Documente Academic
Documente Profesional
Documente Cultură
allip:acl=a2;
allip:acl=strsp:r=all;
rrpar; ! corrects Transcoder pool config timeout !
strsp:r=IM7598O; ! status survey !
strdp:r=I47879I;
exdep:dev=BT4M-122;
ntcop:snt=ET4M-5,dipinf;
dtstp:dip=31RBLT; ! stat dip !
stdep:dev=BT4M-120&&-143; ! show status !
blodi:dev=UPDNAM-13845; ! block dev !
dtbli:dip=31RBLT; ! block dip !
dtidc:dip=31RBLT,lc=0,frs=0; ! dig path trans, init data, chanbge !
dtble:dip=31RBLT; ! de-block dip !
dtstp:dip=31RBLT; ! STATUS DIP !
dtbli:dip=31RBLT; ! block dig path !
dtidc:dip=31RBLT,lc=1,frs=1; ! dig path init data change !
dtble:dip=31RBLT; !de-block dig path !
dtstp:dip=31RBLT; ! dig path trans state print !
stdep:dev=updna51-5544&&-5567;
blode:dev=UPDNAM-13845; ! de-block devices !
stdep:dev=UPDNAM-13845;
ntstp:snt=etmaltm-37; ! stat snt !
ntbli:snt=snt; ! block snt !
ntble:snt=snt; ! de-block snt !
blori:r=xxxxxxx,blt=all; ! block route !
blore:r=xxxxxxx; ! de-block route !
seqar:r=; ! reset device !
!****************************************************************************!
================================================================================
================
Date & Time (Local) S Specific Problem Cause Mo-Reference
`
Finn Magnusson 2010-01-21 rev PA78 131/370
================================================================================
================
2008-11-28 00:06:57 m Loss of Synch Reference Redundancy replaceable_unit_proble
m Synchronization=1
2008-11-28 00:06:57 M TU Synch Reference Loss of Signal loss_of_signal Subrack=M
S,Slot=5,PlugInUnit=1,TimingUnit=1,TuSyncRef=1
2008-11-28 00:06:57 M TU Synch Reference Loss of Signal loss_of_signal Subrack=M
S,Slot=4,PlugInUnit=1,TimingUnit=1,TuSyncRef=1
2008-11-28 00:07:00 M Loss of Signal loss_of_signal
Subrack=MS,Slot=7,PlugInUnit=1,ExchangeTerminal=1,Os155SpiTtp=1
2008-11-28 00:07:12 M Rach_NbapMessageFailure call_establishment_error UtranCell
=Iub-3-2,Rach=1041
2008-11-28 00:10:40 M Plug-In Unit General Problem processor_problem_m3100 Subra
ck=MS,Slot=18,PlugInUnit=1
>>> Total: 6 Alarms (0 Critical, 5 Major)
Note: it is also possible to create MO groups with the commands hget/lhget, st/l
st, lk/llk, and
pdiff/lpdiff.
6.To check if GPRS is enabled or not:
rlgsp:cell=cellname;
7.To check the traffic:
rxtcp:moty=rxotg,cell=cellname;(get TG value)
rxmsp:mo=rxocf-TG No,subord;
8.Signalling and status of channel configuration:
rlcrp:cell=cellname;
9. To lock the site
rxbli:mo=rxocf-TG /CF No.,subord,force;
To unlock the site
rxble:mo=rxocf-TG /CF No.,subord;
10. To lock the TRX
rxbli:mo=rxotrx-TG /CF No.-trx.No.,subord,force;
To unlock the TRX
rxble:mo=rxotrx-TG /CF No.-trx.No.,subord;