Sunteți pe pagina 1din 111

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

UMTS RF Troubleshooting Guideline UA6.0


(For internal Use Only)

Kiosk Live: Editor: Date: Version:

UMT/IRC/INF/026976 V01/EN UMTS RF Troubleshooting Guidelines Irfan Mahmood 26th June 2009 1.02

UMTS Operational Network Engineering

(For Internal Use Only)

Page 1 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Table of Contents
1. 2. 3. GLOSSARY OF TERMS AND ABBREVIATIONS................................................................. 6 REFERENCES ........................................................................................................................... 11 ABOUT THIS DOCUMENT..................................................................................................... 13 3.1. 3.2. 3.3. 3.4. 3.5. 3.6. 4. 5. INTRODUCTION ...................................................................................................................... 13 CONTENT ............................................................................................................................... 13 HOW TO READ THIS GUIDE ..................................................................................................... 14 UTRAN/CN RELEASE AND VENDOR DEPENDENCY ............................................................... 14 INTENDED AUDIENCE ............................................................................................................. 14 DISCLAIMER - WHAT IS NOT COVERED ................................................................................... 14

DESCRIPTION OF THE OPTIMISATION PROCESS ........................................................ 15 CALL SETUP ............................................................................................................................. 17 5.1. CALL SETUP RRC CONNECTION ESTABLISHMENT ............................................................... 17 5.1.1. PLMN/cell selection and reselection ............................................................................ 17 5.1.2. Failures on the AICH, PICH and PCH......................................................................... 21 5.1.3. Random Access Procedure ........................................................................................... 24 5.1.4. Call Admission Control (CAC) ..................................................................................... 27 5.1.5. Radio Link Setup........................................................................................................... 29 5.1.6. Call setup failures on the FACH................................................................................... 31 5.2. CALL SETUP FAILURES DURING THE CALL SETUP PHASE ..................................................... 33 5.2.1. Concept ......................................................................................................................... 33 5.2.2. Failure symptoms, identification and fixes for improvement ........................................ 34 5.3. CALL SETUP CORE NETWORK FAILURES ............................................................................. 35 5.3.1. Mobility Management failures...................................................................................... 35 5.3.2. Call Control failures..................................................................................................... 36 5.3.3. Session Management failures ....................................................................................... 37 5.4. CALL SETUP RAB ESTABLISHMENT .................................................................................... 38 5.4.1. Intelligent Rate Matching CAC (iRM CAC) ................................................................. 39 5.4.2. Radio Link Reconfiguration.......................................................................................... 41 5.4.3. Radio Bearer Establishment ......................................................................................... 42

6.

CALL RELIABILITY (RETAINABILITY)............................................................................ 44 6.1. CALL RELIABILITY RADIO LINK FAILURE (RLF) ................................................................ 44 6.1.1. Concept ......................................................................................................................... 44 6.1.2. Failure symptoms, identification and fixes for improvement ........................................ 47 6.2. CALL RELIABILITY DROP OF THE RAB ................................................................................ 48 6.2.1. Concept ......................................................................................................................... 48 6.2.2. Failure symptoms, identification and fixes for improvement ........................................ 49 6.3. CALL RELIABILITY DROP OF RRC CONNECTION AFTER CALL SETUP ................................... 51 6.3.1. Concept ......................................................................................................................... 51 6.3.2. Failure symptoms, identification and fixes for improvement ........................................ 53 6.4. CALL RELIABILITY RF PLANNING RELATED ISSUES ............................................................. 54 6.4.1. Introduction .................................................................................................................. 54 6.4.2. Pilot pollution ............................................................................................................... 54 6.4.3. Around-the-corner-effect .............................................................................................. 56 6.4.4. Non-optimal neighbour definitions ............................................................................... 57

UMTS Operational Network Engineering

(For Internal Use Only)

Page 2 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

6.4.5. Poor RF coverage......................................................................................................... 60 6.4.6. Poor PSC plan .............................................................................................................. 61 6.5. CALL RELIABILITY CONGESTION CONTROL ........................................................................ 61 6.5.1. Concept ......................................................................................................................... 61 6.5.2. Failure symptoms, identification and fixes for improvement ........................................ 62 6.6. CALL RELIABILITY FAILURES IN URA_PCH/CELL_PCH MODE ........................................ 62 6.6.1. Concept ......................................................................................................................... 62 6.6.2. Failure symptoms, identification and fixes for improvement ........................................ 63 6.7. CALL RELIABILITY FAILURES IN CELL_FACH MODE ........................................................ 64 6.7.1. Concept ......................................................................................................................... 64 6.7.2. Failure symptoms, identification and fixes for improvement ........................................ 66 6.8. CALL RELIABILITY HARDWARE AND NETWORK INTERFACE OUTAGES ................................. 67 6.8.1. Concept ......................................................................................................................... 67 6.8.2. Failure symptoms, identification and fixes for improvement ........................................ 67 6.9. CALL RELIABILITY INTRA FREQUENCY SOFT/ER HANDOVER ............................................... 67 6.9.1. Concept ......................................................................................................................... 67 6.9.2. Failure symptoms, identification and fixes for improvement ........................................ 69 6.10. CALL RELIABILITY IRAT HANDOVER ............................................................................. 71 6.10.1. Concept (UMTS->GSM)............................................................................................... 71 6.10.2. Failure symptoms, identification and fixes for improvement (UMTS->GSM).............. 72 6.10.3. Concept (CS GSM ->UMTS) ........................................................................................ 73 6.10.4. Failure symptoms, identification and fixes for improvement (CS GSM ->UMTS) ....... 74 6.11. CALL RELIABILITY CELL CHANGE ORDER FROM UTRAN............................................... 75 6.11.1. Concept ......................................................................................................................... 75 6.11.2. Failure symptoms, identification and fixes for improvement ........................................ 75 6.12. CALL RELIABILITY INTER FREQUENCY HANDOVER ......................................................... 76 6.12.1. Concept ......................................................................................................................... 76 6.12.2. Failure symptoms, identification and fixes for improvement ........................................ 77 6.13. CALL RELIABILITY FAILURES ON THE TRANSPORT NETWORK......................................... 78 6.14. CALL RELIABILITY FAILURES ON RLC ............................................................................ 78 6.14.1. Concept ......................................................................................................................... 78 6.14.2. Failure symptoms, identification and fixes for improvement ........................................ 81 6.15. CALL RELIABILITY HSDPA ............................................................................................ 82 6.15.1. Introduction .................................................................................................................. 82 6.15.2. Mobility aspects of HSDPA .......................................................................................... 83 6.15.3. RF related issues........................................................................................................... 85 6.15.4. UE limitations............................................................................................................... 87 6.15.5. Capacity issues ............................................................................................................. 87 6.16. CALL RELIABILITY HSUPA/EDCH ................................................................................ 88 6.16.1. Introduction .................................................................................................................. 88 6.16.2. Mobility aspects of HSUPA .......................................................................................... 89 6.16.3. MAC/ RF related Issues................................................................................................ 90 6.16.4. UE Limitations.............................................................................................................. 91 6.16.5. Capacity issues ............................................................................................................. 91 6.17. CALL RELIABILITY MISCELLANEOUS FAILURES ............................................................... 92 6.17.1. RB Reconfiguration failure ........................................................................................... 92 6.17.2. Relocation failures........................................................................................................ 93 6.17.3. Failures during the RAB and RL release procedure..................................................... 95 7. CALL QUALITY ....................................................................................................................... 96 7.1. CALL QUALITY - BLOCK ERROR RATE (BLER) ..................................................................... 96 7.1.1. DL Block Error Rate (BLER) analysis.......................................................................... 96 7.1.2. UL Block Error Rate (BLER) analysis.......................................................................... 98 7.2. CALL QUALITY QUALITY OF SERVICE (QOS) .................................................................... 100 7.2.1. QoS general ............................................................................................................. 100 7.2.2. QoS voice service..................................................................................................... 100

UMTS Operational Network Engineering

(For Internal Use Only)

Page 3 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

7.2.3. 7.2.4.

QoS data services..................................................................................................... 101 QoS VT service ........................................................................................................ 105

APPENDIX ....................................................................................................................................... 106 A. MEASUREMENT DEFINITION ........................................................................................................ 106 A.1. Measurement definition voice .......................................................................................... 106 A.2. Measurement definition data............................................................................................ 106 A.3. Measurement definition VT .............................................................................................. 109 B. TIME SYNCHRONISATION OF MEASUREMENT TRACES.................................................................. 109

UMTS Operational Network Engineering

(For Internal Use Only)

Page 4 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Change Record
This table details the changes done to the document since the last version

Date 28 February 2009 26th June 2009


th

Changes Updated draft after ONE team review for UA6 converged UTRAN Updated final version after SDT/ONE/SBG teams review for UA6 converged UTRAN

Issue# 1.01 1.02

UMTS Operational Network Engineering

(For Internal Use Only)

Page 5 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

1. Glossary of terms and abbreviations


ACB ACK AICH ALCAP APN AM ARFCN AO ARQ AS ATM BCCH BER BLER BSIC BSS CAC CCPCH CEM CM CN CPICH CQI CRC CRCI CS CT DAHO DBC DCCH DCH DL DRNC Access Class Barring Acknowledgement Acquisition Indication Channel Access Link Control Application Protocol Access Point Number Acknowledged Mode Absolute Radio Frequency Channel Number Always On Automatic Repeat Request Access Stratum Asynchronous Transfer Mode Broadcast Control Channel Bit Error Rate Block Error Rate Base Station Identity Code (GSM) Base Station Subsystem (GSM) Call Admission Control Common Control Physical Channel Channel Element Module Configuration Management / Connection Management Core Network Common Pilot Channel Channel Quality Indicator Cyclic Redundancy Checksum CRC Indicator Circuit Switched Call Trace Database Assisted HO Dynamic Bearer Control Dedicated Control Channel Dedicated Channel Downlink Drift RNC

UMTS Operational Network Engineering

(For Internal Use Only)

Page 6 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

DRX EDCH ETSI FACH FDD FM FP FSN FTP GGSN GMM GPRS GPS GSM HCS HLR HHO HO H-PLMN HSDPA HS-DSCH HSUPA HTTP H-USDPA HW IE ICMP IMCTA IP IRAT IRM KPI LA LWS MAC MAC-hs MAHO

Discontinuous Reception Enhanced DCH European Telecommunication Standard Institute Forward Access Channel Frequency Division Duplex Fault Management Framing Protocol First SN File Transfer Protocol Gateway GPRS Support Node GPRS MM General Packet Radio Services Global Positioning System Global System for Mobile Communication Hierarchical Cell Structure Home Location Register Hard Handover Handover Home PLMN High Speed Downlink Packet Access High Speed Downlink Shared Channel High Speed Uplink Packet Access Hyper Text Transfer Protocol High Speed Downlink Packet Access Hardware Information Element Internet Control Message Protocol Intelligent Multi-Carrier Traffic Allocation Internet Protocol Inter Radio Access Technology Intelligent Rate Matching Key Performance Indicator Location Area Lucent Worldwide Services Medium Access Control Medium Access Control high speed Mobile Assisted HO

UMTS Operational Network Engineering

(For Internal Use Only)

Page 7 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

MIB MM MMS MO MOS MSC MSS MNC MT NACK NAS NBAP NTP OAM OMC-U PCPICH PC PCH PDCP PDP PDU PHY PICH PLMN PM PPP PS PSC QE QoS RA RAB RACH RAN RANAP RB RL

Master Information Block Mobility Management Multi Media SMS Mobile Originating Mean Opinion Score Mobile Switching Centre Maximum Segment Size Mobile Network Code Mobile Terminating Negative ACK Non access stratum NodeB Application Part Network Time Protocol Operation and Maintenance Operations and Maintenance Centre UMTS Primary CPICH Power Control Paging Channel Packet Data Convergence Protocol Packet Data Protocol Protocol Data Unit Physical Layer Paging Indication Channel Public Land Mobile Network Performance Measurement Point to Point Protocol Packet Switched Primary Scrambling Code Quality Estimate Quality of Service Routing Area Radio Access Bearer Random Access Channel Radio Access Network Radio Access Network Application Part Radio Bearer Radio Link

UMTS Operational Network Engineering

(For Internal Use Only)

Page 8 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

RLC RLF RF RNC RNSAP RRC RRM RSSI RSCP RTP RTT RXLEV SACK SBG SC SCCPCH SCH SDU SGSN SHO SIB SIM SIR SM SMS SN SRB SRNC TB TBS TCP TFCI TGPS TM TPC TSSI TX

Radio Link Control Radio Link Failure Radio Frequency Radio Network Controller Radio Network Subsystem Application Part Radio Resource Control Radio Resource Management Received Signal Strength Indicator Received Signal Code Power Real Time Protocol Round Trip Time Receive Level (GSM) Selective ACKs Services Business Group Scrambling Code Secondary CCPCH Synchronization Channel Service Data Unit Serving GPRS Support Node Soft/softer Handover System Information Broadcast Subscriber Identity Module Signal to Interference Ratio Session Management Short Message Service Sequence Number Signalling Radio Bearer Serving RNC Transport Block Transport Block Size Transmission Control Protocol Transport Format Combination Indicator Transmission Gap Pattern Sequence Transparent Mode Transmit Power Control Transmitted Signal Strength Indicator Transmitted

UMTS Operational Network Engineering

(For Internal Use Only)

Page 9 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

UDP UE UL UM UMTS URA U-SIM UTRAN VT

User Datagram Protocol User Equipment (mobile station) Uplink Unacknowledged Mode Universal Mobile Telecommunication Standard UTRAN Registration Area UMTS Subscriber Identity Module UMTS Terrestrial Radio Access Network Video Telephony

A reference for abbreviations can be found in [23].

UMTS Operational Network Engineering

(For Internal Use Only)

Page 10 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

2. References
[1] TS 23122 NAS Functions related to Mobile Station (MS) in idle mode [2] TS 11.11 Specification of the SIM ME interface [3] TS 25304 UE Procedures in Idle Mode and Procedures for Cell Reselection in Connected Mode [4] GSM 03.22 Functions related to Mobile Station in idle mode and group receive mode [5] TS 24008 Mobile radio interface layer 3 specification; Core Network Protocols Stage3 [6] TS 25331 RRC Protocol Specification [7] TS 25433 UTRAN Iub Interface NBAP Signalling [8] TS 24007 Mobile radio interface signalling layer 3 specification; general aspects [9] TS 25413 UTRAN Iu Interface RANAP Signalling [10] TS 25423 UTRAN Iur Interface RNSAP Signalling [11] TS 25214 Physical layer procedures (FDD) [12] TS 25922 Radio resource management strategies [13] TS 25201 User Equipment (UE) Radio transmission and reception (FDD) [14] TS 25306 UE Radio Access Capabilities [15] TS 34121 Terminal conformance specification; Radio transmission and reception (FDD) [16] HSxPA Parameter User Guide for UA6.0, https://wcdmall.app.alcatellucent.com/livelink/livelink.exe?func=ll&objId=42687602&objAction=browse& sort=name&viewType=1 [17] UMTS Parameter User Guide for UA6.0, https://wcdma-ll.app.alcatellucent.com/livelink/livelink.exe?func=ll&objId=41590109&objAction=browse& sort=name&viewType=1 [18] Actix, http://www.actix.com [19] Wireshark, documentation and download at http://www.wireshark.org/ [20] tcptrace, documentation and download at www.tcptrace.org [21] Tardis2000, www.kaska.demon.co.uk/tardis.htm [22] TS 25322 RLC protocol specification [23] TS 21905 Vocabulary for 3GPP Specifications [24] Cygwin available at http://www.cygwin.com/ [25] DR TCP available at http://www2.kansas.net/drtcp.asp [26] TS 25323 Packet Data Convergence Protocol (PDCP) Specification [27] Alcatel-Lucent 9300 W-CDMA product family counters dictionary RNC/NodeB Counters, NN20500-028PX: https://wcdma-ll.app.alcatel-

UMTS Operational Network Engineering

(For Internal Use Only)

Page 11 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

lucent.com/livelink/livelink.exe?func=ll&objId=44811811&objAction=browse& sort=name&viewType=3 [28] TR 26975 Performance characterisation of the AMR speech codec Report [29] Performance monitoring guidelines for UA06, https://wcdma-ll.app.alcatellucent.com/livelink/livelink.exe?func=ll&objId=43991232&objAction=browse& sort=name&viewType=1 [30] Wireless Quality Aanalysis (WQA) Tool, https://wcdma-ll.app.alcatellucent.com/livelink/livelink.exe?func=ll&objId=37186755&objAction=browse& sort=name&viewType=3 [31] Feature strategy and monitoring document, 33821 & 34700, PS RRC reestablishment UA06 feature, https://wcdma-ll.app.alcatellucent.com/livelink/livelink.exe?func=ll&objId=41699995&objAction=browse& sort=name&viewType=1 [32] ITU-T J.144 Objective perceptual video quality measurement techniques for digital cable television in the presence of a full reference [33] RF Optimisation and Analysis Tool Suit http://navigator.web.lucent.com/ [34] EDCH Settings cookbook - UA5.x and UA6 https://wcdma-ll.app.alcatellucent.com/livelink/livelink.exe?func=ll&objid=35999228 [35] Technical Card How to reach HSxPA Highest Throughput, U-TC-19 http://frctfd0f06660.ad2.ad.alcatel.com/GPS_Tools/tcardsUMTS/list.php?idP=10 &idR=14&idT=T [36] RNC9370 Call trace (CT) User Guide, https://wcdma-ll.app.alcatellucent.com/livelink/livelink.exe?func=ll&objid=37184418&objAction=browse&sor t=name [37] Iub Engineering Guidelines, https://wcdma-ll.app.alcatellucent.com/livelink/livelink.exe?func=ll&objId=51388411&objAction=browse& sort=name&viewType=1

UMTS Operational Network Engineering

(For Internal Use Only)

Page 12 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

3. About this document


3.1. Introduction
The UMTS RF Troubleshooting Guideline is one of the base documents for the UMTS deployment process and is used for the identification, classification and resolution of problems, failures or performance degradations that might be observed during this activity. This document covers the following items: Drive test data analysis (Uu traces and 2G/3G scanner measurements) UTRAN call trace analysis (Uu and Iub tracing) Network interface tracing analysis (e.g. Iu, Iur and Iub interface tracing) PM KPI analysis End-to-end performance analysis

Furthermore this guideline is cross correlating the observed occurrences to the corresponding UTRAN parameter, PM counters and KPIs of the ALU UTRAN and/or CN and gives references. All configuration parameters are given in the format OAM Object.Parameter Name to facilitate finding it.

3.2.

Content
There are five main chapters in this document: Chapter About this document is providing an introduction and an overview of the UMTS RF Troubleshooting Guideline. Chapter Description of the optimisation process is providing a short overview of the UMTS optimisation process as covered by the UMTS RF Troubleshooting Guideline. Chapter Call setup is listing all problems that might occur at the call establishment phase. Chapter Call reliability is describing failures and problems that might occur after call establishment; examples are dropped calls, radio link failures or handover problems. Chapter Call quality is dealing with quality problems as perceived by the UMTS subscriber.

UMTS Operational Network Engineering

(For Internal Use Only)

Page 13 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

3.3.

How to read this guide


The main analysis chapters are subdivided into subsections that are describing the particular problems and failures step by step. Basis for the structure is the UMTS call handling. The subsections are structured as follows: In the first part, the problem and when applicable corresponding UTRAN parameters are described and listed; this part has the subtitle concept. In the second part called failure symptoms, identification and fixes for improvement there are if applicable two tables: o The first table is specifying the trigger points for the identification in the network interface trace or in the drive test data including the type of traces necessary for problem identification (e.g. Uu trace, 3G scanner measurements or TCP/IP protocol interface trace) The second table is listing the PM KPIs as retrieved by the UTRAN PM system

3.4. UTRAN/CN release and vendor dependency


This document is a living document and is updated on a regular basis based on the experience coming from the different projects. This version of the UMTS RF Troubleshooting Guideline is supporting ALU equipment only. Whenever a new UTRAN release is available certain tables and descriptions have to be updated while others parameters are project / market dependent and hence no particular value is assigned to them.

3.5.

Intended audience
This document is directed to system engineers, network planners, RF optimisation engineers and all SBG engineers who are optimising and troubleshooting ALU 9370 based UMTS network. This document assumes that the reader has a good understanding of the UMTS call processing and is familiar with the various troubleshooting and monitoring tools that are available like RFO, LDAT3G, CT (g, b or n), WQA, SPO in US and NPO in Global market.

3.6.

Disclaimer - what is not covered


This document is not covering Element Management Layer activities. As a consequence this Guideline cannot be used for troubleshooting maintenance task issues. This document does not support how to trace and to operate measurements instruments and tools. For more details check the corresponding documentation refered to in this document. Core Network specific problems are only covered in this guideline in the way to explain how to identify these kind of problems during the analysis. The question of the root cause and how to overcome this problem is not part of the UMTS RF Troubleshooting Guideline.

UMTS Operational Network Engineering

(For Internal Use Only)

Page 14 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

4. Description of the optimisation process


The different fields of UMTS RF optimisation can be summarised by the following items: FM audit and analysis RF design audit and optimisation CM audit and optimisation PM audit and optimisation Drive testing and investigation Network interface tracing and analysis Lab investigation and optimisation

These fields of UMTS optimisation are displayed in Figure 1 in yellow below.

Figure 1: ALU UMTS optimisation process process flow

UMTS Operational Network Engineering

(For Internal Use Only)

Page 15 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Pre-requisite before starting with a performance verification and optimisation is that The FM analysis shows no severe alarms that might influence the performance measurements as retrieved by the PM statistic or drive test data The RF design audit and optimisation has been finished for the region to be optimised

In case, one or both pre-requisites are not fulfilled starting with the performance investigation and troubleshooting does not make much sense. For troubleshooting and optimizing new clusters, the Drive test and interfaces traces would be more relevant than PMs that may get skewed because of small number of users.

UMTS Operational Network Engineering

(For Internal Use Only)

Page 16 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

5. Call setup
One important user perception of a UMTS network is the success of setting-up a UMTS call. This section is describing all kind of failures and problems that might occur during the call establishment phase. The different phases during the call setup are covered step-by-step in the following subsections of this chapter.

5.1.

Call setup RRC connection establishment


5.1.1.1. Concept PLMN selection and reselection Cell selection and reselection Location registration

5.1.1. PLMN/cell selection and reselection

The UE in idle mode has to perform the following tasks:

The whole procedure is visualised in Figure 2 below and will be explained in detail in the following subsections:

Figure 2: PLMN (re-)selection and cell (re-) selection process If the UE is in CELL_FACH or URA_PCH, the UE also performs cell reselections; however possible failures that may occur are covered in the subsection regarding failures on RACH (subsection 5.1.3) and FACH (subsection 5.1.6). In the following it is assumed that the UE is in idle mode. The NAS part is described in [1] and depends mainly on the information stored on the U-SIM [2]. After power-on the UE starts with the initial cell search procedure and tries to decode the network information as broadcasted by the 2G or 3G cells on the

UMTS Operational Network Engineering

(For Internal Use Only)

Page 17 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

BCCH. The UE is either selecting the best suitable cell (in terms of the cell selection criteria, see below) of its H-PLMN and starts with the location registration procedure or otherwise when the H-PLMN is not available the UE is selecting a non-forbidden PLMN, camping on the best suitable cell and starts with the location registration procedure. In case there is no suitable cell of a non-forbidden network (no roaming agreement, lack of coverage, SIM locked in the HLR etc.) the mobile enters the Limited Service state. In this state the UE is only allowed to initiate emergency calls in case it detects any PLMN coverage. The AS part is defined in [3] for UMTS and in [4] for GSM. Optimisation approach is to ensure that the UE camps on the best suitable cell (in terms of RF conditions, traffic distribution assumptions etc.) to setup a call. The process can be configured by OAM parameters as explained below: In case ACB is used the UE is selecting a non-barred cell based on either cell information stored on the U-SIM or after doing the initial cell search. Prerequisite for the cell selection (and also cell reselection) are that the following criteria are fulfilled:

For UMTS:

Squal = Qqualmeas - Qqualmin > 0 AND Srxlev = Qrxlevmeas Qrxlevmin - Pcompensation > 0 Srxlev = Qrxlevmeas Qrxlevmin - Pcompensation > 0

For GSM:

The different terms in the formula are defined as follows: Qqualmeas is the measured cell quality value. The quality of the received signal expressed in CPICH
Ec/N0 (dB) for FDD cells. Not applicable for TDD cells or GSM cells.

Qrxlevmeas is cell RX level value. This is received signal, CPICH RSCP for FDD cells (dBm),
P-CCPCH RSCP for TDD cells (dBm) and RXLEV for GSM cells (dBm) Pcompensation is the defined as Max(UE_TXPWR_MAX_RACH Max(MS_TXPWR_MAX_CCH P, 0) (GSM) P_MAX, 0) (UMTS),

UE_TXPWR_MAX_RACH is the maximum allowed power for the RACH and P_MAX is the maximum power for the given mobile power class.

The different OAM parameters of the formula above are listed in Table 1 below:

Parameter

Description

CellSelectionInfo Minimum required quality level in the cell (dB). Not applicable for TDD cells or GSM cells, broadcasted via SIB3 and SIB4 .qQualMin CellSelectionInfo Minimum required RX level in the cell (dBm), broadcasted via SIB3 and SIB4 .qRxLevMin PowerConfClass Maximum allowed UE Tx power (dBm) broadcasted on SIB3 and SIB4 .sibMaxAllowedUlTxP owerOnRach Table 1: Parameters used for cell selection The current formulas can only be used in case HCS is not deployed i.e. FDDCell.isHcsUsed = False. Furthermore while camping the UE shall start to perform inter-RAT measurements if Squal <= SSearchRAT, otherwise not. SSearchRAT is a configurable

UMTS Operational Network Engineering

(For Internal Use Only)

Page 18 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

UMTS parameter broadcasted on SIB3/SIB4. However note that to avoid ping ponging between UMTS and GSM the following condition should be fulfilled: FDD_Qmin > Qqualmin + SsearchRAT FDD_Qmin defines minimum UMTS quality before UE can reselect from GSM to UMTS layer. If the above condition is not satisfied, a UE will move from GSM to UMTS and immediately start monitoring neighboring GSM cells again, an undesirable condition. Furthermore frequent re-selections between UMTS and GSM can cause mobile terminating call failure in case the PLMN pages the current network while the UE is in the process of registering with the other network. In a similar way the criterion for UMTS Interfrequency measurements is defined; for this parameter Sintersearch is used and is broadcasted on SIB3/SIB4. The UE can only reselect one of the 2G or 3G cells that are defined in the reselection list that are broadcasted via SIB11/SIB12 on the BCCH. For cell reselection the target cell has to fulfill the same criteria as specified for the cell selection case. The UE ranks the cells according to the cell ranking criteria Rs (serving cell) and Rn (neighbour cell). The UE will reselect the best GSM or UMTS cell of the ranking list if at least Treselection (UMTS parameter) has elapsed when camping on the cell. For UMTS network without HCS the following formulas are used (both for GSM and UMTS neighbouring cells): Rs = Qmeas,s + Qhysts Rn = Qmeas,n - Qoffsets,n For UMTS Qmeas is based either on RSCP or Ec/No measurements of the server/neighbour cell depending on whether a first or second ranking is being performed, respectively. Qhysts is an hysteresis to avoid ping-pong effects, Qoffsets,n is an offset defined on a per-neighbour definition. . The reselection process using the mentioned parameters (Qoffsets,n = 0) is visualised in Figure 3 below:

Figure 3: Cell reselection process Table 2 below is listing the main parameters configuring the cell reselection process in case no HCS is used:

UMTS Operational Network Engineering

(For Internal Use Only)

Page 19 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Parameter CellSelectionInfo .tReselection CellSelectionInfo .sSearchRatGsm CellSelectionInfo .sInterSearch

Description
Time hysteresis for the cell reselection UMTS parameter broadcasted via the SIB3/SIB4 defining whether or not to start with inter-RAT measurements (setting of SSearchRAT) UMTS parameter broadcasted via the SIB3/SIB4 defining whether or not to start with UMTS interfrequency measurements (setting of Sintersearch)

CellSelectionInfo Hysteresis to avoid ping-pong effects (RSCP, Ec/No specific respectively) .qHyst1 .qHyst2 UmtsNeighbouringRelation or UMTS parameter broadcasted via the SIB11/SIB12 defining an offset on a per neighbour basis GsmNeighbouringCell .qOffset1sn UmtsNeighbouringRelation. UMTS parameter broadcasted via the SIB11/SIB12 defining an offset on a per UMTS FDD neighbour basis qOffset2sn Table 2: Most important parameter used for cell reselection, non HCS The Location Registration procedure is initiated by the UE by sending MM/GMM Direct Transfer messages. For these kinds of failures see subsection 5.3.1. The cell selection and reselection process and its translations are covered in more details in [17]. 5.1.1.2. Failure symptoms, identification and fixes for improvement

A failure of the PLMN selection/reselection during a drive test can be easily identified when the screen of the drive test mobile is showing Limited Service and the MNC of the selected cell is different from the H-PLMN. The root cause might be a network outage due to NodeB, RNC or any particular network interface like Iub or Iu (see also subsection 6.4.5 and 6.8) or when the test van is driven out of the coverage footprint of the (GSM and UMTS) network. In that case the drive test route should be checked. When the PM counters of the CN are showing a high rejection rate due to missing national roaming it may be caused by an interface problem to or an outage in the roaming networks be it UMTS or GSM. Another problem might be ACB on one or several of the surrounding GSM and/or UMTS cells. Information regarding Access Class Barring is broadcasted via SIB3 or SIB4 [6]. ACB is used during the integration of cells. Common problems of the cell selection/reselection procedure are non-optimised configuration of the UTRAN parameters shown in Table 1 and Table 2. As a consequence the call will be setup on a non-optimal cell or a non-optimal RAN so the call-setup might fail during the RACH procedure (subsection 5.1.3), the paging procedure (subsection 5.1.2) or during the call setup procedure (subsection 5.2). A consistency check of the parameters listed in Table 1 and Table 2 might help to find parameter misconfiguration. Parameter Qoffsets,n used for optimisation of a per-cell basis should be reviewed. In case of poor 3G coverage and low call setup success rate the parameter SSearchRAT might be set to a lower value so the UE will start earlier with inter-RAT measurements. Also the cell offsets for the GSM cells can be adapted to prefer call setup on the 2G layer.

UMTS Operational Network Engineering

(For Internal Use Only)

Page 20 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Another problem arises when different LA codes are defined for the GSM and UMTS networks and the Inter-RAT reselection criterion is met. This is in particular the case for subscribers inside a building where the UMTS coverage is not as strong compared to the GSM coverage, but the preference is on the UMTS network. As a consequence it is recommended to assign the same LA codes to GSM and UMTS cells that are providing coverage to the same area to avoid LAU ping-pong. Table 3 below is listing the identification techniques of PLMN/cell (re-)selection failures in drive test traces and scanner measurements:

Problem
Wrong PLMN selected ACB Call setup on nonoptimal cell Call setup on nonoptimal RAN technology Ping-pong LU between 2G / 3G

Trace
Uu Uu Uu, 3G scanner Uu, 2G/3G scanner

Trigger
Any occurrence of the MNC of the cell the UE is camping on is different from the MNC of the H-PLMN Any occurrence of IE Access Class Barred = TRUE in SIB3/SIB4 The call is setup via RRCConnectionSetup message on a cell that is not on the x best cell listed by the 3G scanner within y dB window. The RXLEV of the best measured 2G cell is within a x dB window (or even better) for y seconds compared to the RSCP of the cell the UE is camping on when sending the RRC Connection Request or Cell Update message on RACH There are two consecutive LUs between 2G and 3G within x seconds and the LA codes for the cells are different.

Uu

Table 3: Identification of PLMN/cell (re-)selection failures in traces Cell selection and reselection failures cannot be detected via PMs because the process is within the UE. Failures during the Location Registration procedure are identified via CN PMs and covered in subsection 5.3.1.

5.1.2. Failures on the AICH, PICH and PCH 5.1.2.1. Concept

The UTRAN might initiate the paging procedure because of the following events: The UTRAN is receiving a paging request from the CN via RANAP The UE has an established PDP context, but the UE is in URA_PCH or Cell_PCH mode and downlink PS data are scheduled to be delivered

If the UE is in idle, URA_PCH or CELL_PCH modes and the UE is receiving a Paging Indication on the PICH from the NodeB; then the UE is starting to monitor the PCH to receive the paging (Paging Type 1). In case the UE is in connected mode and is paged, then the UTRAN is sending the paging via DCCH (Paging Type 2). The CN might perform a repetition of paging process in case the UE has not answered within a certain time period. In addition the RNC might trigger the repetition of the UE paging in the UTRAN. The repetition timers of the RNC and CN have to be set accordantly. In the following it is assumed that the UE is not in connected mode so it has received a Paging Type 1.

UMTS Operational Network Engineering

(For Internal Use Only)

Page 21 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

After the UE has successfully decoded the paging on the PCH it sends a RACH Preamble using the open loop power control algorithm. When the NodeB receives the RACH Preamble it answers by sending an indication on the AICH, the reception of the AICH is answered by the UE by sending a RRC Connection Request/Cell Update/URA Update message using the RACH (so called RACH Message Part). Upon successful decoding the NodeB forwards the RACH Message Part to the RNC. RACH failures are covered in subsection 5.1.3. The RNC sends back (on the FACH) the RRC Connection Setup/Cell Update Confirm/URA Update Confirm message (successful case). FACH failures are covered in subsection 5.1.6. 5.1.2.2. Failure symptoms, identification and fixes for improvement Non-optimal power settings of the PICH, AICH or PCH Poor radio conditions in terms of low RSCP or Ec/No because of e.g. pilot pollution (subsection 6.4.1), poor RF coverage (subsection 6.4.5), camping on a non-optimal cell (see subsection 5.1.1) etc. Congestion on the PCH UTRAN sending paging to incorrect URA area or mismatch in paging DRX cycle coefficient (sent in SIB1, RRC connection setup and RB reconfiguration messages) or UE timing issues to lock on PCH (i.e. UE still asleep when paging is sent) especially if no response from UE while RF conditions are good

Failures on the PCH, PICH and AICH are most likely due to

Table 4 below is listing the main UTRAN parameters configuring the PICH, PCH and AICH:

Parameter PCH. pichPowerRelativeToPcpich SCCPCH. SccpchPowerRelativeToPcpich RACH. aichPowerRelativeToPcpich xxPagingTimer1 PCH. nrOfPagingRepetition

Description
UTRAN parameter defining the power settings of the PICH UTRAN parameter defining the power settings of the SCCPCH UTRAN parameter defining the power settings of the AICH Timeout when the RNC will repeat the paging Number of Type 1 paging repetitions sent by the RNC provided isPagingRepetitionAllowed = True

Table 4: Parameter used for configuring the PICH, AICH and PCH

The paging itself is sent on the PCH that is a PHY channel on Uu. The drive test equipment can record paging requests. However analysing drive test logs is not a good way to investigate paging problems because paging that is not received by the UE can only be detected via parallel Iub tracing. A better approach for analysing call setup problems due to paging failures is to use PM counters of the UTRAN.
1

Note this is a static MIB parameter and is not visible via OAM (e.g. WiPS) (For Internal Use Only) Page 22 of 110

UMTS Operational Network Engineering

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

If the UE is in URA_PCH or CELL_PCH mode, the RRC connection is maintained via the common physical channels (subsection 6.6). When the UE cannot be reached via paging the UTRAN may decide to drop the RRC connection.

VS.IuReleaseReq.PS.UtranPageFail

Figure 4: Dropped RRC connection due to unsuccessful paging A solution of lowering the paging load might be to separate the FACH and PCH on two SCCPCH by introducing an additional SCCPCH channel. In addition creating smaller Location Areas / Routing Areas will also lower the paging load. Failures on the AICH or PICH (PHY channels, no corresponding Transport channels) can be detected using advanced UE log collection. In such cases UE repeats RACH preamble and there is no AICH reply even after max number of preambles exhausted; on the other hand if AICH reports NACK it means power settings for AICH is optimum but we could have UL RSSI issue which leads to maximum preamble being transmitted but still NACK received on AICH. Note that PHY ACK on AICH can only be recorded and analysed by certain UE tools like Qualcomm QXDM and QCAT respectively. In addition normal RF optimisation for areas with low Ec/No will improve the situation and power increase can also help if no AICH response seen on PHY. Table 5 below is listing of how failures on the PICH/AICH/PCH can be identified in network traces: UMTS Operational Network Engineering (For Internal Use Only) Page 23 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Problem
RRC drop due to unsuccessful paging

Trace
CT

Trigger
Cross correlation Iu and CTg trace: any occurrence where a UE page is recorded in CT, there is no Cell Update recorded on CT within x seconds and the RNC is sending back within y seconds an Iu Release Request message with cause Release due to UTRAN generated reason (UE is either in URA_PCH or CELL_PCH mode) Any occurrence where a UE is paged and recorded on the CT and there is no answer by the UE on UL CCCH also recorded in the CT within x seconds

Unsuccessful paging

CT

Table 5: Identification of PICH/PCH/AICH failures in traces Table 6 below is listing the identification possibilities using KPIs/Counters retrieved by the UTRAN PM system. PM system
UtranCell

Counter / KPI
(VS.NbrCellUpdates.PagingResponse /(VS.IuReleaseReqPS.UtranPageFail + VS.NbrCellUpdates.PagingResponse)) VS.UnhandledPagingRequests.OverloadControls

KPI Name / Description


UTRAN pagging response success rate

RNC

This measurement provides the number of paging attempts discarded by the RNC TPU due to processor load for CS and PS calls This measurement provides the number of paging attempts received by the RNC Provides the channel occupancy for the PCH channel

RNC UtranCell

VS.ReceivedPagingRequest VS.CommonMacDownlinkPcchSdu

Table 6: PM KPIs/Counters for PICH/PCH/AICH failures

5.1.3. Random Access Procedure 5.1.3.1. Concept

The RACH Access Procedure is used when attaching to the network, setting up a call, answering to a page or performing a LA Update/RA Update. The RACH procedure has been successfully performed when the RACH Message Part is received by the RNC upon successful decoding at the NodeB. The RACH is transmitted on the PHY in two separated parts: first a certain number of RACH Preambles are sent. The power of the first RACH Preamble is relatively low and calculated using Open Loop Power Control. Each of the following RACH Preambles are transmitted with an increased power level till an ACK is received on the AICH. Then the UE transmits the RRC Connection Request (Cell Update, URA Update) message in the RACH Message Part. Figure 5 below illustrates the transmission of several RACH Preambles in different Ramping Cycles and only after the reception of an ACK on AICH, the transmission of the RACH message part:

UMTS Operational Network Engineering

(For Internal Use Only)

Page 24 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Figure 5: RACH procedure with RACH Preambles and Message Part When the UE sends the RRC Connection Request message for the first time, it resets its internal counter V300 to 1 and stars its internal guard timer T300 (taken from UTRAN parameter t300); if the UE has already sent one or several RRC Connection Request messages before, counter V300 is incremented by one and guard timer T300 is restarted. Upon reception of the RRC Connection Request message at the RNC, PM counter RRC.AttConnEstab.<per 2 establishment cause> is incremented by one . Upon expiry of timer T300 the UE may start again by sending RACH Preambles depending on the status of counter V300. If V300 <= N300 (configured by UTRAN parameter n300), the UE increments V300 by one, resets T300 and sends the RACH Preamble again. If V300 > N300, the UE stops sending on the RACH and stays in idle mode [6]. For the Cell Update and URA Update procedure N302 and T302 are used (from network broadcasted parameters n302 and t302). Figure 6 below is showing as an example the Cell Update procedure:

Figure 6: Cell Update procedure supervised by T302 and N302

<per establishment cause> is a placeholder for e.g. OrigConvCall, OrigStrmCall etc. A full list is available in [27]. UMTS Operational Network Engineering (For Internal Use Only) Page 25 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Failures in the RACH procedure occur if either the RACH Preamble or the RACH Message Part cannot be decoded. Possible reasons for these decoding problems are: Non optimal RACH power settings Non optimal RACH counter/timer settings RACH congestion Non optimal setting of RACH search Window
3

Poor radio conditions in terms of low RSCP or Ec/No because of e.g. pilot pollution (subsection 6.4.1), poor RF coverage (subsection 6.4.5), camping on a non-optimal cell (see subsection 5.1.1) etc.

In the following only the RACH specific issues are covered, for the other (common) RF issues see the corresponding subsections. Table 7 below is listing the main UTRAN parameters configuring the RACH:

Parameter RACH. constantValue RACH. powerOffsetPo RACH. preambleRetransMax RACH. preambleThreshold PowerConfClass .sibMaxAllowedUlTxP owerOnRach RACHTxParameters. mMax UeTimerCstIdelMode .t300 UeTimerCstIdelMode .n300 UeTimerCstConnected Mode .t302 UeTimerCstConnected Mode .n302

Description
Used by UE to calculate Initial Preamble Power Determines the power increment between two successive RACH Preambles Determines the maximum number of preambles allowed within one Power Ramping Cycle The threshold for preamble detection. The ratio between received preamble power during the preamble period and interference level shall be above this threshold in order to be acknowledged. This parameter is ignored by OneBTS, as it uses its internal value. This parameter defines the maximum allowed power the UE may use when accessing the cell on PRACH in idle mode Determine the maximum number of power ramping cycles allowed

UE guard timer that is supervising the RRC Connection Setup procedure when the UE is waiting for the RRC Connection Setup message Defines the number of times the UE is allowed to send the same RRC Connection Request message UE guard timer that is supervising the Cell/URA Update procedure when the UE is waiting for the Cell Update Confirm/ URA Update Confirm message Defines the number of times the UE is allowed to send the same Cell Update/ URA Update message

Table 7: Parameter used for configuring the RACH

Static NodeB tunable parameters for OneBTS and Class 0 parameter BTSCell.cellSize in iBTS (For Internal Use Only) Page 26 of 110

UMTS Operational Network Engineering

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

5.1.3.2.

Failure symptoms, identification and fixes for improvement

The RACH Preambles may only be recorded in internal UE or NodeB traces, but not by normal drive test tools. In most cases only limited statistic about the PHY and MAC procedure of the RACH is listed in the drive test logs e.g. number of RACH Preambles sent, last transmitted power etc4. The RACH performance can be improved by changing of the power settings and/or changing of the timer/counter as listed in Table 7. Also refer to suggestions in section 5.1.2.2 in this regards. Table 8 below is listing the identification possibilities for network and UE traces; Table 9 below is listing the identification possibilities using KPIs retrieved by the UTRAN PM system.

Problem
RACH message lost

Trace
Uu and CT

Trigger
Cross-correlation Uu/CT trace: RACH Message Part (RRC Connection Request, Cell Update or URA Update) is recorded on the Uu, but not captured in CT traces.

Table 8: Identification of RACH failures in traces PM system


UtranCell

Counter / KPI
(VS.CommonMacUplinkCcchSdu / (VS.CommonRlcCcchDiscardSdu + VS.CommonMacUplinkCcchSdu)) VS.CommonMacUplinkDcchOverRachSdu + VS.CommonMacUplinkDtchOverRachSdu VS.NbrCellUpdates.<causes>

KPI Name / Description


KPI RACH transport block good CRC rate is the percentage of RACH Transport Blocks with good CRC. This measurement provides the channel occupancy for Radio Access Channel. Number of cell updates received with a specific cause like RLC error, RLF, Cell re-selection, reentered service area, paging response, uplink data transmission and periodic cell update

UtranCell UtranCell

Table 9: PM KPIs for RACH failures

5.1.4. Call Admission Control (CAC) 5.1.4.1. Concept

The Call Admission Control (CAC) procedure admits or denies the establishment of the RRC connection upon RACH access to avoid an overload of the UMTS system. The CAC thresholds can be defined based on uplink noise rise and downlink load separately. The CAC algorithms and the corresponding parameter are described in detail in [17]. The CAC is started after the RNC receives the RRC Connection Request message on RACH and executes UL and DL CAC before setting up the first RL on NBAP for the initial SRB channel (see Figure 7 below):
4

Note: It might be that in the drive test logs a RRCConnectionRequest message is listed, but the RACH message part is never transmitted via the air interface in case the RACH preamble has already failed. The higher layer (RRC) initiates the transmission of the RACH message. In case of a lower layer failure to deliver preamble it is up to the higher layer re-initiate the whole RACH procedure again (means in the RRC decoding another RACH Message would be listed). UMTS Operational Network Engineering (For Internal Use Only) Page 27 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

RRC.FailConnEstab.Cong.Sum

Figure 7: CAC executed after reception of RACH Message Part If the defined thresholds for CAC are exceeded the RRC connection establishment request is denied and a RRC Connection Reject message with cause Congestion is sent back to the UE. The only optimisation approach in case of CAC rejections is to optimise the RF environment in terms of pilot pollution, neighbour list optimisation etc. In addition it should be verified that the CAC thresholds are set correctly and the power control settings dont result in consuming too much resources to support a call. Table 10 below is listing the main parameters configuring CAC before RRC connection setup is sent back from UTRAN:

Parameter CacConfClass .maxUlInterferenceLevel PowerPartConfClass .callAdmissionRatio

Description
Specifies the threshold for UL call admission of a RRC connection request received on RACH. Specfies the threshold for DL call admission of a first RL setup in response to RRC connection request received

Table 10: Parameters configuring CAC at RRC connection setup

5.1.4.2.

Failure symptoms, identification and fixes for improvement

CAC failures can only be identified in a reliable manner via PM counters or internal call trace/ UE logs.

Problem
RRC Connection Reject

Trace
Uu or CT

Trigger
After the UE sends a RRC Connection Request message and RNC replies with RRC Connection Reject message with cause Congestion.

Table 11: Identification of RRC Connection Reject due to Congestion For CAC related PM KPIs see [27] however the main PM counter is given below:

UMTS Operational Network Engineering

(For Internal Use Only)

Page 28 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

PM system
UtranCell UtranCell UtranCell

Counter / KPI
RRC.FailConnEstab.Cong.Sum RRC.FailConnEstab.DLPowRsrc VS.RadioLinkFirstSetupFailure.R rmRefusal

Name / Description
This measurement provides the number of RRC connection rejects sent with cause Congestion This measurement provides the number of failed RRC connection due to lack of DL power First RL setup failure caused by rejection due to lack of resources

Table 12: PM Counter for CAC failures 5.1.5. Radio Link Setup 5.1.5.1. Concept During the call establishment phase after the CAC is granted, the RNC requests the NodeB to allocate resources through the NBAP Radio Link Setup message. In case of soft handover when allocating resources on a new NodeB

The Radio Link Setup procedure is initiated in two cases:

Note that after the Radio Link Setup on NBAP the RNC should initiate the establishment of the AAL2 bearer over the Iub interface using ALCAP (ALCAP Establishment Request and ALCAP Establishment Confirm). Problems on ALCAP could be due to ATM configuration and are outside the scope of this document. ATM synchronisation problems are not expected at this stage of the call because of the already successful NBAP procedure. The same is valid for the synchronisation between NodeB and RNC via the DCH-FP over AAL5 bearer.

Figure 8: Initial RRC Setup Steps after successful CAC 5.1.5.2. Failure symptoms, identification and fixes for improvement

The NBAP First Radio Link Setup procedure may fail and the NodeB sends back the Radio Link Setup Failure message.

UMTS Operational Network Engineering

(For Internal Use Only)

Page 29 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

According to [7] the failure causes can be classified as follows: Radio Network Layer Cause Transport Layer Cause Protocol Cause Miscellaneous Cause

Each category has many subcauses like Transport Resources unavailable, NodeB Resources unavailable, DL Radio resources unavailable, Semantic error etc. 3GPP has defined a variety of failure causes. Here one major reason for NodeB resources problem can be UCU/CEM capacity shortage, while transport resources issue can point to the backhaul bandwidth limitation. RNC can also cancel an on-going NBAP pocedure if nbap_TimerInMsec expires. This is a static parameter in 9370 and all such parameters need a MIB patch if a change is required. Table 13 below is listing the identification possibilities for network interface traces; Table 14 is listing the identification possibilities using KPIs retrieved by the UTRAN PM system. For identification of failures during the Radio Link Setup procedure, CT traces are mandatory. Reason is that on Uu, the RRC Connection Reject message is available with only two possible failure causes (congestion and unspecified), see also subsection 5.1.4.

Problem
Radio Link Setup I

Trace
Uu and CT CT

Trigger
Cross-correlation Uu/CT trace: Any occurrence of the NBAP Radio Link Setup Failure message in CT and RRC Connection Reject with cause unspecified or congestion after that Any occurrence of the NBAP Radio Link Setup Failure message in CT

Radio Link Setup II

Table 13: Identification of failures in the Radio Link Setup PM system


UtranCell

Counter / KPI
(RRC.FailConnEstab.Unspec / RRC.AttConnEstab.<sum>)

KPI Name / Description


Failed RRC Connection Establishment Rate due to cause unspecified Radio link setup success rate on Iub Radio link setup failure rate on Iub due to lack of resources (NodeB &/or transport) First RL setup attempt failure with 8 different screenings Radio link setup success rate on Iur

UtranCell UtranCell

(VS.RadioLinkSetupSuccess / VS.RadioLinkSetupRequest.<sum>) ((RLM.FailRLSetupIub.PS.Resource + RLM.FailRLSetupIub.CS.Resource) / VS.RadioLinkSetupRequest.<sum>) VS.RadioLinkFirstSetupFailure.<cause>5 (VS.IurDrncRadioLinkSetupSuccess / (VS.IurDrncRadioLinkSetupUnsuccess + VS.IurDrncRadioLinkSetupSuccess))

UtranCell RNC

Table 14: PM KPIs for Radio Link Setup procedure

<cause> include RRM refusal, INode refusal, timeout, RL setup failure, Iub congestion, lack of Iub CID, lack of CEM L1 resources, lack of Iub bandwidth. (For Internal Use Only) Page 30 of 110

UMTS Operational Network Engineering

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

5.1.6.Call setup failures on the FACH 5.1.6.1. Concept

This subsection is covering only call setup related failures on FACH; for failures in CELL_FACH mode see subsection 6.7. It is assumed that the RACH Message Part has been successfully received, the CAC has been granted and the RL are established. In this case the RNC sends back either the RRC Connection Setup, Cell Update Confirm or URA Update Confirm message on FACH (successful case). Here we only discuss RRC connection procedure The RNC sends the FACH message, resets internal counter V351 and starts its guard timer T351. When the RNC receives the answer by the UE (i.e. RRC Connection Setup Complete) before T351 expires, the RNC stops T351. If the RNC does not receive the message before T351 expires, the RNC may resend the FACH message depending on the status of V351. If V351<= N351 (maximum number of retries), the RNC increments V351 by one, resets timer T351 and sends the FACH message again. If V351 > N351, the RNC will stop sending FACHs to the UE and will release the reserved resources on NBAP and ALCAP. This UE context release will be initiated by counter T352. Note that the RNC will not send any failure message on the Uu. The whole procedure is visualised in Figure 9 below:

UMTS Operational Network Engineering

(For Internal Use Only)

Page 31 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

RRC.FailConnEstab.TimeoutRepeat + RRC.FailConnEstab.Reselect

Figure 9: Failures on FACH during RRC connection phase Table 15 below is listing the parameters configuring the FACH:

Parameter FACH. fachTrbPowerOffset FACH. fachSrbPowerOffset CallAccessPerformanceConf. t351 CallAccessPerformanceConf. n351 CallAccessPerformanceConf. t352

Description
UTRAN parameter defining the power settings of the FACH data part UTRAN parameter defining the power settings of the FACH control part UTRAN timer to repeat RRC connection setup upon expiry

Maximum number of RRC connection setup repititions

UTRAN timer to release UE context upon expiry, should be => t351*(n351+1)

Table 15: Parameters used for configuring the FACH

UMTS Operational Network Engineering

(For Internal Use Only)

Page 32 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

5.1.6.2.

Failure symptoms, identification and fixes for improvement Non optimal UTRAN parameter settings (e.g. FACH signalling and traffic power) FACH message is not successfully decoded due to poor FACH coverage. This can be improved by enabling the RRC connection quick repeat and FACH power adjustment feature by setting CallAccessPerformanceConf.isQuickRepeatAllowed = TRUE Call setup not done on an optimal cell (subsection 5.1.1) The message on the FACH is successfully decoded by the UE, but afterwards the RNC cannot successfully decode the answer sent by the UE (UE is already in CELL_DCH mode, see also subsection 5.2) Rogue UE keeps retrying to setup RRC connection via RACH but does not repond to RRC connection setup from RNC. No IMSI assigned at this stage so difficult to pinpoint the UE. One can use propagation delay IE in the RRC connection setup request and LAC/RAC to validate if single UE is responsible.

There are the following possible reasons for failures on FACH:

Failures on the FACH can be indicated by UTRAN PM Statistics, Iub and Uu traces. On Uu FACH failures cannot be directly observed because there is no corresponding failure message sent. Table 16 below is listing the identification of FACH failures using call trace and UE logs, Table 17 the corresponding PM KPIs:

Problem
Lost FACH SRB message FACH Failure

Trace
Uu and CT Uu and CT

Trigger
Cross-correlation Uu/CT trace: one or more FACH messages are recorded in CT, but not on the Uu interface Occurrence of Cell Update messages (repeated Cell Update Confirms ignored by the UE as seen in CT), then RRC Connection Release message with specified cause other than normal event sent back by the RNC on Uu

Table 16: Identification of failures on the FACH

PM system
UtranCell UtranCell

Counter / KPI
((RRC.FailConnEstab.TimeoutRepeat + RRC.FailConnEstab.Reselect) / RRC.AttConnEstab.<sum>) VS.CommonMacDownlinkDcchOverFachSdu + VS.CommonMacDownlinkDtchOverFachSdu

KPI Name / Description


Failed RRC connection Establishment Rate timeout BW Occupancy on FACH

Table 17: PM KPIs for failures on the FACH

5.2.

Call setup failures during the call setup phase


At this point in time the UE is in the transition phase to CELL_DCH mode. The next message will already be sent in the new mode (RRC Connection Setup Complete sent on UL DCCH). Straight after transitioning to CELL_DCH, UE can be put in soft/softer handover. This is the case if

5.2.1. Concept

UMTS Operational Network Engineering

(For Internal Use Only)

Page 33 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

UE is configured to report the measurements of more than one NodeB by activation of Event 1A measurement on SIB 11 The measurement from more than current cell is reported RNC then directs the UE to soft/softer HO through ASU procedure

Table below is listing the parameters that are important for the call setup phase:

Parameter HoConfClass .Event1AHoConfInSIB11

Description
Object that contains the event 1A related parameters like reporting range, time to trigger, hysteresis etc broadcasted on SIB 11

FDDCell. Activates the event 1A measurement to be broadcasted on SIB11 isSib11MeasReportingAllowed Table 18: Parameter important for the call setup phase

For more details about the translations see [17]. If the call is setup in an area where several NodeBs are providing marginal coverage and if it is not possible to add the radio legs quickly, there is a big likelihood that the call will fail before RAB is actually established. The above feature tries to minimise the wait for the reception of the Measurement Control message and helps in avoiding a call drop in such conditions. 5.2.2.Failure symptoms, identification and fixes for improvement The RRC connection might drop in this early stage due to the following reasons: Non optimal handover parameter configuring the call setup in soft/softer handover mode Non optimal power settings Poor radio conditions in terms of low RSCP or Ec/No because of e.g. pilot pollution (subsection 6.4.1), poor RF coverage (subsection 6.4.5), camping on a non-optimal cell resulting in non-optimal reselection list (see subsection 5.1.1) etc.

There are no specific PM counters available that can be used to identify issues during the call setup phase because at this point the UE is already in CELL_DCH mode so a drop of the RRC connection cannot be differentiated from an RRC drop occurred in a later stage of the call. Also the drop might occur only a very short time later, but the root cause for the failure is one of the issues mentioned above. Nevertheless it is possible to identify issues in UE traces as listed in Table 19 below:

Problem
Call setup on a nonoptimal cell Not best cells in AS at call setup

Trace
Uu, 3G scanner Uu, 3G scanner

Trigger
The call is setup via RRCConnectionSetup message on a cell and at the same time the 3G scanner is reporting at least x cells that are within a y dB window compared to the best measured cell. The number of cells in the Active Set is smaller than max AS size, but one neighbouring cell is within xdB window compared to the Ec/No of the best cell in the Active Set

UMTS Operational Network Engineering

(For Internal Use Only)

Page 34 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Drop of RRC connection at call setup

Uu

The call is dropped within x seconds after sending the RRC Connection Request

Table 19: Identification of call setup in traces

5.3.

Call setup Core Network failures


After establishment of the RRC connection the UE and the CN exchange Direct Transfer messages so the UE can GPRS attach to the PS network, perform a Location or Routing Area Update or initiate a data, voice or VT call. LAU/RAU involves only the mobility management procedures while the Call setup also includes call control and session management protocols for CS and PS calls respectively. The following subsections are summarising possible failures that might occur during these procedures. The subsections are grouped by the following three different protocols: Mobility Management (MM) and GPRS Mobility Management (GMM) Call Control (CC) Session Management (SM)

The three protocols are sublayer protocols of the Connection Management (CM); these protocols are specified in [5] and [8]. CM failures causes like CM Service Reject Cause is mapped on the Reject Cause of the Mobility Management IE [5]. Note that (almost) any failure in this subsection is not UTRAN related because 6 Direct Transfer messages are transparent to the UTRAN . Any of the failures can be easily detected by the corresponding failure messages. Because the protocols are transparent to the UTRAN all PM KPIs are defined within the CN entities e.g. SGSN / GGSN, 3G-MSC basis.

5.3.1. Mobility Management failures 5.3.1.1. Concept

The main function of the mobility management is to support the mobility of user terminals, such as informing the network of its present location and providing user identity confidentiality. A mobility management context in the SGSN or 3GMSC is a prerequisite for the initialisation of voice, data or VT services. 5.3.1.2. Failure symptoms, identification and fixes for improvement

For the root cause analysis please review the timer settings supervising the mobility management protocols as specified in [5] chapter 11.2. The settings of these timers are specified and not configurable. In addition Mobility Management failures might be due to missing roaming agreement, locked SIM card, CN problems like authentication not possible due to inaccessible HLR database etc. The failure messages are retrieved from [5] chapter 9.2 (MM/CM)

Exception: there might be the case that due to a bad RF environment the direct transfer messages cannot be delivered to the other entity because the RLC layer is not able to deliver the corresponding message also after RLC retransmissions, RLC resets etc. It is up to the corresponding higher layer (e.g. CC, GMM, MM or SM) to react accordantly of the discarded message. UMTS Operational Network Engineering (For Internal Use Only) Page 35 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

and 9.4 (GMM). Table 20 below is listing the Mobility Management failures as they can be retrieved by UE or call traces:

Problem
MM Authentication Reject CM Service Reject CM Service Abort

Trace
Uu or CT Uu or CT Uu or CT

Trigger
Any occurrence of a MM Authentication reject message sent by the CN e.g. because of not-allowed national/international roaming Any occurrence of a CM Service reject message sent by the CN; the reject cause will give an indication of the occurred failure. Any occurrence of a CM Service abort message sent by the UE. This message is sent by the mobile station to the network to request the abortion of the first MM connection establishment in progress and the release of the RRC connection. Any occurrence of a MM Abort message sent by the CN. This message is sent by the network to the mobile station to initiate the abortion of all MM connections and to indicate the reason for the abortion. The rejection cause will give an indication about the occurred failure. Any occurrence of a MM Location updating reject message sent by the CN. The specified rejection cause will indicate the reason for the failure e.g. IMSI unknown in the HLR, illegal MS/ME, roaming not allowed etc. Any occurrence of a GMM Attach Reject message sent by the CN. The specified rejection cause will indicate the reason for the failure e.g. protocol error, wrong or incorrect IE format etc. Any occurrence of a GMM Authentication and Ciphering Failure message sent by the UE. The specified rejection cause will indicate the reason for the failure e.g. a sync failure. Any occurrence of a GMM Authentication and Ciphering Reject message sent by the CN. Any occurrence of a GMM Routing area update reject message sent by the CN. The specified rejection cause will indicate the reason for the failure e.g. protocol error, wrong or incorrect IE format etc. Any occurrence of a GMM Service reject message sent by the CN

MM Abort

Uu or CT

MM Location Updating Reject

Uu or CT

GMM Attach Reject

Uu or CT

GMM Authentication and Ciphering Failure GMM Authentication and Ciphering Reject GMM Routing Area Update Reject GMM Service Reject

Uu or CT

Uu or CT Uu or CT

Uu or CT

Table 20: Identification of Mobility Management failures in interface traces For listing of the PM KPIs of the Mobility Management refer to the PM counters documentation of the 3G-MSC and SGSN from applicable vendor.

5.3.2.Call Control failures 5.3.2.1. Concept

This subsection describes failures on the Call Control (CC) protocol. The CC protocol is responsible for CS call establishment and clearing procedures, calls information phase procedures etc. CC procedures can only be performed if a MM context has been established between the UE and the CN (subsection 5.3.1). 5.3.2.2. Failure symptoms, identification and fixes for improvement

Table 21 below is listing the CC failures as they can be retrieved by various traces [5]; note that the specified cause might depend on the 3G-MSC/UE vendors:

UMTS Operational Network Engineering

(For Internal Use Only)

Page 36 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Problem
Abnormal Disconnect Abnormal Release CC CC

Trace
Uu or CT Uu or CT

Trigger
Any occurrence of a CC Disconnect message (either UE or CN initiated) with specified cause other than normal event Any occurrence of a CC Release / Release Complete message (either UE or CN initiated) with specified cause other than normal event

Table 21: Identification of CC failures in interface traces For listing of the PM KPIs of the CC failures as they can be retrieved by the PM system of the 3G-MSC, refer to PM counters documentation from applicable CN vendor. Depending on the specified failure cause the failure might be due to missing resources (e.g. requested circuit/channel not available), drive test configuration issue (e.g. User busy) or protocol failure. For the root cause analysis please check the timer settings supervising the CC protocol in [5] chapter 11.3. The settings of these timers are not configurable.

5.3.3.Session Management failures 5.3.3.1. Concept

The main function of SM is to support the PDP context handling of the PS services. The SM comprises procedures for identified PDP context activation, deactivation and modification. SM procedures for identified access can only be performed if a GMM context has been established between the UE and the CN (subsection 5.3.1). 5.3.3.2. Failure symptoms, identification and fixes for improvement

The failure messages are retrieved from [5]. Table 22 below is listing the SM failures as they can be retrieved by either UE logs or UTRAN call trace:

Problem
SM Activate PDP Context Reject

Trace
Uu or CT

Trigger
Any occurrence of a SM Activate PDP Context Reject message sent by the CN. The specified rejection cause is giving an indication of the type of failure e.g. protocol error, missing or faulty APN, lack of resources etc. Any occurrence of a SM Activate Secondary PDP Context Reject message sent by the CN. The specified rejection cause is giving an indication of the type of failure e.g. protocol error, missing or faulty APN, lack of resources etc. Any occurrence of a SM Request PDP Context Activation Reject message sent by the UE. The specified rejection cause is giving an indication of the type of failure e.g. protocol error, feature not supported, lack of resources etc. Any occurrence of a SM Modify PDP Context Reject message sent by the CN. The specified rejection cause is giving an indication of the type of failure e.g. protocol error, service option not supported, lack of resources etc.

SM Activate Secondary PDP Context Reject

Uu or CT

SM Request PDP Context Activation Reject

Uu or CT

SM Modify PDP Context Reject

Uu or CT

Table 22: Identification of SM failures in interface traces

UMTS Operational Network Engineering

(For Internal Use Only)

Page 37 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Again for listing of the PM KPIs of the SM failures as they can be retrieved by the PM system of the GGSN, refer to PM counters documentation from applicable CN vendor. The most common SM failures are PDP Context activation failures due to wrong or missing APN or if the user is not allowed to subscribe to PS services. This is also a typical configuration issue of the drive test equipment. For the root cause analysis please review the timer settings supervising the SM protocol in [5] chapter 11.2.3. The settings of these timers are specified and not configurable.

5.4.

Call setup RAB establishment


The RAB establishment is started at higher layer signalling after the RRC Connection establishment and CM procedures are successful. Figure 10 below is showing the flow chart for a PS data call:

Figure 10: RAB establishment procedure RAB establishment procedure is always initiated by the RANAP RAB Assignment Request and terminated by the RAB Assignment Response. The failure and failure causes of the RAB Establishment are specified in [9]. In ALU UTRAN, a RRC RB reconfiguration for RLC settings change is also done straight after RNC receives the RB setup complete. And UTRAN only sends back RAB Assignment Response upon completion of this reconfiguration. This is the case if SRB with high data rate is used to setup call and later changed to lower rate and both use different RLC settings. In case low rate SRB channel is used throughout or same RLC settings employed for the two SRB then this extra reconfiguration doesnt take place and call flow as per

UMTS Operational Network Engineering

(For Internal Use Only)

Page 38 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Figure 10 applies. Table 23 below is listing how to identify failures of the RAB establishment procedure in network call trace:

Problem
RAB establishment failure

Trace
CT

Trigger
Any occurrence of an RAB Assignment Response with specified failure cause according to 3GPP7

Table 23: Identification of RAB establishment failures in traces

In the following subsections possible root causes for an unsuccessful RAB establishment are discussed in detail.

5.4.1. Intelligent Rate Matching CAC (iRM CAC) 5.4.1.1. Concept

iRM CAC is used to prevent overload of the system due to high call load, in case new resources or increase in resources are requested. In case Fair sharing (feature 33694) is enabled, in addition of R99 traffic, GBR calls on HSDPA will also be taken into account, in DL power and code cell colour calculations. This check takes place During the RAB establishment after the RNC is receiving the RAB Assignment Request on RANAP During the transition of CELL_FACH/URA_PCH to CELL_DCH mode (see also subsection 6.6) after the RNC is receiving the corresponding RACH messages In case data rate increase is triggered (see also subsection 7.2.3) after the RNC measures the DL BO/throughput increase or receives a UL BO RRC Measurement Report from the UE In case data rate change is triggered due to downlink dedicated Tx code power crossing certain thresholds for a R99 PS call

Cell colour thresholds can be defined for UL (noise rise, CEM) and DL (power, code, CEM) loads separately and options exist to disregard taking into account some of these resources in overall cell colour calculations. In case iRM CAC grants the requested service the call handling proceeds as specified (depending on the phase of the call), otherwise the call handling is as follows: During the RAB establishment the RNC sends a RAB Assignment Response message on RANAP with specified cause No resource available under miscellaneous class. On Uu the following messages/outcomes will be indicating that CAC has not granted the requested service: o The assigned PS RB is smaller than the default one or the one requested in the PDP Context Activation message8; the default PS RB is configurable

There are a huge number of failure causes, but not all related to RAB assignment failure. (For Internal Use Only) Page 39 of 110

UMTS Operational Network Engineering

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

OR the PDP Context Activation is rejected with an appropriate specified cause like QoS not accepted or Insufficient resources o o o The VT call is not granted or instead a voice call is setup The Voice call receives a CC Disconnect message with specified cause resource unavailable

During the transition of CELL_FACH/URA_PCH to CELL_DCH mode: The RNC sends back the UE to idle mode with the RRC Connection Release message and specified cause congestion OR The RNC sends back to the UE either a Cell Update Confirm / URA Update Confirm message, but the RRC State Indicator is set to CELL_FACH/URA_PCH. In case of throughput or BO measurement based data rate increase: the internal RNC BO or throughput or UE RRC Measurement is just ignored so the UTRAN keeps the current RB data rate

Not granting the requested service by iRM CAC indicates either high cell loading (reflected by Red cell colour) or an area of high interference. The approach in interference is to optimise the RF environment in terms of reducing pilot pollution, improving RF coverage, neighbour list optimisation etc. Features like iMCTA CAC can be enabled to divert the newly setup calls by triggering HHO to different 3G or 2G layer in case these experience CAC. Even iMCTA service can be configured to offload on-going calls to other 3G carriers or 2G once originating cell colour turns Red while the target 2G/3G cell is Green. One may confirm that the various resource thresholds to change cell colour are not set to trigger early transition to Red. An example threshold is given below, please refer to [17] volume 5 for detailed discussion on iRM CAC and colour thresholds.

Parameter

Description

IrmOnCellColourParameters. Threshold for DL power yellow2RedPLCThreshold IrmOnCellColourParameters. Threshold for DL code yellow2RedCLCThreshold DlIrmCEMParameters. Threshold for DL CEM/UCU usage yellow2RedDlCEMThresold UlIrmRadioLoadParameters. Threshold for UL noise level yellow2RedUlRadioLoadThreshold UlIrmCEMParameters. Threshold for UL CEM/UCU usage yellow2RedUlCEMThresold IrmIubTransportLoadParameter. Threshold for Iub usage yellow2RedDlTLCThresold Table 24: Cell colour threshold (Yellow to Red) for various resources

The requested QoS profile in the PDP Context Activation message might be ignored and only a default one is assigned UMTS Operational Network Engineering (For Internal Use Only) Page 40 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

5.4.1.2.

Failure symptoms, identification and fixes for improvement

Table 25 is listing the identification techniques in traces in case CAC is not granting the requested service:

Problem
CAC RAB not granted on Iu CAC RAB not granted on Iu and Uu CAC RAB PS not granted CAC RB Setup PS CAC RB Setup VT CAC Release RRC

Trace
CT CT and Uu CT or Uu Uu

Trigger
Any occurrence of a RAB Assignment Response message on RANAP with specified cause No resource available Cross-correlation Uu/CT trace: Any occurrence of a RAB Assignment Response message on RANAP with specified cause No resource available Any occurrence of a SM Activate PDP Context Reject message sent by the CN to the UE and the specified cause is Insufficient resources On Uu, in the RRC RB Setup Message the IE Spreading Factor is larger than the default one and a PDP Context Activation message was sent within the last x seconds with the requested bit rate in the DL higher than the granted one The VT call has been requested, the called entity is also a UE with VT capabilities but a voice RB is setup Any occurrence of an RRC Cell Update/URA Update message following within x seconds a RRC Connection Release message with specified cause congestion and the UE is in either CELL_PCH or URA_PCH mode The UE is sending a CC Setup message and within x seconds gets a CC Disconnect with cause resource unavailable The UE is sending a Cell Update/URA Update message and the RNC is sending back within x seconds a Cell Update Confirm/URA Update Confirm message with RRC State Indicator set to CELL_PCH/URA_PCH.

Uu Uu

CAC RB Setup voice CAC Cell/URA update failed

Uu Uu

Table 25: Identification of iRM CAC rejections in interface traces For iRM CAC related PM counters see [27] with a summarized version shown below. Note that <Cause> can be UL interference, DL code starvation or DL power. There are also counters that track the duration of time cell color was red or yellow for UL and DL.

PM system
UtranCell UtranCell UtranCell

Counter / KPI
RAB.FailEstab.PS.<cause> RAB.FailEstab.CS.<cause> VS.IRMTimeCellRadioColorR ed, Yellow

Name / Description
Number of RAB Establishment Failures due to a given cause for CS domain. Number of RAB Establishment Failures due to a given cause for PS domain. Counter that tracks the percentage of time that a particular cell is considered red or yellow by iRM

Table 26: PM Counters indicating potential R99 iRM CAC failures

5.4.2.Radio Link Reconfiguration 5.4.2.1. Concept

After iRM CAC has taken place the RLs on the Iub have to be reconfigured using the Radio Link Reconfiguration procedure on NBAP. The flowchart can be seen in Figure 10.

UMTS Operational Network Engineering

(For Internal Use Only)

Page 41 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

RNC tries to allocate resources on the Iub by sending a RL Reconfiguration Prepare message on NBAP. The NodeB answers by either sending a Radio Link Reconfiguration Ready (successful case) or Radio Link Reconfiguration Failure (unsuccessful case). The successful case ends in the RNC sending a Radio Link Reconfiguration Commit to the NodeB. This procedure is used to order the Node B to switch to the new configuration for the Radio Link(s) within the Node B at a given activation CFN. The whole procedure is described in [7]. 5.4.2.2. Failure symptoms, identification and fixes for improvement

For the failure analysis, please refer to subsection 5.1.5.2 as same failure causes are used in both cases. Table 27 below is listing the identification triggers for network traces, Table 28 the corresponding UTRAN KPIs.

Problem
Radio Link Reconfiguration failure

Trace
CT

Trigger
Any occurrence of the NBAP Radio Link Reconfiguration Failure message on Iub x seconds after there was a Radio Link Reconfiguration Prepare on NBAP

Table 27: Identification of RL reconfiguration failures in traces PM system


UtranCell

Counter / KPI
(VS.RadioLinkReconfigurationPrepareSuccess / (VS.RadioLinkReconfigurationPrepareUnsuccess.<sum> + VS.RadioLinkReconfigurationPrepareSuccess)) VS.RadioLinkReconfigurationPrepareUnsuccess.<cause>9 VS.RadioLinkReconfigurationCancel

KPI Name / Description


Radio link reconfiguration preparation success rate Radio link reconfiguration prepare failure with 9 different screenings Radio link reconfiguration cancel sent by RNC in case of ALAP problem, NBAP timeout etc

UtranCell UtranCell

Table 28: PM KPIs for RL reconfiguration failures

5.4.3. Radio Bearer Establishment 5.4.3.1. Concept

Once the required resources have been successfully reconfigured in the NodeB, RNC sends the Radio Bearer Setup message to the UE that sends back the Radio Bearer Setup Complete message upon successfully allocating resources for the new RB. The Radio Bearer Establishment procedure may fail for different reasons (see below); in that case the UE sends back a Radio Bearer Setup Failure message to the RNC. When a physical dedicated channel establishment is initiated by the UE, the UE shall start a timer T312 and wait for N312 successive in sync indications. On receiving N312 successive in sync indications, the physical channel is considered established and the timer T312 is stopped and reset. If the timer T312 expires before the physical channel is established, the UE shall consider this as a physical channel establishment failure. The whole procedure is <cause> include RRM refusal, INode refusal, NBAP timeout, RL reconfiguration failure, Iub congestion, lack of Iub CID, lack of CEM L1 resources, lack of Iub bandwidth and NodeB out of order UMTS Operational Network Engineering (For Internal Use Only) Page 42 of 110
9

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

explained in [6]. Table 29 below is listing the parameters for the RB Establishment:

Parameter UeTimerCstConnectedMode .t312 UeTimerCstConnectedMode .n312

Description
UTRAN parameter configuring timer T312

UTRAN parameter configuring maximum count N312

Table 29: Parameter important for the RB Establishment

5.4.3.2.

Failure symptoms, identification and fixes for improvement

In case the UE sends back the Radio Bearer Setup Failure message to the RNC and the Radio Bearer Establishment procedure fails. Main reason for the failure can be subdivided as follows: Physical Channel Failure (i.e. T312 expiry) Unsupported or invalid configuration in the UE Code starvation (the required channelisation code is not available anymore from the code tree) Protocol Error

In general, the physical channel failure occurs when there is loss of synchronisation between UE and NodeB. This is mainly caused by poor RF conditions; see also subsection 6.1 and 6.4 for details. The other causes are expected to occur infrequently and in general are not related to RF issues. The causes of the Radio Bearer Setup Failure message are listed in chapter 10.3.3.13 in [6]. Again it is up to the UE vendor, which cause out of this list is chosen for the particular failure that has occurred. Table 30 is listing the identification techniques in traces, Table 31 the corresponding PM KPIs for failures in the Radio Bearer Setup procedure:

Problem
RB setup failure

Trace
Uu or CT

Trigger
Any occurrence of the RRC Radio Bearer Setup Failure message

Table 30: Identification of Radio Bearer Setup failures in traces PM system


UtranCell UtranCell

Counter / KPI10
(RAB.FailEstab.CS.RBSetupFail / RAB.AttEstab.CS) (RAB.FailEstab.PS.RBSetupFail / RAB.AttEstab.PS)

KPI Name / Description


CS RAB establishment failure rate due to RB setup failure PS RAB establishment failure rate due to RB setup failure

Table 31: PM KPIs for Radio Bearer Setup failures

10

For corresponding definitions of CS RAB Attempts and PS RAB Attempts see [27]. (For Internal Use Only) Page 43 of 110

UMTS Operational Network Engineering

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

6. Call Reliability (Retainability)


This section is describing failures and occurrences that might happen after the call has been successfully setup. This can not only endanger the single particular call to drop, but also the overall quality of the UMTS network as well as user perceived quality (section 7) might be degraded. For a detailed discussion on relationship between possible reason of PS call drop and corresponding failure cause sent in the Iu release request to the CN, refer to [29].

6.1.

Call reliability Radio Link Failure (RLF)


According to [11] the PHY layer in the NodeB and UE checks every radio frame the synchronisation status. The status is indicated to higher layers using the CPHY-Sync-IND and CPHY-Out-of-Sync-IND primitives indicating in-sync state and out-of-sync state respectively. In the following the UL and DL are treated separately. RLF and RL Restore in the UL The RLF and restore procedures in the UL are supervised in the NodeB on NBAP; the UL radio link sets are monitored to trigger if necessary RLF and RL Restore procedures. When the radio link set is in the in-sync state and the NodeB is receiving consecutive N_OUTSYNC_IND out-of-sync indications, NodeB starts timer T_RLFAILURE. The NodeB stops and resets timer T_RLFAILURE upon receiving successive N_INSYNC_IND in-sync indications. If timer T_RLFAILURE expires, the NodeB triggers the RLF procedure and indicates which radio link set is out-of-sync. In that case, the state of the radio link set changes to the out-of-sync state and the NodeB indicates the RLF to the RNC by sending a Radio Link Failure Indication on NBAP with the cause Synchronisation Failure (see [7]). Upon reception of this message the RNC starts timer T_RL_RESYNC (defined by timer RadioAccessService.rlRestoreTimerAfterRlFailure). This timer is stopped and no further action is taken if the RNC receives from the NodeB the NBAP Radio Link Restore Indication message. The NodeB sends this message if the radio link set is in the out-of-sync state and the NodeB is receiving successive N_INSYNC_IND in-sync indications. The NodeB indicates which radio link set has re-established synchronisation. When the RL Restore procedure is triggered, the state of the radio link set changes to the in-sync state again. Upon expiration of timer T_RL_RESYNC, the RNC removes the particular RL in the NodeB via the NBAP Radio Link Deletion procedure. After the deletion of the RL the RNC starts either With the Active Set Update procedure on RRC in case the UE is in soft/softer HO mode; note that this is not a dropped call (in terms RAB or RRC drop) Timer T314/T315 giving the UE the possibility to re-establish the RRC connection. In case timer T314/T315 is expired the RNC releases the call by sending RANAP Iu Release Request message with specified cause Release due to UTRAN generated reason to the CN. Afterwards the RNC also releases the RRC connection by sending the RRC Connection Release message with cause other than normal

6.1.1. Concept

UMTS Operational Network Engineering

(For Internal Use Only)

Page 44 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

event. Finally the UE sends back a RRC Connection Release Complete and the procedure ends. Figure 11 below is showing the call handling of the RAB release in case of a dropped call:

CN

Figure 11: RAB release call flow RLF and RL Restore in the DL: The RLF procedure in the DL is supervised on RRC on the UE side. In CELL_DCH state, the UE starts timer T313 after receiving N313 consecutive out-of-sync indications for the established DPCCH physical channel. The UE stops and resets timer T313 upon receiving successive N315 in-sync indications. If T313 expires, the RRC connection is dropped and the UE goes to idle mode. In idle mode the UE will select a suitable cell according to the cell reselection criteria and will initiate a Cell Update procedure with specified cause radio link failure (chapter 8.5.6 in [6]). Subsequently the RLF in the UL will be triggered when the UE is in idle mode by the UTRAN on its own accord. Figure 12 below is showing the transitions between the different states; the initial state of a RL is defined as the state when a new RL is to setup:

UMTS Operational Network Engineering

(For Internal Use Only)

Page 45 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Figure 12: Transitions between different states Table 32 below is listing the parameters that are configuring the RLF and RL Restore procedure:

Parameter SynchronisationConfiguration .tRLFailure SynchronisationConfiguration .noOutSyncInd SynchronisationConfiguration .noInSyncInd RadioAccessService .RlRestoreTimer RadioAccessService .rlRestoreTimerAfterRlFailure

Direction
UL

Description
This parameter is defining the setting of T_RLFAILURE This parameter is defining the setting of N_OUTSYNC_IND This parameter is defining the setting of N_INSYNC_IND Configure guard timer to allow time for radio link restore to occur for the first RL when setting up the call. On expiry the RNC releases the call. Configure guard timer T_RL_RESYNC to allow time for the normal operation of the handover and power control algorithm to delete a radio link affected by a loss of synchronization or for re-synchronization to occur when the radio link is one of several associated with a UE connection. This parameter is defining the setting of T313

UL

UL

UL

UL

UeTimerCstConnectedMode .t313 UeTimerCstConnectedMode .n313 UeTimerCstConnectedMode .t314 UeTimerCstConnectedMode .t315 UeTimerCstConnectedMode .n315

DL

DL

This parameter is defining the setting of N313

DL

This parameter is defining the setting of T314

DL

This parameter is defining the setting of T315

DL

This parameter is defining the setting of N315

Table 32: Parameter configuring the RLF and RL Restore procedure

UMTS Operational Network Engineering

(For Internal Use Only)

Page 46 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

6.1.2. Failure symptoms, identification and fixes for improvement There are a variety of causes responsible for RLFs possibly resulting in dropped calls: Pilot pollution and around-the-corner effect (subsections 6.4.2 & 6.4.3) Weaknesses in the neighbour planning (subsection 6.4.4) Problems during (or before) the call establishment phase (section 5) Problems with the RF coverage (subsection 6.4.5) Problems with the SC plan (subsection 6.4.6)

RLF in the UL that is causing a removal of a radio leg can be directly identified in UTRAN traces, if there is no Measurement Report with type 1b/1c sent previously and a NBAP radio link failure indication is received with cause Synchronisation failure. If RLF with any other cause is received, the RNC should delete the RL straightaway without waiting for RL restore timer. UL RLF could also be due to DL RLC disrupttion detected at UE which turns off its PA and later sends Cell Update with cause RLC unrecoverable error. Identification of a dropped call due to RLF in the UL only with Uu traces is difficult because the RRC Connection Release message sent by the RNC does not have a unique cause id. For a reliable identification additional Iub/UTRAN tracing is required. Dropped calls due to RLF in the DL can be easily identified in UE logs or network traces with the Cell Update message sent by the UE. There might be an optional failure cause specified. Other cell update failures are covered in subsection 6.3 and 6.14.2. Table 33 below is listing the identification possibilities using UE and network traces.

Problem
Dropped call due to RLF in the DL on Uu RLF and RL Restore in CT and Uu RLF and RL Deletion in CT and Uu RLF and dropped call in CT and Uu UL RLF and leg removal on Uu High UE Tx power High DL BLER

Trace
Uu

Trigger
Any occurrence of a RRC Cell Update message with specified cell update cause (not failure cause) radio link failure. Note that the dropped call is the previous call and not the current one! There might be an optional failure cause specified. Cross-correlation of Uu/CT traces: Any occurrence of an Radio Link Failure Indication on NBAP with the cause Synchronisation Failure and after x seconds a Radio Link Restore Indication on NBAP Cross-correlation of Uu/CT traces: Any occurrence of an Radio Link Failure Indication on NBAP with the cause Synchronisation Failure and after x seconds a Radio Link Deletion on NBAP and the number of radio legs is more than one Cross-correlation of Uu/CT traces: Any occurrence of an Radio Link Failure Indication on NBAP with the cause Synchronisation Failure and after x seconds a Radio Link Deletion on NBAP and the number of radio legs is equal to one Any occurrence of an Active Set Update containing any entries in the group RemovalInformationList and there was no Measurement Report within x seconds before either with specified event id 1b/1c or without any specified event id11 Any occurrence if the UE is transmitting with maximum allowed power for x seconds Any occurrence if the UE is reporting a BLER higher than x% for y seconds

CT and Uu CT and Uu CT and Uu Uu

Uu Uu

Table 33: Identification of RLF in traces

11

To be noted: the group eventResults containing the IE eventID is optional, for example when periodic reporting is enabled. UMTS Operational Network Engineering (For Internal Use Only) Page 47 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Table 34 below is listing the identification possibilities using KPIs retrieved by the UTRAN PM system. Refer to Figure 13 that shows at what point during the call flow the PM counters are updated.

PM system
UtranCell

Counter / KPI
(VS.RAB.Drop.CS.Cause.DL_RLF / ((RAB.AttEstab.CSV.RelocIratHO RAB.FailEstab.CSV.RelocIratHO) + RAB.SuccEstab.CS)) (VS.RAB.Drop.CS.Cause.UL_RLF /((RAB.AttEstab.CSV.RelocIratHO RAB.FailEstab.CSV.RelocIratHO) + RAB.SuccEstab.CS)) (VS.RAB.Drop.PS.Cause.DL_RLF / RAB.SuccEstab.PS.<sum>) (VS.RAB.Drop.PS.Cause.UL_RLF / RAB.SuccEstab.PS.<sum>)

KPI Name / Description


CS RAB Drop Rate due to DL RLF

UtranCell

CS RAB Drop Rate due to UL RLF

UtranCell UtranCell

PS RAB Drop Rate due to DL RLF PS RAB Drop Rate due to UL RLF

Table 34: PM KPIs indicating RLF

6.2.

Call reliability drop of the RAB


RAB drop due to UTRAN reasons The drop of the RAB that is caused by a failure within the UTRAN is always initiated by an Iu Release Request message on RANAP with cause Release due to UTRAN generated reason; the call handling is shown in Figure 11. The CN will send back an Iu Release Command message on RANAP with the same specified cause (chapter 9.2.1.4 in [9]). After sending this message the UTRAN will release the RRC connection (subsection 6.3). To be noted that this does not mean the PDP context is removed, but e.g. a FTP session that is up and running might time out. The UE can re-establish the RRC connection after doing a cell reselection by sending RRC Connection Request message with establishment cause Call re-establishment (subsection 7.2.3). There are a variety of reasons why the RAB drops due to UTRAN reasons: RLF (subsection 6.1) because of e.g. RF issues (subsection 6.4) Hardware failures and outages on UTRAN (subsection 6.8) Failures that occurred on NBAP (e.g. subsection 5.4.2) General drops of the RRC connection (subsection 6.3)

6.2.1. Concept

For the reasons of these failures please refer to the corresponding sections. Note that in Figure 13, T_RL_RESYNCH is shown as radio link failure resynchronisation response timer. RAB drop due to CN reasons RAB drops that are not caused within the UTRAN can be identified by the Iu Release Command message on RANAP; the specified cause is other than Release due to UTRAN generated reason and normal-release. The specified cause is CN vendor dependent.

UMTS Operational Network Engineering

(For Internal Use Only)

Page 48 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Figure 13: Drop of the RAB due to RLF on single RLS 6.2.2. Failure symptoms, identification and fixes for improvement Table 35 is showing the identification techniques in call trace and UE logs:

Problem
RAB drop due to UTRAN reasons on Iu RAB drop due to UTRAN reasons on Iu and Uu RAB drop due to CN reasons on Iu RAB drop due to CN reasons on Iu and Uu

Trace
CT

Trigger
Any occurrence of an Iu Release Request message with cause Release due to UTRAN generated reason on Iu Cross-correlation CT and Uu: Any occurrence of an Iu Release Request message with cause Release due to UTRAN generated reason on Iu Any occurrence of an Iu Release Command message with cause other than Release due to UTRAN generated reason or normal-release on Iu Cross-correlation CT and Uu: Any occurrence of an Iu Release Command message with cause other than Release due to UTRAN generated reason or normal-release on Iu

CT and Uu

CT CT and Uu

Table 35: Identification of RAB drops in network interface traces There are different PM KPIs describing RAB drops and can be seen in Table 36. The different PM KPIs describing RAB drops are differentiated as:

UMTS Operational Network Engineering

(For Internal Use Only)

Page 49 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

CS/PS RAB drops Reason (due to UE inactivity, due to DL power, due to Inter-frequency HHO, UE Poor Quality Minimum Rate, SRNS Relocation, ) RNC level and UtranCell level

PM system
UtranCell

Counter / KPI
VS.RAB.Drop.CSV.UESigConnRel

KPI Name / Description


Dropped CS Voice RAB Connections due to UE Initiated Signalling Connection Release Dropped CS RAB connection per failure cause: Downlink/Uplink Radio Link Failure Dropped CS RAB connection due to SRNS relocation. Dropped CS RAB connections due to unrecoverable failures during inter-frequency hard handover Dropped CN (core network) initiated CS Voice RAB Connections. Dropped CS RAB connections during AMR codec change due to unsuccessful termination of the Iu Rate Control procedure. Dropped UTRAN Initiated PS RAB Connections with UE in Cell_DCH. Dropped UTRAN Initiated PS RAB Connections with UE in Cell_FACH Dropped PS RAB connection per failure cause.

UtranCell

VS.RAB.Drop.CS.Cause.DL_RLF VS.RAB.Drop.CS.Cause.UL_RLF

UtranCell UtranCell

VS.RAB.Drop.CS.RelocUEInvol VS.RAB.Drop.CS.InterFreqHHO

UtranCell UtranCell

VS.RAB.Drop.CN.Init.CSV VS.RAB.Drop.CS.CodecChange

UtranCell UtranCell UtranCell

VS.RAB.Drop.PS.CellDCH.RelProc.<causes> VS.RAB.Drop.PS.CellFACH VS.RAB.Drop.PS.Cause.DL_RLCErrRate VS.RAB.Drop.PS.Cause.UL_RLCErrRate VS.RAB.Drop.PS.Cause.DL_RLF VS.RAB.Drop.PS.Cause.UL_RLF

UtranCell

VS.RAB.Drop.PS.UESigConnRel

Dropped PS RAB Connections due to UE Initiated Signalling Connection Release Dropped RAB connection caused by SRNS relocation for the PS domain. Dropped PS RAB connections due to unrecoverable failures at interfrequency hard handover. CN (core network) initiated dropped PS RAB connections for Ues in Cell_DCH state per transport channel type. Dropped PS RAB connections due to successful CS IRAT HO.

UtranCell UtranCell

VS.RAB.Drop.PS.Reloc.UEInvol VS.RAB.Drop.PS.InterFreqHHO

UtranCell

VS.RAB.Drop.CN.Init.PS.CellDCH.<causes>

UtranCell

VS.RAB.Drop.PS.CsIratHo

Table 36: PM Counters for RAB Drops

UMTS Operational Network Engineering

(For Internal Use Only)

Page 50 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

6.3.

Call reliability drop of RRC connection after call setup


The RRC is the context between UE and RNC on layer 3. A drop of the RRC connection can be identified as follows: The RNC sends a RRC Connection Release message with specified 12 cause unspecified or pre-emptive release The UE sends a Cell Update message with cell update cause radio link failure or RLC unrecoverable error and/or AM_RLC error indication is set to TRUE (see below) The UE sends a RRC Connection Request message with cause Call re-establishment (see comments in subsection 6.2.1 and 7.2.3). For the variety of reasons of dropped calls (paging, RLF, Random Access procedure etc.) please refer to the corresponding subsections in this document.

6.3.1. Concept

Note that the IE AM_RLC error indication in the Cell Update/URA Update is specifying whether an error occurred on the RLC or not. If this IE is set to TRUE it is indicating that the RLC in the UE has detected a failure on one of its AM RLC entities that has not been resolved by e.g. resetting of the RLC [22]. For more details regarding failures on the RLC see subsection 6.14. If there is a RRC Connection Release message with cause congestion the reason might be either iRM CAC (subsection 5.4.1) or Congestion Control (subsection 6.5). ALU supports the RRC connection re-establishment for PS, CS and simbearer services, where by on detection of the RLF or RLC error, the UE sends a cell update with corresponding cause and consequently old radio links are deleted and the new radio links are established by the RNC. This procedure fails if the UE does not send the cell update, a RANAP procedure has started or a NAS message is received to be forwarded to the UE. The procedure will also not occur if all the radio legs are on the Drift RNC, a RANAP procedure is in progress or UE indicates that the T314 or T315 timer has expired. Further information on activation, configuration and monitioring of this feature set can be obtained from [31].

Parameter RadioAccessService .isPsRrcReestablishAllowed RadioAccessService .isCSRrcReestablishAllowed RadioAccessService .isPSRrcReestablishforICFailureAllowed RadioAccessService

Description
Activation flag for PS call reestablishment feature Activation flag for CS call reestablishment feature Activation flag for PS call reestablishment for invalid configuration failure scenario while doing UL data rate change for HSDPA call Timer started at RNC on reception of NBAP RLF for a CS call, if no cell update from UE received within this

12

The case RRCConnectionRelease with cause congestion is covered in subsection 5.4.1. (For Internal Use Only) Page 51 of 110

UMTS Operational Network Engineering

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

.rrcReestCSMaxAllowedTimer RadioAccessService . rrcReestPSMaxAllowedTimer RadioAccessService .rrcReestablishPSThreshold RadioAccessService .rrcReestablishCSThreshold

time, call is dropped Timer started at RNC on reception of NBAP RLF for a PS call, if no cell update from UE received within this time, call is dropped Quality threshold for deciding if PS reestablishment should take place based on EcNo reported by UE in cell update Quality threshold for deciding if CS reestablishment should take place based on EcNo reported by UE in cell update

Table 37: Parameter configuring the RRC connection re-establishment

UE

Node B

RNC

CN

RNC suspends RLC, MAC

1) Cell Update (Cause Radio Link Failure) 2) Radio Link Deletion Request 3) Radio Link Deletion Response 4) ALCAP Release

New radio links based upon measured Ec/Io UE Moved back to Cell DCH

5) Radio Link Setup 6) Radio Link Setup Response 7) ALCAP & FP Synch 8) Cell Update Confirm 9) Radio Bearer Reconfiguration Complete 10) UE Measurements

Figure 14: DL RLF and RRC re-establishment

UMTS Operational Network Engineering

(For Internal Use Only)

Page 52 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

UE
T_RL_RESYNCH expires, UE is PS only

Node B

RNC

CN

1) Radio Link Failure Indication 2) Radio Link Deletion Request


T_RL_RESYNCH

RNC suspends RLC & MAC, Starts Timer

3) Radio Link Deletion Response 4) ALCAP Release

RNC stops Timer

5) Cell Update (Cause Radio Link Failure) 6) Radio Link Setup 7) Radio Link Setup Response 8) ALCAP & FP Synch 9) Cell Update Confirm 10) Radio Bearer Reconfiguration Complete 11) UE Measurements

New radio links based upon measured Ec/Io UE Moved back to Cell DCH

Figure 15: UL RLF and RRC re-establishment

6.3.2.Failure symptoms, identification and fixes for improvement Table 38 and Table 39 below list the identification of dropped RRC connection and the corresponding PM KPIs respectively:

Problem
Drop of RRC connection I Drop of RRC connection II Drop of RRC connection III

Trace
Uu Uu Uu

Trigger
Any occurrence of a RRC Connection Release message on Uu with specified cause unspecified or pre-emptive release Any occurrence of a RRC Connection Request message on Uu with establishment cause Call re-establishment The UE is simply going to idle mode without dropping the call in a regular way. There are no RRC/Direct Transfer messages indicating a regular/irregular call termination within x ms. The UE start monitoring the BCCH and might perform a cell re-selection following a Cell Update with cause RLF or RLC unrecoverable error (see also Table 33 on page 47). RNC sent a Cell update confirm but the UE didnt respond back with a RB reconfiguration complete within x seconds showing failure of the reestablishment

Drop of RRC connection IV

Uu

Table 38: Identification of dropped RRC connections in interface traces

PM system
UtranCell UtranCell

Counter / KPI
(VS.RrcReEstablishmentSuccess.<sum> / VS.RrcReEstablishmentAttempt.<sum>) VS.RrcConnectionRelease.ReestablishmentReject

KPI Name / Description


RRC Connection Re-establishment success rate Number of RRC connection release when re-establishment was not

UMTS Operational Network Engineering

(For Internal Use Only)

Page 53 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

successful or when RNC receiving the cell update is drift UtranCell VS.RrcReEstablishmentAttempt.PS_Other VS.RrcReEstablishmentAttempt.PSULRLFail VS.RrcReEstablishmentAttempt.PSDLRLFail VS.RrcReEstablishmentAttempt.PSULRlcUnrecoverErr VS.RrcReEstablishmentAttempt.PSDLRlcUnrecoverErr VS.RrcReEstablishmentAttempt.PSInvCfgFail VS.RrcReEstablishmentAttempt.CS_Other VS.RrcReEstablishmentAttempt.CSULRLFail VS.RrcReEstablishmentAttempt.CSDLRLFail UtranCell VS.RrcReEstablishmentSuccess.PS_Other VS.RrcReEstablishmentSuccess.PSULRLFail VS.RrcReEstablishmentSuccess.PSDLRLFail VS.RrcReEstablishmentSuccess.PSULRlcUnrecoverErr VS.RrcReEstablishmentSuccess.PSDLRlcUnrecoverErr VS.RrcReEstablishmentSuccess.PSInvCfgFail VS.RrcReEstablishmentSuccess.CS_Other VS.RrcReEstablishmentSuccess.CSULRLFail VS.RrcReEstablishmentSuccess.CSDLRLFail Number of successes for RRC connection re-establishment procedure for different reestablishment types. Number of attempts for RRC connection re-establishment procedure for different reestablishment types.

Table 39: PM KPIs of RRC connection Re-establishment

6.4.

Call reliability RF planning related issues


A detailed explanation of how to improve the RF environment is outside the scope of this document. This guideline only briefly provides the techniques to identify these issues using Uu traces and 2G/3G scanner measurements. There are no specific PM counters available that could differentiate RRC and RAB drops in terms of e.g. pilot pollution, round-the-corner effect etc. For that reason no PM KPIs describing dropped calls are listed in this subsection, reference the previous sections 6.1, 6.2 and 6.3.

6.4.1. Introduction

6.4.2. Pilot pollution 6.4.2.1. Concept

Pilot pollution means an excessive overlapping of coverage footprints of different cells with no dominant pilot. This leads to poor Ec/Io ratios. As a consequence, the RL could fail due to out-of-synchronisation (subsection 6.1). Pilot pollution is in particular an issue when the number of best cells within a certain range is exceeding the maximum size of the cells in the active set. In this case the cells that cannot be included into the active set are decreasing the quality of the signal by acting as interference. Because in HSDPA there is no soft/softer HO gain in the downlink, HSDPA is much more sensitive to pilot pollution compared to R99 services, see also chapter 6.15 for details.

UMTS Operational Network Engineering

(For Internal Use Only)

Page 54 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

6.4.2.2.

Failure symptoms, identification and fixes for improvement

This is a typical issue for RF optimisation and can be detected via Uu interface traces and 2G/3G scanner measurements of the PHY layer. In addition the number of cells in the active set is also a good metric of handover zone definition within the UMTS network. Table 40 is listing identification techniques in drive test and scanner measurement data while gives a way to identify areas with multiple pilot overlap at sector level:

Problem
Pilot pollution I Pilot pollution II High number of cells in active set Overshooting

Trace
UE or 3G scanner UE or 3G scanner Uu UE or 3G scanner

Trigger
There are more than x cells with a measured Ec/No within x dB compared to the best measured Ec/No The aggregate Ec/No of the cells in the active set is below x dB while the measured RSCP is above y dBm for z ms The active set size is > 1 in more than x % of all measured samples13 Ec/No of a site y km away is within x dB of the best measured Ec/No

cells

Table 40: Identification of pilot pollution

PM system
UtranCell

Counter / KPI
VS. UeWithNRadioLinksEstCellsBts.<causes>

KPI Name / Description


Distribution of the number of mobiles having N Radio-Links in their Active Set Average active set size

UtranCell

(( ( VS.UeWithNRadioLinksEstCellsBts.N1Rl * 1 ) + ( ( VS.UeWithNRadioLinksEstCellsBts.N2RL1Rc1SBts + VS.UeWithNRadioLinksEstCellsBts.N2RL1Rc1ABts ) * 2 ) + ( ( VS.UeWithNRadioLinksEstCellsBts.N3RL1Rc2SBts + VS.UeWithNRadioLinksEstCellsBts.N3RL1Rc1SBts1ABts + VS.UeWithNRadioLinksEstCellsBts.N3RL1Rc2ABts ) * 3 ) + ( ( VS.UeWithNRadioLinksEstCellsBts.N4RL1Rc2SBts1ABts + VS.UeWithNRadioLinksEstCellsBts.N4RL1Rc1SBts2ABts + VS.UeWithNRadioLinksEstCellsBts.N4RL1Rc3ABts ) * 4 ) + ( ( VS.UeWithNRadioLinksEstCellsBts.N5RL1Rc2SBts2ABts + VS.UeWithNRadioLinksEstCellsBts.N5RL1Rc1SBts3ABts + VS.UeWithNRadioLinksEstCellsBts.N5RL1Rc4ABts ) * 5 )+ ( (VS.UeWithNRadioLinksEstCellsBts.N6RL1Rc2SBts3ABts + VS.UeWithNRadioLinksEstCellsBts.N6RL1Rc1SBts4ABts + VS.UeWithNRadioLinksEstCellsBts.N6RL1Rc5ABts ) * 6 ) ) / VS.UeWithNRadioLinksEstCellsBts.<sum>)

Table 41: PM Counter for estimation of soft handover zone

13

This is not really a problem to be identified in a trace; it is more an indication for in general nonoptimal RF conditions. (For Internal Use Only) Page 55 of 110

UMTS Operational Network Engineering

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

6.4.3. Around-the-corner-effect 6.4.3.1. Concept

Around-the-corner-effect is quite often encountered in a dense urban environment. The effect describes a moving UE where the receive level of the cells in the active set decreases dramatically (in terms of Ec/No and RSCP) and the receive level of cells in the monitored or detected set suddenly increases. The root cause for this problem is shadowing of buildings or other obstructions. As a consequence the quality of the call will always drop if the UE is not fast enough to adapt (via Active Set Update) to the new RF conditions. Figure 16 is showing the effect in a dense urban environment:
Active Set Pilot Interfering Pilot

Figure 16: Around-the-corner problem To overcome around-the-corner problem local optimisation of the RF environment is required. In addition the RF planer has to ensure that the parameters configuring the handover procedure is fast enough (subsection 6.9). If a drop does happen, provided its not over the Iur, RRC connection reestablishment feature will be able to recover the call. 6.4.3.2. Failure symptoms, identification and fixes for improvement

Around-the-corner effect can be detected via UE traces when analyzing the PHY layer; Table 42 is summarising the triggers in UE traces:

Problem
Around-the-corner effect I Around-the-corner effect II

Trace
Uu Uu

Trigger
Sudden drop/increase of the Ec/No of cells in the active set by x dB for the next at least y ms; the average aggregate Ec/No is below z dB Sudden drop/increase of the RSCP of cells in the active set by x dB for the next at least y ms; the average aggregate RSCP is below z dBm

Table 42: Identification of around-the-corner effect

UMTS Operational Network Engineering

(For Internal Use Only)

Page 56 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

6.4.4. Non-optimal neighbour definitions 6.4.4.1. Concept

One of the essential tasks of RF planning is neighbour list assignment. When the neighbour lists are not well defined the UE might not be on an optimal cell (or set of cells) and the call is endangered to drop. The following neighbour lists exist in the OAM: 3G-3G soft/softer MAHO list 3G-2G neighbour MAHO list 3G-2G neighbour DAHO/blind HO list 2G-3G neighbour list

The parameters configuring the intra-frequency soft/softer HO are listed in subsection 6.9, 2G IRAT parameter settings are covered in subsection 6.10. This subsection is focused on the integrity of the different neighbour lists definitions itself. To maintain the integrity of the different HO list it is required to use a database system with the following tables: Table keeping site specific information of the UMTS cells o o o o Site id (for identification for co-located 2G/3G cells) Sector id (to check if a 2G cell is identical resulting in identical coverage footprint for a possible DAHO/ blind HO definition) Userlabel Flag borderCellToGSM

Table keeping site specific information of the GSM cells o o o Site id (for identification for co-located 2G/3G cells) Sector id (to check if a 3G cell is identical resulting in identical coverage footprint for a possible DAHO/ blind HO definition) BCCH frequency

Different neighbour lists including o Priority flag for 3G-3G HO definition in case Type 1 is the selected NL selection algorithm (see also subsection 6.9 for details) Distance between the two cells

With this kind of information the following database queries might be defined Check for symmetry or reciprocity Check for missing co-located neighbour definition (3G-3G, 3G-2G, 2G3G) Check for right Priority flag Check for missing DAHO/ blind HO definitions

Figure 17 below is showing a sample database in MS Access format:

UMTS Operational Network Engineering

(For Internal Use Only)

Page 57 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Figure 17: neighbour list checking using MS Access RF drive data analysis tools like LDAT [33] have the missing neighbour list analysis feature that can be used to debug existing network as well as suggest NL for technology overlay deployment based on GSM HO matrix:

Figure 18: 3G/IFHHO neighbour list visualisation using LDAT

UMTS Operational Network Engineering

(For Internal Use Only)

Page 58 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

6.4.4.2.

Failure symptoms, identification and fixes for improvement

Following methods can be used to fix/detect a non-optimal neighbour list assignment: Cross-correlation measurements o o of Uu drive test logs with 2G/3G scanner

Missing 3G-3G neighbour definition: measured RSSI is relatively high, but the RSCP of the cells in the active set is relatively low Missing 3G-2G neighbour definition: the UE measured RSSI is relatively low and the GSM coverage footprint is relatively strong as measured by the 2G scanner. Missing 2G-3G neighbour definition: UE is staying in 2G although there is sufficient 3G coverage as indicated by the RSSI measurements of the 3G scanner Analysis of the UE Measurement Reports: the UE might report cells of the detected set but these cells are not defined in the Compund NLA (see also subsection 6.9)

RF prediction tool analysis like LDAT3G CTn traces [36] which specifically capture 3G-3G and 3G-2G mobility data. For example from these IRAT HO Matrix can be derived and analysed using WQA tool [30] with the focus on o o Deletion of unnecessary handover definitions Investigation of high amount of HO failures

In a similar way the intra-frequency HO matrix can be derived and analysed using CTn and WQA for discovering possible missing neighbor list entries or over-shooting sectors. Table 43 below is listing the identification possibilities for network interface traces:

Problem
Missing 3G/3G neighbour definition

Trace
Uu, 3G scanner

Trigger
Any occurrence where the measured RSSI (retrieved by 3G scanner) is within a xdB window compared with the measured aggregate RSCP of the cells in the active set (measured by the UE) for y seconds; at the time of the measurement the UE is in 3G The measured RXLEV of the best 2G cell (measured by the 2G scanner) is within a xdB window compared to the measured aggregate RSCP of the cells in the active set (measured by the UE) for y seconds; at the time of the measurement the UE is in 3G Any occurrence where the measured RSSI (retrieved by 3G scanner) is within a xdB window compared with the measured RXLEV of the 2G serving cell (measured by the UE) for y seconds; at the time of the measurement the UE is in 2G

Missing 3G/2G neighbour definition

Uu, 2G scanner

Missing 2G/3G neighbour definition

Uu, 3G scanner

Table 43: Identification of non-optimal neighbour definitions in traces

UMTS Operational Network Engineering

(For Internal Use Only)

Page 59 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

6.4.5. Poor RF coverage 6.4.5.1. Concept

Especially in the early days of 3G there will be many areas with a poor RF coverage. But also after the integration of the sites it might happen that due to cell breathing (especially in the busy hour) the Ec/No is not sufficient to guarantee (for some services like 384 kbit/s) sufficient RF coverage. When this happens either the radio bearer has to be reconfigured due to an increasing Tx code power in the DL when using a PS R99 data service (subsection 6.17.1) or a HHO handover towards 3G or 2G cell has to be triggered to rescue the call using iMCTA Alarm mechanism. In subsection 6.7.1 a drop of the RRC is described for a mobile in CELL_FACH mode. In subsection 6.6 a similar scenario is described for a UE in CELL_PCH/URA_PCH mode. 6.4.5.2. Failure symptoms, identification and fixes for improvement Low receive level in terms of RSSI (means low measured RSCP values for all pilots in the active set) High NodeB TX power (probably also high UE TX power)

Low RF coverage can be identified as follows:

One root cause for low RF coverage might be a NodeB outage; this has to be crosschecked with the Alarm data (see also subsection 6.8). Table 44 below is listing identification triggers for low RF coverage in various traces:

Problem
Low RF coverage I Low RF coverage II Low RF coverage III Low Ec/No

Trace
3G scanner or Uu 3G scanner, Uu Uu, CT Uu

Trigger
Measured RSSI of the 3G cells is below x dBm for y seconds Measured aggregate RSCP of the cells in the active set is below x dBm for y seconds and there is no RSCP of a 3G cell measured by the 3G scanner better than z dB compared to the aggregate RSCP The reported NodeB TX power is for x second above y dBm and the measured RSCP of that NodeB is below z dBm Measured aggregate Ec/No of the cells in the active set is below x dB for y seconds

Table 44: Identification of low RF coverage in network interface traces ALU PM System does allow the monitoring of Ec/Io, RSCP and CQI values reported by the UE. Knowing the cell selection criteria (UPUG default Qqualmin = -16dB and Qrxlevmin = -115dBm) and design coverage probability of the 3G network one can roughly estimate if coverage hole exist at sector level.

PM system
UtranCell UtranCell UtranCell

Counter / KPI
VS.IrmcacDistributionEcNO.<screenings> VS. IrmcacDistributionRscp.<screenings> VS. HsdpaReceivedCQI.<screenings>

KPI Name / Description


Ec/No distribution RSCP distribution CQI distribution

Table 45: Ec/Io and CQI distribution counters

UMTS Operational Network Engineering

(For Internal Use Only)

Page 60 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

6.4.6. Poor PSC plan The PSC is used for cell identification during the initial cell search and when measuring the neighbour cells in idle and connected mode. In case proper rules are not followed, the UE may experience failures in the neighbour list measurements or in case of overlapping coverage areas of two NodeBs sharing the same PSC, interference and synchronisation issues will occur. This will be the case if an overshooting site has the same PSC as one of the cells in the active set causing co-pilot interference or if the neighbours of the two existing active set cells share the same PSC creating NL ambiguity. It is hardly possible to identify PSC issues in drive test data because the measured low Ec/No values or even RLF can also be the result of pilot pollution or around-the-corner effect (subsection 6.1 and 6.4.1). WQA should permit to detect PSC duplication using CTn traces. The following counters can also be used to detect cells that may contain ambiguous PSC entries after neighbor list compounding. For intra-frequency neighbors the PSC entries must be unique, while for inter-Freq enteries the ARFCN and PSC combination should be unique, and this may be the case for first teir neighbors. However this may not be the case when neighbor list compounding is used, as several neighbor lists will be combined to create the final neighbor list.

PM system
UtranCell

Counter/KPI
VS.AggregateCellListAmbiguousCellIntraFreq

KPI Name / Description


The aggregate intra-frequency neighbour list contains an ambiguous cell. The aggregate inter-frequency neighbour list contains an ambiguous cell.

UtranCell

VS.AggrCellListAmbigCellInterFreq

Table 46: Count of NL sent with at least one ambiguous cell at RRC

6.5.

Call reliability Congestion Control


The Congestion Control function is used to handle situations when the system is going into overload or getting close to an overload situation. Congestion Control is based on UL and DL load estimations as reported by a change in downlink cell congestion colour or uplink cell congestion colour from 'normal' to 'congested'. It handles user already in connected mode and is activated by RadioAccessService.isCongestionDowngradeAllowed. The RNC can initiate the following actions for already connected users to resolve the overload situation: Rank the PS R99 users according to their preemptionVulnerability (taken either from ARP IE in RAB request or from OAM object PreemptionOmcrPcPvInfo ) depending upon preemptionMode, PreemptionServiceInfo.preemptionPriorityOfService and gain from downgrade

6.5.1. Concept

UMTS Operational Network Engineering

(For Internal Use Only)

Page 61 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Transit IrmPreemptionCacParams.numUsersDowngrade out of top ranked users connected to PS data services to a lower bit rate (e.g. from 384 kbit/s to 128 kbit/s) Transfer of rest of PS data users to another state e.g. from CELL_DCH to CELL_FACH or idle depending upon the setting for RadioAccessService.congestionDowngradeReleaseTarget if initial data rate is 8k/8k

The lowering of the PS data rate is done by using the RB Reconfiguration procedure (subsection 6.17.1). The state transfer is done by the RRC Connection Release procedure (transfer to idle mode, RAB is released) or by the RB Reconfiguration procedure (transfer to CELL_FACH, RAB is set to inactive); in both cases the PDP context is retained. The initiating of Congestion Control is indicating a high interference in the RF environment. 6.5.2. Failure symptoms, identification and fixes for improvement Table 47 is listing the identification techniques in traces in case of Congestion control, relevant PM KPIs are also listed below in Table 48:

Problem
Congestion Control RRC PS data reduction DL

Trace
Uu, TCP/IP trace in or after CN

Trigger
Cross-correlation of interface traces on Uu and TCP/ in or after CN side: Any occurrence when either the PS data rate is reduced or the UE is transferred from CELL_DCH to CELL_FACH / CELL_PCH / URA_PCH mode and at the same time there is still data in the RLC buffer of the RNC as measured in Wireshark

Table 47: Identification of Congestion Control in interface traces

PM system
UtranCell

Counter / KPI
VS.DataRateAtt.Dec.CongDowngrade.DL VS.DataRateAtt.Dec.CongDowngrade.UL

KPI Name / Description


Number of attempts to downgrade data rate due to congestion Percentage of time Cell color congested in DL Percentage of time Cell color congested in DL due to power, code, CEM or Iub transport

UtranCell UtranCell

VS.IrmPreemptionTimeCellColorCongested VS.IrmPreemptionTimeCellColorCongestedBecauseOfOvsfCodes VS.IrmPreemptionTimeCellColorCongestedBecauseOfPower VS.QosDlCemLdCellPreemptClrCngstd VS.IrmPreemptionTimeDlIubTransportCongested

Table 48: PM KPIs identifying congestion control activation

6.6.

Call reliability failures in URA_PCH/CELL_PCH mode


When the UE is in CELL_PCH or URA_PCH, the RRC Connection is maintained using common physical channels (RACH in the UL and the SCCPCH in the DL). On the UTRAN side no dedicated radio resources are allocated (means no RB on RRC and RL on NBAP). On the CN side there is

6.6.1. Concept

UMTS Operational Network Engineering

(For Internal Use Only)

Page 62 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

always a RAB associated with the RRC connection but the RAB is marked (inside the RNC) as inactive. When there is data received from the CN side, the RLC buffer in the RNC belonging to the RAB is queues the data and the RNC initiates a state transition of the UE to deliver the DL data. For TCP applications this is appropriate because TCP traffic always starts using the Slow Start procedure, but for UDP or RTP this might result in lost data frames. The UE might indicate to the RNC if the UE RLC buffer is filled up rapidly by sending cell update with cause Uplink data transmission on RACH. ALU UTRAN initiates a state transition to Cell_FACH by sending back a cell update confirm. According to [6] the UE has to monitor the PICH and PCH, do periodical URA/PCH updates and perform cell reselections while being in URA_PCH or Cell_PCH state. It might be that URA_PCH/CELL_PCH mode is not used. Instead for a PS call when the inactivity timer T1 elapses, the RRC resources are released while maintaining the PDP context; the UE is sent to idle mode. The associated RAB is removed. The advantage of the URA_PCH/CELL_PCH mode compared to the idle mode is that the re-establishment can be done faster because the RAB and RRC connection does not need to be re-established again. Disadvantage is that there are still some (very low) UTRAN resources that the RNC has to maintain. Figure 19 below is showing the transition phases between different UE states:

Figure 19: Transition phases between the different UE states 6.6.2. Failure symptoms, identification and fixes for improvement Failures and dropped RRC connections when the UE is in URA_PCH or CELL_PCH mode might occur in the cell selection/reselection process (subsection 5.1.1), failures due to periodical URA updates (subsection 5.3.1). For Call admission (iRM CAC) failures see subsection 5.4.1. Failures due to PCH/AICH/PICH or the RACH procedure might lead to a drop of the RRC connection as described in subsection 5.1.2. In this case the RAB will be removed. If RNC traces show that cell update was sent in good RF (better than -10dB) but UE repeatedly didnt respond to cell update confirm, this can either be a UE or

UMTS Operational Network Engineering

(For Internal Use Only)

Page 63 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

an RNC bug. It probably causes the UE to ignore the cell update confirm, so after sending cell update five times the UE drops this call and establishes a new PS call. This results in CN sending Iu release command for the old call to the RNC. Following table shows the PM counters useful in monitoring the URA_PCH transitions and success rate

PM system
UtranCell

Counter / KPI
VS.UEStateTransAtt.UraPCH.CellDCH VS.UEStateTransSucc.UraPCH.CellDCH

KPI Name / Description


Attempts and Successes UE state transitions to move a UE from URA PCH to Cell DCH. Attempted and succesful reconfigurations for transitions from URA_PCH to Cell_DCH with an HSDSCH.

UtranCell

VS.UEStateTransAtt.UraPCH_CellDCH.DCH_HSDSCH VS.UEStateTransFail.UraPCH_CellDCH.DCH_HSDSCH

Table 49: PM Counters for URA_PCH Transitions Failures due to the RB Reconfiguration procedure are described in subsection 6.17.1.

6.7.

Call reliability failures in CELL_FACH mode


When only a small amount of data has to be exchanged the UE can be in CELL_FACH mode camping on one cell in order to save battery and network resources. The UE has no dedicated UTRAN radio resources; the RRC connection is established using the common channels (FACH in the DL and the RACH in the UL), on Iub there are no dedicated resources available. There is always a RAB associated with the RRC connection because any DL data received by the GGSN has to be forwarded to the UE. The concept is similar to that described in subsection 6.6.1; difference is that a state transition is not mandatory (but might be useful). According to [6] the UE has to monitor the FACH transport channels in the downlink. The UE in CELL_FACH mode informs the UTRAN when reselecting a new cell by sending a RRC Cell Update message on RACH; the RNC answers by sending a Cell Update Confirm message on the FACH and the procedure ends with the UE sending an UTRAN Mobility Information Confirm message again on RACH. The SRNC decides whether or not to transit the UE to another state. Figure 19 is showing the different UE states and possible transition between them. In all cases the RNC will initiate the transition by using the RB Reconfiguration on RRC (subsection 6.17.1). It might be necessary to either delete or setup resources on the Iub via the corresponding NBAP procedures (exception is the transition from CELL_FACH to URA_PCH/CELL_PCH). The algorithm to transition to/from CELL_FACH takes into account the data activity which is measured over fixed time windows. RNC only decides to send the UE to CELL_FACH once both UL and DL data transmission falls below a threshold for a T1 time period. Figure 20 and Figure 21 below are visualising the call handling for the transition from CELL_DCH to CELL_FACH and vice versa:

6.7.1. Concept

UMTS Operational Network Engineering

(For Internal Use Only)

Page 64 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Figure 20: Call handling for transition from CELL_DCH to CELL_FACH

Figure 21: Call handling for transition from CELL_FACH to CELL_DCH

UMTS Operational Network Engineering

(For Internal Use Only)

Page 65 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Figure 22: Parameters govering various UE states controlled through AO The RNC may decide to release the RRC connection due to extended data inactivity especially if URA_PCH is disabled. In this case the RNC sends a RRC Connection Release message on FACH and the UE sends back a RRC Connection Release Complete message on RACH before transiting to idle mode. In parallel the RAB will be released on Iu with cause: user-inactivity. 6.7.2. Failure symptoms, identification and fixes for improvement A drop of the RRC connection might occur if the UE is leaving the RF coverage area and upon selecting a cell the UE has to inform the UTRAN by sending a Cell Update message with cause Re-enter service area. This happens when the UE cant find a suitable cell to camp on for at least 4 seconds. In the meantime the UTRAN might already have dropped the RRC if it had tried and failed to send PS data in the DL. It is recommended to make SRB and TRB in FACH/RACH robust by making the RLC timers long, so to avoid call drop in case of short disruption in data transfer. Since FACH is a slow channel and there is no dedicated link so it can also suffer from contention between different users. As a rule of thumb the RLC UL/DL timeout should be >15 sec for TRB_FACH/RACH and greater than timeout for DCCH_3.4k for SRB_FACH/RACH. The following failures might occur for UEs in CELL_FACH mode or during the transition from/to CELL_FACH mode: Failures related to the cell selection / reselection (subsection 5.1.1) Failures related to the Random Access Procedure (subsection 5.1.3) Failures related to the FACH (subsection 5.1.6) Failures related to the setup of the RL on NBAP (subsection 5.1.5) Failures related to the Radio Bearer Reconfiguration procedure on RRC (subsection 6.17.1)

UMTS Operational Network Engineering

(For Internal Use Only)

Page 66 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Table 50 is listing failures for UEs in CELL_FACH mode and how to identify it in traces:

Problem
Dropped call in CELL_FACH

Trace
Uu

Trigger
Any occurrence when the RRC connection dropped while the UE was in CELL_FACH state

Table 50: Failure identification in traces if the UE is in CELL_FACH mode There are a lot of PM counters available counting the number of attempts and failures for the state transitions, see [27] for details.

6.8.

Call reliability hardware and network interface outages


Hardware failures can occur on the different nodes of the UTRAN and the CN, but also on the particular interfaces as defined in the 3GPP specification. There are many reasons for outages; analysing the retrieved FM data can give a good indication for the failure cause. Outages may lead to drops of the RAB and the RRC connection because of missing synchronisation. Furthermore coverage issues (subsection 6.4.5), problems in the neighbour definition (subsection 6.4.4) and problems in the cell/PLMN selection/reselection procedure (subsection 5.1.1) may also occur leading to dropped calls and network degradation even on NodeBs not affected by the outages.

6.8.1. Concept

6.8.2. Failure symptoms, identification and fixes for improvement Outages can be easily identified when tracing the interfaces that have been outof-sync. Table 51 is listing possibilities of detecting the outages:

Problem
Iub out-of-sync I Iub out-of-sync II Iu out-of-sync I Iu out-of-sync II

Trace
Iub Iub Iu Iu

Trigger
Missing STAT PDUs on AAL5 for more than 5 seconds Any occurrence of an AuditRequiredInformation on NBAP Missing STAT PDUs on AAL5 for more than 5 seconds Any occurrence of a Reset on RANAP

Table 51: Identification of outages in network interface traces Transport engineering guidelines [37] may also have useful information about transport outage.

6.9.

Call reliability intra frequency soft/er handover


Within UMTS networks intra-frequency soft/softer handover is one basic feature that ensures seamless mobility as well as call performance and quality improvement. The soft/softer handovers requested by the UE (mobile evaluated HO) are the ones supported by ALU RNC. In addition the reporting criteria are set to event

6.9.1. Concept

UMTS Operational Network Engineering

(For Internal Use Only)

Page 67 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

triggered rather than periodically. All intra-frequency measurement reporting events (1a to 1j) are defined in [6]. According to [12] the soft/softer HO procedure consists of the following steps: Cell search and measurements of cells in the active set and the monitored set Reporting of measurement results by the UE (RRC Measurement Report message including specified event id) SHO decision Allocation/release/change of network resources on NBAP Execution of the HO (RRC Active Set Update message) by the RNC If necessary execution of RNS relocation procedure (subsection 6.17.2) Active Set Update Complete message on RRC from UE (successful case) RNC updates the measurement parameters including cells belonging to the new monitored set and other measurement parameters via the RRC Measurement Control Message

The different steps are configurable using UTRAN RRM parameters. As an example Figure 23 below is visualising the HO parameter like time to trigger (T) and the HO hysteresis for the Measurement Report events 1a, 1b and 1c:

Figure 23: HO parameter for event 1a, 1b and 1c

UMTS Operational Network Engineering

(For Internal Use Only)

Page 68 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

The call handling depends on the type of event; as an example Figure 24 below is showing a flowchart for an intra-RNC Active Set Update procedure of type event 1a (the grey box contains the RL deletion in case of event 1c):

Figure 24: Call handling flowchart of Active Set Update event 1a (event 1c)

6.9.2. Failure symptoms, identification and fixes for improvement There are many different reasons why the HO procedure might fail or not be executed in an optimal manner: Measurement problems of the cells in the active and monitored set. These failures are most likely due to RF planning issues like nonoptimal neighbour definitions, pilot pollution, weak PSC plan etc. (see subsection 6.4 for details) Misconfiguration of UTRAN parameter setting up the filtering, timing and SHO algorithm Problems with the allocation of network resources on NBAP: Radio Link Setup procedure in case no RL exists to the particular (new) NodeB (subsection 5.1.5) and Radio Link Addition procedure in case there is already a RL to the NodeB Problems during RNS relocation procedure are covered in subsection 6.17.2

UMTS Operational Network Engineering

(For Internal Use Only)

Page 69 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Failures during the release of network resources on NBAP (e.g. event 1c); these failures should occur very rarely (subsection 6.17.3) Measurement Control Failure message (e.g. the UTRAN instructs the UE to perform a measurement that is not supported by the UE) RRC Active Set Update failure message from UE in case of o o o o o o Unsupported or invalid configuration Incompatible simultaneous reconfiguration Invalid Active Set Update message UE in non Cell_DCH state to receive that message Protocol error Physical channel error

The filtering, timing and SHO algorithm are configurable by UTRAN parameters. Especially in dense urban environment these parameter have to be optimised e.g. to react faster to the around-the-corner effect or in areas with weak coverage (in 3G border areas) to trigger the 3G-2G HO quickly. Table 52 below is summarising how to identify these issues in network interface traces. Note that the handover delay can be confused with missing RRC messages (check event id of Measurement Report with removal/addition list of ASU message). As a general point LDAT3G allows delay between two RRC messages to be quantified using the UDR Time difference option under Report Menu. Long handover delays can result in dropped calls and in a decrease of the overall UMTS RF conditions. ALU RNC does have blocking phases that means that an on-going procedure like RB Reconfiguration may cause the SHO to be blocked. Enabling the RadioAccessService.shoAfterBlockingPhaseEnable will ensure that all received reports are queued for processing once blocking ends.

Problem
Intra Delay Frequency Handover

Trace
Uu

Trigger
Any occurrence where the UE sends a Measurement Report 1x and the RNC does not reply with an Active Set Update message within y seconds Any occurrence where the UE is sending an Active Set Update Failure message Any occurrence where the RNC is not sending the Measurement Control message within y seconds after the UE has sent the Active Set Update Complete message and the event ID of the last Measurement Report has been event 1x14 Any occurrence of a dropped call within y seconds after the RNC has sent an the Active Set Update message and the event ID of the last Measurement Report has been event 1x There is one (or more) intra-frequency cell measured by the 3G scanner that is not in the active set and its Ec/No is for x seconds better than y dB compared to the best cell in the active set and the UE is not sending within that time period a Measurement Report

Active Set Update Failure Long delay of Measurement Control message after Active Set Update Complete for event 1x Dropped call during event 1x

Uu Uu

Uu

HO event 1a/1c is too slow

Uu, 3G scanner

14

In case of e.g. periodic reporting an update via Measurement Control message is not required (For Internal Use Only) Page 70 of 110

UMTS Operational Network Engineering

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

with id 1a or 1c Ping-pong HO Measurement Control Failure Uu Uu Whenever a cell is added to the active set (event 1a) , it is removed within x seconds again (event 1b or 1c) or vice versa Any occurrence where the UE is sending an Measurement Control Failure message

Table 52: Identification handover issues in traces PM KPIs related to the intra-frequency handover process are available in [27].

6.10. Call reliability IRAT handover


6.10.1. Concept (UMTS->GSM) IRAT handover are used to maintain UMTS voice call in case 3G coverage (RSCP) and/or quality (Ec/No) is not sufficient and trigger iMCTA Alarm. Furthermore they can be used for traffic distribution from loaded sites (iMCTA Service) or initiated after a call is rejected by CAC (iMCTA CAC). IRAT handovers are always hard handovers and mobile assisted in ALU RNC. The measurement reporting and filtering methods are similar to the one of the intra-frequency handover as explained in subsection 6.9. When the measured Ec/No or RSCP of the cells in the active sets drops below a certain threshold, the UE sends a compressed mode (CM) activation Report Event 2d to the RNC and after receiving the RRC measurement control message from the UTRAN activates the pre-configured compressed mode pattern to start the IRAT measurements as specified in the message. When the measured Ec/No or RSCP of the cells in the active set exceeds a specific threshold the UE sends a Measurement Report Event 2f. RNC allows the current CM pattern to proceed till expiry but doesnt setup a new CM. While in compressed mode, the UE sends periodic Measurement Report every 0.5sec with the measured level on the GSM/GPRS neighbour cells. The UTRAN might decide to trigger the IRAT handover by sending the Handover From Utran command on RRC if the reported level exceeds a predefined threshold RadioAccessService.minimumGsmRssiValueForHO. Figure 25 below shows the call flow chart across the UMTS and GSM network for performing UMTS to GSM CS voice handover including the 3G and 2G CN:

UMTS Operational Network Engineering

(For Internal Use Only)

Page 71 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Phases

Figure 25: Flow chart of successful UMTS to GSM voice handover 6.10.2. Failure symptoms, identification and fixes for improvement (UMTS>GSM) UMTS to GSM Handover failure may occur during one of the phases as following: Relocation procedure failures (subsection 6.17.2/phase 1 in figure) Handover procedure failures in GSM network (phase 2 in figure) Release procedure failures (subsection 6.17.3/phase 3 in figure)

Upon successful completion of the relocation procedure, the SRNC sends the Handover From UTRAN Command including the GSM Handover Command to the UE. If the UE fails to complete the requested handover then SRNC receives a Handover From UTRAN Command Failure message from the UE. According to [9] the failure causes specified within this message can be subdivided as follows: Physical channel failure Unacceptable configuration Protocol error

The first cause refers to the case when there is loss of synchronisation between UE and 2G-NodeB. This is mainly caused by poor RF conditions, especially if the coverage of the co-located 2G site/neighbour is not as good as that for 3G network or if UE reported 2G neighbors BSIC is ambiguis and CN prepared a different 2G NodeB. This problem can also occur due to incorrect provisioning in 2G network. The last two causes are expected to occur seldom and in general are not related to RF issues. The IRAT HO can be configured with the parameters as described in [17]. In case of a high failure rate during the IRAT handover procedure it should be checked if the HO has to be triggered earlier under better 2G and 3G

UMTS Operational Network Engineering

(For Internal Use Only)

Page 72 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

conditions. However this may increase the proportion of CS calls going over to 2G, which may be against customer expectations. Table 53 below is listing the identification triggers for IRAT HO problems in traces: Problem
Delayed IRAT HO after UE report Handover From UTRAN Command Failure RRC drop compressed mode in

Trace
Uu Uu

Trigger
Any occurrence of a periodic Measurement Report sent by the UE, but there is no Handover From UTRAN Command within x seconds Any occurrence of a Handover From UTRAN Command Failure message sent by the UE Any occurrence of a drop of the RRC connection when the UE was in compressed mode

Uu

Table 53: Identification of IRAT HO problems in traces

PM system
UtranCell UtranCell

Counter / KPI
(IRATHO.SuccOutCS.<sum> / IRATHO.AttRelocPrepOutCS) VS.AggrCellListAmbigCellInterRAT

KPI Name / Description


Outgoing CS Inter RAT handover success rate (UMTS->GSM) The aggregate inter-RAT neighbour list contains an ambiguous cell

Table 54: PM KPI for outgoing CS IRAT success rate

For counters dealing with preparation phase during IRAT-HO, refer to section 6.17.2.

6.10.3.

Concept (CS GSM ->UMTS) The IRAT for GSM to UMTS would allow the operator to make use of the 3G coverage in case of GSM network overload or simply to maximise the usage of UMTS network. However the HO is actually initiated by the GSM network and hence not discussed any further. This HO is limited to CS calls and in case of combined CS/PS call the UE is required to setup the PS part of the call upon successful completion of CS handover. The following figure shows HO execution signaling flow that starts with the RNC receiving Relocation Request from 3G MSC and ends when the RNC sends back Relocation Complete after receiving Handover to UTRAN Complete RRC message from the UE. From UTRAN perspective RadioAccessService.is2gto3gCSHandoverAllowedWithinRNC is used to ensure that RNC will accept the incoming relocation procedure involving SCCP connection initiated by the CN.

UMTS Operational Network Engineering

(For Internal Use Only)

Page 73 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Figure 26: Flow chart of successful GSM to UMTS CS handover

6.10.4. Failure symptoms, identification and fixes for improvement (CS GSM >UMTS) Some main reasons as to why the GSM to UMTS handover procedure may fail can be as follows. The GSM to UMTS handover feature is not enabled in UTRAN target cell The UE does not support the target cell frequency band The requested radio resources cannot be established, e.g. radio link setup fails on Iub or the ALCAP Iu transport bearer cannot be established The RNC does not receive a HANDOVER TO UTRAN COMPLETE message from the UE, because the UE has received an invalid HANDOVER TO UTRAN COMMAND message or it does not support the configuration included in the message. In this case the timer expires The MSC cancels the relocation by releasing the Iu connection PM KPIs related to the IRAT Handover process are detailed in [27] with some example shown below:

PM system
UtranCell

Counter / KPI
((VS.IuRelocationRequests.Cs2Gto3GRelocation VS.IuRelocationRequestFailuresCs.2Gto3G.<sum>) / VS.IuRelocationRequests.Cs2Gto3GRelocation)

KPI Name / Description


Incoming CS Inter RAT handover success rate (GSM->UMTS)

Table 55: PM KPI for incoming CS IRAT success rate

UMTS Operational Network Engineering

(For Internal Use Only)

Page 74 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

6.11. Call reliability Cell change order from UTRAN


6.11.1. Concept The cell change order from UTRAN procedure may be initiated by the UTRAN when the UE is in CELL_DCH mode. PS inter-system/RAT handover can be initiated due to reasons that are similar to the ones for the CS inter-system handover (subsection 6.10). Furthemore, a two-step approach to first measure BCCH/RXLEV of the neighbouring GSM cells and then the BSIC is specified by ALU RNC in the Measurement Control message which sets the compressed mode patterns. However BSIC confirmation is not normally used as it substantially increases the UE measurement time. Nevertheless when the UTRAN decides to direct the UE to the GPRS domain, a BSIC and BCCH are specified. The UE is doing an inter-RAT cell reselection as specified within IE "Target cell description" of the Cell Change Order from UTRAN message. In the UE, timer T309 supervises this procedure.

Figure 27: Flow chart of successful UMTS to GSM PS handover The SRNS context transfer procedure is not fully supported by the ALU source RNC (i.e. the messaging is supported but the PDU counters are not transferred). Furthermore data forwarding is also not supported by the ALU SRNC. Therefore, some packets will be lost during the handover. End-to-end reliability is supposed to be provided by end-to-end transport layer (e.g. TCP).

6.11.2.

Failure symptoms, identification and fixes for improvement In case the UE cannot successfully complete the procedure and T309 expires, the UE will

UMTS Operational Network Engineering

(For Internal Use Only)

Page 75 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Re-establish the UTRAN physical channel(s) used at the time for reception of cell change order from UTRAN and transmit the cell change order from UTRAN failure message and set the IE "Inter-RAT change failure" to "physical channel failure" OR when not successful in re-establishing the UTRA channels, perform a cell update procedure with cause "Radio link failure"

Table 56 below is listing the parameter for the cell change order from UTRAN procedure:

Parameter UeTimerCstConnectedMode. t309

Description
Timer starts upon reception of CELL CHANGE ORDER FROM UTRAN message, and stops when a successful establishment is made in the new 2G cell.

Table 56: Parameter used for configuring the cell change order from UTRAN Table 57 below is listing the identification in interface traces possibilities for the cell change order from UTRAN procedure:

Problem
Cell Change Order from UTRAN I Cell Change Order from UTRAN II

Trace
Uu Uu

Trigger
Any occurrence of the RRC message CellChangeOrderFromUTRANFailure Any occurrence of the RRC message CellChangeOrderFromUTRAN and within x seconds there is a cell update message with cause "Radio link failure"

Table 57: Identification of cell change order from UTRAN failures in traces PM KPIs related to the process are available in [27] with an example below.

PM system
UtranCell

Counter / KPI
(IRATHO.SuccOutPSUTRAN.<sum> / VS.RrcCellChgOrderUtranCmd.<sum>)

KPI Name / Description


Outgoing PS CCO success rate (UMTS->GSM)

Table 58: PM KPI for outgoing PS CCO success rate

6.12. Call reliability inter frequency handover


6.12.1. Concept In UMTS networks inter-frequency hard handover is a feature that ensures seamless mobility between frequency carriers in same or different spectrum bands on same or different RNC. In ALU UTRAN, hard handovers can be triggered by the degrading quality of the current frequency or if a newly setup signalling call experiences CAC failure while setting up the traffic RB or to offload an on-going call if the primary or best cell is congested. All inter-frequency measurement-reporting events (2a to 2f) are defined in [6].

UMTS Operational Network Engineering

(For Internal Use Only)

Page 76 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

According to [17] this procedure consists of the following steps: Detection of the need for inter-Frequency HO HO algorithm selection and measurement report setup Measurement event report reception and HO execution If necessary execution of RNS relocation procedure (subsection 6.17.2)

DAHO (or blind) algorithm is only used when handing over from a Micro to a Macro site. Otherwise MAHO is recommended for most scenarios. Irrespective of the reason for initiation, the call flow follows slightly different sequence if the HO is inter/intra-NodeB and inter/intra-RNC. Furthermore RB reconfiguration message is used to performe this HHO. 6.12.2. Failure symptoms, identification and fixes for improvement The reasons for inter-frequency HO failures are similar to the ones that may be encountered during intra-frequency or IRAT HO, as constituent procedures are the same, however some salient failure mechanisms are: Target Node B is unable to allocate the resources requested. Then it returns a NBAP Radio Link Addition Failure or Radio Link Setup Failure message to the SRNC (section 5.1.5). The UE may not be able to perform the new configuration and returns a Radio Bearer Reconfiguration Failure. The newly allocated resources on the target cell are released by means of the NBAP Radio Link Deletion procedure by the RNC. The call continues on the current configuration. If the Inter-Frequency Handover Timer Imcta.measurementGuardTimerFdd expires and no neighbouring cell is found to be suitable candidate for HHO (no inter-frequency cell has been reported or the reported cells are not found to be elligible). Then Compressed Mode is reactivated if Event 2f for same quantity (i.e EcNo or RSCP) has not been received which triggered the measurements in the first place in the form of Event 2d, i.e. trigger was Alarm. However, UE remains on the original frequency if trigger was due to CAC or Service without invoking CM again.

The user plane interruption is likely to be longer for the UL as DL data is sent on both the old and new RL while UL is only sent on old RL until either it fails or the new RL is restored. Table 59 shows some failures that can be identified using network traces

Problem
Inter Frequency HO Delay

Trace
Uu

Trigger
Any occurrence where the UE sends a inter-frequency Measurement Report and the RNC does not reply with RB Reconfiguration message immediately RNC sends a RB Reconfiguration message but the UE does not respond back with either complete or failure message within RNC static timer T361. This will be followed by RNC initiaiting Iu release procedure with cause Unspecified.

Dropped call during IF HHO

Uu and CT

Table 59: Identification of inter Freq HO failures from traces UTRAN

UMTS Operational Network Engineering

(For Internal Use Only)

Page 77 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Some important KPIs/Counters pegged during this process are given below:

PM system
UtranCell UtranCell

Counter / KPI
(HHO.SuccOutInterFreq / HHO.AttOutInterFreq) (VS.IncomInterFreqHoSuc.<trigger>15 / VS.IncomInterFreqHoAtt.<trigger>)

KPI Name / Description


Inter-frequency hard handover success rate - Outgoing Inter-frequency hard handover success rate - Incoming

Table 60: PM KPI - Inter-Freq HHO success rate

6.13. Call reliability failures on the Transport Network


The underlying transport network on the Iub and Iu interface is mostly ATM. On the Iub interface AAL2 and AAL5 are used, and with help of the ALCAP protocol resources are allocated. On the Iu interface the underlying ATM protocol is AAL5. ATM failures and performance statistics of the Transport Network are not reported at the FM/PM system of the UTRAN, but on the ATM system. But it would be advisable to check for any VCC Alarms that may have occurred on the NodeB (identified by the PSC of its sector) where the drop occurred and there is no other possible explanation like bad RF, RLC error etc. Main problems that might occur on the Transport Network are as follows: Link synchronisation problems e.g. when using microwave links Configuration issues

6.14. Call reliability failures on RLC


6.14.1. Concept The specification of the RLC protocol is provided in [22]. A detailed description of the ALU implementation is available in [17]. RLC is a sublayer in layer 2 of UMTS protocol stack. RLC provides three basic tasks: 1. Buffering Buffering is required in RLC to compensate for the data rate variations of higher and lower layers: TCP/IP based applications typically generate IP packets at variable data rate, while the air interface provides varying throughput due to changing channel conditions. 2. Segmentation and reassembly Variable-sized IP packets provided by the PDCP as RLC SDUs are segmented into fixed sized RLC PDUs. Concatenation and padding are used for efficient packing. Each RLC PDU is transferred as one fixed-sized PHY TB. 3. Error control AM RLC provides the link-layer ARQ scheme that is required to hide PHY block errors from higher layers.

15

Triggers include Rescue (Alarm due to 2d/2f), Service (due to Red cell colour) and NoRsrcAvailCacFailure (no resources available) (For Internal Use Only) Page 78 of 110

UMTS Operational Network Engineering

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

The RLC provides three different types of data transfer modes: TM data transfer o o No protocol overhead added; transparent to the RLC Used for signalling SRB (e.g. broadcast SRB on BCCH, paging SRBs on PCH), voice services and CS data

UM data transfer o Buffer control of RLC SDUs for smoothing data rate variations introduced by burst-traffic sources (e.g. TCP flow control) and lower layer variations Segmentation, concatenation and padding into RLC PDUs. Each PDU is transferred as one physical layer TB. Reassembly of PHY data from TB into RLC PDUs and RLC SDUs Used for fast signalling (e.g. SRB1 on DCCH)

o o o

AM data transfer o o o UM data transfer features plus Error control feedback, retransmission of erroneous or lost PDUs and in sequence delivery of RLC PDUs by ARQ Used for signalling (SRB 2-4) and PS data services

There is one pair of AM RLC entities per RB. In the following TM is not considered any further because there is no performance impact due to RLC. Figure 28 below is showing the UMTS protocol stack of the user plane for a TCP/IP data application:

Figure 28: UMTS protocol stack of the userplane for a TCP/IP application TCP has its own flow control and ARQ algorithms so the OAM parameter of RLC has to be adapted to interwork with TCP in an optimal way. Because the TCP settings could be different on each client PC (and the corresponding server

UMTS Operational Network Engineering

(For Internal Use Only)

Page 79 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

in the Internet or corporate business network) a reference client-server system should be defined and used to optimise the RLC settings. A RLC PDU for PS RB has a size of 42 bytes (40 byte payload and 2 byte header), which is relatively small compared to a TCP/IP packet size of around 1000 byte17. As a consequence retransmission on RLC results in a retransmission of relatively small amount of data compared to that on TCP/IP layer. Furthermore if a data PDU is not completely filled with data of one SDU, concatenation and/or padding are applied. For each TB set, the PHY is performing a CRC check; in the UL the NodeB is adding the CRCI to each TB set (see also subsection 7.1.2.1). Furthermore the physical frames on Iub are protected by additional CRCs. If one of both CRC fails, lower layer discards the whole frame on Iub / the whole TB set. It is up to the RLC of how to react on lost data and possibly initiate retransmission. RLC ARQ mechanism For identification each PDU has (for DL and UL and per RLC entity separately) an increasing SN (0,, 4095 for AM, 0,, 127 for UM). At the TX the data PDUs are stored in a retransmission buffer when they are submitted to the MAC and PHY layer. If a data PDU is NACKed it can be quickly retransmitted. ARQ is using the following mechanism: Status reporting on the RX: the RX sends a status report in so-called STATUS PDUs containing a detailed list of received and missing PDUs. STATUS PDUs have priority over retransmitted data. They can be sent periodically or unsolicited e.g. after loss detection Polling from TX: the TX can request a status report by setting a poll bit in the RLC-PDU header forcing the acknowledgement of previous PDU by the RX Window mechanism: a sliding window allows the TX to transmit new PDUs while waiting for the ACKs till end of the window size. SDU discard function: when the delivery of a SDU cannot be managed because of e.g. repeated errors, the transmission of SDUs is stopped and discarded on both TX and RX side.
16

Protocol error recovery Data PDUs carrying poll requests and status or other control PDUs require a special ACK and are protected by timers When timer protected PDUs are not acknowledged before the timer elapses these PDUs are retransmitted If timer protected PDUs are retransmitted and still no ACK received o If data PDU retransmission did not succeed, go either to SDU discard or RLC reset of the RLC connection between the two entities o If SDU discard does not succeed, go to RLC reset of the RLC connection between the two entities o If RLC reset does not succeed, signal unrecoverable error to higher layers. In this case the RRC might be dropped and the UE performs
16

Size of signaling SRB is 16 bytes plus 2 bytes header Size of the TCP/IP packet is depending on the MSS negotiated for each TCP session during the connection setup. In addition it might be that the IP packet is further segmented by one Internet server
17

UMTS Operational Network Engineering

(For Internal Use Only)

Page 80 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

a Cell Update and the IE AM_RLC error indication is set to TRUE (subsection 6.3.1) Parameters configuring the RLC are available in [17] along with features that can improve RLC performance. Reason for problems on the RLC might be due to RF related issues like pilot pollution, incorrect neighbouring definitions Lower layer problems on the Iub, ATM cell discarding occurs causing the packets to be lost Forced decrease of the data rate due to congestion control resulting in SDU discarding in RNC UE or RNC software bugs where the behaviour does not follow 3GPP standard

6.14.2.

Failure symptoms, identification and fixes for improvement The retransmission on RLC layer can be easily identified by a not-in-sequence delivery of RLC PDUs on Iub; this information is normally not available in Uu traces. The RX acknowledges in its status reports all PDUs with a SN < LSN. However, CTg or CTb with RLC information can also be used in this investigation especially if explicit Iub tracing is not possible or allowed. For better identification on Iub the particular call has to be extracted so as not to mix up with RLC PDUs of other calls. In addition special ASCII files downloaded via FTP can be used to easily identify retransmission (only possible when PPP and PDCP compression techniques as well as ciphering is disabled, see also subsection 7.2.3). However these limitations dont apply to CT tracing feature as RNC recorded each call separately. Another (but quite complicated) possibility is the analysis of the BITMAP in the status reports of the RX. The BITMAP is giving the TX an indication about which PDUs have been successfully received and which not starting from the First SN (number of octets determined by LENGTH) [22]. A dropped (CS or PS) call due to a RLC error can be easily identified by a Cell Update message in UE log with cell update cause RLC unrecoverable error. Note that an RLC error in the SRB2-4 (represented by cell update IE AM_RLC error indication = True for RB2-4) cannot be reconnected for CS voice and always results in drop call as per 3GPP [6]. The SDU discard function removes the RLC PDU from the buffer on the transmitter side, when the transmission of the RLC PDU does not succeed for a long time. Hence it allows avoiding buffer overflow. There will be several alternative operation modes of the RLC SDU discard function, and which discard function to use will be given by the QoS requirements of the Radio Access Bearer. Table 61 is listing problems that can be detected in interface traces and Table 62 the corresponding KPIs in the PM system:

Problem
RLC Resets RLC retransmission SDU discard with

Trace
Iub Iub Iub

Trigger
Any occurrence of RLC Resets in Iub traces Any occurrence of retransmission of RLC PDUs per RLC session Any occurrence of a Move Receiving Window (MRW) command indicating a

UMTS Operational Network Engineering

(For Internal Use Only)

Page 81 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

explicit signalling Dropped call due to RLC error Uu

SDU discard and/or a MRW-ACK Any occurrence of a RRC Cell Update message with specified cell update cause (not failure cause) RLC unrecoverable error. The IE AM_RLC error might be set to True depending upon if error occurred on SRB/ RB2-4 or TRB/RB5 and above.

Table 61: Identification of RLC problems in traces

PM system
UtranCell

Counter / KPI
VS.NbrCellUpdates.RlcUnrecoverableError

KPI Name / Description


Number of requested cell updates with cause Radio Link Control (RLC) Unrecoverable Error received by the RNC from the UE Number of PS RLC PDUs Retransmitted on Reference Cell provided for various data rates and traffic classes Number of HSDPA Transport Blocks Discarded due to Max. Number of Retransmissions Reached or timer expiry

UtranCell

VS.DedicatedDownlinkRetransmittedPdusRlcRefer enceCell.<screenings> VS.HsdpaDiscTransportBlocksOnMaxRetrans VS.HsdpaDiscMACdPDUsTimerExpiry

UtranCell

Table 62: PM Counters to monitor drop or BLER at RLC layer

6.15. Call reliability HSDPA


6.15.1. Introduction From 3GPP Release 5 onwards HSDPA is supported in order to provide UMTS subscribers higher throughput rates in the downlink as well as better resource allocation in the UTRAN. Compared to Release 99 the following changes have been done for HSDPA: On UTRAN, new modulation schemes, fast scheduling and resource sharing techniques New UMTS physical channels New handsets with high speed capability Core Network accommodation for more traffic

Figure 29 below is visualising the changes in the UMTS protocol stack in order to support HSDPA:

UMTS Operational Network Engineering

(For Internal Use Only)

Page 82 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

UE

Uu

Node B

Iub

RNC

Iups

SGSN

Gn

GGSN

SM SM PM M M M PDCP RRC RRC PHY RL C codec RL C MC A MC A Phy-up Phy-up IP

SM M M PM M SM RRC PDCP GTP-U RRC RLC RL C MC A MC A A CA L P P M C-hs STC.2 NBA A DCH FP HSDSCH FP PHY A L2 A A TM E1/ STM -1 SSCF-UNI SSCOP A L5 A A CA L P NBA STC.2 P NBA A CA P L P Phy-up Phy-up IP SCCP SCCP M TP3-b DCH FP SSCF-N SSCF SSCOP A L5 A A A L5 A L5 A IP SCCP SCCP Q2150.1 M TP3-b M TP3B M TP3B SSCF-N SSCF SSCF SSCOP SSCOP SSCOP A L5 A L2 A L5 A L5 A A A L2 A L1 A TM A TM STM -1 E1 UDP RA P NA FP RA P NA GTP-U Q2150.1 GTP-C UDP Iu UP IP Q2150. 1 M TP3B SSCF SSCOP L2 A L5 A L1 IP Q2150.1 GTP-C GTP-U UDP Q2150.1

PHY DCH

PHY HSDPA

PHY PHY HSDPA DCH

HSFP SSCF-UNI SSCF SSCF DSCH FP SSCOP SSCOP SSCOP A L5 A A L5 A L5 A A

A L2 A A L2 A L2 A A A TM A TM STM -1 E1

Control Plane

User Plane

Transport Plane

Com on m

Figure 29: HSDPA protocol stack enhancements The following subsections are describing different aspects of HSDPA data calls.

6.15.2.

Mobility aspects of HSDPA Concept For the UL the mobility procedures are largely mostly the same as for PS calls over DCH (e.g. soft/softer HO triggered via event 1a, 1b and 1c) For the DL the HS-DSCH for a given UE belongs to only one of the radio links of one sector of the NodeB where the UL is connected. As a consequence only Hard Handovers (Cell Changes) are triggered based on the reception of Event 1d.

6.15.2.1.

The mobility aspect of a HSDPA user is as follows:

The RNC is forwarding the DL application data to the NodeB from the MAC layer to the new MAC-hs layer that is scheduling the data for delivery. In case of a Hard Handover the NodeB discards data that has not been transmitted yet. In this case it is up to the higher layer protocols (RLC or TCP) to retransmit lost data. As a consequence too many serving HS-DSCH Cell Changes within a short period of time (Ping-Pong handovers) may cause a reduced throughput. A typically scenario might look as follows: UE connected to NodeB A, NodeB B is becoming stronger and stronger UE sends Measurement Report with Event 1a RNC adds NodeB B to the Active Set via Active Set Update procedure UE sending Measurement Report with Event 1d RNC triggers Hard Handover via Radio Bearer Reconfiguration procedure

UMTS Operational Network Engineering

(For Internal Use Only)

Page 83 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

UE sends Measurement Report with Event 1b to remove NodeB A from the active set

The optimisation approach when triggering Event 1d is as follows: HSDPA cell change should not be performed too late, when the UE has already moved 'far' into the area of another cell where it could have better throughput. HSDPA Hard Handovers should not be executed too early, so that it immediately changes back to the previous cell if the radio conditions vary (Ping-Pong effect).

If the new primary cell does not support HSDPA or suffers from CAC failure, then the HS-DSCH RB(s) is (are) reconfigured to DCH (if iRM CAC is successful). In case of CAC failure for the DCH then the PS RAB(s) is (are) released. For parameters configuring HSDPA see [16]. Again like DCH calls iMCTA CAC can also trigger (if DCH fallback not enabled or fails) to transfer the call to another inter-frequency 3G or inter-system 2G cell. 6.15.2.2. Failure symptoms, identification and fixes for improvement

HSDPA performance degradations due to mobility issues can be best observed by analysing drive test data. It is very important to trigger handover at the right time as too late and UE may be served by a NodeB that is much worse compared to the best cell in the active set or too early and frequent handovers can hurt throughput as well. Furthermore non-optimal handover settings might cause unnecessary transitions from HS-DSCH to DCH if too many HSDPA users; as a result the benefits from HSDPA will not be available to a HS capable UE. Finally during the Hard Handover there might be major transmission gaps including TCP retransmission. The reason might be synchronisation problems or not optimal timing during the handover procedure e.g. the timing when the RNC stops forwarding data towards the old NodeB. This problem can be easily detected when correlating RRC with TCP/IP data. Figure 30 below shows an example cross-correlated by Actix [18]; in the upper left part of the picture the RRC protocol is shown, the lower left picture shows the TCP SQN recorded at the client site by Wireshark (previously Ethereal):

UMTS Operational Network Engineering

(For Internal Use Only)

Page 84 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Figure 30: Hard handover problems identified by cross-correlated RRC and TCP data Table 63 below is listing the identification techniques for HSDPA mobility problems:

Problem
HSDPA ping-pong Transmission gap during HO in HSDPA call

Trace
Uu Uu, TCP

Trigger
There are two consecutive Radio Bearer Reconfiguration procedures within x seconds Cross-correlation Uu and TCP trace: during a Radio Bearer Reconfiguration procedure there is a transmission gap on TCP layer in the DL for x seconds

Table 63: HSDPA related problems indicated by network interface traces

6.15.3.

RF related issues RF related issues on the air interface are one of the main reasons for performance throughput degradations of HSDPA calls. The optimisation has to be done on a per-cell basis using UE drive test data. In the following subsections the most important measures are summarised. Due to the fact that in the downlink there is no gain from soft/softer HO a UE in HSDPA mode is more sensitive regarding pilot pollution (subsection 6.4.2).

6.15.3.1.

RF related issues - CQI

The DL quality of the HSDPA shared channel is reflected by the channel quality indicator (CQI) UE sends back to the Node B in the UL HS-DPCCH. The CQI ranges from 0 to 30, with greater values indicating better quality. It is based on the instantaneous measurements of the RF conditions. NodeB decides based upon the reported CQI values which Transport Format Resource Combination

UMTS Operational Network Engineering

(For Internal Use Only)

Page 85 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

(TFRC) can be transmitted given a certain transmit power and an expected error rate that is directly impacting the expected throughput. 3GPP [11] defines the meaning of the reported CQI values for each UE category. In [15] requirements for the accuracy of the channel quality measurements are given. The UE shall assume for the purpose of CQI reporting a total received HS-PDSCH power PHSDPSCH = PCPICH + + in dB

where the total received power is evenly distributed among the HS-PDSCH codes which correspond to the reported CQI. The measurement power offset is signaled by the RNC and the reference power adjustment is given for each UE category in [11]. PCPICH is the transmit power of the Primary CPICH. It should be noted that the 3GPP specification does not demand that PCPICH + is equal to the total available HSDPA power. The aim of analysing CQI is to understand in the even of throughput degradation, if the scheduler is efficiently utilising the air-interface by cross correlating CQI with codes, modulation and TB used to achieve a target HARQ BLER. Such information is readily available in UE logs. Figure 31 below show as a graphical distribution of the throughput versus CQI; the test has been done stationary, the cell was unloaded and application was FTP download via TCP/IP:
1800 1600

App Fwd Throughput [kbps]

1400 1200 1000 800 600 400 200 0 0 5 10 15 20 25

CQI

Figure 31: HSDPA - throughput versus CQI for TCP download Note: when the CQI is exceeding 15 there is no obvious throughput improvement observed anymore because the UE capability of 12 is in this case the limiting the maximum TBS (see also subsection 6.15.4). 6.15.3.2. RF related issues Ec/No

For the same test case as described in previous subsection the HSDPA throughput versus Ec/No were analysed. Again a strong correlation between both measures has been recorded as visualised in Figure 32:

UMTS Operational Network Engineering

(For Internal Use Only)

Page 86 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

1800 1600 1400 1200 1000 800 600 400 200 0 -20 -18 -16 -14 -12 -10 -8 -6 -4

App Fwd Throughput [kbps]

Ec/No [dB]

Figure 32: HSDPA - throughput versus Ec/No for TCP download To be noted: the Ec/No is never exceeding (excluding single measurement samples) around 6 dB because the No term includes the HSDPA traffic of the user. Furthermore for Ec/No values exceeding around 8 dB no throughput performance could be observed indicating UE limitations. 6.15.3.3. RF related issues other optimisation problems

For any other optimisation problems as neighbour list planning, access parameters or power control settings please take a look in the corresponding subsections of this guideline. 6.15.4. UE limitations HSDPA capable terminals with resulting peak data rates ranging from 1.2 Mbit/s to 14.4 Mbit/s at physical layer, see also [14] and [16]. Depending on the terminal type different maximum number of HS-DSCH codes, different maximum TBS or modulation schemes are supported. As a consequence the maximum achievable throughput is terminal dependent and should be taken into consideration when analysing HSDPA UE traces especially in good RF. 6.15.5. Capacity issues Because the HS-DSCH is a shared channel the throughput of one UE highly depends on the overall HSDPA traffic in the particular NodeB. Two cases can be differentiated: 6.15.5.1. Capacity issues sharing of the bandwidth

When sharing the HSDPA bandwidth with other users the application throughput will not be optimal due to the fact that The bandwidth provided by the HS-DSCH is limited The bandwidth on the backhaul transport network is limited

These kinds of capacity issues can be detected as follows:

UMTS Operational Network Engineering

(For Internal Use Only)

Page 87 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Indirectly by execution of UE performance tests during the busy hour and a comparison to the non-busy hour; another good test method might be static automatic tests over a day By evaluation of PM counter statistics to examine the frequency of UEs of certain category being scheduled and how often multiple users were scheduled per TTI Evaluation of Iub traces in regards to the HS-DSCH FP flow control and congestion management especially if number of E1/T1 are low.

6.15.5.2. Capacity issues HSDPA call cannot be established on a particular NodeB Failed establishment of HSDPA call on a NodeB can be due to following and are easily identifiable in the CT as HsdpaCacFailure. Hard limits During call set up, HS-DSCH serving cell change via hard handover and transition from URA_PCH/CELL_FACH to CELL_DCH with HSDPA, the number of active HSDPA users is checked on a cell level against the parameter hsdpaCellClass.maximumNumberOfUsers. HSDPA hardware and processing resources are limited in the NodeB, for more details see [16]. For ALU UA6.0x the UCU-III/xCEM hardware limitation due to UL (and default parameter setting) is 32, although more than 64 users have been shown to be supported per sector-carrier under lab conditions and with very low UL data rates of 8kbps. Soft limits Each time when a UE tries to establish a HSDPA call on a new NodeB via a RadioBearerReconfiguration procedure iRM CAC is also checking the soft limitations for the associated DCH. For ALU UTRAN the corresponding parameter and algorithm configuring iRM CAC are explained in [17]. In case Fair-sharing (33694) is truned on, the CAC will depend upon the resources reserved for the existing HSDPA users and can trigger a failure even with less number of users per cell than above. So this depends upon the QoS requirements of existing users and can change with the dynamics of the traffic mix. HSDPA related PM counters are available in [27].

6.16. Call reliability HSUPA/EDCH


6.16.1. Introduction From 3GPP Release 6 onwards HSUPA is supported in order to provide UMTS subscribers higher throughput rates in the uplink as well as better resource sharing in the UTRAN. But in UA6 release HSUPA is only supported in UL, if HSDPA is configured in the DL. Furthermore new UL MAC functionality has been split into RNC (MAC-es) and NodeB (MAC-e) entities respectively.

UMTS Operational Network Engineering

(For Internal Use Only)

Page 88 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Figure 33 below is visualising the changes in the UMTS protocol stack in order to support HSUPA:

Figure 33: HSUPA changes done to the Protocol Stack The following subsections are describing different aspects of HSUPA data call. 6.16.2. Mobility aspects of HSUPA Concept

6.16.2.1.

The mobility aspect of a HSUPA user is as follows: In general the mobility procedures are the same as for PS calls over DCH (e.g. soft/softer HO triggered via event 1a, 1b and 1c). However for networks supporting EDCH Macrodiversity, event 1j is also configured. This event is used to keep the DCH active set and the EDCH active set consistent when certain active set updates take place [16] However one of the radio links acts as the serving cell which is selected to be the same as for HSDPA in the DL In HSUPA serving cell is responsible for issuing absolute serving grants (AG) for the UE to send data. And as such this cell change only involves changing the physical channels E-AGCH/E-RGCH to accommodate the new role of the cell. The support of soft/softer HO means that the possibility of performance degradation is much less as compared to HSDPA. UA6.0 only supports HSUPA over Iur boundary if feature 30744 is enabled on SRNC and DRNC and both are RNC9370. So in markets where the above scenario is not applicable (like USA), if the primary radio leg goes over to the drift RNC, the HSDPA/E-DCH call will be reconfigured to HSDPA/DCH state with a maximum data rate controlled by DchRateCapping.maxUlRateHsdpaAndEdchToHsdpaAndDch.

UMTS Operational Network Engineering

(For Internal Use Only)

Page 89 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

A timer is used to supervise the reconfiguration back to HSDPA/E-DCH state (only possible in SRNS relocation or when all radio legs handover back to SRNC) and an optimum value should avoid ping ponging between DCH and EDCH states in case call stays around Iur boundary. However reconfiguration to DCH can also occur if there are cells involved which dont support E-DCH or cells are fully loaded with maximum allowed number of E-DCH users or if UTRAN wants to activate compressed mode on the UE. 6.16.2.2. Failure symptoms, identification and fixes for improvement

Depending upon the initial E-DCH throughput, the new DCH bearer throughput will be lower at application level. If some of the radio legs go back to SRNC then there is possibility that bearer will never configure back up to E-DCH. However such situation will only occur if the user only moves along the Iur boundary. Problem
HSUPA ping-pong along Iur Reduction in throughput during HO along Iur

Trace
Uu Uu

Trigger
There are consecutive Radio Bearer Reconfiguration procedures within x seconds doing E-DCH DCH state changes frequently There is no subsequent Radio Bearer Reconfiguration procedure observed after the initial procedure that configured UL to DCH

Table 64: HSUPA HO related issues involving Iur Some relavent KPIs/Counters are given that deal with the handover and call reliability aspects of HSUPA

PM system
UtranCell UtranCell

Counter/KPI
VS.EdchCellDeletion.RadioLinkFail VS.RAB.Drop.PS.CellDCH.EDCH_HSDSCH

KPI Name / Description


Number of E-DCH Cell Deletion. Deletion due to Radio Link failure Dropped UTRAN Initiated PS RAB Connections with UE in Cell_DCH per transport channel format. UL EDCH and DL HSDSCH CN (core network) initiated dropped PS RAB connections for UEs in Cell_DCH state per transport channel type EDCH Serving Cell change Success rate

UtranCell

VS.RAB.Drop.CN.Init.PS.CellDCH.EDCH_HSDSCH

UtranCell

(VS.EdchSucMobility.EdchCallToEdchCallIntraFreqMob / (VS.EdchSucMobility.EdchCallToEdchCallIntraFreqMob +VS.EdchUnsucMobility.EdchCallToEdchCallIntraFreqMob))

Table 65: PM Counter/KPI for E-DCH Mobility & Call Drop

6.16.3.

MAC/ RF related Issues The scheduling mechanism for EDCH involves UEs sending scheduling requests that are assigned resources by the MAC-e entity upon evaluation of a set of criteria. This scheduling grant takes the form of absolute (giving max uplink power that can be transmitted) or relative (stipulating change/no-change in power with respect to previous TTI). However in case of overload (on Uu or Iub) the scheduler will not honour the request and would most likely start downgrading the served and non-served UEs through absolute and relative grants respectively. Hence it is important to

UMTS Operational Network Engineering

(For Internal Use Only)

Page 90 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

ensure that UL target load and Iub links are setup correctly to give desired cell throughput. The scheduler is also responsible for the hybrid ARQ to ensure error-free delivery avoiding re-transmissions at higher layers, reducing delay. Furthermore the UL EDPCCH contains a happy bit that shows if the UE is satisfied with the current grant. This can act as an indicator of how fairly each UE is being scheduled. Under bad RF conditions the UE is likely to be transmitting at high power to reach the NodeB and hence will not have sufficient power available to send the data resulting in loss of throughput. 6.16.4. UE Limitations HSUPA capable terminals have peak data rates ranging from 0.7 Mbit/s to 5.7 Mbit/s at physical layer, see also [14] and [17]. Depending on the terminal type, various options for maximum number of UL codes, minimum SF and TTI durations are supported. As a consequence the maximum achievable throughput is terminal dependent and should be taken into consideration when analysing HSUPA UE traces. 6.16.5. Capacity issues Because the E-DPDCH is a shared channel the throughput of one UE highly depends on the overall HSUPA traffic in the particular NodeB. Two cases can be differentiated: 6.16.5.1. Capacity issues sharing of the bandwidth

When sharing the HSUPA bandwidth with other users the application throughput will not be optimal due to the fact that The bandwidth provided by the E-DPDCH is limited, see Figure 34 The bandwidth on the backhaul transport network is limited

These kinds of capacity issues can be detected in a similar way to what has been described for HSDPA

UMTS Operational Network Engineering

(For Internal Use Only)

Page 91 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Figure 34: User versus Cell throughput variation with increase in users 6.16.5.2. Capacity issues HSUPA call cannot be established on a particular NodeB During call set up, E-DCH serving cell change and transition from URA_PCH/CELL_FACH/CELL_DCH to CELL_DCH with E-DCH the number of active HSUPA users is checked on a cell level against the parameters BTSEquipment.edchMaxNumberUserEbbu & BTSEquipment .edchMaxNumberUserNodeB. HSUPA capacity is also heavily dependent on hardware and processing resources which are limited in the NodeB, for more details see [16]. Some relevant KPIs/Counters are given that deal with NodeB capacity aspects of HSUPA. A full set of HSUPA related PM counters are available in [28].

PM system
UtranCell UtranCell UtranCell UtranCell UtranCell

Counter/KPI
VS.EdchIubTnlCongestIndc.Reserved VS.EdchIubTnlCongestIndc.DelayBuildUp VS.EdchIubTnlCongestIndc.FrameLoss VS.EdchIubTnlCongestIndc.NoCongestion VS.EdchIuRelAbnormal.CACReject

KPI Name / Description


Number of E-DCH Congestion Indication sent: Reserved Number of E-DCH Congestion Indication sent: Delay Build Up Number of E-DCH Congestion Indication sent: Frame loss Number of E-DCH Congestion Indication sent: No Congestion Number of Iu release requested for E-DCH call. CAC Reject on the EDCH Cell At each expiry of the EdchBLSupervisionTimer timer, the IubReductionFactor is computed.

NodeB

VS.eDCHBLReductionFactor.IuBFactor

UMTS Operational Network Engineering

(For Internal Use Only)

Page 92 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Depending on the value the corresponding sub counter is incremented.

Table 66: PM Counters dealing with EDCH capacity aspects

6.17. Call reliability miscellaneous failures


6.17.1. RB Reconfiguration failure Concept In case of UE state transitions e.g. when going from CELL_DCH mode to CELL_FACH mode in case the inactivity timer expires (subsection 6.7) or because of Congestion Control (subsection 6.5) Hard handover for HSDPA best cell change (subsection 6.15.2) and for inter-frequency mobility (subsection 6.12) In case RNC requests the UE to change the RB due to e.g. PS traffic measurements triggered either on receipt of a Measurement Report 4a from the UE or by the UTRAN monitoring the UL or DL RLC buffer occupancy (subsection 7.2.3) In case RNC requests the UE to change the DL R99 data rate due to high DL TX code power reported by the NodeB (iRM scheduling) 6.17.1.1.

RB Reconfiguration is used in ALU RNC for most of the RRM procedures:

In case of a change of R99 UL/DL data rate or HSDPA best cell, first a synchronised Radio Link Reconfiguration on NBAP is executed following changes of the ATM resources on the Iub via ALCAP procedures. RNC sends a RB Reconfiguration message on RRC and in case of a failure the UE sends back the RB reconfiguration failure. 6.17.1.2. Failure symptoms, identification and fixes for improvement

One reason for a failure in this procedure is that the UE is not supporting the requested new configuration. Failure can also occur due to un-optimised activation CFN in case of SRLR and physical channel failure while performing inter-frequency handover. Also during DCH to/from FACH transitions, the RNC is not able to listen to both FACH and DCH channels, which makes it vulnerable especially if UE experinces a failure and remains in one state while RNC changes the state causing either RB reconfiguration timeout or RLC disruption depending upon which is smaller. Table 67 and Table 68 are listing the identification of RB Reconfiguration Failures in traces and in the PM system:

Problem
RB Reconfiguration failure

Trace
Uu or CT

Trigger
Any occurrence of the RRC message RB Reconfiguration Failure

Table 67: Identification of RB Reconfiguration Failures in traces PM Counter / KPI KPI Name / Description

UMTS Operational Network Engineering

(For Internal Use Only)

Page 93 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

system
UtranCell and RNC UtranCell (VS.RRC.RBReconfigSucc / VS.RRC.RBReconfigAtt) VS.RadioBearerReconfigurationUnsuccess.Timeout RadioBearerReconfiguration Success rate Number of radio bearer reconfiguration not successful due to timeout Number of Radio Bearers that failed to be reconfigured due to various causes

UtranCell

VS.RadioBearerReconfigFailure.<cause>18

Table 68: PM KPIs identifying RB Reconfiguration Success and Failures

6.17.2.

Relocation failures Concept IRAT-HO (subsection 6.10 for details) Inter-RNC HO (SRNS relocation (UE not involved)) In case of a Cell Update on a new RNC

6.17.2.1.

The relocation procedure is used in case of

The procedure is described in [9]. The SRNC sends a Relocation Required message on RANAP. The CN sends back the Relocation Command message (successful case) or Relocation Preparation Failure (unsuccessful case). 6.17.2.2. Failure symptoms, identification and fixes for improvement

Failures of the relocation procedure occur most likely during the IRAT-HO, which is described here. A failure is detected during the RANAP Relocation Preparation procedure due to the following causes: Timer TRELOCprep (5sec) expiry at the SRNC Relocation Preparation Failure

In the first case the SRNC initiates the Relocation Cancel procedure at the Iu interface. This procedure enables the CN to initiate the release of the resources allocated during the Relocation Preparation procedure in the GSM network. The SRNC considers the UMTS to GSM handover as not possible at this point in time and keeps the existing radio connections established. This means that the existing Iu-signalling connection can still be used for the call. In the second case upon receiving a Relocation Preparation Failure message from the 3G CN, the SRNC still maintains the call. If the failure cause specified within the message is Relocation Failure in Target CN/RNC or Target System or Relocation not supported in Target RNC or Target System then SRNC repeats the Relocation Preparation procedure with the next suitable cell from the list of potential GSM target cells otherwise the SRNC considers the UMTS to GSM handover as not possible at this point in time. Table 69 is listing methods of how to identify relocation problems in call trace:

18

Causes include no DL code resources, no DL power resources, unspecified, CAC RNC processing resources, lack of bandwidth on Iu, Iur and Iub UMTS Operational Network Engineering (For Internal Use Only) Page 94 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Problem
Relocation Preparation Failure Relocation Cancel

Trace
CT CT

Trigger
Any occurrence of the RANAP message Relocation Preparation Failure Any occurrence of the RANAP message Relocation Cancel

Table 69: Identification of relocation failures in interface traces

Figure 35: Call Flow IRAT HO relocation cancellation due to timer expiry Tables below are listing the PM KPIs describing relocation failure and success:

PM system
UtranCell UtranCell

Counter / KPI
VS.RAB.Drop.CS.RelocUEInvol / RAB.SuccEstab.CS VS.RAB.Drop.PS.RelocUEInvol / RAB.SuccEstab.PS.Sum

KPI Name / Description


CS RAB Drop Rate due to SRNS Relocation (UE involved) PS RAB Drop Rate due to SRNS Relocation (UE involved)

Table 70: Drop rate due to Failure in SRNS relocation UE involved

PM system
UtranCell

Counter / KPI
(IRATHO.AttRelocPrepOutCS IRATHO.FailRelocPrepOutCS.<sum>)/ IRATHO.AttRelocPrepOutCS IRATHO.FailRelocPrepOutCS.TRELOCprep_exp/ IRATHO.AttRelocPrepOutCS

KPI Name / Description


Relocation preparation for CS UMTS to GSM HHO success rate Relocation preparation UMTS to GSM fail rate T Relocprep expiry

UtranCell

Table 71: PM KPIs for IRAT-HO relocation failure and success rates

6.17.3.

Failures during the RAB and RL release procedure The release of the RAB and the RL is not only used when terminating the voice or data call, but also when doing an IRAT HO from 3G to 2G.

UMTS Operational Network Engineering

(For Internal Use Only)

Page 95 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

In general failures are not expected to occur on this stage. The call handling is shown in Figure 11; the normal release procedure is identical with this call handling, the only exception is that it is not initiated by an Iu Release Request.

UMTS Operational Network Engineering

(For Internal Use Only)

Page 96 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

7. Call quality
In this section those aspects are investigated that have a direct influence of the user perceived call quality. In the first part the BLER in the DL and UL is discussed. The second part gives a definition of the Quality of Service (QoS) parameters for the different types of services like voice, data and VT and a description of performance weaknesses and how to overcome these.

7.1.

Call quality - Block Error Rate (BLER)


For the different types of services like voice, data and VT, a specific BLER has to be maintained to guarantee a good call quality. In case of voice or VT call the quality degradation can be directly experienced during the conversation. In addition VT calls will result in a fragmented and interrupted video signal. In case of data call the poor quality may cause throughput degradation or high ping delay times. The DL and UL Block Error Rate (BLER) are the KPIs providing an indication of the quality of the UMTS call from user perspective. The DL BLER is the percentage of corrupted blocks over the total number of blocks received by the UE; this KPI can be retrieved via UE logging or by setting up DL-BLER measurements from the UE: DL BLER = 100 * (NumRecBlocksErrDL / NumRecBlocksTotDL) The UL BLER is the percentage of corrupted blocks received by the Serving RNC (before frame selection) over the total number of blocks received (before frame selection). The UL BLER is provided via the following formula on a per RNC basis; statistics can be retrieved via the PM system (subsection 7.1.2) as: UL BLER = 100 * (NumTransBlockErrUL / NumTransBlockTotUL) The DL and UL PC algorithms are there to control the BLER to a maximum value. BLER degradation occurs in case of pilot pollution, non-optimal neighbouring definitions etc. as explained in subsection 6.4. High BLER can be observed in the UL or in the DL separately. The reasons observing high BLER might be as follows: Non-optimal Power control settings Maximum NodeB or UE transmit power for the dedicated channels has been reached Power restrictions to avoid system overload

In the following subsections the DL and UL BLER analysis is reflected in more detail. 7.1.1. DL Block Error Rate (BLER) analysis 7.1.1.1. Concept

The DL closed loop power control is in charge of keeping the DL BLER in a predefined range. The DL closed loop power control can be split into two loops: outer and inner loop. Figure 36 below is showing the principle of the DL PC:

UMTS Operational Network Engineering

(For Internal Use Only)

Page 97 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Figure 36: Downlink power control principle DL outer loop PC: The RNC sends a target value for the BLER to the UE on the DCCH. This value should guarantee an optimal performance for the (voice or data) service based on the requested QoS parameters. The DL outer loop PC in the UE defines a SIR target based on the BLER. The control loop runs autonomously in the UE with a maximum speed of 100Hz. The method on how to set SIR target in order to provide the requested BLER is not specified in the 3GPP standard. However some UE performances in given RF conditions are specified in [13]. When the UE is in compressed mode higher SIR target values will be defined, as there is no power control during transmission gaps. DL inner loop PC: The inner loop PC purpose is fast adaptation of the NodeB transmit power in order to achieve the targeted SIR for the considered downlink radio channel. Because of the speed of the control loop (up to 1500 Hz) the only elements involved in the inner loop power control are the UE and the NodeB. TPC pattern that the UE is sending to the NodeB is based on the comparison of the SIR estimation versus the SIR target. However the NodeB transmit power is limited to parameters given by the RNC on NBAP. 7.1.1.2. Failure symptoms, identification and fixes for improvement

The DL BLER is reported by any drive test system in Uu traces while the DL Tx code power can be captured using NodeB logging tool like OTCell or CDM/x or even with RNC initiated Call Trace if it is configured with NbapDedicatedMeasurements. Table 72 is listing the triggers in these traces:

Problem
High DL BLER in Uu NodeB Tx Pwr via CT

Trac e
Uu CT

Trigger
DL BLER higher than x % for more than y seconds NodeB transmit power is exceeding for service x more than y seconds z dBm.

Table 72: Identification of high DL BLER in interface traces

UMTS Operational Network Engineering

(For Internal Use Only)

Page 98 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

7.1.2. UL Block Error Rate (BLER) analysis 7.1.2.1. Concept

The UL closed loop power control is in charge of keeping the UL BLER in a predefined range. The UL closed loop power control can be split into two loops: outer and inner loop: UL outer loop PC: The UL outer loop PC is located at the RNC and is responsible for updating the UL SIR target so that the UL BLER ensures the QoS of the requested (voice or data) service. The RNC provides the NodeB the updated SIR target via the DCH FP on the Iub. The control loop runs in the RNC with a speed of up to 100 Hz. For updating the SIR target the RNC takes into account not only the measured BLER, but also the reported Quality estimates (QE) provided by the NodeB. In case Power Control Enhancements (DynamicParameterPerDch. qeThresholdForUlOlpc = 255) is not available then RNC relies only on the reported CRCI from the NodeB. Figure 37 below is visualising the principle:

Figure 37: UL outer loop power control If the UE is in soft/softer HO mode and one particular NodeB has more than one leg, the NodeB does frame selection in the NodeB (called micro-diversity). For frames coming from different NodeBs belonging to the same RNC the RNC is doing the frame selection (termed macro-diversity). In case the NodeBs belong to different RNCs the SRNC is doing the frame selection; the data is provided via the Iur interface. For each UL TB set the NodeB is performing a CRC check on PHY layer and adding a CRCI to the DCH-FP frame. In addition NodeB can also estimate the quality of the link and send to the SRNC via same frame in QE field. QE value ranges from 0 to 255 (small QEs are indicating good quality) and can be based

UMTS Operational Network Engineering

(For Internal Use Only)

Page 99 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

upon Physical or Tranmsport channel BER. QE can also be used by the OLPC in the SRNC if 0 < DynamicParameterPerDch. qeThresholdForUlOlpc < 255. UL inner loop PC: The UL inner loop PC is adjusting the transmit power of the UE in order to achieve the SIR target provided by SRNC. All NodeBs involved in the particular call are sending TPC commands with a rate of up to 1500 Hz. The TPC commands of NodeBs can differ from one another. In this case if only one of the NodeBs is sending a power down command, the UE will lower its transmit power by the defined power-down-step. In case there is no TPC at all the transmit power of the UE remains unchanged. More information including parameter can be found in [17]. 7.1.2.2. Failure symptoms, identification and fixes for improvement

Cells suffering with high UL BLER can be easily identified using data from the PM system. When doing drive testing high UL BLER can be identified by using the IMSI based call trace (CTb) in parallel to tracking the PMs as retrieved by the RNC. High UL BLER might cause a RLF in the UL and/or the drop of the call (see also subsection 6.1). A high UL BLER at RNS level may indicate inappropriate provisioning of TFCI for the various R99 UL services. For example TFI0 = 0x81 is chosen instead of 1x0 then this would disable the reporting of CRC from UE per TTI and hence impact the OLPC performance if silent mode is activated on the NodeB via activation flags: NodeB.isSilentModeAllowed and UlRbSetConf.ulFpMode = ulFpModeSilent. Table 73 and Table 74 are listing the triggers in interface traces and the corresponding PM KPIs:

Problem
High UL BLER High UE reached Bad CRCI Bad QE SIR exceeded target power

Trace
CT Uu Iub Iub Iub Iub

Trigger
UL BLER higher than x % for more than y seconds Any occurrence where the UE is sending with at least y dB UE power for more than x seconds19 More than x % of the CRCIs within y seconds have a CRCI equal to 1. More than x % of the QEs within y seconds have a QE more than y. The SIR target for service x is exceeding value y. Any occurrence where the UL SIR target is not updated for more than x seconds. This is an indication of failure in the UL that might lead to an UL RLF.

UL SIR target not updated

Table 73: Identification of high UL BLER in interface traces

PM system
RNC RNC

Counter / KPI
(VS.DdUlAmrABtBadFrm / (VS.DdUlAmrABtGoodFrm + VS.DdUlAmrABtBadFrm)) (VS.DedicatedUplinkBadPdus.<sum> / (VS.DedicatedUplinkPduRlc + VS.DedicatedUplinkBadPdus))

KPI Name / Description


UL BLER rate for All CSV AMR codec rates UL BLER rate for PS

Table 74: PM KPIs identifying BLER issues


19

Note that according to the 3GPP specification there are four power classes defined (power class 1 to 4) with maximum output power +33 dBm, +27 dBm, +24 dBm and +21 dBm. The most common mobiles on the market are class 3 (+24 dBm).

UMTS Operational Network Engineering

(For Internal Use Only)

Page 100 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

7.2.

Call quality Quality of service (QoS)


QoS reflects the quality of a wireless network from the user perspective in terms of voice quality, data throughput or the quality of the video signal using VT. The QoS can be measured with special drive test equipment. For evaluation purposes the drive test equipment should use a predefined measurement sequence for each of the service types as given in the appendix of this document. In this chapter the QoS for the different service types are discussed as well as how to identify possible failures and quality degradations. It is assumed that the number of measurement samples is sufficient to get a reliable result.

7.2.1. QoS general In this subsection general QoS KPIs are listed that are not linked to a particular service like voice, data or VT. Monioring these or similar KPIs can act as trigger points for identifying non-optimal performance.

KPI
No network [%] Attach failure [%] Attach setup time [s] Location update success rate [%] SMS failure rate [%] MMS failure rate [%] SMS delivery time [s] MMS delivery time [s]

Table 75: General QoS KPI measured on application level

In ALU UA6.0 QoS parameters like TC, ARP and THP given in the RANAP RAB Assignment Request message can be used for the OLS differentiation in various features like power control, iRM CAC, AO and iRM pre-emption, see [17] for details.

7.2.2. QoS voice service Because UMTS UL and DL links are uncorrelated due to different frequencies and reception paths it is necessary to measure the UL and DL voice quality separately. The voice quality equipment compares the received voice samples with the transmitted voice samples. In that way the evaluation software can do a voice quality classification for both directions independently. Table 77 below is giving the QoS KPIs for voice services. For the voice quality evaluation the Mean Opinion Score (MOS) is used. The MOS is defined by the ITU and is ranging from 1 to 5, for details see also ITU P.800 and ITU P.862. For further discussion on the MOS performance of various AMR codec rates see [28]. A good voice quality can be considered when the MOS is exceeding

UMTS Operational Network Engineering

(For Internal Use Only)

Page 101 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

3.0. Voice quality degradations like e.g. echo or voice delay are reflected by this measure.

Mean Opinion Score (MOS)


Below 2.0 2.0 to 3.0 3.0 to 4.0 Above 4.0

QoS value
Poor Fair Good Excellent

Table 76: QoS of voice services - MOS

KPI
Call completion success rate voice [%] Block call rate voice [%] Dropped calls voice [%] HandoverSuccess3G2G [%] HandoverSuccess2G3G [%] Call setup success rate voice [%] Good voice quality [%]

Table 77: QoS of voice services KPIs

7.2.3. QoS data services 7.2.3.1. Concept

There are different metrics available defining the QoS of data services like throughput, delay, jitter etc. In the PDP Context Activation Request message the UE can optionaly request pre-defined QoS profiles as specified in [5]. The CN can check the requested QoS profile with entries from the HLR. The CN makes these negotiated QoS parameters available to the UTRAN via the RAB Assignment Request [9]. Dedicated and common UTRAN resources can be dynamically assigned depending on traffic measurements or load. The initially assigned PS RB at the beginning of a PDP session depends on the UTRAN configuration. The RB data rate can be dynamically changed (or even the mobile is sent to idle mode/URA_PCH mode) depending on the data to be sent in the UL and/or DL. Depending on the status of the RLC buffer in the UE, the mobile might send a Measurement Report Event 4a (in case the buffer occupancy exceeds an absolute threshold) depending upon whether feature 34227.1 is enabled in UA6.0 via RadioAccessService.isBOTriggerForRbAdaptationAllowed. The RNC would then react on this Measurement Report by doing a RB reconfiguration (see subsection 5.4.1 and 6.17.1). Furthermore a smaller RB can be assigned in case of overload estimations done by the RNC (subsection 6.5). Furthermore data rates assigned at various state transitions can also be capped thanks to feature 34227.3 enabled via RadioAccessService. isOamCappingOfDataAllowd.

UMTS Operational Network Engineering

(For Internal Use Only)

Page 102 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Another difference when describing the PS data user perceived QoS is that a drop of the RAB and RRC connection does not (necessarily) mean that the PDP Context is removed from the GGSN or the FTP session drops. After the reestablishment of the RRC connection or the new establishment of the RAB, the FTP session can be resumed in case the session has not timed out. For the user the drop of the RRC and RAB is visible by stalling of the FTP transfer and low throughput rates. In case of real time applications like video streaming or web radio the drop will be noticed by the user if the buffer of the application is emptied and no new data is received. It might be that the application will re-start with codecs requiring lower bandwidth to fill the internal buffer again. On the PPP link of the PS data session the TCP/IP header and data can be compressed resulting in a throughput increase. For most Microsoft operating systems, compression is an available option in the PPP settings of the dial-up networking. In addition PDCP layer is providing header compression for e.g. TCP, UDP, RTP and IP header [26]. Simple FTP-download tests of files with the size of 1MB in the UMTS networks has shown that the throughput for zipped binary files is around 25% less compared with the ASCII files. 7.2.3.2. Failure symptoms, identification and fixes for improvement UE state (Cell_DCH with HSPA, Cell_DCH, Cell_FACH or URA_PCH) Chosen RB rate (in case of R99 Cell_DCH) Reported failures of the transport network (subsection 6.13) Problems detected on the RLC layer e.g. RLC retransmission or RLC resets (subsection 6.14) Reported BLER in UL and/or DL (subsection 7.1) TCP configuration like TCP window size or MSS (see subsection 6.14.1) Retransmissions on TCP layer PPP/PDCP compression used/not-used. Usage of zipped files/unzipped ASCII files

For analysing low PS data performance the following has to be considered:

The analysis should follow a top-down-approach: First the end-to-end data performance should be investigated Then delay measurements should be done indicating the source of the performance degradation (e.g. delay due to non-optimal RLC queue, retransmission on RLC etc.)

One example of an (graphical) analysis is shown in Figure 38 below. The throughput of a FTP transfer is measured by Wireshark [19] and visualised by tcptrace [20] is low. The root cause for the non-optimal performance is Congestion Control:

UMTS Operational Network Engineering

(For Internal Use Only)

Page 103 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Figure 38: FTP performance degradation caused by Congestion Control The FTP throughput is the gradient of the curve; in addition TCP retransmission caused by SDU discards on RLC are shown in the right part of the picture (see also subsection 6.14.1). It is possible to cross-correlate the UE traces with Wireshark traces recorded at the FTP server and also with RF data like Ec/No or Active Set Update messages recorded by the UE logging tools. In that way FTP performance degradations can be linked to handover problems, bad radio conditions in terms of Ec/No or neighbour definition problems. When the traces are recorded by different mechanisms, it would be necessary to correlate the PC clocks by using time synchronisation. Otherwise tools like Actix or RFO can do event-based cross correlation. Another example for an end-to-end analysis is shown in Figure 39 below; the picture is visualising the delay of an ICMP ping between Internet server and PC client for UL and DL separately. The trace was recorded with Wireshark [19]. Furthermore by tracing on the Iub, Iu and Gn interface it is possible to make similar delay plots for the particular interfaces. This will unveil where the high delay peaks are coming from and will help further the investigation.

UMTS Operational Network Engineering

(For Internal Use Only)

Page 104 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Figure 39: end-to-end delay of an ICMP ping For the same measurement the delay on the Gn interface were also measured as shown in Figure 40 below. As expected the delay is very small and dont have a big impact on the overall delay. This trace was recorded using a Tektronix K12 protocol tracer.

Figure 40: delay measured on the Gn interface

UMTS Operational Network Engineering

(For Internal Use Only)

Page 105 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Table 78 below is listing the identification triggers in network interface traces:

Problem
TCP reset TCP retransmission TCP SACKs

Trace
TCP TCP TCP

Trigger
Number of occurrences if the REST flag of the TCP options is set to TRUE. Statistic counted per TCP session Number of occurrences of TCP retransmissions. Statistic counted per TCP session Number of SACK. Statistic counted per TCP session

Table 78: Identification of QoS issues for data service

Table 79 below is listing the data QoS for identifying non-optimal performance:

KPI
PDP context activation failure [%] PDP context activation time [s] PDP context cut off rate [%] FTP cut off rate [%] FTP throughput [kbit/s] Ping delay [s] HTTP failures [%] RB Assignment Success Rate [%]

Table 79: QoS of data services KPIs 7.2.4. QoS VT service For VT calls the QoS consists of voice and video quality. One Tool that can provide the quality assessment of the video samples, as a MOS value, is ALUs LVAT. Although there is an ITU standard that defines the framework of video quality measurement [32], it does not layout the algorithm and calibration of the MOS and hence that remains vendor propriatry. For voice QoS parameter the metric of subsection 7.2.2 is used. Table 80 below is listing the KPIs to retrieve the other QoS parameters for VT:

KPI
Call completion success rate VT [%] Block call rate VT [%] Dropped calls VT [%] Call setup success rate VT [%]

Table 80: QoS of VT services KPIs

UMTS Operational Network Engineering

(For Internal Use Only)

Page 106 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Appendix
A. Measurement definition
A.1. Measurement definition voice For voice services the UMTS UE in the drive test van should call an ISDN line in the PLMN because otherwise it is hard to distinguish if the first or the second mobile is responsible for observed failures or also for voice quality degradations. This will help the RF planner to analyse the failure and propose additional network changes. One suggested voice test call sequence for the UMTS UE in the drive test van can be as follows: Network attach Mobile Originating Call (MOC), duration 2 minutes, alternating speech sample from the UE to the PLMN and vice versa. Network detach and pause of around 10 seconds Network attach Mobile Terminating Call (MTC), duration 2 minutes, alternating speech sample from UE to the PLMN and vice versa. Network detach and pause of around 10 seconds

The drive test kit should be capable of generating this measurement sequence automatically. In parallel the RF conditions of the UE and the neighbouring cells should be recorded using the drive test tool along with a 3G and 2G scanner for parallel verification. A.2. Measurement definition data When doing KPI performance verification of data services the FTP server should be directly connected to the GGSN to avoid any latency and delay caused by the Internet. For security reasons a special test APN should be used. The FTP throughput should be measured in motion and in addition also stationary in case that there are some Hot Spots inside the UMTS cluster e.g. railway stations, big hotels or airports. It is recommended to do testing via scripts; the advantage being the repeatability leading to ease of comparison and analysis. Data scripts are supported by most of the drive test tools, but can also be made with tools like 20 cygwin providing a full Linux command shell environment [24] . The data test call sequence should be as follows: Network attach and PDP context activation FTP download of three times 5 MB file, 5 seconds pause in between Pause of 20 seconds FTP download of three times 5 MB file, 5 seconds pause in between

20

The original DOS FTP client should be used instead the FTP client from cygwin (/usr/bin/ftp). This can be achieved by defining a variable called FTP_CMD = c:\winnt\system32\ftp.exe in the scripts. UMTS Operational Network Engineering (For Internal Use Only) Page 107 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Pause of 20 seconds FTP upload of three times 2 MB file, 5 seconds pause in between Network detach, PDP context deactivation and pause of around 10 seconds

For troubleshooting purposes it might be necessary to record the TCP/IP protocol analyser as Wireshark on both the UE and the FTP server side. In parallel the RF conditions should be recorded. For measuring the maximum possible throughput on a radio link UDP shall be used because TCP retransmission might give an incorrect picture of the bandwidth capability. The TCP configuration of the client PC and the server should be comparable with the settings most common used by normal UMTS subscribers and in the Internet. TCP window size of the sending entity should be large enough so the RLC queue in the RNC is not going into underrun. Table 81 below is listing the default TCP/IP parameter that should be used during the testing:

Entity
Client Server

Feature
SACK TCP window size PDCP compression PPP compression Starting MSS ICMP packet size MSS

Setting
Set to TRUE 64 kbyte

Short description
SACK allows the receiver to inform the sender about all segments that are successfully received The TCP window is the amount of outstanding data a sender can send before it gets an acknowledgment for the receiving entity When doing root cause analysis the feature should be disabled When doing root cause analysis the feature should be disabled The amount of TCP/IP packets sent by the sending entity at the beginning. Further packets will be send after reception of the first TCP ACK To measure the ICMP RTT an IP packet should be sent with the size of 40 byte (8 byte header plus 32 byte payload) The MSS should be 1460 byte resulting in a MTU of 1500 byte (= MSS + 20 byte TCP header + 20 byte IP header). The actual TCP/IP packet size used might be smaller if Internet router is segmenting the packets

Client/server Client/server Server

Disable Disable 4 packets

Client

40 byte

Client/server

1460 byte

Table 81: Default TCP/IP parameter settings used for testing The TCP/IP settings can be verified using Wireshark. The settings can be set for Windows PCs in the registry or with help of shareware tools like [25]. For UNIX and Linux operating systems the settings can be set in the corresponding configuration files. In case ciphering on RLC/MAC and data compression on PPP/PDCP are not used, special prepared ASCII files shall be used. This will ease the identification of each single packet in Wireshark, Iub or Iu traces to detect retransmission on TCP or RLC. Note that on Iu, Gn and Gi there is no compression and ciphering used so using the particular tracing equipment can identify the ASCII payload.

UMTS Operational Network Engineering

(For Internal Use Only)

Page 108 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

The special ASCII files should contain only one (!) line and as an example the following sequence: umts000000000umts000000001umts000000002umts000000003umts0000000 04umts000000005umts000000006 In case PPP data compression is on, zipped data shall be used to avoid irregular throughput measurements. Finally care should be taken that no other application on the PC are generating any unnecessary network traffic like keep alive signals. Figure 41 below is showing a snapshot of the Wireshark protocol analyser:

Figure 41: Wireshark protocol analyser

UMTS Operational Network Engineering

(For Internal Use Only)

Page 109 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

A.3. Measurement definition VT For VT one mobile should be located in the drive test van, the other mobile should be stationary located close to a UMTS site outside the UMTS cluster under test; this will minimise possible failure causes for this second UE and help the RF planner at the root cause analysis. The measurement sequence should be the same as defined for voice calls except that a network attach/detach is not necessary because this is service independent. So the full measurement sequence for the VT should be as follows: Mobile Originating Call (MOC), duration 2 minutes, alternating speech sample from UE 1 to UE 2 and vice versa. Pause of around 10 seconds Mobile Terminating Call (MTC), duration 2 minutes, alternating speech sample from UE 1 to UE 2 and vice versa Pause of around 10 seconds.

B. Time synchronisation of measurement traces


When collecting traces from different interfaces it might be necessary to ensure rd time synchronisation to enable a 3 party software like Actix to do the crosscorrelation. There are many possibilities to synchronise clocks of the particular measurement PC like NTP, GPS or also using a radio clock available in some European countries. Under no circumstances NTP should be used via an UMTS link because NTP is not designed for wireless network showing a high variance on the lower protocol layer like RLC. One software that can be used for time synchronisation is Tardis2000.[21] It can be configured as a NTP server and NTP client or using GPS. Furthermore it is possible to configure the Tardis2000 NTP client that it adjusts its internal clock within a predefined time frame. It has to be verified if the application running on the PC has to be restarted in order to retrieve the updated time. Figure 42 below is showing the measurement setup for analysing PS data services when doing drive testing in a van, Figure 43 for doing VT testing in a lab.

UMTS Operational Network Engineering

(For Internal Use Only)

Page 110 of 110

Document name:

UMTS RF Troubleshooting Guideline UA6.0


Rev: 1.02 Status: Approved-STANDARD

Date:

2009-26-06

Figure 42: Measurement setup for PS data analysis in a van

Uu (cabled)

Stationary voice/VT evaluation drive test equipment

2nd mobile in shadowing box Uu (cabled)

Iub

Iu

Mobile voice evaluation drive test equipment

Fading simulator

NodeB

RNC

CN

UMTS protocol analyser

Local NTP server

Figure 43: Measurement setup for VT testing in the lab

UMTS Operational Network Engineering

(For Internal Use Only)

Page 111 of 110

S-ar putea să vă placă și