Documente Academic
Documente Profesional
Documente Cultură
Page 1/5
Reviewed on 23.07.2004
KAN BASE
Further information obtainable from: Product safety department Information in case of emergency: +49-8171-53-222
2 Composition/information on ingredients
Chemical characterization Description: Quarternary polyammonium compound Dangerous components: CAS: 12125-02-9 ammonium chloride Xn; R 22-36 10-30% EINECS: 235-186-4 Additional information: For the wording of the listed risk phrases refer to section 16.
3 Hazards identification
Hazard description: Not applicable. Information concerning particular hazards for human and environment: The product does not have to be labelled due to the calculation procedure of the "General Classification guideline for preparations of the EU" in the latest valid version. Classification system: The classification is according to the latest editions of the EU-lists, and extended by company and literature data.
4 First-aid measures
General information: Immediately remove any clothing soiled by the product. By continuous complaints consult a physician. After inhalation: Supply fresh air; consult doctor in case of complaints. After skin contact: Immediately wash with water and soap and rinse thoroughly. After eye contact: Rinse opened eye for several minutes under running water. After swallowing: Seek medical treatment. Do not induce vomiting. Never give anything by mouth to an unconscious person.
AUS
(Contd. on page 2)
DR
Page 2/5
Reviewed on 23.07.2004
KAN BASE
(Contd. of page 1)
5 Fire-fighting measures
Suitable extinguishing agents: CO2, powder or water spray. Fight larger fires with water spray or alcohol resistant foam. For safety reasons unsuitable extinguishing agents: Water with full jet Special hazards caused by the substance, its products of combustion or resulting gases: In case of fire, the following can be released: Nitrogen oxides (NOx) Carbon monoxide (CO) Hydrogen chloride (HCl) Carbon dioxide (CO2) Protective equipment: Wear self-contained respiratory protective device. Additional information Dispose of fire debris and contaminated fire fighting water in accordance with official regulations.
Storage: Requirements to be met by storerooms and receptacles: Use polyolefine receptacles. Information about storage in one common storage facility: Store away from oxidizing agents. Further information about storage conditions: Protect from frost. Recommended storage temperature: 5-30C Storage stability Storage period up to 6 months
(Contd. on page 3)
AUS
DR
Page 3/5
Reviewed on 23.07.2004
KAN BASE
(Contd. of page 2)
Due to missing tests no recommendation to the glove material can be given for the product/ the preparation/ the chemical mixture. Selection of the glove material on consideration of the penetration times, rates of diffusion and the degradation Material of gloves The selection of the suitable gloves does not only depend on the material, but also on further marks of quality and varies from manufacturer to manufacturer. As the product is a preparation of several substances, the resistance of the glove material can not be calculated in advance and has therefore to be checked prior to the application. Penetration time of glove material The exact break trough time has to be found out by the manufacturer of the protective gloves and has to be observed. For the permanent contact of a maximum of 15 minutes gloves made of the following materials are suitable: Butyl rubber, BR Nitrile rubber, NBR As protection from splashes gloves made of the following materials are suitable: Butyl rubber, BR Nitrile rubber, NBR Eye protection: Safety glasses Body protection: Protective work clothing
Change in condition Melting point/Melting range: Not determined Boiling point/Boiling range: 100C Flash point: Self-igniting: Not applicable. Product is not selfigniting 23 hPa
Solubility in / Miscibility with Fully miscible water: pH-value at 20C: Viscosity: Kinematic at 20C: Organic solvents: 5.5 - 7.5
(Contd. on page 4)
DR
Page 4/5
Reviewed on 23.07.2004
KAN BASE
(Contd. of page 3)
11 Toxicological information
Acute toxicity: LD/LC50 values relevant for classification: Oral LD-50 > 2000 mg/kg (Rat) 12125-02-9 ammonium chloride Oral LD-50 1650 mg/kg (Rat) Primary irritant effect: on the skin: Due to the product composition slight irritations of the skin cannot be excluded. on the eye: Due to the product composition slight irritations of the eyes cannot be excluded. Sensitization: No sensitizing effects known. Additional toxicological information: The product is not subject to classification according to the calculation method of the General EU Classification Guidelines for Preparations as issued in the latest version. When used and handled according to specifications, the product does not have any harmful effects to our experience and the information provided to us. The product has not been tested. The information is derived from the properties of the individual components.
12 Ecological information
Information about elimination (persistence and degradability): Method OECD 302 B Analysing method DOC decrease Degree of elimination: 20-70 % Classification: Moderately eliminable from water Other information: The product is cationic and in presence of anionic surfactants in industrial waste water it forms neutral salts that are almost completely eliminable. Ecotoxical effects: Aquatic toxicity: LC-50 > 1 mg/l (Vertebrata) Behaviour in sewage processing plants: EC-50 > 10 mg/l (activated sludge) Additional ecological information: COD-value: not available BOD5-value: not available AOX-indication: Product does not contain any organic bound Halogens which could lead to AOX-values. According to the formulation contains the following heavy metals and compounds from the EU guideline NO. 76/464 EC: The Product does not contain heavy metals in waste water relevant concentrations.
(Contd. on page 5)
AUS
DR
Page 5/5
Reviewed on 23.07.2004
KAN BASE
(Contd. of page 4)
General notes: The ecotoxic effect of the product has not been tested. The information on this was derived from products of similar structure or composition. Do not allow product to reach ground water, water course or sewage system.
13 Disposal considerations
Recommendation After prior treatment product has to be disposed of in an incinerator for hazardous waste adhering to the regulations pertaining to the disposal of particularly hazardous waste. Uncleaned packaging: Recommendation: Disposal must be made according to official regulations. Recommended cleansing agents: Water, if necessary together with cleansing agents.
14 Transport information
Land transport ADR/RID (cross-border) ADR/RID class: Maritime transport IMDG: IMDG Class: Marine pollutant: No
Air transport ICAO-TI and IATA-DGR: ICAO/IATA Class: Transport/Additional information: Not dangerous according to the above specifications.
15 Regulatory information
Labelling according to EU guidelines: Observe the general safety regulations when handling chemicals. The product is not subject to identification regulations under EU Directives and the Ordinance on Hazardous Materials (German GefStoffV).
16 Other information
This information is based on our present knowledge. However, this shall not constitute a guarantee for any specific product features and shall not establish a legally valid contractual relationship.
DR