Documente Academic
Documente Profesional
Documente Cultură
General Description
The TS7900 series of fixed output negative voltage regulators are intended as complements to the popular TS7800 series device. These negative regulators are available in the same seven-voltage options as the TS7800 devices. In addition, one extra voltage option commonly employed in MECL systems is also available in the negative TS7900 Series. Available in fixed output voltage options from -5.0 to -24 volts, these regulators employ current limiting, thermal shutdown, and safe-area compensation--making them remarkably rugged under most operating conditions. With adequate heatsinking they can deliver output currents in excess of 1 ampere. This series is offered in 3-pin TO-220, ITO-220 package.
Features
Output current up to 1A No external components required Internal thermal overload protection Internal short-circuit current limiting Output transistor safe-area compensation Output voltage offered in 4% tolerance
Standard Application
Ordering Information
Part No.
TS79xxCZ TS79xxCI
Package
TO-220 ITO-220
A common ground is required between the input and the output voltages. The input voltage must remain typically 2.0V above the output voltage even during the low point on the Input ripple voltage. XX = these two digits of the type number indicate voltage. * = Cin is required if regulator is located an appreciable distance from power supply filter. ** = Co is not needed for stability; however, it does improve transient response.
V V
C/W
C C
TS7900 series
1-7
2003/12 rev. A
Parameter
Output voltage
Symbol
o
Test Conditions
Tj=25 C -7.5V@Vin@ -20V, 10mA@Iout@1A, PD@15W
Min
-4.80 -4.75
Typ
-5 -5
Max
-5.20 -5.25
Unit
V
Vout
Line Regulation
REGline
Tj=25 C
-7.5V@Vin@-25V -8V@Vin@-12V
--------
3 1 15 5 4 --40 74 2 2.1 -1
mV
Load Regulation Quiescent Current Quiescent Current Change Output Noise Voltage Ripple Rejection Ratio Voltage Drop Peak Output Current Temperature Coefficient of Output Voltage
Tj=25 C
10mA@Iout@1A 250mA@Iout@750mA
o
Iout=0, Tj=25 C -7.5V@Vin@-25V 10mA@Iout@1A 10Hz@f@100KHz, Tj=25 C f=120Hz, -8V@Vin@-18V Iout=1.0A, Tj=25 C Tj=25 C Iout=10mA, 0 C @Tj@125 C
o o o o o
mA
-62 ----
Parameter
Output Voltage
Symbol
o
Test Conditions
Tj=25 C
Min
-5.75 -6.3
Typ
-6 -6
Max
-6.25 -6.3
Unit
V
Vout
Line Regulation
REGline
Tj=25 oC
-8.5V@Vin@-25V -9V@Vin@-13V
--------
mV
Load Regulation Quiescent Current Quiescent Current Change Output Noise Voltage Ripple Rejection Ratio Voltage Drop Peak Output Current Temperature Coefficient of Output Voltage z z
Tj=25 oC
10mA@Iout@1A 250mA@Iout@750mA
o
Iout=0, Tj=25 C -8.5V@Vin@-25V 10mA@Iout@1A 10Hz@f@100KHz, Tj=25 C f=120Hz, -9V@Vin@-19V Iout=1.0A, Tj=25 C Tj=25 C Iout=10mA, 0 C @Tj@125 C
o o o o o
mA
-60 ----
Pulse testing techniques are used to maintain the junction temperature as close to the ambient temperature as possible, and thermal effects must be taken into account separately. This specification applies only for DC power dissipation permitted by absolute maximum ratings.
TS7900 series
2-7
2003/12 rev. A
Parameter
Output Voltage
Symbol
o
Test Conditions
Tj=25 C -10.5V@Vin@-23V, 10mA@Iout@1A, PD@15W
Min
-7.69 -7.61
Typ
-8 -8
Max
-8.32 -8.40
Unit
V
Vout
Line Regulation
REGline
Tj=25 C
-10.5V@Vin@-25V -11V@Vin@-17V
--------
6 2 12 4 4 --52 72 2 2.1 -1
mV
Load Regulation Quiescent Current Quiescent Current Change Output Noise Voltage Ripple Rejection Ratio Voltage Drop Peak Output Current Temperature Coefficient of Output Voltage
Tj=25 C
10mA@Iout@1A 250mA@Iout@750mA
o
Iout=0, Tj=25 C -10.5V@Vin@-25V 10mA@Iout@1A 10Hz@f@100KHz, Tj=25 C f=120Hz, -11V@Vin@-21V Iout=1.0A, Tj=25 C Tj=25 C Iout=10mA, 0 C @Tj@125 C
o o o o o
mA
-56 ----
Parameter
Output Voltage
Symbol
o
Test Conditions
Tj=25 C
Min
-8.65 -8.57
Typ
-9 -9
Max
-9.36 -9.45
Unit
V
Vout
Line Regulation
REGline
Tj=25 oC
-11.5V@Vin@-26V -12V@Vin@-17V
--------
6 2 12 4 4 --58 71 2 2.1 -1
mV
Load Regulation Quiescent Current Quiescent Current Change Output Noise Voltage Ripple Rejection Ratio Voltage Drop Peak Output Current Temperature Coefficient of Output Voltage z z
Tj=25 oC
10mA@Iout@1A 250mA@Iout@750mA
o
Iout=0, Tj=25 C -11.5V@Vin@-26V 10mA@Iout@1A 10Hz@f@100KHz, Tj=25 C f=120Hz, -12V@Vin@-22V Iout=1.0A, Tj=25 C Tj=25 C Iout=10mA, 0 C @Tj@125 C
o o o o o
mA
-56 ----
Pulse testing techniques are used to maintain the junction temperature as close to the ambient temperature as possible, and thermal effects must be taken into account separately. This specification applies only for DC power dissipation permitted by absolute maximum ratings.
TS7900 series
3-7
2003/12 rev. A
Parameter
Output Voltage
Symbol
o
Test Conditions
Tj=25 C -14.5V@Vin@-27V, 10mA@Iout@1A, PD @15W
Min
-11.53 -11.42
Typ
-12 -12
Max
-12.48 -12.60
Unit
V
Vout
Line Regulation
REGline
Tj=25 C
-14.5V@Vin@-30V -15V@Vin@-19V
--------
10 3 12 4 4 --75 70 2 2.1 -1
mV
Load Regulation Quiescent Current Quiescent Current Change Output Noise Voltage Ripple Rejection Ratio Voltage Drop Peak Output Current Temperature Coefficient of Output Voltage
Tj=25 C
o
10mA@Iout@1A 250mA@Iout@750mA
Tj=25 C, Iout=0 -14.5V@Vin@-30V 10mA@Iout@1A 10Hz@f@100KHz, Tj=25 C f=120Hz, 15V@Vin@25V Iout=1.0A, Tj=25 C Tj=25 C Iout=10mA, 0 C @Tj@125 C
o o o o o
mA
-55 ----
Parameter
Output Voltage
Symbol
o
Test Conditions
Tj=25 C
Min
-14.42 -14.28
Typ
-15 -15
Max
-15.60 -15.75
Unit
V
Vout
Line Regulation
REGline
Tj=25 oC
-17.5V@Vin@-30V -18V@Vin@-22V
--------
12 3 12 4 4 --90 69 2 2.1 -1
mV
Load Regulation Quiescent Current Quiescent Current Change Output Noise Voltage Ripple Rejection Ratio Voltage Drop Peak Output Current Temperature Coefficient of Output Voltage z z
Tj=25 oC
o
10mA@Iout@1A 250mA@Iout@750mA
Tj=25 C, Iout=0 -17.5V@Vin@-30V 10mA@Iout@1A 10Hz@f@100KHz, Tj=25 C f=120Hz, -18V@Vin@-28V Iout=1.0A, Tj=25 C Tj=25 C Iout=10mA, 0 C @Tj@125 C
o o o o o
mA
-54 ----
Pulse testing techniques are used to maintain the junction temperature as close to the ambient temperature as possible, and thermal effects must be taken into account separately. This specification applies only for DC power dissipation permitted by absolute maximum ratings.
TS7900 series
4-7
2003/12 rev. A
Parameter
Output Voltage
Symbol
o
Test Conditions
Tj=25 C -21V@Vin@-33V, 10mA@Iout@1A, PD @15W
Min
-17.30 -17.14
Typ
-18 -18
Max
-18.72 -18.90
Unit
V
Vout
Line Regulation
REGline
Tj=25 C
-21V@Vin@-33V -22V@Vin@-26V
--------
15 5 12 4 4 --110 68 2 2.1 -1
mV
Load Regulation Quiescent Current Quiescent Current Change Output Noise Voltage Ripple Rejection Ratio Voltage Drop Peak Output Current Temperature Coefficient of Output Voltage
Tj=25 C
o
10mA@Iout@1A 250mA@Iout@750mA
Tj=25 C, Iout=0 -21V@Vin@-33V 10mA@Iout@1A 10Hz@f@100KHz, Tj=25 C f=120Hz, -21V@Vin@-31V Iout=1.0A, Tj=25 C Tj=25 C Iout=10mA, 0 C @Tj@125 C
o o o o o
mA
-53 ----
Parameter
Output Voltage
Symbol
o
Test Conditions
Tj=25 C
Min
-23.07 -22.85
Typ
-24 -24
Max
-24.96 -25.20
Unit
V
Vout
Line Regulation
REGline
Tj=25 oC
-27V@Vin@-38V -28V@Vin@-32V
--------
18 6 12 4 4 --170 65 2 2.1 -1
mV
Load Regulation Quiescent Current Quiescent Current Change Output Noise Voltage Ripple Rejection Ratio Voltage Drop Peak Output Current Temperature Coefficient of Output Voltage z z
Tj=25 oC
10mA@Iout@1A 250mA@Iout@750mA
o
Iout=0, Tj=25 C -27V@Vin@-38V 10mA@Iout@1A 10Hz@f@100KHz, Tj=25 C f=120Hz, -27V@Vin@-37V Iout=1.0A, Tj=25 C Tj=25 C Iout=10mA, 0 C @Tj@125 C
o o o o o
mA
-50 ----
Pulse testing techniques are used to maintain the junction temperature as close to the ambient temperature as possible, and thermal effects must be taken into account separately. This specification applies only for DC power dissipation permitted by absolute maximum ratings.
TS7900 series
5-7
2003/12 rev. A
TS7900 series
6-7
2003/12 rev. A
B
C
K L
DIM
TO-220 DIMENSION MILLIMETERS MIN MAX 10.000 3.240 2.440 0.381 2.345 4.690 12.700 8.382 14.224 3.556 0.508 27.700 2.032 0.255 5.842 10.500 4.440 2.940 6.350 1.106 2.715 5.430 14.732 9.017 16.510 4.826 1.397 29.620 2.921 0.610 6.858 INCHES MIN MAX 0.394 0.128 0.096 0.015 0.092 0.092 0.500 0.330 0.560 0.140 0.020 1.060 0.080 0.010 0.230 0.413 0.175 0.116 0.250 0.040 0.058 0.107 0.581 0.355 0.650 0.190 0.055 1.230 0.115 0.024 0.270
A B C D
J I
M
E F G H I J K L M N
D H F G E
O N
TS7900 series 7-7
O P
2003/12 rev. A