Documente Academic
Documente Profesional
Documente Cultură
This procedure only can perform before configure OAM script and ExternalHw scripts
. Pull out ETMc1 board from slot 2 Go to Emas SwAllocation=RBS_ETMc1 right click EditSlots change slot =2 to slot =3
Install back ETMc1 to slot 3 and wait until the LED light permanent green Go to EMAS under Equipment view and check slot=3 is been Enabled
NOTE: ET-MFX board only can install when the site is fully ON AIR without any alarm. You need to Un-tick autoConfigurationAllowed before install the board Create CV backup
END