Documente Academic
Documente Profesional
Documente Cultură
Forew ord
List of Amendments
(Where D = diameter of the mandrel and T = thickness of test piece) Heat treatment: The castings shall be normally supplied in the annealed or normalised condition to obtain the desired properties. The normalised castings may be tempered, at the discretion of the Inspecting Authority.
Ibr Forms
Home
Chromium Molybdenum steel castings : Chemical composition (%) Gr. A Carbon Silicon Manganese Chromium Molybdenum Nickel* Copper* Sulphur Phosphorus Incidental elements* Mechanical Properties: Gr. A Minimum Tensile strength kg/mm Minimum yield point kg/mm % Elongation on gauge length=5.65 A Minimum Charphy Impact Values kg/mm 49 28 17 min. 4 Gr. B 49 28 17 min. 4
1/2
Search
Gr. B 0.18 max. 0.60 max. 0.18 max. 0.18 max. 0.18 max. 0.18 max. 0.18 max. 0.18 max. 0.18 max.
Help
0.20 max. 0.60 max. 0.20 max. 0.20 max. 0.20 max. 0.20 max. 0.20 max. 0.20 max. 0.20 max.
Contact Us
dipp.nic.in/boiler_rules_updated/reg282a-1.htm
1/31/13
Bend test
120 on D=3t
90 on D=3t
(where t = thickness of the test piece; D = diameter of the mandrel). Heat Treatment: The castings shall be supplied in the annealed or normalised condition to obtain the desired properties. If normalised, the castings shall be subsequently tempered at a temperature not exceeding 650C in the case of Gr.A and 690C in the case of Gr. B. The tempering temperature may be varied by the Inspecting Authority to suit the steel being tempered. Note:- Alloy steels other than those specified above may be accepted at the discretion of the Inspection Authority. Next >>>
Message from Chairman of Central Boilers Board About Central Boiler Board History of Indian Boiler Regulations
Forew ord Contents Chapter Wise Contents Regulation Wise List of Amendments Indian Boilers Act 1923 Ibr Forms Home Search Help Contact Us
dipp.nic.in/boiler_rules_updated/reg282a-1.htm
2/2