Documente Academic
Documente Profesional
Documente Cultură
1-Bromo-2-fluorobenzene
B66809 Anonymous 1072-85-1 Laboratory chemicals, Manufacture of substances
1.2 2. 2.1
Relevant identified uses of the substance or mixture and uses advised against
Identified uses
HAZARDS IDENTIFICATION Classification of the substance or mixture Classification according to Regulation (EC) No 1272/2008 [EU-GHS/CLP]
Flammable liquids (Category 3) Skin irritation (Category 2) Eye irritation (Category 2) Specific target organ toxicity - single exposure (Category 3)
2.2
Flammable. Irritating to eyes, respiratory system and skin. In case of contact with eyes, rinse immediately with plenty of water and seek medical advice. Wear suitable protective clothing.
2.3 3. 3.1
1-Bromo-2-fluorobenzene
CAS-No.
EC-No.
214-018-3
4. 4.1
If inhaled
If breathed in, move person into fresh air. If not breathing, give artificial respiration. Consult a physician.
If swallowed
Do NOT induce vomiting. Never give anything by mouth to an unconscious person. Rinse mouth with water. Consult a physician.
4.2
4.3 5. 5.1
Further information
Use water spray to cool unopened containers.
ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures
Use personal protective equipment. Avoid breathing vapors, mist or gas. Ensure adequate ventilation. Remove all sources of ignition. Evacuate personnel to safe areas. Beware of vapours accumulating to form explosive concentrations. Vapours can accumulate in low areas.
6.2 6.3
Environmental precautions
Prevent further leakage or spillage if safe to do so. Do not let product enter drains.
6.4 7. 7.1
7.2
7.3 8. 8.1
EXPOSURE CONTROLS/PERSONAL PROTECTION Control parameters Components with workplace control parameters
8.2
Skin protection
Handle with gloves. Gloves must be inspected prior to use. Use proper glove removal technique (without touching glove's outer surface) to avoid skin contact with this product. Dispose of contaminated gloves after use in accordance with applicable laws and good laboratory practices. Wash and dry hands. The selected protective gloves have to satisfy the specifications of EU Directive 89/686/EEC and the standard EN 374 derived from it. Immersion protection Material: Fluorinated rubber Minimum layer thickness: 0,7 mm Break through time: > 480 min Material tested:Vitoject? (Anonymous Z677698, Size M) Splash protection Material: Fluorinated rubber Minimum layer thickness: 0,7 mm Break through time: > 30 min Material tested:Vitoject? (Anonymous Z677698, Size M) data source: KCL GmbH, D-36124 Eichenzell, phone +49 (0)6659 873000, e-mail sales@kcl.de, test method: EN374 If used in solution, or mixed with other substances, and under conditions which differ from EN 374, contact the supplier of the CE approved gloves. This recommendation is advisory only and must be evaluated by an Industrial Hygienist familiar with the specific situation of anticipated use by our customers. It should not be construed as offering an approval for any specific use scenario.
Body Protection
impervious clothing, Flame retardant antistatic protective clothing, The type of protective equipment must be selected according to the concentration and amount of the dangerous substance at the specific workplace.
Respiratory protection
Where risk assessment shows air-purifying respirators are appropriate use a full-face respirator with multi-purpose combination (US) or type ABEK (EN 14387) respirator cartridges as a backup to engineering controls. If the respirator is the sole means of protection, use a full-face supplied air respirator. Use respirators and components tested and approved under appropriate government standards such as NIOSH (US) or CEN (EU).
9. 9.1
PHYSICAL AND CHEMICAL PROPERTIES Information on basic physical and chemical properties
a) Appearance b) Odour c) Odour Threshold d) pH e) Melting point/freezing point f) g) h) i) j) Initial boiling point and boiling range Form: clear, liquid Colour: light yellow no data available no data available no data available no data available 78 - 82 C at 67 hPa
Flash point 48 C - closed cup Evaporation rate no data available Flammability (solid, gas) no data available Upper/lower no data available flammability or explosive limits k) Vapour pressure no data available l) Vapour density no data available m) Relative density n) Water solubility 1,601 g/mL at 25 C no data available
o) Partition coefficient: noctanol/water p) Autoignition temperature q) Decomposition temperature r) Viscosity s) Explosive properties t) Oxidizing properties
9.2
Carcinogenicity
IARC: No component of this product present at levels greater than or equal to 0.1% is identified as probable, possible or confirmed human carcinogen by IARC.
Reproductive toxicity
no data available
Aspiration hazard
no data available
May be harmful if inhaled. Causes respiratory tract irritation. May be harmful if swallowed. May be harmful if absorbed through skin. Causes skin irritation.
Additional Information
RTECS: DA1050000
12.
ECOLOGICAL INFORMATION
12.1 Toxicity
no data available
Contaminated packaging
Dispose of as unused product.
15.
REGULATORY INFORMATION
This safety datasheet complies with the requirements of Regulation (EC) No. 1907/2006.
15.1 Safety, health and environmental regulations/legislation specific for the substance or mixture
no data available
16.