78
0112-3104-5116
46
C79
0112-3104-5116
47
C80
0112-3104-5116
48
C81
0112-3104-5116
49
C82
0112-3104-5116
50
C83
0112-3104-5116
51
C87
0112-3101-5106
52
C88
0112-3474-2515
53
C89
0112-3104-5116
54
C90
0112-3104-5116
55
C91
0112-3104-5116
56
C92
0112-3104-5116
57
C93
0112-3104-5116
58
C94
0112-3104-5116
59
C95
0112-3104-5116
60
C96
0112-3104-5116
61
C97
0112-3104-5116
62
C98
0112-3104-5116
63
C99
0112-3471-5106
Page 11-14
File No. SG-0159
ITEM
64
65
D10
SS
66
67
LOCATION
M/S
D11
SS
68
D12
PART NO.
DESCRPTION
0390-5001-9293
0390-5001-9133
0390-5001-9293
0390-5001-9133
0390-5000-1053
69
CS
0390-5000-1093
70
CS
0390-5000-1223
0390-5001-9293
0390-5001-9133
0390-5001-9293
0390-5001-9133
0390-5000-1053
71
72
D18
SS
73
74
D19
SS
75
D20
76
CS
0390-5000-1093
77
CS
0390-5000-1223
0390-5001-9293
0390-5001-9133
0390-5001-9293
0390-5001-9133
0390-5001-9293
0390-5001-9133
0390-5001-9293
0390-5001-9133
0390-5001-9293
0390-5001-9133
0390-5001-9293
0390-5001-9133
78
79
D4
SS
80
81
D5
SS
82
83
D6
SS
84
85
D7
SS
86
87
D8
SS
88
89
D9
SS
QTY
1
90
F1
0185-1402-0003
91
L10
0130-0000-1859
92
L11
0111-3103-5116
93
L12
0111-3103-5116
94
L13
0111-3103-5116
95
L14
0370-0000-6452
96
L15
0370-0000-6452
Page 11-15
File No. SG-0159
ITEM
LOCATION
M/S
PART NO.
DESCRPTION
QTY
97
L16
0370-0000-6452
98
L17
0370-0000-6452
99
L18
0370-0000-4651
100
L4
0111-3103-5116
101
L5
0111-3103-5116
102
Q1
0420-2003-1626
103
Q10
0420-1002-4611
104
Q2
0420-1002-4611
105
Q9
0410-5000-1610
0410-5000-1604
106
CS
107
RP1
0141-1001-3851
108
RP10
0141-0000-3851
109
RP11
0141-0000-3851
110
RP12
0141-0000-3851
111
RP13
0141-0000-3851
112
RP14
0141-0000-3851
113
RP15
0141-0000-3851
114
RP16
0141-2209-3851
115
RP17
0141-2209-3851
116
RP18
0141-0000-3851
117
RP19
0141-2209-3851
118
RP2
0141-1001-3851
119
RP20
0141-2209-3851
120
RP21
0141-2209-3851
121
RP22
0141-2209-3851
122
RP9
0141-0000-3851
123
R11
0130-0000-0055
124
R111
0130-1009-0055
125
R112
0130-1009-0055
126
R113
0130-1009-0055
127
R114
0130-4708-0055
128
R117
0130-1000-0055
129
R118
0130-1000-0055
Page 11-16
File No. SG-0159
ITEM
M/S
LOCATION
PART NO.
DESCRPTION
QTY
130
R119
0130-1002-0055
131
R120
0130-1002-0055
132
R121
0130-5100-0055
133
R122
0130-1000-0055
134
R123
0130-0000-0055
135
R124
0130-4701-0055
136
R125
0130-1001-0055
137
R126
0130-0000-0055
138
R127
0130-1002-0055
139
R128
0130-0000-0055
140
R129
0130-1002-0055
141
R131
0130-0000-0055
142
R136
0130-4701-0055
143
R137
0130-4701-0055
144
R141
0130-0000-0055
145
R142
0130-1003-0055
146
R143
0130-0000-0055
147
R145
0130-1003-0055
148
R146
0130-0000-0055
149
R147
0130-0000-1859
150
R148
0111-3103-5116
151
R149
0111-3103-5116
152
R150
0130-0000-0055
153
R152
0130-1000-1858
154
R155
0130-1002-0055
155
R23
0130-1002-0055
156
R24
0130-1001-0055
157
R25
0130-1004-0055
158
R34
0130-0000-0055
159
R35
0130-4709-0055
160
R36
0130-4709-0055
161
R37
0130-4709-0055
162
R38
0130-4709-0055
Page 11-17
File No. SG-0159
ITEM
M/S
LOCATION
PART NO.
DESCRPTION
QTY
163
R39
0130-4709-0055
164
R4
0131-6049-0015
165
R40
0130-4709-0055
166
R41
0130-1002-0055
167
R42
0130-1002-0055
168
R43
0130-1004-0055
169
R45
0130-1001-0055
170
R46
0130-0000-0055
171
R47
0130-8201-0055
172
R51
0130-0000-0055
173
R55
0130-2209-0055
174
R56
0130-2209-0055
175
R57
0130-2209-0055
176
R6
0130-1000-0055
177
R61
0130-1001-0055
178
R62
0130-8201-0055
179
R63
0130-1000-0055
180
R64
0130-1000-0055
181
R65
0130-1000-0055
182
R66
0130-1000-0055
183
R67
0130-1000-0055
184
R68
0130-1001-0055
185
R69
0130-1001-0055
186
R84
0130-1002-0055
187
R85
0130-4702-0055
188
R86
0130-1003-0055
189
R87
0130-2700-0055
190
R88
0130-1000-0055
191
R90
0130-0000-0055
192
R93
0130-4701-0055
193
R94
0130-4701-0055
194
U10
0430-7024-1738
IC SiI1161CT100 TQFP100
195
U11
0430-3001-1011
Page 11-18
File No. SG-0159
ITEM
196
M/S
LOCATION
SS
PART NO.
DESCRPTION
0430-3000-5017
QTY
197
U15
0430-5011-4788
198
U2
0430-6005-6004
199
U5
0430-5007-5578
200
U5S
0204-1274-4012
201
U7
0430-8001-0804
0430-7024-1799
202
SS
203
W4
0302-2000-0306
204
ZD1
0400-0491-5012
ZENER
205
ZD10
0400-0491-5012
ZENER
206
ZD11
0400-0491-5012
ZENER
207
ZD12
0400-0491-5012
ZENER
208
ZD13
0400-0491-5012
ZENER
209
ZD2
0400-0491-5012
ZENER
210
ZD3
0400-0491-5012
ZENER
211
ZD4
0400-0491-5012
ZENER
212
ZD5
0400-0491-5012
ZENER
213
ZD7
0400-0721-5012
ZENER
214
ZD8
0400-0491-5012
ZENER
215
ZD9
0400-0491-5012
ZENER
Page 11-19
File No. SG-0159
3842-0032-0189M
ITEM
M/S
LOCATION
PART NO.
DESCRPTION
DR1
0440-5000-0170
DR1-H
1701-1500-0940
DR5
0440-1000-0050
LED L-934ID-F01 3
DR5-H
1701-1500-0950
UR1
0980-0200-2130
WR1
0451-2000-0566
QTY
1
1
RED
Page 11-20
File No. SG-0159
3842-0032-0189S
ITEM
M/S
LOCATION
PART NO.
DESCRPTION
QTY
0171-1641-0222
CR2
0112-3104-5116
CR3
0112-3104-5116
CR4
0111-3475-1135
LR1
0370-0000-6452
QR1
0410-5000-1610
0410-5000-1604
0410-5000-2610
0410-5000-2604
0410-5000-1610
0410-5000-1604
CS
8
9
QR2
CS
10
11
QR3
CS
12
RR1
0130-4709-0055
13
RR10
0130-4709-0055
14
RR13
0130-3301-0055
15
RR17
0130-4700-0055
16
RR2
0130-4709-0055
17
RR4
0130-3301-0055
18
RR5
0130-4700-0055
19
RR6
0130-3301-0055
20
RR7
0130-3301-0055
21
RR8
0130-3301-0055
22
UR2
0430-1004-7035
23
ZDR1
0400-0491-5012
ZENER
24
ZDR2
0400-0491-5012
ZENER
25
ZDR3
0400-0491-5012
ZENER
Page 11-21
File No. SG-0159
U1
LM2575-ADJ
4
2
L1
5V_uP
100uH_1A(DIP)
5V_uP
D1
SB560
R3
6.12K
R5
0
+
C3
1000uF/16V
PW_POMUTE (2)
PW_SW
(2)
N.C W250-7pin,180''
C4
0.1uF
V33_uP
U2
SPX1117-ADJ
3
IN
OUT
C6
C5
470uF/16V0.1uF
+
R11
R14
R15
0
N.C 0
RELAY_ON (2)
BK_LIGHT (2)
PWM_P
(2)
VIN
CTL
R10
N.C 0
C10
C9
N.C 0.1uF
N.C 1000uF/25V/LOW ESR
C8
100uF/16V
FBK
OPT
R8
N.C 0/0603
SW-V120
L2
N.C 100uH_1A(DIP)
D2
N.C SB560
R12
N.C 0
R13
N.C 10K
N.C 10K
C12
N.C 0.1uF
C11
N.C 1000uF/16V
C13
N.C 10uF/16V
R16
FUSE
1
2
3
4
5
6
F1
R19
C16
N.C 0
N.C 0.1uF
C14
N.C 1000uF/25V/LOW ESR
VIN
CTL
GND
SW-V180
A18V
J2
N.C 1.2K
U4
N.C LM2576-ADJ
FBK
OPT
R17
N.C 0
SW-V50
L3
W250-8pin,180''
N.C F1001
GND
FUSE
1
2
3
4
5
6
7
8
A18V
W1
U3
N.C LM2575-ADJ
SW-V180
0.1uF
100
2K
N.C 0/1206
C7
60.4/0603
R6
R7
R9
R4
R2
0
C2
0.1uF
C1
N.C 1000uF/25V/LOW ESR
FBK
OPT
CTL
ADJ
POWER_ON (2)
VIN
R1
N.C 0
1
2
3
4
5
6
7
J1
A18V1
GND
A18V
N.C 100uH_3A(DIP)
D3
N.C SB560
R21
NC 0
R20
N.C 6.12K
C17
N.C 0.1uF
C15
N.C 1000uF/16V
W250-6pin,180''
B
R22
Q1
A18V1
0/1206
MOS_S
L5
N.C 2K
SW-V180
P2003EV
1
2
3
0/1206
N.C AOD-405
MOS_S 2
MOS_D
R23
10K
Q15
MOS_D
5
6
7
8
L4
MOS_G
MOS_G
L6
0/1206
+
C18
R24
1K
(2)
R149
0/1206
SW_ON
R25
Q2
2N7002
1M
2
R26
N.C 1N4148
N.C 10K
C86
AmTRAN
D21
0/1206
N.C 470uF/25V
R148
TECHNOLOGY
47uF/16V
MODEL
PD-42S (3842-0012-0154)
CIRCUITY
POWER
CHECKED BY:
PCB P/ N: 0171-2141-0062
ECN NO: APCN04090017
APPROVED BY:
Sheet
of
REV:
02
PCB REV:
02
W1
1
2
3
4
5
6
7
C
W200-7
SWK1
SWK2
SWK3
SWK4
SWK5
SWK6
VOL-
VOL+
CH-
CH+
SOURCE
POWER
AmTRAN
TECHNOLOGY
CHECKED BY:
PD42S (3842-0022-0156)
CIRCUITY
KEYPAD
PCB P/ N: 0170-1740-1181
Sheet
ECN NO:
REV:
02
PCB REV:
01
APCN04090017
APPROVED BY:
5
MODEL
of
V50
CR2
0.1uF/0603
V50
RR10
UR1
FM-6038LM-5A
47
3
VCC
VO
V50
1
UR2
CR4
GND
4.7uF/0805
RR1
47/0603
NC VCC
GND
RR2
47/0603
7SZ14
RR3
QR1
2N3904-SOT23
3
NC 0/0603
V50
C
DR1
LR1
470/0603
1 RR5
470/0603
LED1
3
3 RR11
470/0603
1 RR12
470/0603
RR14
470/0603
RR15
470/0603
DR2
2
IR
3 RR4
80/0805
LED2
QR2
2N3906
RR7
3.3K/0603
CR3
RR8
0.1uF/0603 3.3K/0603
QR3
ZDR3
2
1
N.C LED3
2N3904-SOT23
RR17
DR5
N.C LED1
UDZS 5.1B
UDZS 5.1B
470/0603
WR2
DR6
LED1
LED1
2
1
2
1
N.C W200-2
DR4
UDZS 5.1B
RR9
470/0603
470/0603
RR16
ZDR2
RR13
3.3K/0603
3
RR6
3.3K/0603
1
2
3
4
5
W200-5
ZDR1
DR3
WR1
AmTRAN
TECHNOLOGY
MODEL
PD-42S (3842-0032-0189)
CIRCUITY
IR
CHECKED BY:
PCB P/ N: 0171-1641-0222
ECN NO: APCN04090017
APPROVED BY:
Sheet
of
REV:
02
PCB REV:
02
5V_uP
LED1
Q3
3 2
N.C 2N3904-SOT23
1
1 R31
N.C 470
U4PLCC 44 type, U4S
SMD Socket
R138
N.C 4.7K
N.C LED1
R134
R135
R136
N.C 4.7K N.C 4.7K 4.7K
R137
4.7K
R27
R28
R29
N.C 0
N.C 0
N.C 0
N.C R30
N.C R32
0
0
R34
POWER_ON (1)
PW_POMUTE (1)
PW_SW
(1)
BK_LIGHT (1)
PWM_P
(1)
FOR NEC
Plasma Panel
U5
D
R33
(6)
(6)
(3)
(3)
(7)
N.C 1K
LED1
LED2
47
47
47
47
R35
R36
R37
R38
SCLK
SDATA
PDP_SCLK
PDP_SDATA
DVI_HotPlug
C19
C20
KPD0
KPD1
KPD2
KPD3
KPD4
KPD5
KPD6
PW RON
Y1
1
SB140
5V_uP
P1.0
P1.1
P1.2
P1.3
P1.4
P1.5
P1.6
P1.7
23
34
1
12
TP1
D22
P2.0/A8
P2.1/A9
P2.2/A10
P2.3/A11
P2.4/A12
P2.5/A13
P2.6/A14
P2.7/A15
24
25
26
27
28
29
30
31
P3.0/RxD
P3.1/TxD
P3.2/INT0
P3.3/INT1
P3.4/T0
P3.5/T1
P3.6WR
P3.7RD
11
13
14
15
16
17
18
19
P0.0/AD0
P0.1/AD1
P0.2/AD2
P0.3/AD3
P0.4/AD4
P0.5/AD5
P0.6/AD6
P0.7/AD7
2
3
4
5
6
7
8
9
(8) CPLD_EN
(8) CPLD_ByPass
(7) EEPROM_EN
5V_uP
43
42
41
40
39
38
37
36
P4.0
P4.1
P4.2/INT3
P4.3/INT2
20
21
XTAL2
XTAL1
44
VDD
C21
PSEN
32
ALE
33
RST
EA
10
35
VSS
22
BLKH
(3)
SW_ON
(1)
LE
(3)
LVDS_387_PD (3)
MUTE
(5)
R39
R40
CTL_MODE1
CTL_MODE2
5V_uP
1K
LED2
5V_uP
1M
C23
C24
15pF
15pF
N.C 1K
U6
5V_uP
R48
N.C 1K 2
R46
R49
N.C 100
RP2
1K
R50
N.C 1K
0
R52
N.C 470 2
(3,7,8)
BAV99
D5
D6
D7
BAV99
BAV99
N.C 2N3904-SOT23
D4
3
BAV99
BAV99
Q5
BAV99
AmTRAN
BAV99
1
BAV99
CP2
0.01uF
CP1
0.01uF
D11
D10
5V_uP
DVS
D9
2
D8
5V_uP
2
5V_uP
2
5V_uP
5V_uP
5V_uP
5V_uP
DVS_D
3
R51
W200-9R
5V_uP
8.2K
5V_uP
9
8
7
6
5
4
3
2
1
KPD3
KPD4
KPD5
KPD6
R47
N.C 2N3904-SOT23
W3
KPD0
KPD1
KPD2
+ C22
10u/1206
Q4
1
5V_uP
RP1
1K
TECHNOLOGY
RESET_uP
N.C MAX809
W200-6A
PWRON
KPD[6:0]
2
4
5V_uP
GND
PWRON
JP1
1
3
R44
(4)
10K CTL_MODE1
10K CTL_MODE2
HDR_2X2/2.54mm
5V_uP
VCC
R45
IR
R41
R42
5V_uP
W78LE51P
RSTN
IR
LED1
RxD
(4)
TxD
(4)
ALARM
(3)
DHS_D
(3)
DB15_HotPlug (4)
DVI_ON (7)
DVS_D
R43
1
2
3
4
5
6
47
47
FOR SAMSUNG
Plasma
Panel
0.1uF
24MHz
W2
RELAY_ON (1)
MODEL
PD-42S (3842-0012-0154)
CIRCUITY
POWER
CHECKED BY:
PCB P/ N: 0171-2141-0062
ECN NO: APCN04090017
APPROVED BY:
Sheet
of
REV:
02
PCB REV:
02
V33_uP
RP8
G16
G17
G10
G11
G12
G13
G14
G15
86
85
92
91
90
89
88
87
B16
B17
B10
B11
B12
B13
B14
B15
76
75
84
81
80
79
78
77
R26
R27
R20
R21
R22
R23
R24
R25
66
65
74
73
72
71
70
69
G26
G27
G20
G21
G22
G23
G24
G25
58
57
64
63
62
61
60
59
B26
B27
B20
B21
B22
B23
B24
B25
22
PD
14
15
20
21
23
24
PRE
PLLSEL
R_FB
R_FDE
DUAL
BAL
DBE0
DBE1
DBE2
DBE3
DBE4
DBE5
DBE6
DBE7
RRE6 0
RRE7
RRE0
RRE1
RRE2 0
RRE3
RRE4
RRE5
FOR CMO
SAMSUNG
RP9
RP10
RGE6 0
RGE7
RGE0
RGE1
RGE2 0
RGE3
RGE4
RGE5
RP11
RBE6 0
RBE7
RBE0
RBE1
RBE2 0
RBE3
RBE4
RBE5
RP13
RP12
RP14
DRE0
DRE1
DRE2
DRE3
DRE4
DRE5
DRE6
DRE7
DGE0
DGE1
DGE2
DGE3
DGE4
DGE5
DGE6
DGE7
(2)
(2)
(2)
DBE0
DBE1
DBE2
DBE3
DBE4
DBE5
DBE6
DBE7
LE
PDP_SCLK
PDP_SDATA
C38
N.C 15pF
C39
N.C 15pF
(2) LVDS_387_PD
V33_uP
R58
V33_uP
R60
DUAL
N.C 1K
R61
53
67
82
97
C29
C30
C31
C32
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
SW-V120
V33_uP V33_uP V33_uP V33_uP V33_uP
A0
A0
49
50
RA+
RA-
A1
A1
46
47
RB+
RB-
A2
A2
44
45
RC+
RC-
A3
A3
38
39
RD+
RD-
CLK1
CLK1
41
42
RCLK+
RCLK-
A4
A4
36
37
RE+
RE-
A5
A5
33
34
RF+
RF-
A6
A6
31
32
RG+
RG-
A7
A7
28
29
RH+
RH-
CLK2
CLK2
26
27
U7
DS90C387
L7
N.C 0/1206
L8
N.C 0/1206
(2)
L10 0/1206
2
C34
C35
C36
C37
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
W4
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
RARA+
RBRB+
RCRC+
RCLKRCLK+
RDRD+
RERE+
ALARM
C33
L9
N.C 0/1206
RFRF+
RGRG+
RHRH+
13
16
17
19
DUAL
N.C 4.7K
SW-V50
C28
94
93
2
1
100
99
96
95
VCC1
VCC2
VCC3
VCC4
DGE0
DGE1
DGE2
DGE3
DGE4
DGE5
DGE6
DGE7
PVCC1
PVCC2
R16
R17
R10
R11
R12
R13
R14
R15
LVCC1
LVCC2
LVCC3
12
18
DBE0
DBE1
DBE2
DBE3
DBE4
DBE5
DBE6
DBE7
4
3
10
9
8
7
6
5
RP7
DGE0
DGE1
DGE2
DGE3
DGE4
DGE5
DGE6
DGE7
DRE0
DRE1
DRE2
DRE3
DRE4
DRE5
DRE6
DRE7
0.1uF
RBE0 N.C 0
RBE1
RBE2
RBE3
RBE4 N.C 0
RBE5
RBE6
RBE7
RP6
N.C 22
N.C 22
0/0603
C27
0.1uF
RP5
R139
R140
R150
C26
RGE0 N.C 0
RGE1
RGE2
RGE3
RGE4 N.C 0
RGE5
RGE6
RGE7
(2,7,8) DVS
(7,8) DHS
(2) DHS_D
22
22
22
CLKIN
DE
VSYNC
HSYNC
(7) RBE[7:0]
RP4
DRE0
DRE1
DRE2
DRE3
DRE4
DRE5
DRE6
DRE7
R55
R56
R57
11
56
55
54
R151
N.C 0/0603
DF14A-30P-1.25H
GND1
GND3
GND3
GND4
(7) RGE[7:0]
RP3
N.C 22
V33_uP V33_uP
+ C25
10u/1206
R59
N.C 10K
52
68
83
98
RRE0 N.C 0
RRE1
RRE2
RRE3
RRE4 N.C 0
RRE5
RRE6
RRE7
R54
LGND1
LGND2
LGND3
LGND4
(7) RRE[7:0]
N.C 22
25
35
43
51
DCLK
DEN
DVS_Out
DHS_Out
R53
PGND1
PGND2
PGND3
PGND4
(7,8)
(7,8)
(8)
(8)
BLKH
30
40
48
V33_uP
(2)
1K
AmTRAN
TECHNOLOGY
CHECKED BY:
APPROVED BY:
5
MODEL
PD-42S (3842-0012-0154)
CIRCUITY
LVDS_TR
PCB P/ N: 0171-2141-0062
ECN NO:
APCN04090017
Sheet
of
REV:
02
PCB REV:
02
ZD1
UDZS 5.1B
C40
ZD2
100pF
UDZS 5.1B
C41
100pF
W5
(2)
R63
IR
5V_uP
(2) DB15_HotPlug
5V_uP
C
(2)
(2)
(5)
RxD
TxD
Audio_L
100
R62
1
2
3
4
5
6
7
8
9
10
8.2K
R141
R65
R66
R67
100
100
100
R64
11
12
13
14
15
16
17
18
19
20
R68
1K
100
Audio_R
V33_uP
5V_uP
SDO/TDO (8)
SDI/TDI
(8)
MODE/TMS (8)
5V_uP
SCLK/TCK (8)
ZD5
C43
100pF
UDZS 5.1B
ZD8
C45
100pF
UDZS 5.1B
C87
100pF
ZD9
UDZS 5.1B
ZD10
UDZS 5.1B
ZD11
UDZS 5.1B
ZD13
UDZS 5.1B
UDZS 5.1B
R71
ZD6
C42
C44
100pF
100pF
ZD12
R69
R70
N.C 47K
CON20B
ZD3
(5)
N.C 100
Q6
N.C BC847
Audio_C
C46
N.C 100pF
R72
N.C 22K
(5)
R73
N.C 470
1K
UDZS5.1B
UDZS 5.1B
B
AmTRAN
TECHNOLOGY
MODEL
PD-42S (3842-0012-0154)
CIRCUITY
D-TYPE
CHECKED BY:
PCB P/ N: 0171-2141-0062
ECN NO: APCN04090017
APPROVED BY:
Sheet
of
REV:
02
PCB REV:
02
5V_uP
(4)
5V_uP
R74
N.C 47K
R75
N.C 47K
Q7
N.C BC847
Audio_R
(4)
2 R76
1
C47
R79
N.C 470
R78
N.C 22K
N.C 1K
Q8
N.C BC847
Audio_L
C48
Audio_RL
N.C 47uF/16V
R80
N.C 22K
R81
N.C 470
R77
N.C 1K
Audio_RL
N.C 47uF/16V
SW-V180
width 120 mil
C49
(4)
C88
0.47uF/0805
R146
0/0603
R82
N.C 0
R83
N.C 0
IN1+
IN2+
0/0603
C52
R145
100K
R143
N.C 0/0603
Audio_L
U8
N.C 0.22uF/0805
Audio_RL
R85
100K
R87
J3
RL+
12
0.47uF/0805
C54
22uF/25V
13
IN4+
OUT4+
CIV
OUT3-
11
2.2uF/25V
14
C57
220uF/25V
Q10
2N7002
MOD2
1
2
Speaker L
C55 W250-2pin,180''
N.C 470uF/25V
SGND
10
MODE1
MODE2
15
2
C58
Speaker R
J4
1
2
1
2
N.C W250-2pin,180''
RLSUBWF+
SUBWF-
J5
GND2
C56
1
2
17
SVR
GND1
MUTE
100
IN3+
2
1
(2)
R88
Q9
2N3904
UDZS 7.5B
270
1N4148
1
ZD7
D12
2
7.5V
C53
R86
47K
OUT2-
R84
10K
Audio_C
R147 0/1206R
(4)
OUT1+
9
SW-V180
C50
N.C 1000uF/25V/LOW ESR
R144
N.C 0.22uF/0805
VCC2
R142
100K
C51
Audio_R
VCC1
(4)
16
0.1uF
2
1
SUBWFSUBWF+
W250-2pin,180''
TDA8947J
width 120 mil
R89
SW-V180
1UF
N.C 1.5K
R90
MOD2 R91
L11
0/0805
R152
0/0805
L12
0/0805
R153
0/0805
L13
0/0805
MOD2
N.C 0
AmTRAN
TECHNOLOGY
MODEL
PD-42S (3842-0012-0154)
CIRCUITY
AMP
CHECKED BY:
PCB P/ N: 0171-2141-0062
ECN NO: APCN04090017
APPROVED BY:
Sheet
of
REV:
02
PCB REV:
02
V33_uP
V33_uP
R93
R94
R95
R96
4.7K
4.7K
N.C 4.7K
N.C 4.7K
R97
R98
SCLK
SDATA
C61
N.C 10K
V33_uP
I2C address
Hi=0x5Ch ,
Low=0x5Ah
C59
C60
N.C 0.1uF
N.C 10u/1206
U9
FANIN1
FANIN2
PWMOUT1
PWMOUT2
(2)
(2)
R92
PWMOUT1
1
2
3
4
5
6
7
8
N.C 47
N.C 47
FANIN1
FANIN2/GPIO0
PWMOUT1/ADDR_TRAP
PWMOUT2/GPIO1
FAN_FAULT#SMI#GPIO2
VOLT_FAULT#OVT#GPIO3
SCLK
SDATA
VCC
VT1
VT2
VREF
VIN1
VIN2
VIN3
GND
16
15
14
13
12
11
10
9
T1
T2
VREF
CN1
T1
VREF
3
2
1
T1
R132
N.C 10K 1%
R133
VREF
N.C 3pin,180''
N.C F75373S
C62
SW-V120
R99
N.C 4.7K
R100
N.C 1K
CN2
D14
N.C PBSS5140T
SOT23
N.C 100
2
C63
3
R102
Q12
N.C 2N7002
N.C 10uF/16V
CN3
N.C 4.7K
N.C 3pin,180''
R103
N.C 27K
3
2
1
PWMOUT1
R101
N.C 1N4148
T2
VREF
3
2
1
Q11
FANIN1
R104
N.C 10K
N.C 3pin,180''
R106
N.C 1K
Q13
N.C 4.7K
SW-V120
R105
1
N.C PBSS5140T
Q14
N.C 2N7002
N.C 100
2
C64
3
R108
N.C 10uF/16V
PWMOUT2
D15
R107
N.C 1N4148
N.C 4.7K
SOT23
CN4
R109
N.C 27K
3
2
1
FANIN2
R110
N.C 10K
N.C 3pin,180''
AmTRAN
TECHNOLOGY
MODEL
PD-42S (3842-0012-0154)
CIRCUITY
Fan
CHECKED BY:
PCB P/ N: 0171-2141-0062
ECN NO: APCN04090017
APPROVED BY:
Sheet
of
REV:
02
PCB REV:
02
ZD14
ZD15
ZD16
ZD17
CVCC
RP15
D16
U10
N.C 1N4148
VCCX
QO22
QO21
QO20
QO19
QO18
QO17
QO16
GND
VCC
QO15
QO14
QO13
QO12
QO11
QO10
QO9
QO8
OGND
OVCC
QO7
QO6
QO5
QO4
QO3
QO2
V33_uP
5V_uP
N.C 1N4148
C65
0.1uF
OVCC
W6
DVI
BAV99
D18
VCCX
2
(2)
8
7
6
5
EEPROM_EN
DVI_SCL
DVI_SDA
R117
R118
VCC
VCLK
SCL
SDA
100
100
NC
NC
NC
GND
1
2
3
4
AVCC
AVCC
24C02/SMD
AVCC
3
1
2
BAV99
1N4148
D20
R122
100
D19
VCCX
0
4.7K
VCCX
RP18
C66
47pF
R119
10K
47pF
R120
10K
AVCC
C67
RXR+
RXRRXC+
RXC-
AVCC
R121 510
PVCC
Sii1161_EP-387A
R123
CVCC
ZD18
ZD19
ZD21
ZD22
R124
OGND
QO23
OVCC
AGND
RX2+
RX2AVCC
AGND
AVCC
RX1+
RX1AGND
AVCC
AGND
RX0+
RX0AGND
RXC+
RXCAVCC
EXT_RES
PVCC
PGND
RESERVED
OCKINV
QO1
QO0
HS
VS
DE
OGND
ODCK
OVCC
CTL3
CTL2
CTL1
GND
VCC
QE23
QE22
QE21
QE20
QE19
QE18
QE17
QE16
OVCC
OGND
QE15
QE14
SiI161
50
49
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
R111
R112
R113
10
10
10
R114
4.7
R125
DVI_HotPlug (2)
1K
R115
R116
CVCC
ZD20
N.C UDZS 5.1B
R127
10K
RRE[7:0]
RP16 RR E7
RR E6
RR E5
RR E4
RP17 RR E3
RR E2
RR E1
RR E0
22
22
D VI_ON
DVI_ON
R128
22
CVCC
Sii1161_EP-387A
R129
10K
(3)
C
RP19 RGE7
RGE6
RGE5
RGE4
RP20 RGE3
RGE2
RGE1
RGE0
R126
0
CVCC
(3,8)
OVCC
OVCC
(2)
(3,8)
(2,3,8)
(3,8)
DCLK
CVCC
22
0
DHS
DVS
DEN
OVCC
N.C 0
N.C 0
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
U11
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
100
DFO
PD
ST
PIXS
GND
VCC
STAG_OUT
SCDT
PDO
QE0
QE1
QE2
QE3
QE4
QE5
QE6
QE7
OVCC
OGND
QE8
QE9
QE10
QE11
QE12
QE13
D17
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
C1
C2
C3
C4
C5
C6
OVCC
RXB+
RXBRXG+
RXG-
75
74
73
72
71
70
69
68
67
66
65
64
63
62
61
60
59
58
57
56
55
54
53
52
51
CVCC
22
R130
22
RP21 RBE7
RBE6
RBE5
RBE4
RP22 RBE3
RBE2
RBE1
RBE0
N.C 10K
RGE[7:0]
(3)
RBE[7:0]
(3)
V33_uP
AVCC
L14
2
CVCC
1
2
C70
47uF/16V
AVCC
80/0805
AVCC
PVCC
CVCC
CVCC
CVCC
OVCC
OVCC
OVCC
OVCC
OVCC
C84
47uF/16V
C71
C72
C73
C74
C75
C76
C77
C78
C79
C80
C81
C82
C83
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
AVCC
OVCC
L17
80/0805
AVCC
CVCC
L16
R156
2
80/0805
0/0603
C69
47uF/16V
PVCC
L15
1
R155Sii1161_EP-387A
N.C 0/0603
80/0805
C68
100uF/16V
R131
0
C85
47uF/16V
AmTRAN
TECHNOLOGY
CHECKED BY:
APPROVED BY:
5
MODEL
PD-42S (3842-0012-0154)
CIRCUITY
Sil161
PCB P/ N: 0171-2141-0062
Sheet
APCN04090017
REV:
02
PCB REV:
02
ECN NO:
of
TP60
TP_DIP 1
TP61
TP_DIP 1
TP62
TP_DIP 1
TP63
TP_DIP 1
100
99
98
97
96
95
94
93
92
91
90
89
88
87
86
85
84
83
82
81
80
79
78
77
76
LC4064/128/256-T100_FULL
TP8
TP_DIP
TP9
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
SDI/TDI
TP_DIP
1
DHS
TP_DIP
DCLK
(2,3,7) DVS
TP13
LC4064/128/258-T100C
1
VCC
TDO
INPUT(B1)
I/O(B1)
I/O(B1)
I/O(B1)
I/O(B1)
GND(B1)
I/O(B1)
I/O(B1)
I/O(B1)
I/O(B1)
VCCO(B1)
INPUT(B1)
I/O(B1)
I/O(B1)
I/O(B1)
I/O(B1)
GND(B1)
I/O(B1)
I/O(B1)
I/O(B1)
I/O(B1)
TMS
GND
SDO/TDO
1
1
1
1
1
1
TP_DIP
TP43TP_DIP
TP42TP_DIP
TP41TP_DIP
TP40TP_DIP
TP39TP_DIP
TP38TP_DIP
TP37TP_DIP
TP_DIP
TP36
TP_DIP
TP35
1
TP_DIP
TP34
1
TP_DIP
TP33
1
MODE/TMS
TP_DIP
TP32
1
TP_DIP
TP31
1
TP_DIP
V33_uP
TP_DIP
TP12
75
74
73
72
71
70
69
68
67
66
65
64
63
62
61
60
59
58
57
56
55
54
53
52
51
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
SCLK/TCK
GND
TDI
I/O(B0)
I/O(B0)
I/O(B0)
I/O(B0)
GND(B0)
I/O(B0)
I/O(B0)
I/O(B0)
I/O(B0)
INPUT(B0)
VCCO(B0)
I/O(B0)
I/O(B0)
I/O(B0)
I/O(B0)
GND(B0)
I/O(B0)
I/O(B0)
I/O(B0)
I/O(B0)
INPUT(B0)
TCK
VCC
TP44
V33_uP
I/O(B0)
I/O(B0)
I/O(B0)
I/O(B0)
GND(B0)
VCCO(B0)
I/O(B0)
I/O(B0)
I/O(B0)
IO/GOE0(B0)
VCC
CLK0/INPUT(B0)
CLK3/INPUT(B1)
IO/GOE1(B1)
I/O(B1)
I/O(B1)
I/O(B1)
VCCO(B1)
GND(B1)
I/O(B1)
I/O(B1)
I/O(B1)
I/O(B1)
INPUT(B1)
GND
(2) CPLD_EN
(2) CPLD_ByPass
GND
INPUT(B0)
I/O(B0)
I/O(B0)
I/O(B0)
I/O(B0)
GND(B0)
VCCO(B0)
I/O(B0)
I/O(B0)
I/O(B0)
I/O(B0)
CLK1/INPUT(B0)
CLK2/INPUT(B1)
VCC
I/O(B1)
I/O(B1)
I/O(B1)
I/O(B1)
VCCO(B1)
GND(B1)
I/O(B1)
I/O(B1)
I/O(B1)
I/O(B1)
TP_DIP
1
TP5
TP48
1 TP_DIP
TP47
TP_DIP
TP46
1 TP_DIP
TP45
TP_DIP
1
V33_uP
U15
(3,7)
TP56
1 TP_DIP
TP55
TP_DIP
TP54
1 TP_DIP
TP53
1 TP_DIP
TP52
1 TP_DIP
TP51
1 TP_DIP
TP50
1 TP_DIP
TP49
TP_DIP
1
V33_uP
TP7
(3,7)
TP_DIP
1
TP4
TP57
TP_DIP 1
TP58
TP_DIP 1
TP59
TP_DIP 1
TP64
TP_DIP 1
TP65
TP_DIP 1
TP66
TP_DIP 1
TP67
TP_DIP 1
TP_DIP
1
TP3
TP6
TP2
TP_DIP TP_DIP
TP20
TP10
TP_DIP TP_DIP
TP11
TP_DIP
1
(3)
DVS_Out
TP14
TP_DIP
TP15
TP_DIP
1
TP16
TP_DIP
(3)
1
1
TP17
1
1
TP_DIP
DHS_Out
1
TP18
TP_DIP TP19
(3,7)
TP_DIP
DEN
TP23
TP24
TP28
TP29
TP30
B
TP_DIP
TP_DIP
TP27 TP_DIP
TP25 TP_DIP
V33_uP
SDO/TDO
SDI/TDI
(4) SDO/TDO
(4) SDI/TDI
TP_DIP
TP_DIP
MODE/TMS
G ND
SCLK/TCK
(4) MODE/TMS
TP22 TP_DIP
V33_uP
TP26 TP_DIP
(4) SCLK/TCK
1
2
3
4
5
6
7
8
TP21 TP_DIP
N.C CON8
TP_DIP
V33_uP
V33_uP
V33_uP
V33_uP
V33_uP
V33_uP
V33_uP
V33_uP
V33_uP
V33_uP
C89
C90
C91
C92
C93
C94
C95
C96
C97
C98
0.1uF/0603C0.1uF/0603C0.1uF/0603C0.1uF/0603C0.1uF/0603C0.1uF/0603C0.1uF/0603C0.1uF/0603C0.1uF/0603C0.1uF/0603C
AmTRAN
TECHNOLOGY
CHECKED BY:
APPROVED BY:
MODEL
PD-42S (3842-0012-0154)
CIRCUITY
CPLD
PCB P/ N: 0171-2141-0062
Sheet
APCN04090017
REV:
02
PCB REV:
02
ECN NO:
of