Sunteți pe pagina 1din 40

All rights reserved Alcatel-Lucent 2011 Passing on and copying of this document, use and communication of its contents

s not permitted without written authorization from Alcatel-Lucent

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 1

Section 1. Product Overview Module 1. 1350 OMS Overview Module 2. 1350 OMS WDM Overview Section 2. Graphical Interface Module 1. Web Portal Module 2. Multi Service GUI Module 3. 1350 OMS MAP version 2.0 Section 3. Network Management Module 1. Network Element Management Section 4. Link, Cross and Inconsistent Connections Module 1. Link Connections Module 2. Cross Connections Module 3. Inconsistent Connections Section 5. WDM Connection Management Module 1. Physical Connections Module 2. Path and Trail Connections Module 3. Optical Transport Services Section 6. Wavelength Tracker (WLT) Module 1. WLT Concepts Section 7. Commissioning and Power Balancing (CPB) Module 1. CPB Concepts Section 8. Fault Management Module 1. 1350 OMS Alarm Management Module 2. WDM Alarm Management Section 9. Performance Monitoring (PM) Module 1. PM Management

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 5

Welcome to 1350 OMS WDM R 9.5 Operation

Upon completion of this course, you should be able to:

1. 2. 3. 4. 5. 6. 7. 8. 9.

Comprehend the 1350 OMS WDM application topology Navigate the 1350 OMS WDM Graphical User Interface Manipulate WDM physical and logical connections Identify Link, Cross, and Inconsistent connection concepts Determine Physical, Path and Trail requirements Determine Transport Services requirements Identify Wavelength Tracker concepts Perform Commissioning and Power Balancing Perform Fault Management

10. Determine Performance Monitoring requirements

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 6

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 117

This section presents an introduction to the 1350 OMS WDM functionality and its relationship to the Element Management Layer (EML). Futher discussion of the functionality depicted on these slides will be discussed in more detail through out the course.

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 119

When a Q3 interface is used, the NE needs to be configured with a NSAP OSI address. When a SNMP or TL1 interface is used, the NE needs to be configured with an IP address.

Note
This module will discuss the creation of an 1830PSS (4G TL1) NE. The 1350 OMS EML R 9.5 Operation course (TOS63017) provides creation procedures for the different families of equipment based on their management interfaces (Q3, TL1, SNMP, Q3 CNA etc.).

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 120

The SID is known as the Target Identifier (TID) in 1830 PSS. The SID/TID is composed of a string of up to 32 (for ETSI) and 20 (for ANSI) non case-sensitive alphanumeric characters, including the hyphen (-) character or a quoted string up to 32 (for ETSI) and 20 (for ANSI), including any special characters. In the non-quoted string, the SID/TID must start with a letter and end with an alphanumeric character. Consecutive hyphens (-) are not allowed. The number of hyphens used in the string must not be greater than four. The OSPF routing for the OAMP port should be set to redistribute if the routing table of the Gateway NE is not to be advertised externally.

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 121

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 122

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 123

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 124

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 125

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 126

OSPF Areas is for an OSPF configuration where automatic routing is required. OSPF is a form of dynamic routing which uses a routing table to determine the best route path. Static routes are routes through a data network described by fixed paths (statically).

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 127

This slide and the next two slides focus on the creation and addressing of an 1830 PSS without security.

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 128

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Section 3 Page 131 1 Page 131 Module

Check the correct configuration and process status with the System Administrator.

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 132

If the operator doesnt select the Supervision Area and the EML Domain, in the above procedure, EML will automatically chose these two parameters. The system takes account of each available EMLIMSNA and tries to make their load homogeneous. The Directory Field refers to the Physical Network Management GUI server (PNMIM) of the EML instance in which the NE must be created. Normally there is only one EML instance installed in 1350 OMS and the field is automatically completed with the proper value. If more than one EML instance is available, the operator must select the desired PNM GUI Server from the drop-down list.

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 133

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 134

The GNE Flag enables a TL1 command line interface operator to act on a Remote NE (RNE) through a Telnet access to he Gateway NE (GNE). This feature is applicable only to the ANSI environment. If the FTAM parameter is set to Use GW, the NE under creation can be used as a repository to download the SW to its Remote NE. This feature will be available in future releases. The TID (Target Identifier) i.e. the NE identifier used in the messages exchanged between the NE and the EML, must be equal to the System IDentifier (SID) set into the NE.

SID (or TID) is a string of up to 32 (for ETSI) or 20 (for ANSI) non case-sensitive alphanumeric characters, including the hyphen (-) character, or a quoted string of up to 32 for ETSI (20 for ANSI) characters, including any special character. If it is a non-quoted string, SID (or TID) must start with a letter and end with an alphanumeric character. Consecutive hyphens (-) shall not be allowed. Number of hyphens shall not be greater than four.

The NE address can be modified only if the NE is not supervised (i.e. in the "declared" state). The SNMP address setting is not required.

Note
For the creation of 1830 PSS NEs, the GNE/RNE flag setting is not critical and should be left in the default state. 1830PSS GNE/RNE roles are defined at the IP DCN level and transparent to 1350 OMS. 1350 OMS treats all the PSS NEs as GNEs. However, the GNE/RNE flag is critical for other NE types thought. For example correct settings are mandatory for TL1 NEs.

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 135

Prior to starting supervision, check to see if the NE is reachable.


Ping (Packet Internet Grouper) tests the DCN parameters (address, DCC, LAN interfaces etc.) Supervision tests the supervision rights

The Ping NE function of the Telecommunication Network Management OS enables the administrator to test the communication link with an NE. The Ping NE function is managed by the Middleware Interface (MW-INT) application, which is the platform on which the 1350 OMS is built.

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 136

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 137

Supervising NEs is an essential aspect of the network management. It enables the gathering of information concerning the behavior of the NE with respect to its functional state. The supervision of an NE consists in establishing a communication that allows the user to perform EML operations such as configuration and alarm management. The NE address must be declared before starting the supervision of this NE. After supervision is started, the Supervision State attribute changes from DECLARED to SUPERVISED.

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 138

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 139

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 140

All the procedures on networks and sub-networks described in the present Module can be issued as well from the MS-GUI networks and sub-networks lists. To open the network list: Search Map Networks (only ROOT is shown). From the ROOT object in the list it is possible to create sub-networks (Actions Create Sub-Network) or list the first-level sub-networks (Search Sub-Networks). From the Sub-Networks in the Sub-Network lists, it is then possible:

To search the contained Sub-Networks or other Physical or SDH (OTN) objects. To create a new contained sub-network. To modify (or even delete) the selected sub-network

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 141

ROOT is always configured by default as the root network under which all managed sub-networks must be created, based on the desired hierarchy. ROOT cannot directly contain nodes.

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 142

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 143

If the creation is successful, the header window of the Create Sub-network panel turns green for success; red indicates a failure.

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 144

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 145

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 146

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 147

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 148

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 149

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 150

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Section 3 Page 151 1 Page 151 Module

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 152

The operator is optionally allowed to enter a filtering criteria defined in terms of a list IP Address/Mask pairs. Only the filtered list of NE belonging to the subnets defined by any of the masks will be given back to the GUI. In case of the operator is not filling in any filtering criteria, the discovery scope will consist of the overall subset of 1830PSS network elements that are reachable from the NE where the action is triggered.

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 153

The discovery process can last several minutes, depending on the number of NEs to be discovered. Location Name and Supervision area are populated based on the gateway NE by which the process has been started. In the case of an Abort request, the NEs discovered up to the time the discovery was interrupted can be created by clicking on Next.

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 154

The address and User ID and password of the auto discovered NEs are automatically set during the discovery procedure.

Address is set based on the info sent by the discovered NEs. User ID and password are the same as the ones of the Gateway NE.

Eventually change the location name, check NE IP address, User ID and password, and start supervision.

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 155

All Rights Reserved Alcatel-Lucent 2012 1350 OMS WDM Operation and Maintenance Page 156

S-ar putea să vă placă și