Documente Academic
Documente Profesional
Documente Cultură
uk
SPECIFIC FITTING INSTRUCTIONS Mercedes C Class Estate 2008on our ref H0473
Load cover cassette REMOVED (cassette removed from the vehicle). You cannot replace it with the liner in place.
(Should you wish to leave the cassette in place: order the option: Load cover left IN )
Packing requirements BOOTLINER Minimum of 12 self-adhesive loop Velcro tabs 2 x ref: 104 ( self-adhesive loop velcro) 2 x ref: 121 (plastic + loop velcro) 2 x longer versions of ref: 121 (1@195mm + 1@250mm long) 2 x Fabric / Hook / Loop velcro tabs REAR DOOR COVER Minimum of 26 self-adhesive loop Velcro tabs
Photo A
PREPARATION
Photo A Remove the load cover cassette: Unlock the rear seats and fold flat. Open the passenger doors. From the offside, give the end of the cassette a hard push in the direction of the nearside door, to slide it off the 60% seat.
Photo B
Photo C
Photo D
Photo E
FITTING
Unfold the Hatchbag and place in the vehicle so that the base fits snugly in position. The panel with the Hatchbag label sits against the back of the rear seat. Photos B + C + D Please note these are non-specific to your car Locate the two hook velcro strips on the reverse side of the liner at the tailgate end. Photo B: Attach the two Fabric / Hook / Loop velcro tabs to the floors inner plastic molding. Use the self-adhesive loop velcro pads (supplied separately) Photo D: The tabs will protrude out of the floor panel when its replaced allowing the liner to be Velcro closed to them. Self-adhesive the 2 additional welds to the plastic Photo E Please note this is non-specific to your car Push the two foam tabs down into the void between the rear seat and the boot floor. Re-lock the rear seats. Feed the velcro straps around each corresponding headrest strap and close back upon themselves.
Photo G
Place the side panels snuggly into place. Photo G + H + I Open the 2 storage access panels. From the Start point slide the plastic part of the 2 large clips ref. 121 behind the carpeted panel, so that the loop velcro section hangs over the front face of the panel. See Photo H Photo I. At the tailgates end: Hold a small clip ref 121 behind the side panel. Feed the velcro part of the clip from the inside, out through the gap of the carpeted panel and the rubber seal. The plastic section will remain trapped behind the panel. Photo J Pass the large elastic loop over the top of the door and slide them down. Pass the small elastic loop over the door catch. Photo K Attach the velcro tabs 104 to the reverse side of the access panels, in line with the hook velcro welds on the wrong side of the liner. The section of velcro without adhesive will protrude out of the access panel. The liner will velcro close to these tabs. Photo L Attach the sides to all the tabs Replace the cassette and relock the rear seats. Fasten the front panel.
START HERE
Photo H
Photo I
Photo J
Photo K
Photo L
Optional extras
TAILGATE COVER
Please note this is non-specific to your car Use the self-adhesive loop velcro tabs to attach the cover to the plastic trim.
BUMPER FLAP
Please note this is non-specific to your car Fit Bootliner Attach the Bumper Flap to the Velcro strip that has been manufactured into the base of the boot liner. The Bumper Flap either folds into the vehicle OR can be detached and stored elsewhere when you close the tailgate. Please note that the edges of the fabric are not bound so that any mud, dirt or water can run off.