Documente Academic
Documente Profesional
Documente Cultură
2A
3A
7A
13A
25A
25B
34A
COMPARISON OF PANTOGRAPHS
TYPE OF PANTO MAKE BASE FRAME UPPER FRAME PT S/MOTOR LOCATION YORK ASSLY MECHANISM ASSLY CENTRE SWING LINK OEM MODIFICATION RDSO MODIFICATION AM-12 SIL & CCPL. SQUARE TYPE. Two Nos longitudinal tubes attached with centre swing link. Opposite side of raising spring A Long. Aluminium make.
NIL.
IR03H CCPL SQUARE TYPE. Upper frame tube pipe support with cross bar. Opposite side of raising spring A Long. M.S. make.
NIL.
AM-92 BVGY SIL I TYPE. Upper frame assembly with supporting rod with rainbow joint. Mounted rear side of centre swing link. Cam sling assembly. Small. Aluminium make.
NIL. NIL.
PHOTOGRAPHS
NOTE:
Three Nos Brackets provided on Lower Arm to prevent falling down of Anti-balancing tube & raising spring vide drawing No. WR/BRCY/ EL/4-PT-017 have been done in BRC Locos. Some Sheds provide single strip as below. However, three strips and their way of fixing provides better protection.
15A
I. II.
RECOGNITION :
Reverser ( J-1 / J-2 )has two positions marked as F / R. Reverser ( J-1 / J-2 ) has a locking pin on one side. CTF has two positions marked as TR / BR. There is no locking pin on CTF. CTF ( 1 / 2 / 3 ) HANDLE POSITION WORKING CAB ANY CAB TRACTION TOP BRAKING BOTTOM
WORKING :
WORKING CAB CAB-1 CAB-2 REVERSER ( J-1 / J-2 ) HANDLE POSITION FORWARD REVERSE TOP BOTTOM BOTTOM TOP
III.
TROUBLE SHOOTING :
SN
1. 2. 3. 1. 2. 3. 4. 5.
REMEDIAL ACTION
Operate MPJ handle F/R . Ensure EP COC open in HT compartments. Ensure proper setting of both Reverser & CTFs. Operate them manually, Wedge Q-50. Ensure handles of all CTF in traction ( UP ). Operate 2-3 times manually. Try to resume traction if succeed ignore LSB. Isolate reverser by isolating corresponding RSI block & wedged Q-50 & refer TSD for further action.
12A