Documente Academic
Documente Profesional
Documente Cultură
Circuit Board Function Tuner, AU_9V, 9V, REG5V, Panel 5V. Mute Circuit. Power AMP. Graphic equalizer. Audio processor. Main CPU. Color decoder, 3D Comb filters. DRC and Scan converter. 18/25/33V regulators. Panel driver. AC input from power cord, fuse relay, and line filter. Sends voltage to the G1 and G2 boards. STBY 5V. Surge and protection circuits Required Adjustments when board is changed. Part Number
AU
None
A1052775A
BP
Swap IC1004
A1052773A
F G1
None None Input an all WHITE video signal to the video input and adjust VA (RV6825/ TP6102), VSCAN (RV6854/ TP6103), VS (RV6504/ TP6108), VSET (RV6847/ TP6105), VE (RV6835/ TP6107) to the voltages specified on the rear of the plasma panel to a tolerance of +/- 0.3V. Input signal is an NTSC 3.38MHz 100% white signal for these adjustments. None None None None None
A1052771A A1068014A
G2 H1 H2 H3 P UPU
Main power supply. Produces the VS, VC, VA, VE, VSCAN, VSET voltages. Contains Fan Driver. Input Select, CH +/-, VOL +/buttons. P-Save, Power, and StandBY LED's. SIRCS Front input terminal. HDMI receiver. Composite/Components/ SVideo Inputs, AV Switch
KE42M1
Circuit Board
Panel Boards
Function Generates and outputs the address drive output signal and the XY drive signal by processing the video signals. This board buffers the address drive output signal and feeds it to the address driver IC. NOTE: There is an LED that blinks ON/OFF at a one second interval. If it is blinking there is a good chance the logic bd is working. If it is always OFF there is a voltage missing. If it is always ON there is missing data. Generates drive signals in sync with the timing from the Logic Main board and supplies the X electrode of the panel with the drive signal. Generates drive signals in sync with the timing from the Logic Main board and supplies the Y electrode of the panel with the drive signal. Contains 8 scan drivers. Supplies the Y-Terminal with a scan waveform. Contains 8 scan drivers. Supplies the Y-Terminal with a scan waveform. Transmits data and control signals using COF (Chip on Flexible). Required Adjustments when board is changed. Part Number
Logic Main
When you receive the new logic board note the version number of the IC's located in the following two connectors: CN2004 (ex: ver 0908) and CN2003 (ex: ver 040422). If the versions of these IC's are the same on the new board there is no need to change them. If one or both are different swap the different IC chip(s). You want the new logic board to have the same version IC's as the one that is being removed. 178906411
X-Main
None
178906211
Y-Main
Note position of the arrows on the potentiometers. On the new board place the arrow in the exact same position as the board being removed.
178906311
Y-Buffer (upper)
None
178906511
Y-Buffer (lower)
None
178906611
Logic E Buffer
None
178906711
Logic F Buffer
Transmits data and control signals using COF (Chip on Flexible). Transmits data and control signals using COF (Chip on Flexible). Display screen.
None
178906811
None None
178906911 A1078833A
Number
1 2 3 4 5 6 7 8
Board
Logic-Main X-Main Y-Main Y-Buffer (upper) Y-Buffer (lower) Logic E Buffer Logic F Buffer Logic G Buffer