Documente Academic
Documente Profesional
Documente Cultură
- electrical -
CONTENTS
1 2 3 4 Replaceable Components ............................................................. 3 Component Placing ........................................................................ 6 Repair Actions ................................................................................ 7
3.1 Shield Can Fence Modifications .......................................................... 7 3.2 Additional Repair Info ........................................................................... 8
For general information about electrical repair related issues, refer to 1220-1336: Generic Repair Manual - electrical
1230-2332 Rev 2
2(12)
Replaceable Components
1230-2332 Rev 2
3(12)
Position
B3001 B3200 B4600 C3108 C3128 C3420 L3200 L3201 L3300 L3301 L3302 L3401 L3405 L3406 L3501 L3502 L3503 L3504 L4604 L4605 N1001 N1500 N3100 N3103 N3104 N3300 N3700 N3701 N3702 N4100 N4101 N4600 R3137 R3138 V3100 V3101 V3103 V3106 V3402 V4600 V4602 X1500 X1600 X1603 X1604 X1605 X1606 X1607 X1608 X3101 X3401 X3402 X3403
Component
Crystal 32.768 kHz Vibrator Bar Sanyo SMD Microphone Capacitor 70.0 mF 3.3 V Capacitor Ceramic 1,0 uF +/-10% 25,0 V K Capacitor Ceramic 4.7 uF 10% 10.0 V 100nH 5% 0603 0.22A 100nH 5% 0603 0.22A Ind WW 2,2 uH +/-20% K3012 Ind WW 2,2 uH +/-20% K3012 Ind WW 2,2 uH +/-20% K3012 Ind WW 4.7 uH K3012 Filter 100.0 MHz Filter 100.0 MHz Filter 100.0 MHz Filter 100.0 MHz Filter 100.0 MHz Filter 100.0 MHz Ind Chip 22.0 uH 20% 1608(0603) Ind Chip 22.0 uH 20% 1608(0603) IC Vreg PLP1010-4 IC Amp 3.3(L)x2.1(W)x1.1(H) IC Linear IC Lin TDFN-8 IC Lin CSP-9 ASIC PM IC Linear Power Inductor IC Linear Power Inductor IC Voltage Regulator IC 3-axis Electronic Compass ASIC Accelerometer IC Amp Resistor 0, Ohm +/-50m 63 mW K0603 Resistor 0, Ohm +/-50m 63 mW K0603 Trans PNP CHIPFET-8 Trans P-ch FET WDFN6 Diode Small-Signal 1,2 V Diode Schottky Barrier Diode Dual ESD protection diode 6V ZenerDiode, 5.6V, Pb-free Conn Coax Plug 6p RF-probe contact Conn Coax Plug 6p RF-probe contact Conn Leaf Spring Conn Leaf Spring Conn Leaf Spring Conn Leaf Spring Conn Leaf Spring Conn Leaf Spring Conn USB micro B 0p front dip BtB Connector 16p BtB Connector 26p BtB Connector 16p
1230-2332 Rev 2
4(12)
Position
X3404 X3405 X3406 X3407 X3500 Z1500 Z1501
Component
Conn BtB 30 pin Connector Conn Leaf Spring Antenna conn Conn Leaf Spring Antenna conn Conn BtB 30 pin Filter SAW 1,57 GHz Filter Dpx 1.575 GHz TX 2.45 GHz RX
1230-2332 Rev 2
5(12)
Component Placing
To access the Component Placing document, double-click the icon below. Applicable for on-screen viewing only icon not shown on hard-copies.
1230-2332 Rev 2
6(12)
3
3.1
Repair Actions
Shield Can Fence Modifications
Refer to the Tools Catalogue/Matrix for information about equipment required for PBA repair!
Refer to the pictures below of the primary and secondary sides for repairs that require the Shield Can Fence to be modified: the shield can lid has to be removed the red symbols show where the frame should be cut to enable rework after rework the height of the frame should not be affected it should not be visible that rework has been carried out when the lid has been mounted
Primary side
Secondary side
1230-2332 Rev 2
7(12)
Repair Actions
3.2
1
B3200
Protect system connector and two BtB connectors with capton tape!
2
C3128, R3137, R3138, N3104
Protect system connector and BtB connector with capton tape!
3
L3405, L3406
Protect BtB connector and Microphones with capton tape!
4
L3501, L3502, L3503, L3504
Protect BtB connector with capton tape!
1230-2332 Rev 2
8(12)
5
N3103, V3100, V3101, V3106
Protect battery connector with capton tape!
6
B4600, X1600
Protect BtB connector with capton tape!
7
X1604
Protect battery with capton tape!
8
X3101
Protect two BtB connectors with capton tape!
1230-2332 Rev 2
9(12)
9
X3401
Protect BtB connector with capton tape!
10
X3402
Protect microphone and connector with capton tape!
11
X3403
Protect BtB connector with capton tape!
12
X3404
Protect system connector and BtB connector with capton tape!
1230-2332 Rev 2
10(12)
13
X3405
Protect system connector and BtB connector with capton tape!
14
Z1500, Z1501
Protect connector with capton tape!
1230-2332 Rev 2
11(12)
4
Rev. 1 2
Revision History
Date 2010-Mar-11 2010-05-24 Changes / Comments Initial release Update B3200 parts description
1230-2332 Rev 2
12(12)